2006 Hyundai Sonata
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,047 owner complaints filed for this model year. This is the 5th highest complaint count among 26 Sonata model years with reports.
Of the 2006 reports, 43 involved a crash and 9 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 9, 2018
Hyundai Motor America (Hyundai) is recalling certain 2006-2011 Hyundai Azera and 2006 Hyundai Sonata vehicles. Water may enter the Anti-lock Brake (ABS) Module and result in an electrical short .
An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began on February 19, 2018. Owners may call Hyundai at 1-800-633-5151. Hyundai's number for this recall is 172.
Campaign 18V026000 on NHTSA.gov
Suspension, rearAug 12, 2013
Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010 originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt and water can enter portions of the rear crossmember, leading to corrosion of the crossmember steel. This may lead to detachment of one of the rear control arms.
Control arm separation may suddenly change the rear wheel alignment, affecting the handling of the vehicle, increasing the risk of a crash.
Hyundai will notify owners, and dealers will repair or replace the crossmember assembly. The recall began on October 8, 2013. Owners may contact Hyundai Customer Care Center at 1-800-633-5151. Hyundai's recall number is 113.
Campaign 13V354000 on NHTSA.gov
Exterior lightingJul 21, 2009
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
Campaign 09V280000 on NHTSA.gov
Exterior lighting, brake lights, switchApr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V122000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bagsApr 10, 2008
HYUNDAI IS RECALLING 393,308 MY 2006-2008 SONATA VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM WHICH FEATURES AN OCCUPANT CLASSIFICATION SYSTEM (OCS) IN THE RIGHT FRONT SEAT. THE PURPOSE OF THE OCS IS TO DISABLE THE RIGHT PASSENGER SEAT FRONT AIR BAG WHEN IT DETECTS THE PRESENCE OF A CHILD RESTRAINT SYSTEM OR SMALL CHILD IN THE RIGHT FRONT SEAT. THE RIGHT FRONT AIR BAG IS DISABLED TO PREVENT INJURIES TO A CHILD THAT MAY RESULT FROM A RIGHT FRONT AIR BAG INFLATION DURING A CRASH.
MISCLASSIFICATION OF A SMALL STATURE ADULT AS A CHILD IN THE RIGHT FRONT PASSENGER SEAT MAY CAUSE THE RIGHT FRONT AIR BAG TO NOT INFLATE IN AN ACCIDENT THAT MERITS AIR BAG DEPLOYMENT AND MAY RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
DEALERS WILL VERIFY THAT THE OCS DOES NOT PROPERLY RECOGNIZE A PROPERLY SEATED ADULT OCCUPANT. AFTER VERIFICATION, DEALERS WILL REMOVE THE RIGHT FRONT SEAT CUSHION ASSEMBLY AND SHIP IT TO AN EVALUATION AND REPAIR FACILITY. THIS FACILITY WILL EVALUATE AND REPAIR OR REPROGRAM THE SEAT CUSHION AND OCS AS NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 26, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 08V161000 on NHTSA.gov
Exterior lighting, headlightsMar 7, 2008
HYUNDAI-KIA IS RECALLING 4,085 REPLACEMENT HEADLAMP ASSEMBLIES SOLD FOR USE ON 2006-2008 SONATA AND AZERA VEHICLES. THESE HEADLAMP ASSEMBLIES MAY NOT HAVE BEEN ALIGNED PROPERLY AND FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
IMPROPER AIMING OF THE HEADLAMP MAY RESULT IN POOR VISIBILITY POSSIBLY RESULTING IN A VEHICLE CRASH.
HYUNDAI-KIA DEALERS HAVE BEEN NOTIFIED AND INSTRUCTED TO RETURN THEIR SUPPLY TO HYUNDAI MOTOR AMERICA. NONE OF THE HEADLAMPS WERE SOLD AS RETAIL. AS A RESULT, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED.
