2011 Hyundai Sonata
Problems, recalls and owner-reported issues
Steering is the leading concern among 3,376 owner complaints filed for this model year. This is the highest complaint count among 26 Sonata model years with reports.
Of the 2011 reports, 116 involved a crash and 112 involved a fire. 85 people were injured and 3 people died.
What owners report most often
Recalls and investigations
EngineDec 28, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Campaign 18V934000 on NHTSA.gov
Seat belts, pretensionerFeb 27, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.
If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.
Campaign 18V137000 on NHTSA.gov
Seat belts, pretensionerOct 4, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Campaign 17V617000 on NHTSA.gov
Seat belts, front, anchorageMar 8, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Campaign 17V152000 on NHTSA.gov
Steering, electric power assist systemApr 5, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured December 11, 2009, to October 31, 2010. In the affected vehicles, the Electronic Power Steering (EPS) circuit board may be damaged and result in a loss of power steering assist.
With a loss of power steering assist, extra steering effort will be required, especially at lower speeds, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the EPS control unit, free of charge. The recall began May 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 143.
Campaign 16V190000 on NHTSA.gov
Exterior lighting, brake lights, switchNov 16, 2015
Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.
If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Hyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.
Campaign 15V759000 on NHTSA.gov
Suspension, front, springs, coil springsOct 7, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011 Elantra vehicles manufactured November 12, 2010, to March 31, 2011, and Sonata vehicles manufactured December 11, 2009, to February 28, 2010, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the front coil springs, free of charge. Interim notifications were mailed on November 17, 2015. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 133. Note: Vehicles that were previously registered in salt belt states but are currently registered elsewhere are eligible to be inspected and repaired.
Campaign 15V629000 on NHTSA.gov
EngineSep 10, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.
Engine failure would result in a vehicle stall, increasing the risk of a crash.
Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.
Campaign 15V568000 on NHTSA.gov
Power train, automatic transmissionJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Campaign 14V434000 on NHTSA.gov
Service brakes, hydraulicJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured from December 11, 2009, through September 1, 2010. The affected vehicles may experience a brake fluid leak from the two brake lines that connect the brake system's master cylinder to the Hydraulic Electronic Control Unit (HECU) due to insufficient seal between the inner brake hose and metal brake line fitting.
If the brake lines leak brake sufficient fluid, the brake warning lamp in the instrument cluster will illuminate and longer stopping distance will be required, increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will replace the brake hoses with a revised service part, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 122.
Campaign 14V433000 on NHTSA.gov
Exterior lighting, brake lights, switchApr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Campaign 13V113000 on NHTSA.gov
Steering, gear box, shaft sectorOct 1, 2010
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. ON SOME OF THESE VEHICLES THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS MAY HAVE BEEN EITHER IMPROPERLY ASSEMBLED OR INSUFFICIENTLY TIGHTENED.
IMPROPER ASSEMBLY OR INSUFFICIENT TIGHTENING OF THE CONNECTIONS COULD RESULT IN A COMPLETE SEPARATION OR COMPROMISED ATTACHMENT OF THE CONNECTIONS, SUCH THAT THE DRIVER COULD EXPERIENCE A LOSS OF, OR REDUCTION IN, STEERING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS FOR PROPER ASSEMBLY AND TORQUE. IN ADDITION DEALERS WILL UPDATE THE POWER STEERING SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 11, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER SERVICE CENTER AT 1-787-999-3333.
Campaign 10V457000 on NHTSA.gov
Steering, gear box, shaft sectorSep 20, 2010
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. ON SOME OF THESE VEHICLES THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS MAY HAVE BEEN EITHER IMPROPERLY ASSEMBLED OR INSUFFICIENTLY TIGHTENED.
IMPROPER ASSEMBLY OR INSUFFICIENT TIGHTENING OF THE CONNECTIONS COULD RESULT IN A COMPLETE SEPARATION OR COMPROMISED ATTACHMENT OF THE CONNECTIONS, SUCH THAT THE DRIVER COULD EXPERIENCE A LOSS OF, OR REDUCTION IN, STEERING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS FOR PROPER ASSEMBLY AND TORQUE. IN ADDITION DEALERS WILL UPDATE THE POWER STEERING SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 10V426000 on NHTSA.gov
Latches/locks/linkages, doors, latchMar 2, 2010
HYUNDAI-KIA HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009 THROUGH FEBRUARY 15, 2010. THE FRONT INSIDE DOOR LOCK SWITCH CAN REMAIN IN THE UNLATCHED POSITION.
