2011 Hyundai Sonata
Problems, recalls and owner-reported issues
Steering is the leading concern among 3,376 owner complaints filed for this model year. This is the highest complaint count among 26 Sonata model years with reports.
Of the 2011 reports, 116 involved a crash and 112 involved a fire. 85 people were injured and 3 people died.
What owners report most often
Recalls and investigations
EngineDec 28, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.
Campaign 18V934000 on NHTSA.gov
Seat belts, pretensionerFeb 27, 2018
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.
If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.
Campaign 18V137000 on NHTSA.gov
Seat belts, pretensionerOct 4, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Campaign 17V617000 on NHTSA.gov
Seat belts, front, anchorageMar 8, 2017
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Campaign 17V152000 on NHTSA.gov
Steering, electric power assist systemApr 5, 2016
Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured December 11, 2009, to October 31, 2010. In the affected vehicles, the Electronic Power Steering (EPS) circuit board may be damaged and result in a loss of power steering assist.
With a loss of power steering assist, extra steering effort will be required, especially at lower speeds, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the EPS control unit, free of charge. The recall began May 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 143.
Campaign 16V190000 on NHTSA.gov
Exterior lighting, brake lights, switchNov 16, 2015
Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.
If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Hyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.
Campaign 15V759000 on NHTSA.gov
Suspension, front, springs, coil springsOct 7, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011 Elantra vehicles manufactured November 12, 2010, to March 31, 2011, and Sonata vehicles manufactured December 11, 2009, to February 28, 2010, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Hyundai will notify owners, and dealers will replace the front coil springs, free of charge. Interim notifications were mailed on November 17, 2015. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 133. Note: Vehicles that were previously registered in salt belt states but are currently registered elsewhere are eligible to be inspected and repaired.
Campaign 15V629000 on NHTSA.gov
EngineSep 10, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.
Engine failure would result in a vehicle stall, increasing the risk of a crash.
Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.
Campaign 15V568000 on NHTSA.gov
Power train, automatic transmissionJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.
If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.
Campaign 14V434000 on NHTSA.gov
Service brakes, hydraulicJul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured from December 11, 2009, through September 1, 2010. The affected vehicles may experience a brake fluid leak from the two brake lines that connect the brake system's master cylinder to the Hydraulic Electronic Control Unit (HECU) due to insufficient seal between the inner brake hose and metal brake line fitting.
If the brake lines leak brake sufficient fluid, the brake warning lamp in the instrument cluster will illuminate and longer stopping distance will be required, increasing the risk of a vehicle crash.
Hyundai will notify owners, and dealers will replace the brake hoses with a revised service part, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 122.
Campaign 14V433000 on NHTSA.gov
Exterior lighting, brake lights, switchApr 1, 2013
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Campaign 13V113000 on NHTSA.gov
Steering, gear box, shaft sectorOct 1, 2010
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. ON SOME OF THESE VEHICLES THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS MAY HAVE BEEN EITHER IMPROPERLY ASSEMBLED OR INSUFFICIENTLY TIGHTENED.
IMPROPER ASSEMBLY OR INSUFFICIENT TIGHTENING OF THE CONNECTIONS COULD RESULT IN A COMPLETE SEPARATION OR COMPROMISED ATTACHMENT OF THE CONNECTIONS, SUCH THAT THE DRIVER COULD EXPERIENCE A LOSS OF, OR REDUCTION IN, STEERING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS FOR PROPER ASSEMBLY AND TORQUE. IN ADDITION DEALERS WILL UPDATE THE POWER STEERING SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 11, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER SERVICE CENTER AT 1-787-999-3333.
Campaign 10V457000 on NHTSA.gov
Steering, gear box, shaft sectorSep 20, 2010
HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. ON SOME OF THESE VEHICLES THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS MAY HAVE BEEN EITHER IMPROPERLY ASSEMBLED OR INSUFFICIENTLY TIGHTENED.
IMPROPER ASSEMBLY OR INSUFFICIENT TIGHTENING OF THE CONNECTIONS COULD RESULT IN A COMPLETE SEPARATION OR COMPROMISED ATTACHMENT OF THE CONNECTIONS, SUCH THAT THE DRIVER COULD EXPERIENCE A LOSS OF, OR REDUCTION IN, STEERING CAPABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE STEERING COLUMN INTERMEDIATE SHAFT UNIVERSAL JOINT CONNECTIONS FOR PROPER ASSEMBLY AND TORQUE. IN ADDITION DEALERS WILL UPDATE THE POWER STEERING SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 10V426000 on NHTSA.gov
Latches/locks/linkages, doors, latchMar 2, 2010
HYUNDAI-KIA HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009 THROUGH FEBRUARY 15, 2010. THE FRONT INSIDE DOOR LOCK SWITCH CAN REMAIN IN THE UNLATCHED POSITION.