Campaign 08E021000 on NHTSA.gov
Equipment, other, labelsJun 26, 2006
ON CERTAIN PASSENGER VEHICLES, THE AIR BAG WARNING LABEL INSTALLED ON THE SUNVISORS HAD LOST ADHESION TO THE SUNVISORS AND HAD DISTORTED OR SEPARATED FROM THE SUN VISORS.
IF THE LABELS ARE DISTORTED OR MISSING, THE DRIVER OR FRONT SEAT PASSENGER WILL NOT HAVE INFORMATION AVAILABLE THAT MAY HELP PROTECT THEM IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SUNVISOR ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 06V234000 on NHTSA.gov
Exterior lighting, headlightsMay 22, 2006
ON CERTAIN PASSENGER VEHICLES, THE INNER BEZELS OF THE HEADLAMPS WERE NOT PROPERLY ASSEMBLED WHICH MAY CAUSE THE TURN SIGNAL LENSES TO BE IMPROPERLY POSITIONED.
AN IMPROPERLY POSITIONED TURN SIGNAL LENS MAY REDUCE THE INTENSITY OF THE TURN SIGNAL ILLUMINATION, REDUCING ITS VISIBILITY TO ONCOMING TRAFFIC, WHICH MAY RESULT IN A CRASH.
DEALERS WILL REPLACE THE LEFT AND RIGHT HEADLAMP ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 06V180000 on NHTSA.gov
Seats, front assembly, reclinerAug 29, 2005
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT MAY INTERFERE WITH THE MANUAL SEAT BACK RECLINER KNOB AND COULD CAUSE THE FRONT MANUAL SEAT BACK RECLINER TO INADVERTENTLY RELEASE.
THE INADVERTENT RELEASE OF A FRONT SEAT BACK RECLINER MAY RESULT IN INJURY TO VEHICLE OCCUPANTS.
DEALERS WILL REPLACE THE MANUAL SEAT BACK RECLINER KNOB(S) FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V377000 on NHTSA.gov
Electronic stability control, automatic (asc)Jul 7, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3.3 LITER ENGINES AND ELECTRONIC STABILITY CONTROL (ESC), THE ESC MAY HAVE BEEN PROGRAMMED TO BE OVERSENSITIVE TO THE ONSET OF OVERSTEERING WHILE DRIVING ON BANKED CURVES, CAUSING INADVERTENT APPLICATION OF THE FRONT OUTSIDE BRAKE WHEN ESC ACTIVATION MAY NOT BE NEEDED.
THIS MAY CAUSE THE VEHICLE TO SLOW AND MAY AFFECT THE PATH THAT THE VEHICLE IS TRAVELING. BRAKE APPLICATION CAUSED BY INADVERTENT ESC ACTIVATION MAY RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE ESC HYDRAULIC ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V316000 on NHTSA.gov
Representative owner complaints: air bags
435 reports, newest first. Show all
Air bags, Seats, Apr 2, 2014
MY CAR HAS THE SAME PROBLEM AS THIS COMPLAINT NUMBER.10575493 I HAVE BEEN TOLD BY THE DEALER THAT I NEED TO HAVE THE SEAT REPLACED WHICH IS A $1000+ REPAIR. THIS SHOULD BE A SIGNIFICANT SAFETY ISSUE. *TR
Air bags, Seat belts, Mar 29, 2014