THE DOOR MAY NOT BE IN THE LOCKED POSITION AND MAY OPEN WHILE THE VEHICLE IS IN MOTION, POSSIBLY RESULTING IN INJURY TO THE DRIVER OR PASSENGER.
HYUNDAI-KIA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES BY REPLACING LATCHES AFFECTED BY THIS RECALL CAMPAIGN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 12, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 10V070000 on NHTSA.gov
Representative owner complaints
3,376 reports, newest first.
Service brakes, Nov 1, 2014
TL-THE CONTACT OWNS A 2011 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO OPERATE AND THE CONTACT WOULD HAVE TO DEPRESS THE BRAKE PEDAL FIRMLY TO STOP THE VEHICLE. THE CONTACT DISCOVERED THAT THE BRAKE FLUID WAS ALMOST EMPTY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V433000 (BRAKES). HOWEVER, THE FAILURE PERSISTED. THE DEALER DIAGNOSED THAT THE MASTER CYLINDER HAD FAILED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE. NE
Electrical system, Oct 28, 2014
I HAVE HAD SEVERAL OCCURRENCES WHERE IT FEELS AS IF MY CAR IS GOING TO STALL. I ATTEMPTED TO START MY CAR THIS MORNING WHERE IT FAILED TO RESPOND. THE STARTER WAS REPLACED IN 2012, THE BATTERY REPLACED 2013 AND NOW HYUNDAI CLAIMS IT IS MY STARTER LEVER THAT ALSO NEEDS TO BE REPLACED (2014). I HAVE READ NUMEROUS COMPLAINTS FROM OTHER HYUNDAI OWNERS COMPLAINING OF THE SAME ISSUE. NOW, I HAVE TO PAY OVER $300 TO HAVE THE STARTER LEVER REPLACED WHICH WILL NOW BE MY 3RD ISSUE SINCE I HAVE HAD THIS CAR. ALSO, I DID SUFFER FROM THE REAR BRAKE LIGHT ISSUE THAT WAS RECENTLY RECALLED AND HAVE HAD TO REPLACE MY BACK LIGHT SEVERAL TIMES BEFORE THE RECALL WAS INITIATED. DUE TO MY CONTINUATION OF BRAKE LIGHT ISSUES POST RECALL CHANGE, I AM TOLD THAT THE LAMP HAS MELTED DUE TO THE POSSIBILITY OF THE BULB OVERHEATING THE LAMP. I DO NOT SEE HOW ANY OF THESE ISSUES ARE MY FAULT AND BELIEVE THAT HYUNDAI SHOULD RECALL, AND REPLACE ALL OF THESE MALFUNCTIONS. *TR
Steering, Suspension, Exterior lighting, Oct 28, 2014
I WAS INFORMED BY SEVERAL CO-WORKERS THAT THERE WERE RECALLS FOR OUR CAR, THE 2011 HYUNDAI SONATA. THE PROBLEMS THAT ARE AFFECTING MY 2011 HYUNDAI SONATA ARE: EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCHES, BRAKE LIGHT AND STEERING: GEAR BOX: SHAFT SECTOR. THE ONLY RECALL THAT THE HYUNDAI DEALER HONORED WAS FROM CAMPAIGN 123. CAMPAIGN 110 AND 122 WILL NOT BE HONORED DUE TO THE MANUFACTURE DATE OF MY VEHICLE WHICH IS MARCH 28, 2011. IF MY CAR IS HAVING THE SAME PROBLEMS AS THE OTHER 2011 HYUNDAI SONATAS WHY CAN'T MY VEHICLE BE REPAIRED UNDER THE RECALL. I FEEL THAT THIS IS UNFAIR TO CONSUMERS OF THE 2011 HYUNDAI SONATA DUE TO A MANUFACTURING DATE. PLEASE GIVE ME SOME TYPE OF REMEDY FOR THIS MATTER!!! HAD I KNOWN ABOUT THE BUSINESS PRACTICES OF HYUNDAI I WOULD HAVE NEVER PURCHASED THIS VEHICLE!!! *TR
Engine, Oct 28, 2014
