2006 Hyundai Sonata
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,047 owner complaints filed for this model year. This is the 5th highest complaint count among 26 Sonata model years with reports.
Of the 2006 reports, 43 involved a crash and 9 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 9, 2018
Hyundai Motor America (Hyundai) is recalling certain 2006-2011 Hyundai Azera and 2006 Hyundai Sonata vehicles. Water may enter the Anti-lock Brake (ABS) Module and result in an electrical short .
An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began on February 19, 2018. Owners may call Hyundai at 1-800-633-5151. Hyundai's number for this recall is 172.
Campaign 18V026000 on NHTSA.gov
Suspension, rearAug 12, 2013
Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010 originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt and water can enter portions of the rear crossmember, leading to corrosion of the crossmember steel. This may lead to detachment of one of the rear control arms.
Control arm separation may suddenly change the rear wheel alignment, affecting the handling of the vehicle, increasing the risk of a crash.
Hyundai will notify owners, and dealers will repair or replace the crossmember assembly. The recall began on October 8, 2013. Owners may contact Hyundai Customer Care Center at 1-800-633-5151. Hyundai's recall number is 113.
Campaign 13V354000 on NHTSA.gov
Exterior lightingJul 21, 2009
HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.
Campaign 09V280000 on NHTSA.gov
Exterior lighting, brake lights, switchApr 15, 2009
HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 09V122000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bagsApr 10, 2008
HYUNDAI IS RECALLING 393,308 MY 2006-2008 SONATA VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM WHICH FEATURES AN OCCUPANT CLASSIFICATION SYSTEM (OCS) IN THE RIGHT FRONT SEAT. THE PURPOSE OF THE OCS IS TO DISABLE THE RIGHT PASSENGER SEAT FRONT AIR BAG WHEN IT DETECTS THE PRESENCE OF A CHILD RESTRAINT SYSTEM OR SMALL CHILD IN THE RIGHT FRONT SEAT. THE RIGHT FRONT AIR BAG IS DISABLED TO PREVENT INJURIES TO A CHILD THAT MAY RESULT FROM A RIGHT FRONT AIR BAG INFLATION DURING A CRASH.
MISCLASSIFICATION OF A SMALL STATURE ADULT AS A CHILD IN THE RIGHT FRONT PASSENGER SEAT MAY CAUSE THE RIGHT FRONT AIR BAG TO NOT INFLATE IN AN ACCIDENT THAT MERITS AIR BAG DEPLOYMENT AND MAY RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
DEALERS WILL VERIFY THAT THE OCS DOES NOT PROPERLY RECOGNIZE A PROPERLY SEATED ADULT OCCUPANT. AFTER VERIFICATION, DEALERS WILL REMOVE THE RIGHT FRONT SEAT CUSHION ASSEMBLY AND SHIP IT TO AN EVALUATION AND REPAIR FACILITY. THIS FACILITY WILL EVALUATE AND REPAIR OR REPROGRAM THE SEAT CUSHION AND OCS AS NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 26, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 08V161000 on NHTSA.gov
Exterior lighting, headlightsMar 7, 2008
HYUNDAI-KIA IS RECALLING 4,085 REPLACEMENT HEADLAMP ASSEMBLIES SOLD FOR USE ON 2006-2008 SONATA AND AZERA VEHICLES. THESE HEADLAMP ASSEMBLIES MAY NOT HAVE BEEN ALIGNED PROPERLY AND FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
IMPROPER AIMING OF THE HEADLAMP MAY RESULT IN POOR VISIBILITY POSSIBLY RESULTING IN A VEHICLE CRASH.
HYUNDAI-KIA DEALERS HAVE BEEN NOTIFIED AND INSTRUCTED TO RETURN THEIR SUPPLY TO HYUNDAI MOTOR AMERICA. NONE OF THE HEADLAMPS WERE SOLD AS RETAIL. AS A RESULT, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED.