2006 SONATA GLS VERY WELL MAINTAINED (FOR LIFE OF VEHICLE) BY TOP NOTCH LOCAL DEALER + NO ACCIDENT HISTORY - REPORTS DRIVER SIDE SEAT BELT BUCKLE ERR CODE, AIRBAG LIGHT ON/AIRBAG SYSTEM NOT ACTIVATED. DEALER ATTEMPTED OC3 TEST-PASSENGER SEAT VOLUNTARY RECALL ISSUE - COULD NOT COMPLETE TEST-BUCKLE ERROR...REPLACED BUCKLE ASSY: SAME CODE + LIGHT. DASH OPENED, CONSOLE REMOVED, DRIVER SEAT REMOVED: AIRBAG SYSTEM HARNESS INSPECTION, RESEAT CONNECTIONS - NEW CODE APPEARS: DRIVERS BELT RETRACTOR ASSY. REPLACED BELT RETRACTOR ASSY. NO CODE! AND AIRBAG SYSTEM STILL NOT WORKING/AIRBAG LIGHT INDICATOR ON. ..DEALER ADVISED THIS EXPENSIVE PROBLEM IS WELL-KNOWN TO 06, 07 SONATA OWNERS: SOLE VIABLE SOLUTION=REPLACE AIR BAG SYSTEM WIRING HARNESS. ORDERED PART # ON HARNESS - WRONG HARNESS DELIVERED (CONNECTORS IN WRONG LOCATION ON HARNESS/DON'T MEET UP WITH CAR CONNECTORS. ORDERED AGAIN, SAME RESULT (DEALERSHIP NOTED - THESE HARNESSES ARRIVE WITH BAG TORN OPEN (NOT FIRST MECHANIC TO ORDER IT FOR SAME PROBLEM AND OUTCOME).. LOCAL HYUNDAI TERRITORY ENGINEER (TROUBLESHOOTER FOR LARGE PROBLEMS) ASKED TO VISIT FOR DISCUSSIONS - RIGHT PART # / WRONG PART. SOLUTION = I'VE DEALT WITH THIS 3X RECENTLY AND IN THIS AREA - ORDER THIS PART #. GUESS WHAT, NEW PART IS $750 / DOUBLE OLD PART COST. NEW HARNESS REACHES INTO BACK SEAT AREA AS WELL AND CAUSES DOUBLE THE LABOR COSTS >$1,000. ..$1K ALREADY INVESTED IN PARTS AND LABOR PLUS FACING ANOTHER $2K IN HARNESS PARTS & LABOR. DEALER CAN'T PROVIDE ANY GUARANTEE THIS WILL SOLVE IT SHORT TERM LET ALONE LONG TERM - CONTACTED HYUNDAI USA FOR FINANCIAL ASSISTANCE - DENIED DUE TO OUT OF WARRANTY + 2ND OWNER/NOT ORIGINAL (HOW CONVENIENT FOR THEM)..AS MENTIONED, 3X '06 SONATA OWNERS IN THIS TERRITORY RECENTLY EXPERIENCED IDENTICAL ISSUES AND AFTER GETTING TOUGH WITH HYUNDAI USA, RECEIVED BUY-BACKS OF THEIR CARS. TRY TO GUESS MY NEXT MOVE ...UPDATED 08/14/14 *BF *TR *TR
Air bags, Seat belts, Mar 18, 2014
AIR BAG LIGHT COMES ON EVERY OTHER YEAR. I AM HAVING THIS ISSUED FOR THREE TIME AIR BAG LIGHT COMES ON EVERY TIME AND THEN THEY PUT NEW SEAT BELT BUCKLE IT GOES AWAY FIRST TIME IT HAPPENED IN 2010 IT WAS UNDER WARRANTY, SECOND TIME IT HAPPENED IN 2012, AND THIRD TIME IT HAPPENED IN 2014. *TR
Air bags, Mar 17, 2014
AIR BAG LIGHT ILLUMINATED AND WILL NOT GO OFF. FOR A FEW WEEKS, ANYTIME THE DRIVERS SEAT WAS ADJUSTED, IT WOULD TRIGGER THE AIR BAG LIGHT ON THE DASH BUT ONCE THE SEAT WAS MOVED, IT WOULD GO OFF. NOW TO THE POINT, IT WILL NOT SHUT OFF THE AIR BAG LIGHT. SIMILAR THING HAPPENED LAST SUMMER, TOOK TO DEALER AND HAD TO PAY TO HAVE SYSTEM CLEARED AS HYUNDAI IS THE ONLY ONE WITH THE PROPER TOOL TO "SCRUB THE AIR BAG MEMORY". MY CONCERN, IS WILL THE AIR BAGS GO OFF IN THE EVENT OF AN ACCIDENT? WHY SHOULD I HAVE TO GO BACK TO THE DEALER TO PAY TO HAVE ERROR CLEARED IF NO MISUSE ON MY END? IT APPEARS BY READING THIS SITE THAT MANY HYUNDAI OWNERS HAVE EXPERIENCED SIMILAR ISSUES SO PERHAPS THIS IS A RECALL? *TR