MY 2011 HYUNDAI SONATA LIKE MANY OF THE OTHER COMPLAINTS ON HERE HAS HAD CATASTROPHIC ENGINE FAILURE DUE TO A SNAPPED ROD. LIKE MANY OF YOU I HAVE KEPT UP WITH THE REGULAR MAINTENANCE SCHEDULE AND HAVE BEEN SHUT DOWN BY HYUNDAI FOR REPAIR UNDER THE 100,000 MILE WARRANTY. THIS PROBLEM IS A SERIOUS PUBLIC SAFETY CONCERN AS IT HAPPENS WHILE THE CAR IS IN MOTION AND MY QUESTION IS WHAT WILL IT TAKE FOR THE NHTSA TO TAKE ACTION AND FULLY INVESTIGATE THIS ISSUE AND BRING IT TO RECALL? WITH THE AMOUNT OF COMPLAINTS LISTED ON THE NHTSA WEBSITE FOR THIS EXACT ISSUE IT SEEMS LIKE THEY ARE WAITING FOR INJURY OR EVEN WORSE TO OCCUR BEFORE THIS ISSUE IS TAKEN SERIOUSLY. *TR
Steering, Oct 26, 2014
THE VEHICLE WAS MAKING A CLICKING NOISE EVERY TIME THE CAR IS STEERING IN EITHER DIRECTION. IT'S EVEN WORST IF IT IS DRIVE IN AN UNEVEN TERRAIN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION WHERE IT WAS DIAGNOSED THAT THE STEERING WHEEL COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BECAUSE IT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V457000 OR #10V426000. FOR BOTH CAMPAIGNS, THE LAST DATE OF MANUFACTURING IS 09/10/2010 AND MY VEHICLE WAS MANUFACTURED ON 10/18/2010. IN ADDITION, BUTTONS ON THE RIGHT SIDE OF THE STEERING WHEEL ARE NOT WORKING.THE APPROXIMATE FAILURE MILEAGE WAS 87,000. *TR
Engine, Oct 26, 2014
10/1/2014 @ 7:30PM EST - WHILE DRIVING HOME, WAS AT A RED LIGHT WHEN THE CAR STALLED OUT. THEN A LOUD KNOCKING SOUND HAPPENED. *NO ENGINE LIGHT WAS ON* IT IS VERY UNSAFE FOR THE ENGINE TO STALL OR JUST RANDOMLY SHUTOFF WHILE IN TRAFFIC. THERE WERE NO SIGNS OR WARNINGS, THE VEHICLE JUST STALLED. VEHICLE WAS NOT SAFE TO OPERATE. I HAD THE VEHICLE TOWED TO NORTHTOWNE HYUNDAI DEALER ON SHERIDAN DRIVE, BUFFALO NY.10/3/2014 @ 2:47PM EST - NORTHTOWNE HYUNDAI DEALER CALLED ME SAID THAT I NEED TO REPLACE MY ENGINE BECAUSE THE PISTON POPPED. I SAID WELL, MY CAR IS WELL WITHIN THE WARRANTY, ISN'T THIS COVERED? NORTHTOWNE HYUNDAI DEALER SAID THAT WE CAN'T SUBMIT YOUR WARRANTY CLAIM WITH OUT RECEIPTS OF YOUR MAINTENANCE FROM 5K MILES TO PRESENT. 10/3 - 10/13/2014 - CONTACTED OUR 3 LOCAL PLACES WE LIKE TO SEND OUR VEHICLES TO FOR COPIES OF OUR RECEIPTS. WITH NO PROBLEM WE WERE ABLE TO OBTAIN COPIES OF OUR LAST 7 OIL CHANGES AND GENERAL MAINTENANCE RECEIPTS. 10/14/2014 @ 2:00PM EST - MY HUSBAND GAVE NORTHTOWNE HYUNDAI DEALER OUR RECEIPTS AND HE STATED THAT HE WILL SUBMIT OUR CLAIM TO HYUNDAI. 10/24/2014 @ 8:59AM EST - "REGIONAL" / "CORPORATE" CALLED ME AND STATED "THE DISTRICT MANAGER WHO WOULD HAVE AUTHORIZED THE REPAIR, HAD THE DEALERSHIP PARTIALLY DISASSEMBLE THE ENGINE; TAKE OFF THE COVER FOR INSPECTION, AND THERE'S A CONDITION OF SLUDGE WHICH IS INDICATIVE OF EITHER THE MAINTENANCE INTERVALS NOT BEING FOLLOWED; OIL CHANGE NOT FREQUENTLY ENOUGH OR POSSIBLY THE QUALITY OR GRADE OF THE OIL USED. IN EITHER CASE THESE IS NOT A MANUFACTURE DEFECT, SO HE HAS DENIED WARRANTY COVERAGE." I'VE ALSO ADDED MY COMPLAINT TO THE FOLLOWING:[ HTTP://WWW.CHIMICLES.COM/2011-HYUNDAI-SONATA-ENGINE-FAILURE-CLASS-ACTION-LAWSUIT ] ** OUR LAST OIL CHANGE WAS 8/2/2014 AT 43K MILES ** WE HAD A CLEAN BILL OF HEALTH, NO ISSUES WERE REPORTED OR MAINTENANCE RECOMMENDED AT THAT TIME. *TR