Campaign 08E021000 on NHTSA.gov
Equipment, other, labelsJun 26, 2006
ON CERTAIN PASSENGER VEHICLES, THE AIR BAG WARNING LABEL INSTALLED ON THE SUNVISORS HAD LOST ADHESION TO THE SUNVISORS AND HAD DISTORTED OR SEPARATED FROM THE SUN VISORS.
IF THE LABELS ARE DISTORTED OR MISSING, THE DRIVER OR FRONT SEAT PASSENGER WILL NOT HAVE INFORMATION AVAILABLE THAT MAY HELP PROTECT THEM IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SUNVISOR ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 06V234000 on NHTSA.gov
Exterior lighting, headlightsMay 22, 2006
ON CERTAIN PASSENGER VEHICLES, THE INNER BEZELS OF THE HEADLAMPS WERE NOT PROPERLY ASSEMBLED WHICH MAY CAUSE THE TURN SIGNAL LENSES TO BE IMPROPERLY POSITIONED.
AN IMPROPERLY POSITIONED TURN SIGNAL LENS MAY REDUCE THE INTENSITY OF THE TURN SIGNAL ILLUMINATION, REDUCING ITS VISIBILITY TO ONCOMING TRAFFIC, WHICH MAY RESULT IN A CRASH.
DEALERS WILL REPLACE THE LEFT AND RIGHT HEADLAMP ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 06V180000 on NHTSA.gov
Seats, front assembly, reclinerAug 29, 2005
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT MAY INTERFERE WITH THE MANUAL SEAT BACK RECLINER KNOB AND COULD CAUSE THE FRONT MANUAL SEAT BACK RECLINER TO INADVERTENTLY RELEASE.
THE INADVERTENT RELEASE OF A FRONT SEAT BACK RECLINER MAY RESULT IN INJURY TO VEHICLE OCCUPANTS.
DEALERS WILL REPLACE THE MANUAL SEAT BACK RECLINER KNOB(S) FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V377000 on NHTSA.gov
Electronic stability control, automatic (asc)Jul 7, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3.3 LITER ENGINES AND ELECTRONIC STABILITY CONTROL (ESC), THE ESC MAY HAVE BEEN PROGRAMMED TO BE OVERSENSITIVE TO THE ONSET OF OVERSTEERING WHILE DRIVING ON BANKED CURVES, CAUSING INADVERTENT APPLICATION OF THE FRONT OUTSIDE BRAKE WHEN ESC ACTIVATION MAY NOT BE NEEDED.
THIS MAY CAUSE THE VEHICLE TO SLOW AND MAY AFFECT THE PATH THAT THE VEHICLE IS TRAVELING. BRAKE APPLICATION CAUSED BY INADVERTENT ESC ACTIVATION MAY RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE ESC HYDRAULIC ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Campaign 05V316000 on NHTSA.gov
Representative owner complaints
1,047 reports, newest first.
Seat belts, Oct 8, 2014
AIRBAG LIGHT CAME ON PERMANENTLY. DEALERSHIP SAYS IT IS A FAILURE IN THE PASSENGER SEAT BELT PRETENSIONER AND WILL COST ME $432. EDMUNDS RESEARCH REVEALED THAT THE NHTSA IS STUDYING THIS PROBLEM IN CONSIDERATION OF A RECALL. JUST WANTED TO INFORM YOU THAT I ALSO HAVE THIS PROBLEM ALONG WITH MANY OTHER PEOPLE. *TR
Air bags, Oct 8, 2014