Air bags, Feb 20, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE STARTING THE IGNITION, THE PASSENGER'S SIDE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 08V161000 (AIR BAGS) HOWEVER, AFTER THE REMEDY REPAIR WAS PERFORMED THE FAILURE PERSISTED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Air bags, Jan 21, 2014
MY SPOUSE REPORTED TO ME THAT THE AIRBAG FOR DRIVERS SIDE CAME ON AND STAYED ON. TWO DAYS AGO, I TOOK THE CAR TO WORK (READJUSTING THE SEAT) AND THE LIGHT WAS NOT ON. I HAD READ ABOUT THIS ISSUE IN ONLINE FORUMS FOR MY MAKE AND YEAR AND THIS PROBLEM AND THERE WAS MENTION THAT IF YOU MOVE THE SEAT FORWARD AND BACK THAT YOU CAN GET THE LIGHT TO TURN OFF. WELL, I TRIED THAT AND UNFORTUNATELY FOR ME THE LIGHT CAME ON AND HAS STAYED ON. WE PREVIOUSLY HAD THE VEHICLE FOR THE PASSENGER SIDE AIRBAG RECALL AND HAD THAT TAKEN CARE OF. I TOOK THE CAR TO OUR DEALER TO FIND OUT IF THEY HAD SIMILAR OCCURRENCES AND WAS SURPRISED BY MY SERVICE ADVISER'S ATTITUDE. HE APPEARED GUARDED AND WAS VERY UNLIKE HIM. I USUALLY GET ALL MY SERVICE DONE THERE. IT SEEMS TO ME THAT I WAS NOT THE FIRST ONE WITH THIS PROBLEM. HE TOLD ME THAT FIRST I'D HAVE TO GET A DIAGNOSIS ($79+ TAX), THEN ANY REPAIRS ( ANYWHERE FROM $300 TO 1500.) WOULD BE MY RESPONSIBILITY AS THE VEHICLE IS OUT OF WARRANTY. I ALSO ASKED IF THE AIRBAG LIGHT IS ON, DOES THE AIRBAG NOT WORK AND WAS TOLD YES. I JUST WENT TO NHTSA TODAY AND LOOKED IN THE COMPLAINT SECTION FOR THIS VEHICLE AND FOUND NUMEROUS PEOPLE WITH THE SAME ISSUE. REQUIRING AIRBAGS IN VEHICLES IS A FEDERAL LAW REQUIREMENT, SO WHY THEN IF THESE SYSTEMS FAIL WITHOUT ANY OWNERS NEGLIGENCE, ARE THE MANUFACTURERS NOT REQUIRED TO SEE THAT THEY GET REPAIRED? WHAT TRIGGERS A RECALL? AFTER TALKING WITH ONE OF YOUR REPRESENTATIVES, A SHORT TIME AGO, I ASKED THAT QUESTION AND SHE SAID THAT NHTSA CAN'T FORCE A MANUFACTURER FOR JUST ANYTHING. I SAID, "SOMEONE WHOSE AIRBAG DOESN'T DEPLOY IN A CRASH AND DIES MIGHT TRIGGER A RECALL?" THE REPRESENTATIVE REPLIED, "THOSE ARE YOU WORDS, MOT MINE". *TR
Air bags, Seat belts, Jan 21, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE BUCKLE ASSEMBLY PRE TENSIONER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,897.