Engine, Oct 25, 2014
I WAS DRIVING DOWN A 4 LANEROADWAY WHEN THE ENGINE STOPPED. I WAS ABLE TO COAST INTO A GAS STATION AND NOTICED A SMALL AMOUNT OF SMOKE COMING FROM THE ENGINE. HAD IT TOWED TO A DEALERSHIP AND 2 DAYS LATER THEY TOLD ME IT WAS A SEIZED ENGINE AND THAT IT WAS ONLY 1/2 QUART LOW. I FILED A CLAIM WITH MY EXTENDED WARRANTY SERVICE. THEY SENT AN INSPECTOR OUT AND HIS FINDING WERE IT WAS 2-3 QUARTS LOW AND CITED OWNER NEGLECT. WARRANTY SERVICE DENIED THE CLAIM. I USE ROYAL PURPLE SYNTHETIC OIL AND HAVE USED THIS SAME OIL FOR THE PAST 15 YEARS IN ALL MY VEHICLES. I HAD MY OIL CHANGED IN JULY..APPROXIMATELY 3 MONTHS PRIOR. *TR
Steering, Electronic stability control (ESC), Oct 24, 2014
DRIVING ON A BUSY STREET, TURNED DOWN A RESIDENTIAL STREET AND THE STEERING WHEEL STARTED SHAKING VIOLENTLY. WE HAVE OWN THE CAR SINCE JUNE, 2013 AND THIS HAS BEEN AN ONGOING PROBLEM. THE WILL BE A BEEP ,THEN THE EPS AND TRACTION CONTROL WILL SHOW ON THE DASH BOARD AND THEN THE STEERING WHEEL WILL START TO SHAKE VIOLENTLY. MY HUSBAND SHUT OFF THE VEHICLE AND IT VIOLENTLY SHAKE FOR 20 MINS. AT TIMES WHEN THIS PROBLEM OCCURRED IN THE PAST THE CAR WOULD BE ON BUT WE DID NOT EVEN LEAVE THE DRIVE WAY. THE FIRST TIME IT DID IT ME WAS 4 MONTHS AFTER PURCHASING THE VEHICLE AND I HAD MY CHILD IN THE BACK SEAT TAKING HER TO SCHOOL WHEN THE STEERING WHEEL STARTED SHAKING VIOLENTLY, I WAS IN THE MIDDLE OF A BUSY INTERSECTION AND I COULDN'T GET OUT BECAUSE I WAS NOT STRONG ENOUGH TO HANDLE THE STEERING WHEEL, AND WE ALMOST GOT HIT. EACH TIME (MORE THAN 5 TIMES NOW) WE WERE EITHER STOPPED OR GOING LESS THAN 25 MILES PER HOUR, THE EPS AND TRACTION WILL LIGHT, AND THE STEERING WHEEL WILL SHAKE VIOLENTLY ANYWHERE FROM 5 MINUTES TO 45 MINUTES. THERE WAS A TIME WHEN MY HUSBAND WAS DRIVING IN OUR SMALL TOWN WHEN THE EPS LIGHT WAS ON BUT MY HUSBAND HAD NO POWER STEERING. THE STEERING WHEEL DIDN'T SHAKE. *TR
Electrical system, Oct 24, 2014
PUSH START BUTTON FAILED TO WORK. *TR
Exterior lighting, Oct 22, 2014
WHILE I WAS DRIVING, AT ABOUT 40 MPH, ANOTHER DRIVER FLAG ME DOWN AND ASKED ME TO CHECK MY TAILLIGHT. I PARKED MY CAR ON THE SIDE, AND I NOTICED THAT THE WHOLE TAILLIGHT HAD FALLEN OFF THE CAR. IT WAS JUST HANGING FROM THE WIRES. UPON INSPECTION I NOTICED THAT THE PLASTIC STUDS HOLDING THE TAILLIGHT HAD BROKEN OFF. LOTS OF SMALL PLASTIC PIECES ALL OVER. GLAD I WASN'T ON THE FREEWAY, BECAUSE IT WOULD HAD CAUSED AN ACCIDENT IF IT WOULD HAD FALLEN OFF THE CAR. THE TAILLIGHT SHOWS NO SIGNS OF ANY IMPACT AT ALL IT IS CLEAN. *TR
Steering, Exterior lighting, Service brakes, Oct 22, 2014
HAVE REPLACED BRAKE LIGHTS 5 TIMES DUE TO SOMEOME TELLING ME THEY WERE OUT. WAS STOP BY A COP TODAY BECAUSE BOTH BRAKE LIGHTS HE SAID WE'RE OUT. WHY ARE THESE LIGHTS BURNING OUT SO FAST? AUTOMOTIVE GUY SAID PUT SOME GREASE ON BULB THEN PLACE THEM IN. I DID AND THEY STILL WENT OUT? *TR
Steering, Oct 20, 2014