AROUND 18 MONTHS AGO THE RED AIR BAG WARNING LIGHT IN THE DASH CLUSTER WOULD COME ON AT DIFFERENT TIMES. LATER THE LIGHT CAME ON AND STAYED ON. I TOOK IT TO A DEALER AND PAID $100 TO HAVE IT RESET AND WAS TOLD IT WAS POSSIBLY A POOR GROUND WHICH THEY CLEANED. THE LIGHT REMAINED OFF FOR LESS THAN A MONTH, CAME ON AND OFF FOR A WHILE AND IS NOW ON FULL TIME. HAVE READ MUCH ABOUT PEOPLE SPENDING THOUSANDS OF DOLLARS AT DEALERS WITH NO END IN SIGHT AND NOTHING FIXING THE PROBLEM. I CAN NOT FIND ACCURATE INFORMATION EXPLAINING IF THE LIGHT BEING ON IS A INDICATION OF THE AIR BAGS NOT BEING ABLE TO OPERATE PROPERLY OR AT ALL, OR IF IT ONLY INDICATES SOME SECTION HAS A PROBLEM. THIS AFFECTS MY SAFETY AND WELL BEING AS WELL AS CAUSING A LOSS OF VALUE WHEN I SELL THE CAR. I WOULD THINK THAT HYUNDAI SHOULD STAND BEHIND ANY PARTS AND LABOR THAT ARE RELATED TO VEHICLE SAFETY. *TR
Electronic stability control (ESC), Oct 4, 2014
VEHICLE SKIDS OF ROAD AND THE ESC LIGHT CAME ON. THE LIGHT HAS BEEN ON SINCE AND ITS NOT GOING BACK. THE BACK WELLS ARE MAKING FUNNY NOISE AND VIBRATES AT SPEED OF OVER 50MPH. *TR
Air bags, Seat belts, Oct 3, 2014
MY AIRBAG WARNING LIGHT HAS BEEN ILLUMINATED FOR A FEW YEARS NOW. I HAVE BROUGHT IT TO A FEW HYUNDAI DEALERSHIPS AND THEY TELL ME IT IS BECAUSE OF A PROBLEM WITH A SENSOR IN MY SEAT BELTS. THEY ALSO TELL ME THERE IS NO RECALL AND IT WILL COST BETWEEN 500-700 TO FIX IT. WHILE ADVISING ME THAT IS IT A SERIOUS SAFETY RISK AND MAY CAUSE MY AIRBAG TO NOT DEPLOY IN THE EVENT OF A CRASH. I DON'T UNDERSTAND HOW THERE IS NO RECALL ON THIS YET. AS THE DEALERSHIP HAS ALSO INFORMED ME THIS IS A COMMON PROBLEM WITH THE 2006 SONATA'S. *TR
Electrical system, Engine, Sep 30, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE DRIVING 20 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, WHILE ACCELERATING, THE SPEEDOMETER DISPLAYED VARIOUS GEARS BEING SHIFTED AND THERE WAS A LOUD ABNORMAL NOISE COMING FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 108,596.
Air bags, Sep 30, 2014
THE AIR BAG WARNING LIGHT IS ILLUMINATED ON THE DASHBOARD AND THE SERVICE REPRESENTATIVE AT HYUNDAI SAY THAT IT IS RELATED TO THE PRETENSIONER ON THE PASSENGER SIDE AND A VOLTAGE DISCREPANCY FROM THE BATTERY CODES B1102 AND B1706. *TR
Visibility/wiper, Sep 24, 2014
BOTH SUN VISORS HAVE COLLAPSED AND REFUSE TO STAY IN THE UPRIGHT POSITION. THEY FALL DOWN IN FRONT OF MY EYES AT VARIOUS TIMES CAUSING VISIBILITY ISSUES. THIS IS NOT SAFE! *TR
Air bags, Sep 23, 2014
SRS SEAT BELT LIGHT FIRST ON RIGHT SIDE ...SEAT BELT CLIP REPLACED COST 350.00 DOLLARS.. TOLD NO COVERED UNDER WARRANTY... FEW MONTHS LATER LEFT SIDE INDICATOR SES SYSTEM LIGHT ON DASH INSTRUMENT PANEL CAME ... DEALER REPAIR SAID 130 TO CHECK... POSSIBLE VERY EXPENSIVE TO FIX... I CANNOT AFFORD TO REPAIR BECAUSE OF UNKNOWN COST... THIS IS A COMMON PROBLEM ON EARLY MODELS 06 THRU 09 ?? *TR