Air bags, Seat belts, Dec 21, 2013
CAR WAS TAKEN TO HYUNDAI DEALERSHIP FOR OCS RIGHT FRONT PASSENGER SEAT RECALL. A FEW HOURS LATER DEALER CALLED TO ADVISE THAT THERE WAS NO PROBLEM WITH THE OCS AIR BAG. I WAS TOLD THE CODE ASSOCIATED WITH THE LIGHT BEING ON INDICATING "PASSENGER AIR BAG OFF" RELATED TO THE SEAT BELT TENSIONER NOT WORKING, NOT THE OCS. SINCE THE SEAT BELT IS A SAFETY ISSUE, I ASKED THE DEALER TO TAKE CARE OF IT AT NO CHARGE TO ME. THE DEALER (RICK CASE HYUNDAI IN DAVIE, FL) REFUSED TO DO SO SAYING THAT IT WAS NOT COVERED IN THE OCS RECALL AND THE CAR WAS OUT OF WARRANTY. I THEN CALLED HYUNDAI CUSTOMER SERVICE AND REQUESTED THAT HYUNDAI REPAIR THE SEAT BELT TENSIONER AT NO CHARGE TO ME. THEY READ ME A PREPARED STATEMENT STATING THAT THIS WAS NOT COVERED UNDER THE OCS RECALL AND WOULD NOT TAKE CARE OF IT BECAUSE THE CAR WAS OUT OF WARRANTY. AFTER I SPOKE TO A CASE MANAGER AT HYUNDAI, THEY AGREED TO CALL THE DEALERSHIP AND SEE IF THEY COULD WORK SOMETHING OUT WITH THE DEALERSHIP FOR THE SEAT BELT REPAIR. HYUNDAI WAS SUPPOSED TO CALL ME BACK WITHIN A WEEK TO TELL ME WHAT WAS WORKED OUT. THEY DID NOT. WHEN I CALLED BACK A COUPLE OF WEEKS LATER, HYUNDAI AGAIN READ ME THE PREPARED STATEMENT SAYING THIS PROBLEM WAS NOT COVERED UNDER THE RECALL. I REITERATED THAT THE SEAT BELT TENSIONER WAS A SAFETY ISSUE AND I EXPECTED THEM TO REPAIR IT. THEY CONTINUED TO REFUSE TO TAKE RESPONSIBILITY FOR THE REPAIR. I ADVISED I WAS GOING TO REPORT THIS SAFETY ISSUE TO NHTSA. HYUNDAI WAS UNCONCERNED. AS NHTSA SHOULD SEE, SEVERAL HYUNDAI SONATA OWNERS HAVE REPORTED THIS SAME SEAT BELT PROBLEM TO NHTSA. MY PASSENGER SEAT IS RARELY USED, SO THIS SEEMS TO BE A HYUNDAI SAFETY DEFECT FOR WHICH THE DEALERS AND HYUNDAI SHOULD BE REQUIRED TO MAKE A RECALL AND REPAIR AT THEIR EXPENSE.I AM ALSO CONCERNED THAT THE PASSENGER SEAT WAS NOT REMOVED AND SENT TO HYUNDAI FOR ANALYSIS AS NOTED IN THE OCS RECALL. *TR
Electrical system, Air bags, Dec 19, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS). AFTER THE RECALL REPAIR WAS PERFORMED, ALL OF THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED AND THE READING OF THE GAUGES FLUCTUATED ERRATICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.
Air bags, Dec 18, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED WHILE THE PASSENGER'S SEAT WAS OCCUPIED. THE VEHICLE WAS DIAGNOSED AND THE CONTACT WAS INFORMED THAT THE SENSOR IN THE SEAT BELT BUCKLE MALFUNCTIONED. THE CONTACT WAS INFORMED THAT THE DEFECT WAS NOT ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 08V161000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,000.