STEERING WHEEL DEVELOPED NOISE WITH TURNING AND MORE FREE-PLAY IN STEERING WHEEL. I TOOK CAR TO DEALER WHO REPLACED COUPLING SEAL. ACCORDING TO DEALER, THIS HAS BEEN A COMMON PROBLEM THAT CAN LEAD TO SIGNIFICANT STEERING PROBLEMS. *TR
Steering, Oct 20, 2014
I HAVE NOTICED A CLICK OR SLIGHT KNOCK COMING FROM THE STEERING WHEN TURNING WHEEL LEFT OR RIGHT AT LOW SPEEDS, ESPECIALLY WHEN PARKING. OVER UNEVEN SURFACES THERE IS SHAKING OR SHUTTER IN THE STEERING COLUMN ALSO. THESE CONDITIONS SEEM TO BE WORSENING. I WILL BE SCHEDULING FOR SERVICE. *TR
Steering, Oct 19, 2014
THERE IS SOMETHING GOING ON WITH THE STEERING WHEEL OR COLUMN THERE IS LOUD POPPING NOISE IN STEERING WHEEL YOU CAN HEAR IT IN AND OUTSIDE OF CAR. WHEN YOU TURN LEFT OR RIGHT. I HAVE NOT HAD IT INSPECT END YET JUST BOUGHT VEHICLE HAVEN'T HAD IT A YEAR AND HAVE HAD SEVERAL REPAIRS SO FAR. *TR
Engine, Oct 19, 2014
WHILE AT A RED LIGHT ON HIGHWAY 45 IN WHISTLER ALABAMA CAR JUST CUT OFF AND WOULD NOT CRANK BACK UP, POLICE HAD TO COME AND STOP TRAFFIC AND PUSH CAR OUT OF THE HIGHWAY SO IT WOULDN'T BE AN ACCIDENT BECAUSE IT WAS NEAR THE INTERSTATE EXITS TO HIGHWAY 45. *TR
Steering, Oct 17, 2014
STEERING COLUMN BUSHING BECOMES FRAYED AND CHIPS/BREAKS CAUSE LOUD POPPING/CLUNKING NOISE GOING OVER UNEVEN PAYMENT AND LOOSE STEERING CONDITIONS. I AM TOLD THIS WOULD ULTIMATELY CAUSE FAILED STEERING ABILITY. MANY REPORTS OF EXACTLY SAME ISSUE ARE BEING POSTED ON HYUNDAI FORUMS. *TR
Latches/locks/linkages, Oct 16, 2014
TL* THE CONTACT OWNS A 2011 HYUNDAI SONATA. THE CONTACT STATED THAT THE REAR PASSENGER SIDE DOOR FAILED TO LOCK. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE DOOR LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
Steering, Oct 13, 2014
THE STEERING WHEEL FEELS LIKE THERE IS SIGNIFICANT BACKLASH WHEN MOVING IT FROM LEFT TO RIGHT (ESPECIALLY AT LOW SPEEDS). THIS IS ALSO ASSOCIATED WITH A CLICKING SOUND. IN ADDITION, WHEN HITTING A BUMP IN THE ROAD, IT SOUNDS LIKE SOMETHING HAS COME LOOSE IN THE STEERING COLUMN. I AM TAKING THE VEHICLE IN FOR SERVICE ON OCTOBER 16 TO INVESTIGATE. *TR
Engine, Oct 8, 2014
I WAS DRIVING MY 2011 HYUNDAI SONATA ON A MOUNTAIN ROAD 10/4/2014 WHEN IT STARTED TO MAKE A CLICKING SOUND COMING FROM THE ENGINE. BEFORE I EVEN HAD THE CHANCE TO PULL OVER ALL OF MY SENSORS WENT OF THE ENGINE COMPLETELY DIED INCLUDING POWER BRAKES AND STEERING. HUGE SAFETY CONCERN AS I WAS DRIVING ON A WINDING MOUNTAIN ROAD. DEALERSHIP IS TELLING ME I HAVE TO REPLACE MY ENGINE AND BECAUSE I'M THE SECOND OWNER THE 100,000 MILE WARRANTY DOESN'T APPLY TO ME. THIS VEHICLE NEEDS TO BE RECALLED FOR THIS HUGE MANUFACTURING AND OVERLY DANGEROUS FLAW. *TR
Steering, Oct 8, 2014
TL* THE CONTACT OWNS A 2011 HYUNDAI SONATA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL WHEN DRIVING OR MAKING A TURN. THE NOISE WAS HEARD AT VARIOUS SPEEDS. THE DEALER STATED THAT THE STEERING WHEEL ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V457000 (STEERING). THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.