Air bags, Sep 23, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS). THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Steering, Sep 23, 2014
I WAS DRIVING MY 2006 HYUNDAI SONATA YESTERDAY AND AS I WAS DRIVING THROUGH THE RAIN, MY STEERING WHEEL LOCKED UP ON ME. IT HAPPENED ONE DAY LAST WEEK WHEN I WAS DRIVING IN THE RAIN AS WELL. MY BATTERY LIGHT STARTED BLINKING, MY STEERING WHEEL LOCKED, MY CAR STARTED TO SQUEAL, AND THE SEATBELT LIGHT STARTED TO BLINK. AFTER I REACHED A DRY PORTION OF THE ROAD, MY CAR WENT BACK TO DRIVING NORMALLY. I HAD MY TWO YEAR OLD IN THE CAR WITH ME AND THIS WAS VERY TERRIFYING BECAUSE I COULD NOT TURN MY STEERING WHEEL TO THE RIGHT. I TYPED IN THESE SAME ISSUES IN A GOOGLE SEARCH BOX TO SEE IF ANY OTHER OWNERS OF A 06 HYUNDAI SONATA WERE HAVING THE SAME ISSUE. QUITE A FEW NUMBER OF PEOPLE AND NO ONE HAD ANY CLEAR RESOLUTIONS AFTER TAKING THEIR CARS TO THE HYUNDAI DEALERSHIP. I JUST NEED TO KNOW WHAT IS CAUSING THIS AND WHY SO I CAN HAVE IT FIXED IMMEDIATELY BECAUSE THIS IS VERY DANGEROUS. I AM NOW WORRIED TO DRIVE MY CAR IN THE RAIN BUT HAVE NO CHOICE SINCE IT IS MY ONLY SOURCE OF TRANSPORTATION. THIS IS SOMETHING THAT SHOULD DEFINITELY BE INVESTIGATED SINCE THERE ARE QUITE A NUMBER OF CARS EXPERIENCING THESE SAME ISSUES. *TR
Air bags, Seat belts, Sep 19, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 16,000. DJR
Seat belts, Sep 18, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE FRONT PASSENGER SEAT BELT BUCKLE FRACTURED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SEAT BELT BUCKLE SENSOR PRETENSIONER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.
Electronic stability control (ESC), Sep 18, 2014
CASUAL DRIVING JUST PROCEEDING FROM A STOP SIGN AND SUDDENLY ESC FLASHES AND STEERING GOT STIFF AND BRAKES SEEMED TO STUTTER AND GRINDING SOUND WITHOUT MY PRESSING OF BRAKE. HAD COSTLY REPAIR DONE AT HYUNDAI DEALER AND EXACTLY 12 MONTHS LATER SAME PROBLEM. THE ESC SEEMS TO BE AN ISSUE AND DOES INTERRUPT NORMAL DRIVING EVEN IF THE ESC IS OFF. *TR
Air bags, Seat belts, Sep 16, 2014
MY DASHBOARD WARNING LIGHT (RED TEXT: AIR BAG) WENT ON AS I WAS DRIVING AND HAS NOT SHUT OFF. WHEN I CALLED HYUNDAI CORPORATE THEY SAID THIS WAS DUE TO AIR BAG SENSORS ON PASSENGER SEAT AND WAS PART OF AN ONGOING OCS SETTLEMENT SO THEY MADE AN APPT WITH NORTH COUNTY HYUNDAI. WHEN THE DEALER INSPECTED THE ISSUE, THEY SAID IT WAS NOT PART OF THE OCS SETTLEMENT AND THAT IT IS A SEAT BELT TENSIONER/SEAT BELT BUCKLE ISSUE (DIAGNOSTIC CODE B1706) AND THAT IT IS NOT A SAFETY RECALL ITEM, NOR IS IT COVERED UNDER WARRANTY AND WOULD COST ME $336.90. FROM WHAT I HAVE LEARNED, THIS ISSUE RENDERS THE AIR BAG SYSTEM INOPERATIVE SO I AM WONDERING WHY HYUNDAI IS NOT FORCED TO COVER THIS SYSTEM DEFECT UNDER WARRANTY OR IF THERE ARE PLANS AT NHTSA TO ISSUE A MANDATORY RECALL. *TR