Air bags, Seat belts, Dec 10, 2013
AIR BAG LIGHT HAS BEEN ON FOR SIX MONTHS. GOT THE RECALL NOTICE ABOUT PASSENGER OCCUPANT SYSTEM WHICH INDICATED THAT IF THE LIGHT STAYS ON TO BRING THE CAR TO THE DEALERSHIP. I TOOK THE CAR TO THE DEALERSHIP AND WAS TOLD THAT THE SYSTEM CHECKED OUT OKAY. I TOLD THE SERVICE REP THAT THE LIGHT WAS STILL ON. HE INDICATED THAT WAS A PROBLEM WITH THE SEAT BELT BUCKLE. HE ALSO INDICATED THAT THE AIR BAG MAY OR MAY NOT DEPLOY IN THE CASE OF AN ACCIDENT. THIS IS A MAJOR SAFETY ISSUE. HYUNDAI SHOULD ISSUE A RECALL ON THIS APPARENT DEFECT. *TR
Air bags, Dec 4, 2013
TL- THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER A RECALL NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS), HOWEVER THREE MONTH LATER THE SAME PROBLEM RECURRED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 60,000. JR
Air bags, Dec 3, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR RECALL REPAIRS UNDER NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS) HOWEVER, THE CONTACT WAS INFORMED THAT THE PARTS WERE UNAVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Air bags, Nov 26, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS) HOWEVER, ONE WEEK LATER THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, AFTER THE RECALL WAS ANNOUNCED. HOWEVER, THE LIGHT IS STILL BLINKING. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,000. UPDATED 12/30/13*CN UPDATED 01/13/14
Air bags, Nov 26, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS). THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIRS HOWEVER, AFTER THE REPAIR THE AIR BAG WARNING LIGHT ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.
Electrical system, Air bags, Seat belts, Nov 20, 2013
THE DUMMY AIRBAG LIGHT IN MY 2006 SONATA HAS BEEN ON FOR A FEW YEARS. THE LAST TIME I BROUGHT IT IN TO SERVICE, IN JULY 2012- I WAS TOLD THAT MY PASSENGER SEAT MAY NEED TO BE SENT OUT, BUT THAT I WOULD ALSO NEED 2 NEW SEAT BELTS. I WAS TOLD THE AIR BAGS WOULDN'T DEPLOY IF I WAS IN AN ACCIDENT.THE MECHANIC WAS ABLE TO TURN THE DUMMY LIGHT OFF BUT ONLY FOR A DAY OR TWO. THIS NOVEMBER 2013, THE SEAT WAS SENT OUT TO CA UNDER A RECALL NOTICE I WAS SENT BY HYUNDAI, AND I PAID TO HAVE MY SEAT BELTS REPLACED, BUT I FEEL THE WHOLE THING IS RELATED AND SHOULD HAVE BEEN A RECALL. EVERYONE I HAVE SPOKEN TO ABOUT IT FEELS THE SAME WAY. THE SEAT BELT REPLACEMENT COST $350 PER SEAT EXCLUDING TAX. HYUNDAI HAS KNOWN OF THIS PROBLEM (THROUGH MY DEALER) SINCE JULY 2012 AND THE PROBLEM HAD BEEN ONGOING FOR MONTHS PRIOR TO ME TAKING IT IN FOR SERVICING, NOT REALIZING IT WAS A DANGEROUS SITUATION. I MISSED THE 5 YEAR 60K WARRANTY PROBABLY BY 10K MILES OR LESS. I WOULD LIKE TO KNOW HOW MANY OTHER SONATA OWNERS HAVE HAD TO REPLACE THEIR SEAT BELTS AND WHETHER OR NOT WE SHOULD BE SUING HYUNDAI TO HAVE THEM COVER THIS "REPAIR". I COULD GET NO STATISTICS FROM HYUNDAI WHEN I CALLED THEM REGARDING HOW MANY PEOPLE HAVE COMPLAINED ABOUT THIS PROBLEM. THE EXPLANATION PROVIDED TO ME IS THAT THEY ARE SEPARATE PROBLEMS, NOT INTER-RELATED AND THAT THE SEAT BELT ISSUE IS AN ELECTRICAL ISSUE AND THE SERVICE CENTER WAS GIVEN A CODE TO DIAGNOSE THE ISSUE. *TR
Air bags, Nov 18, 2013
2006 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO AIR BAG RECALL NOTICE. *SMD THE CONSUMER WOULD LIKE TO KNOW, WHY THE DIAGNOSIS WAS NOT COVERED UNDER THE RECALL. THE OCS TEST RESULTED IN A PASS/COMPLIANT, BUT THE PASSENGER SEAT BELT BUCKLE PRE-TENSIONER DIDN'T PASS.