Engine, Oct 6, 2014
I WAS DRIVING DOWN THE HIGHWAY AND THE CAR STALLED. I COASTED INTO AN EMPTY PARKING LOT AND TURNED IT OFF. WHEN I TRIED TO RESTART IT, I HEARD ONE CLICK AND THEN NOTHING. THERE WAS NO EVIDENCE THAT ANYTHING WAS WRONG, NO WARNING LIGHTS, NO WEIRD NOISES, NOTHING. I HAD THE CAR TOWED THE FOLLOWING MORNING AND WAS TOLD BY THE REPAIR SHOP THAT THE ENGINE SEIZED UP. I FAITHFULLY HAVE MY OIL CHANGED AND THERE WAS NO INDICATION THAT THE OIL WAS LOW. *TR
Engine, Oct 2, 2014, fire
TL* THE CONTACT OWNS A 2011 HYUNDAI SONATA. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND SMOKE APPEARED FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
Fuel/propulsion system, Oct 1, 2014
FUEL GAUGE IS NOT WORKING PROPERLY. WHEN GAS IS FILLED, IT DISPLAY THE FULL TANK GAUGE. BUT AFTER ~ 100 MILE DRIVE, THE FUEL GAUGE DROPS TO EMPTY TANK WITH ALARM SIGN. AT FIRST IT HAPPENED VERY RARELY, BUT NOW (69000 MILE), EVERY TIME THE FUEL GAUGE DROPS TO EMPTY TANK ONCE IT IS DRIVE >100 MILE AFTER FULL TANK. *TR
Tires, Wheels, Sep 30, 2014
I OWN A 2011 HYUNDAI SONATA LIMITED 2.0T WHICH CAME EQUIPPED WITH HANKOOK OPTIMO H431 TIRES, SIZE 225/45R18V. AT APPROXIMATELY 41000 MILES (AUGUST 2014) I NOTICED A BULGE/BUBBLE ON THE SIDEWALL OF THE RIGHT FRONT TIRE. UPON VISITING A LOCAL TIRE SHOP TO DETERMINE HOW BAD THE PROBLEM WAS, THE TECHNICIAN REMOVED THE TIRE AND ADVISED ME THAT THERE WERE 5 SEPARATE BUBBLES IN THE TIRE AND IT WAS NOT SAFE TO DRIVE. I BROUGHT THE CAR TO THE DEALERSHIP & WAS TOLD THE ISSUE WAS NOT COVERED UNDER ANY WARRANTY AND I HAD TO PURCHASE A NEW TIRE FOR $275. TWO DAYS AGO I WAS WALKING AROUND THE CAR AND I'VE NOTICED A BUBBLE ON THE SIDEWALL OF THE LEFT FRONT TIRE NOW. I DRIVE PRIMARILY ON THE HIGHWAY AND KEEP MY TIRES PROPERLY INFLATED AT ALL TIMES. THERE WERE/ARE NO ABRASIONS, SCUFFS OR CUTS ON THE SIDE OF THE TIRE AT THE SIGHT OF THE BUBBLES. THEY HAVE BEEN LOCATED BOTH IN THE INNER & OUTER SIDEWALLS. *TR
Steering, Sep 29, 2014
TL* THE CONTACT OWNS A 2011 HYUNDAI SONATA. WHILE DRIVING VARIOUS SPEEDS OVER BUMPY ROADS, THE STEERING WHEEL BECAME LOSE AND THERE WAS A CONSISTENT CLICKING NOISE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,500.