Suspension, Sep 13, 2014
CAR HAS STARTED MAKING CLUNKING SOUND FROM REAR END OF CAR. TOOK TO AN AUTO MECHANIC REPLACED STRUTS WHEEL BEARINGS HAS SPENT HOURS ON TRYING TO FIND NOISE, EVEN TO THE POINT OF RIDING IN THE TRUNK FOR 15 BLOCKS.VERY CONCERNED THIS COULD LEAD TO SOMETHING BAD. *TR
Vehicle speed control, Sep 5, 2014, crash
TL-THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY AND CRASHED INTO A BUILDING. THERE WAS ONE INJURY REPORTED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. THE VIN WAS NOT AVAILABLE. DJR
Steering, Electronic stability control (ESC), Service brakes, Sep 3, 2014
THE ESC OFF LIGHT TURNED ON BY ITSELF. WHEN PUSHING THE BUTTON FOR THE ESC OFF, NOTHING HAPPENED. A FEW DAYS LATER I NOTICED A MINOR STUTTER-STEP OF THE CAR'S FORWARD MOTION WITH A SLIGHT GRINDING NOISE, AND THE ESC OFF LIGHT WAS ILLUMINATED AGAIN. THE ESC OFF LIGHT STAYED ILLUMINATED. WHEN I ARRIVED AT MY DESTINATION, I SHUT THE CAR OFF THEN TURNED IT ON AGAIN. THE ESC LIGHT WAS NO LONGER ILLUMINATED. AUGUST 27, 2014, I LEFT MY CAR AT THE DEALERSHIP AND PROCEEDED TO WORK, THEY "FOUND DAMAGE TO LEFT-FRONT WHEEL SPEED SENSOR AND LEFT-FRONT TONE WHEEL. THEY ALSO STATED BOTH THE SPEED SENSOR AND LEFT-FRONT TONE WHEEL NEED TO BE REPLACED BEFORE FURTHER DIAGNOSIS COULD BE PERFORMED. AUGUST 30, 2014, I WAS TRAVELING AT APPROXIMATELY 40 M.P.H. WHEN TRAFFIC AHEAD BEGAN SLOWING. I APPLIED THE BRAKES AND THE CAR DIDN'T JUST STUTTER & GRIND, IT WAS LIKE ONE SIDE OF THE VEHICLE WASN'T BRAKING AT ALL AND THE OTHER SIDE WAS BREAKING HARD. THE CAR JERKED SIDE TO SIDE FOR A SHORT DISTANCE THEN SEEMED TO RIGHT ITSELF. THE ESC OFF LIGHT WAS NOW ILLUMINATED AGAIN. IF I HAD BEEN TRAVELING ANY FASTER, OR IN HEAVIER TRAFFIC, THIS CERTAINLY WOULD HAVE CAUSED ME TO HAVE AN ACCIDENT. I FEEL THIS IS A DESIGN FLAW, NOT AN ERROR ON MY PART AS THE CONSUMER, AND BELIEVE THIS TO BE A LIFE AND DEATH SAFETY ISSUE. MY BRAKES HAVE NEVER BEEN WORKED ON AND THERE'S NO LOGICAL REASON FOR THE SPEED SENSOR AND LEFT-FRONT TONE WHEEL TO BE DAMAGED. *TR
Power train, Service brakes, Sep 2, 2014
WHEN I STARTED THE CAR IN THE MORNING THE( ECO OFF) LIGHT CAME ON, AND THERE WAS NO POWER, BUT THE ENGINE WAS STILL ON. I PULLED OVER TO THE SIDE OF THE ROAD, SHUTOFF THE IGNITION, WHEN I STARTED THE CAR AGAIN, EVERYTHING WAS NORMAL. THE CHECK ENGINE LIGHT WAS ON. IT HAPPENS EVERY TIME THAT THE CAR IS PARKED OVERNIGHT. THE SOLUTION IS ALWAYS THE SAME, PULL OVER AND CUTOFF THE IGNITION FOR A FEW SECONDS. *TR