THE DOOR MAY NOT BE IN THE LOCKED POSITION AND MAY OPEN WHILE THE VEHICLE IS IN MOTION, POSSIBLY RESULTING IN INJURY TO THE DRIVER OR PASSENGER.
HYUNDAI-KIA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES BY REPLACING LATCHES AFFECTED BY THIS RECALL CAMPAIGN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 12, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Campaign 10V070000 on NHTSA.gov
Representative owner complaints
3,376 reports, newest first.
Engine, Sep 11, 2024
Oil keeps drying out and keep smelling antifreeze
Air bags, Aug 9, 2024
Dashboard cracked passenger seat around airbag word. Before weather got very hot outside was sitting in parking lot engine off, heard a loud noise and was not able to locate anything wrong. Thought it was the windshield that has a small crack in it. Noticed nothing. Several days later saw large lines through windshield around airbag. Looked inside car to see better. Several weeks later saw smaller crack on driver side dash nearest to door area. Did have oil changed on car on 4-19-24. This happened weeks later (the cracks). Did notify repair shop (auto dealer Priority) of issue. Next appt was 5-18-24 for new tires to be put on car.
Other or unspecified, Engine, Jul 31, 2024
On July 19 I started my car and there was a loud knocking noise coming from underneath my hood when I lifted the hood the knocking sound was coming from my engine I’ve had this car for 3 years never had any problems or issues at all with my car not sure what’s going on or if there are any recalls on parts for my car
Electrical system, Jul 23, 2024, fire
On [XXX], I smelled a chemical burning smell. We searched the house for about 5 minutes and finally went to the garage. As my husband opened the garage door he said the car is on fire. I looked and smoke was pouring out of the inside. He ran, opened the door and flames came bursting out. He immediately took off to get the fire extinquisher from the kitchen and I called 911. The fire department came and put the flames out. Upon inspection, the dashboard had a fire and the extreme heat had melted the entire dash. The fire chief and my husband were trying to figure out what had happened. The car was not running at the time. A little earlier, my husband had an air compressor plugged into the cigarette lighter. When he finished filling a tire, he unplugged the compressor, put the compressor in the car on the floor and turned the car off. Then later, as I described there was a fire. My husband and the fire chief inspected the engine which had no damage. The were specifically looking for the fuses. All fuses were in tact. In researching I discovered the the Hyundai Sonata had issues and new about the problems. We purchased the car in March and were not aware of any recalls, nor were the previous owners. I have spent the last 6 weeks in communication with Hyundai who led me on a wild goose chase and has refused to take responsibility for the fire. The are trying to blame in on the compressor which was not even plugged in. I was made aware of several class action law suits, but have not been able to find any information. I have kept all communication with Hyundai and have requested the recorded phone conversations also. The car is still in my driveway. Obviously all the electrical is destroyed and not fixable. I was trying to avoid lawyers and just get Hyundai to own up to the problem and take responsibility to pay what I paid for the car. I can get copies of all email communication. I attached the final email received yesterday. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Jul 16, 2024
My car when turned off locks but when turned back on will stay locked. Normally you can turn the car on and off a couple times and it will unlock itself but for the past couple months it is now impossible and is so unsafe to drive. I saw in 2009/2010 there was a recall for this with Hyundai and I’m pretty sure my car is now affected with the same thing but 2011 Hyundai sonata.
Power train, Jul 15, 2024
The gear shift on its own jumps from automatic to manual mode
Engine, Jun 16, 2024
The car has throw a rod in the engine. The safety of my dog and I was okay. And the safety of other drivers were good also. Yes it was inspected and there were no lights on when the car went down.