Suspension, Fuel system, Gasoline, Air bags, Nov 14, 2013
BACK WHEN I PURCHASED THIS 2006 SONATA I WENT BACK IN AIRBAG LIGHT WAS ON THE CAR WAS IN LESS THAN TEN MINUTES DEALER SAID ALL SET AND I WENT IN TO A LOCAL GARAGE FOR INSPECTION BUT THE CAR LEGALLY SHOULDN'T PASS INSPECTION DUE TO SAID AIRBAG ISSUE AND THE GENTLEMAN PUT IT THROUGH BUT SAID AIRBAGS WILL NOT DEPLOY DUE TO THE FUSE WAS PULLED PUT ONE IN BEEN ON SINCE AND IT IS ALL OVER HYUNDAI FORUM SAME PROBLEM/2 MY FRONT SUSPENSION IS RATTLING BAD AND COME TO FIND OUT SAME THING ON HYUNDAI FORUM THEY ALWAYS DON'T KNOW WHAT THIS NOISE IS/3 MY CHECK ENGINE LIGHT ON CODE SEARCH SAYS EVAP LEAK BUT NEED 2 SAY YES ITS NOT FUEL CAP THIS IS A KNOWN SONATA PROBLEM FUEL TANK IS PLASTIC AND THERE IS A PART IN TOP THAT IS METAL RUST OUT AND CAUSES FUEL TANK TO CRACK THIS PART ALONE IS 1500 PLUS LABOR THESE CARS ARE LEMONS WILL NOT BUY ANOTHER ONE THIS IS ALL IN 2 YRS OF OWNING NOT COUNTING THERE WAS A RECALL I JUST HAD DONE BUT NEVER GOT NOTICE ON ANY PRIOR TO HIS I WANT TO SEE ALL THAT WERE SUPPOSEDLY DONE THANKS VERY DIS SATISFIED CUSTOMER. *TR
Air bags, Nov 8, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. UPDATED 3/31/14*CN THE DEALER INFORMED THE CONSUMER, THE AIR BAG LIGHT WAS NOT A SAFETY FACTOR. IN 2013 HE RECEIVED A RECALL NOTICE, REGARDING A DEFECT WITH THE AIR BAG. HOWEVER, THE DEALER STATED IT WAS NOT RECALLED. UPDATED 04/2/41/4
Air bags, Nov 1, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED WHILE STARTING THE VEHICLE THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY WITH AN OCCUPANT IN THE FRONT SEAT. THE FAILURE RECURRED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER NUMEROUS TIMES. THE PASSENGERS SEAT CUSHION WHICH HOUSED THE OCS UNIT WAS REPLACED AND ALSO RECALIBRATED. THE FAILURE PERSISTED AFTER THE REPAIR WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 185. UPDATED 01/07/14*LJ
Air bags, Oct 30, 2013
I CALLED TO BRING MY CAR IN (SATURDAY) TO GLENDALE HYUNDAI FOR A RECALL BUT NOBODY PICKLED UP SO I LEFT A MESSAGE. AFTER NOBODY CALLED AFTER A MANY HOURS LATER I CALLED BACK. I WAS TOLD TO DROP IN ON A WEEKDAY. ON MONDAY THE EMPLOYEE AND MANAGER DID NOT FIX MY CAR BECAUSE I REFUSED TO PAY FOR A DIAGNOSTIC FEE. A RECALL IN MY OPINION SHOULD BE FREE. I CALLED CUSTOMER SERVICE THAT DAY AND WAS GIVEN A CASE NUMBER. I MADE AN APPOINTMENT FOR 4:45 PM WITH HYUNDAI CUSTOMER SERVICE TO GO TO THE GLENDALE HYUNDAI. ON MY ARRIVAL THE EMPLOYEE REFUSED TO CHECK MY CAR