Service brakes, Sep 2, 2014
CAMPAIGN #092 WAS REPLACED ON MY VEHICLE AT BEL AIR HYUNDAI ON 9/14/2010. THE VEHICLE WAS THERE FOR OTHER REGULAR SERVICE AND THE RECALL WAS PERFORMED. AT THAT TIME, THE SWITCH WAS NOT A PROBLEM. NO CHECK ENGINE LIGHT AND WE WERE UNAWARE THAT THIS RECALL WAS EVEN PERFORMED. I'M SURE IT WAS LISTED ON MY PAPERWORK. THIS WEEK, MY CHECK ENGINE LIGHT COMES ON AND MY ABS LIGHT STAYS ON. I TOOK IT TO AUTOZONE. THE CODE WAS P0504. FAULTY STOP LAMP BRAKE SWITCH. I LOOKED IT UP ONLINE, UNAWARE THAT IT WAS ALREADY REPLACED ONCE. CALLED BEL AIR HYUNDAI, MADE MY APPOINTMENT, TOOK THE CAR IN ON AUGUST 29, 2014. I WAS TOLD BY [XXX] THAT MY CAR DID NOT QUALIFY FOR THIS RECALL. NOT THAT IT HAD BEEN REPLACED, BUT THAT MY VIN DID NOT QUALIFY. I TOOK MY VEHICLE BACK BECAUSE I COULD NOT AFFORD THE $160 REPAIR ON THE SWITCH THAT I REALLY AND TRULY THOUGHT WOULD BE COVERED BY THIS RECALL. I CALLED HYUNDAI CUSTOMER SERVICE AND OPENED CASE# [XXX]. THE GENTLEMEN I SPOKE WITH GAVE ME THE INFORMATION REGARDING THE COMPLETED CAMPAIGN FROM 9/14/2010 AND SUGGESTED THAT I CALL BEL AIR HYUNDAI BACK AGAIN AND THAT THEY SHOULD REPLACE THIS SWITCH FOR FREE. I DID AS HE SUGGESTED AND WAS TOLD BY [XXX] THAT THIS WAS NOT THEIR POLICY TO PERFORM RECALLS TWICE AND THE REPAIR WAS GOING TO COST ME $160. NEEDLESS TO SAY, I'M A LITTLE UNHAPPY ABOUT ALL OF THE WORK THAT I'VE HAD TO PUT INTO THIS AND I'M STILL GOING TO BE OUT MONEY FOR THIS REPAIR. THIS IS A FAULTY SWITCH AS PER THE RECALL. WHO IS TO SAY THE 2ND ONE IS NOT FAULTY AS WELL? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).?*TR
Electronic stability control (ESC), Aug 30, 2014
I WAS DRIVING ON THE HIGHWAY, GOING ABOUT 60 MPH, AND SUDDENLY THE ESC OFF LIGHT CAME ON AND I COULD NOT ABLE TO SWITCH IT OFF WITH ESC CONTROL BUTTON. ITS QUIET FREQUENT NOW WHENEVER CAR TOUCHES 60 MPH AND SOMETIME IT AUTOMATICALLY COMES WITHIN CITY DRIVING 30-40 MPH. I HAVE TAKEN MY VEHICLE TO WHEEL WORKS FOR THE CHECKUP AND THEY SUGGESTED TO GET IT CHECKED WITH DEALER AS IT COULD BE A SIGN OF A BIGGER PROBLEM. I HAVE ALSO READ SEVERAL FORUMS AND COME TO KNOW THAT MANY CONSUMERS ARE FACING SIMILAR PROBLEM AND IT COULD BE RELATED TO ACCELERATOR PEDAL OR BRAKE PEDAL. THIS IS ALSO KNOWN PROBLEM TO HYUNDAI BUT THEY ARE NOT DOING A RECALL FOR THIS KNOWN PROBLEM. PLEASE HELP IN ASSISTING ON THIS PROBLEM AND YOUR URGENT ACTION WILL BE APPRECIATED. *TR