Tires, Jun 4, 2024
P205 65 R16 Blizzak tires were purchased in December 2023, online and I had them installed same week. I spoke to the employee who stated as long as I rotated the tires at 5,000 miles, I can drive them all year. I went to Discount tires on Saturday to have my tires checked since I was sliding in the rain. The employee told me my front tires were at a 1 and 2, while the back tires are at 9 and 10. She told me to talk to the front desk about the tires. I went in and asked about the warranty I had purchased. The employee told me it does not apply and that I would need to replace the tires. I explained to him that the car doesn't even have 5,000 miles on it since the purchase of the tires and how did the front wear so quickly? I only started using the car more in March. He also told me it could be the alignment. I had that fixed 2 years ago and the car doesnt pull left or right. He stated that the tires will bald if being driven in over 40 degree temps. I have in the past used winter tires all year and never experienced this. These tires never made it to 5,000 miles. They should not be worn so badly in the front, that this had now cause my back breaks to grind. Not only do I have to buy 4 new tires, since I can't keep the back on there, but I have to eventually get new back brakes, that aren't even 2 years old. These tires should not be on anyone's cars if they wear this quickly.
Engine, May 29, 2024
The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound and while attempting to turn, the vehicle hesitated. The vehicle was restarted but made the abnormal sound and stalled. The contact smelled smoke upon veering to the shoulder of the roadway. The contact exited the vehicle and discovered a liquid substance coming from the under carriage. The vehicle was towed to an independent mechanic and the contact was informed that the engine was cracked, and the contact was informed to take the vehicle to the dealer for service. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 174,000.
Other or unspecified, May 19, 2024
My vehicle dash board has started cracking in several locations. Causing a risk to my safety, having the potential of breaking up in the event of a crash casing the dash board to break up and shatter that would cause injury to my passenger and myself. I have seen on the internet where Hyundai has a recall on this, but I was not contracted about this and wound like this matter review please thanks
Structure, Other or unspecified, Engine, May 13, 2024, fire
Driving from home to a shopping center, approximately 25 miles, I did not observe any unusual noises nor smoke nor dashboard warning lights. Once I parked and shut off the engine in the shopping center parking lot, I observed a small amount of thick, white smoke coming from the hood on the front passenger side of my car, and then the smoke abruptly stopped. I was concerned enough that I decided I should probably move my car to a parking space a bit further away from the store I planned to go into in order to be further away from other vehicles. I started the engine again, and once again, no smoke nor unusual noises nor warning lights. I drove around to the next parking aisle and parked in a different parking space. Once I turned off the engine again, the smoke then immediately started from the right side of the hood again and quickly smoke started coming from the left side of the hood. I was quickly trying to grab my things to get out of the car as I saw the paint starting to peel off of the hood of my car. I was barely able to get out of my car as fire flames and very thick white smoke were then emerging from the hood. A person in the parking lot called 911 for me, and the local fire department arrived and put the fire out that destroyed my car. I am in the process of securing the Fire Marshall's lengthy report. At the present time, my vehicle is at our home where we paid to have it towed.
Air bags, May 12, 2024
I started my car and my steering wheel airbag deployed within a few seconds and injured me. Reason for deployment unknown
Service brakes, Hydraulic, Engine, May 10, 2024
The contact owns a 2011 Hyundai Sonata. The contact stated that while her daughter was driving at approximately 80 MPH, the brake pedal was depressed but was stiff and difficult to depress. The contact stated that her daughter accelerated to steer the vehicle away from slower traffic. The contact stated that her daughter depressed the accelerator pedal however, the vehicle failed to respond and started losing motive power. The contact stated that her daughter was able to steer the vehicle to the side of the road and stop the vehicle. The contact stated that the check engine check brake and several other unknown warning lights were illuminated. The contact had the vehicle towed to an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 120,000.
Other or unspecified, May 3, 2024
My dash board is cracking and the Hyundai dealership don’t seem to think it’s a safety recall. And I found this information, saying this sonatas due to defective materials used for the dashboard that may cause it to crack and form sharp edges, potentially causing injury during an accident. The recall affects over 220,000 vehicles and requires dealers to replace the dashboard in affected models for free. I would like you to look into and see if it’s was a recall please,
Engine, May 2, 2024
My vehicle has the flashing engine light on. The code that comes up is the P1326, causing it to go into “limp mode” making it unsafe to drive. My local Hyundai dealership in Vandalia, Ohio and they only reset the code, giving me the impression they actually FIXED the issue. Five days later, it is doing the same thing. I have asked multiple times for a loaner vehicle while they work on mine, I have been told that is not possible due to the fact they have not found out if my vehicle has a warranted covered issue. I had the engine replaced before in 2019, now I’m having more issues. More assistance should be provided
Steering, Electrical system, May 1, 2024
The contact owns a 2011 Hyundai Sonata. The contact stated that the steering wheel was making an abnormal rattling sound. While making a turn, the steering wheel seized. The contact stated that the horn became inoperable and the buttons on the steering wheel became inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 17,742.