BECAUSE HE SAID THEY DON'T FIX CARS AT 4:45. I ARRIVED EARLY, ABOUT THIRTY MINUTES EARLY, BUT HE SAID IT WAS TOO LATE. THE HYUNDAI CUSTOMER SERVICE HAS A HISTORY OF MAKING APPOINTMENTS THAT DON'T MATCH UP WITH THE HYUNDAI DEALER HOURS. I CALLED CUSTOMER SERVICE TO MAKE AN APPOINTMENT AND THEY TOLD ME THERE SHOULD BE NO DIAGNOSIS FEE. WHEN THE APPOINTMENT WAS MADE THEY TOOK BACK THEIR CLAIM. THEY SAID I MUST PAY A DIAGNOSIS FEE FOR A RECALL. MY CAR IS A SALVAGE TITLE CAR IN GOOD CONDITION BUT HAS THE AIR BAG LIGHT ON. I HAVE NO CHOICE BUT TO NOT FIX A RECALL FOR THE CAR. I DON'T FEEL IT IS CORRECT TO PAY A DIAGNOSIS FEE FOR A RECALL INCIDENT. I WILL NO LONGER BE SHOPPING FOR HYUNDAI OR KIA PRODUCTS IN THE FUTURE. THEY WASTED MY TIME AND WANT TO CHARGE ME FOR A RECALL. *TR
Air bags, Oct 30, 2013
"AIR BAG" LIGHT STAYS ILLUMINATED AT ALL TIMES. RECEIVED RECALL NOTICE FOR THE OCS ON 10/29/13, CALLED DEALERSHIP, THEY SAID IT WOULD COST ME TO HAVE IT CHECKED OUT. I THOUGHT THAT WAS THE WHOLE PURPOSE OF A RECALL NOTICE. THERE IS A PROBLEM AND SHOULD BE FIXED AT NO CHARGE TO CUSTOMER. *TR
Air bags, Seat belts, Vehicle speed control, Oct 28, 2013
WHILE DRIVING ON A BUSY STREET IT FELT LIKE MY GAS PEDAL WAS NOT RESPONDING THEN WITHOUT WARNING IT SUDDENLY LURCHED FORWARD ENOUGH TO SCREECH MY FRONT TIRES. I DO NOT HAVE A FLOOR MAT ON THE DRIVER'S SIDE. THANK GOD NO ONE WAS IN FRONT OF ME, SURELY THERE WOULD HAVE BEEN AN ACCIDENT. I HAVE ALSO HAD THE AIR BAG LIGHT ON SINCE THE CAR WAS NEW. DURING HYUNDAI NEW CAR SERVICE ONE OF THE SERVICE MEN NOTICED AND MENTIONED IT, BUT DID NOTHING TO CORRECT THE PROBLEM AND TODAY I GOT A RECALL ON THE AIR BAG SYSTEM STATING I MISSED THE 1ST RECALL. MY FRONT PASSENGER SEAT BELT LIGHT GOES ON AND OFF SOMETIMES IT IS ON WHEN SOMEONE IS IN THE SEAT BUCKLED UP AND SOMETIMES IT IS ON WHEN NO ONE IS SITTING IN THE SEAT. I AM TAKING MY CAR IN TO HYUNDAI FOR THE RECALL I AM GOING TO MENTION THE LURCHING AND LET THEM KNOW ABOUT ALL THESE COMPLAINTS! I BELIEVE THEY ARE ULTIMATELY RESPONSIBLE FOR THESE PROBLEMS!! *TR
Air bags, Seat belts, Oct 28, 2013
MY AIR BAG LIGHT STAYS ON ALL THE TIME. IN A CRASH MY AIR BAG MAY NOT DEPLOY, THIS IS A SAFETY ISSUE. LOOKING INTO THE COMPUTER I'M NOT THE ONLY ONE WITH THIS PROBLEM. THIS SHOULD BE A RECALL MATTER. *TR
Air bags, Oct 22, 2013
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED HOWEVER, THE CONTACT WAS NOT AWARE OF THE EXACT REPAIRS NEEDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000.