Air bags, Seat belts, Aug 27, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASSENGER SEAT BELT BUCKLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 70,000. THE VIN WAS NOT AVAILABLE...UPDATED 09-23-14 *BF
Engine, Aug 26, 2014
TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, ATTEMPTING TO MAKE A TURN WHEN THE VEHICLE MADE A LOUD REVVING NOISE. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND TURNED IT OFF. THE CONTACT RESTARTED THE VEHICLE BUT IT WOULD NOT ACCELERATE PAST THE FIRST GEAR. THE CONTACT TURNED THE INSTRUMENT PANEL LIGHT OFF AND THE VEHICLE WAS ABLE TO PICK UP MORE SPEED, BUT THE CONTACT WAS ONLY ABLE TO DRIVE AUTOMATICALLY, NOT MANUALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Air bags, Aug 25, 2014
MY AIR BAG LIGHT CAME ON SHORTLY AFTER I BOUGHT MY 2006 HYUNDAI SONATA USED IN 2013. THE CAR DOES NOT HAVE ANY WRECKS TO SHOW THIS DEFAULT. THE DEALERSHIP WANTS TO CHARGE ME $260 FOR EACH NEW BELT BUCKLE BECAUSE THEY SAY THE SENSORS ARE BAD. I WANT THIS TURNED INTO A RECALL AS I DON'T FEEL THEIR MECHANICAL PROBLEM SHOULD END UP COSTING ME AN ADDITIONAL $700 FOR THEIR DEFECTIVE PARTS. *TR
Seat belts, Aug 24, 2014
THE DRIVER SIDE SEAT BELT PRETENSIONER WAS CHANGED UNDER WARRANTY ON MY 2006 SONATA. NOW THE PASSENGER SIDE PRETENSIONER HAS SET A CODE. THE VEHICLE IS NO LONGER COVERED UNDER WARRANTY. AN ONLINE SEARCH PROVED TO BE QUITE FRUITFUL. THIS IS NOT BY ANY MEANS AN ISOLATED INCIDENT. HYUNDAI IS AWARE THIS PROBLEM EXISTS AND SPANS MULTIPLE MODELS YET HAS DONE NOTHING TO REPAIR VEHICLES OUT OF WARRANTY. I WOULD LIKE TO POINT OUT THAT A SEAT BELT PRETENSIONER IS NOT A WEAR ITEM. THIS PART WORKS IN CONCERT WITH YOUR AIRBAG. IT ALSO IS A CONTROLLED EXPLOSION WHICH TIGHTENS THE SEAT BELT TO A PERSON AS THE AIR BAG IS DEPLOYED. IF SOME HYUNDAI AIR BAGS WERE TO SET CODES FOR BEING OUT OF SPEC ALL VEHICLES USING THEM WOULD NO DOUGH BE RECALLED. HOWEVER, A PART WORKING IN UNISON ON THE SAME SYSTEM WITH THE SAME TECHNOLOGY IS NOT. I AM AT A LOSS FOR WHY THIS IS NOT A NATIONAL RECALL. *TR
Air bags, Electronic stability control (ESC), Aug 22, 2014
OVER THE COURSE OF A FEW DAYS, THE DRIVER'S AIR BAG LIGHT STARTED TO BE LIT CONTINUOUSLY WHILE AN OCCUPANT WAS IN THE SEAT. INITIALLY, THE LIGHT WOULD COME ON AND THEN GO OUT AFTER A FEW MOMENTS. HOWEVER, AFTER APPROXIMATELY A WEEK OF THE ON/OFF, THE LIGHT THEN REMAINED LIT ANYTIME THE CAR WAS ON. A FEW WEEKS LATER, THE ESC OFF LIGHT BEGAN TO LIGHT UP WHILE DRIVING THE CAR. THE LIGHT WOULD COME ON WHILE THE CAR WAS IN MOTION AND WOULD NOT SHUT OFF/TURN ESC ON UNLESS THE CAR WAS STOPPED, TURNED OFF, AND THEN BACK ON. THE ISSUE HAS APPEARED SPORADICALLY, USUALLY WHEN ASSOCIATED WITH A TURN. IT HAS HAPPENED APPROXIMATELY 10 TIMES THUS FAR. *TR