Engine, Apr 25, 2024
The engine locked up on the highway My daughter got over to the breakdown lane . We had it towed to a garage and was told the engine locked up — we called Hyundai and got the run around. So we moved on and paid for an engine and got it installed . Then I have been reaching out to see if we could get some type of reimbursement for motor and labor ( something — 91,000 miles when it locked up engine no good) But know I finally got through to a few different people and now they are telling me , because we didn’t go to a Hyundai dealer they won’t do anything. We bought a engine that was from Hyundai [XXX] And my first claim # from you is 11566045 this is HORRIBLE JUST LOOK FOR SOME HELP ON THIS THANKS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Apr 21, 2024, fire
Not sure what component is responsible but the car caught fire while driving on [XXX]. Started smoking and then shut off. Limped car to the shoulder and got out. Saw from underneath that it was on fire and called 911. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Engine, Apr 10, 2024
Prior to my trip I checked all fluids, and all was good levels. Car was traveling on improved interstate at posted highway speed. As I was passing another vehicle my vehicle lost power and I was forced to cross lanes in traffic to get to shoulder. There were no prior warnings or lights before my vehicle lost power. I opened my hood and saw the radiator coolant boiling over in reservoir and the top hose was collapsed. Had the vehicle towed home. I checked and replaced the thermostat however found that the engine would not turn over and the starter failed.
Air bags, Engine, Apr 10, 2024, fire
Engine seized at 82000 miles stranding me in the passing lane of Interstate 10. Was nearly hit by a truck.
Engine, Mar 31, 2024
Hyundai Theta II engine has known defects with excessive engine oil consumption. Numerous consumers have complained of this issue as it appears widespread to the entire line of Theta II engines. A recent class action has limited the scope of the recall but an easy search can see it impacts (or has the potential to impact) nearly all Theta II (six gen) engines from Hyundai. The issue is that the scope of the recall needs to be widened to cover others who are impacted who currently have no recourse. Many are facing the same situation, which can easily be found with a brief search online. [XXX] At this time the issue is the car stalling at unknown times, fire from oil being displaced in other areas and various other issues due to improper and unusual oil consumption. The best situation would be to force Hyundai to review and expand the scope of their recall immediately. I found that I had excessive oil consumption which was causing my car to grind and shift heavily sometimes jerking on the highway. While I didn't crash, that possibility did exist when my car continually grinded heavy between shifting. I took my car to the dealer where they confirmed this issue. However, Hyundai declined to remediate. There are no warning lights and this could easily result in a crash, or fire. Hyundai has records of my maintenance, as my car is only serviced by the dealership where the car was purchased and I am the original owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Fuel system, Gasoline, Mar 25, 2024
The contact owns a 2011 Hyundai Sonata. The contact was informed of NHTSA Campaign Number: 15V568000 (Engine), and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the knock sensor detection system (KSDS) software update and the recall repair had already been performed on the vehicle. The contact stated that a failure related to the recall recurred while driving. The contact stated while driving approximately 60 MPH, the vehicle stalled. No warning light was illuminated. The contact was able to get the vehicle to the shoulder of the highway. The vehicle was towed to the residence, where the contact was able to drive the vehicle again; however, the failure recurred several times. The vehicle was taken to the dealer, where it was diagnosed with a fuel pump failure, and an oil leak. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 150,000.
Vehicle speed control, Engine, Fuel/propulsion system, Mar 19, 2024
I changed my oil on Saturday and it now has no oil. The engine light started flashing and my engine seized up. Now it does not run at all. It turns on halfway where the dashboard turns on but the motor/engine does not turn. It appears to be white smoke coming out of the car after trying to turn it back on.
Fuel system, Gasoline, Mar 19, 2024
The contact owns a 2011 Hyundai Sonata. The contact stated that the vehicle failed to start, and the low fuel light was illuminated. The contact stated that the alternator was replaced prior to the failure. The vehicle was refueled by a tow truck driver. The contact stated that after several days, the vehicle drove as needed; however, the failure reoccurred at a drive-thru. The vehicle was towed to a nearby hotel. The low fuel warning light was illuminated. The vehicle was then towed to the dealer, where it was purchased. The dealer diagnosed the vehicle and determined that the fuel pump had failed and needed to be replaced. The vehicle was repaired; however, the failure reoccurred a week later. The contact stated that while driving at approximately 40 MPH, there was fuel leaking out of the fuel pump gasket. The vehicle was taken back to the dealer where the fuel pump was replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.
Engine, Mar 18, 2024
Vehicle stalled while driving