2002 Jeep Grand Cherokee
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,476 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Grand Cherokee model years with reports.
Of the 2002 reports, 75 involved a crash and 20 involved a fire. 97 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Air bags, frontalJan 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.
Campaign 15V046000 on NHTSA.gov
Air bagsNov 8, 2012
Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.
Campaign 12V527000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Seats, front assembly, seat heater/coolerApr 9, 2009
CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.
OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.
DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 09V117000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Engine and engine cooling, cooling system, fanJun 8, 2006
ON CERTAIN SPORT UTILITY VEHICLES, THE PLASTIC BLADES OF THE ELECTRIC MOTOR DRIVEN COOLING FAN MAY SEPARATE AND PENETRATE THE SHROUD.
IF THIS OCCURS WHILE THE HOOD IS OPEN, A PERSON IN THE VICINITY OF THE ENGINE COULD BE STRUCK BY THE BLADE AND INJURED.
DEALERS WILL REPLACE THE ELECTRIC COOLING FAN MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 4, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 06V199000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Service brakes, hydraulicMar 13, 2006
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Campaign 06E022000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 1, 2006
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.
Campaign 06E011000 on NHTSA.gov
Fuel system, gasoline, fuel injection system, injectorsApr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
THIS COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V104000 on NHTSA.gov
Air bags, frontalMar 26, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER AIR BAG WIRING HARNESS WAS IMPROPERLY MANUFACTURED.
THIS COULD CAUSE IMPROPER AIR BAG DEPLOYMENT IN CERTAIN CRASH CONDITIONS.
DEALERS WILL ADD A WIRING JUMPER TO THE EXISTING CIRCUITRY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V099000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJan 31, 2002
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A FUEL TANK BRUSH GUARD FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) CONTROL VALVE CAN BECOME DETACHED DURING A CRASH, ALLOWING FUEL LEAKAGE.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DEALERS WILL EITHER REPLACE THE FUEL TANK BRUSH GUARD WITH A SKID PLATE OR REINFORCE THE EXISTING FUEL TANK BRUSH GUARD WITH A REINFORCEMENT BRACKET. OWNER NOTIFICATION WILL BEGIN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V032000 on NHTSA.gov
Fuel system, gasoline, deliveryDec 5, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL INLET CHECK VALVE COULD STICK IN THE PARTIALLY OPEN POSITION. THIS CONDITION COULD CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE DURING REFUELING.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE FUEL INLET CHECK VALVE. VEHICLES FOUND TO HAVE A STICKING FUEL INLET CHECK VALVE WILL HAVE THE FUEL TANK ASSEMBLY REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V374000 on NHTSA.gov
Engine and engine cooling, exhaust system, emission controlNov 13, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ONBOARD VAPOR RECOVERY SYSTEM VENT HOSE MAY HAVE BEEN MISROUTED. THIS COULD ALLOW WATER TO ENTER THE CANISTER WHICH CAN CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE WHEN REFUELING THE TANK.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT (AND REPOSITION AS NECESSARY) THE VENT HOSE. IF THE VENT HOSE IS FOUND IN THE BENT DOWN POSITION, AND THE VEHICLE HAS BEEN DRIVEN MORE THAN 20 MILES, THE CANISTER ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V348000 on NHTSA.gov
Electrical system, wiring, interior/under dashSep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V288000 on NHTSA.gov
Representative owner complaints: visibility
326 reports, newest first. Show all
Visibility, Dec 7, 2006
DEFECTIVE HVAC BLEND DOORS ON JEEP GRAND CHEROKEES FROM 99-04. UNDER NORMAL USE THESE BLEND DOORS FAIL AND REQUIRE A $1800 FIX THAT REQUIRES TOTAL DISASSEMBLY OF THE INTERIOR OF THE VEHICLE BY A TRAINED DEALER MECHANIC. IN ORDER TO HAVE ADEQUATE HEAT AND COOLING IN MY VEHICLE I HAD TO PAY TO GET IT FIXED. *NM
Visibility, Dec 6, 2006
UNDER NORMAL USE OF MY 2002 GRAND CHEROKEE OVERLAND, THE AUTOMATIC CLIMATE CONTROLS SYSTEM HAS STARTED TO NOT WORK PROPERLY. THE PROBLEM IS THAT WHEN THE HEAT IS ON, COLD AIR WILL BLOW ON THE PASSENGER SIDE AND THE FRONT DEFROST WILL NOT WORK PROPERLY EITHER. I HAVE NOT FIXED THE FAILURE YET BECAUSE THE REPAIRS COST OVER $800 AND I CAN'T AFFORD IT. *NM
Visibility, Dec 6, 2006
THE DEFROSTER/DEFOGGER SYSTEM HAS FAILED PREVENTING WARM AIR FROM CIRCULATING TO THE DEFROST DUCTS MAKING IT UN-SAFE AND IN-OPERABLE TO DRIVE THIS VEHICLE IN WEATHER THAT WOULD REQUIRE THE DEFROSTER/DEFOGGER SYSTEM. NM
Visibility, Dec 6, 2006
DT*: THE CONTACT STATED WHILE DEPRESSING THE AUTOMATIC POWER WINDOW CONTROL FOR THE FRONT PASSENGER SIDE WINDOW, IT FAILED TO OPERATE, AND WOULD NOT ROLL DOWN. TWO WEEKS LATER, THE FRONT DRIVER SIDE WINDOW FAILED TO OPERATE AS WELL IN THE SAME FASHION. THE DEALER WAS ALERTED. UPDATED 2/12/2007 - *NM
Visibility, Dec 6, 2006
ON OCTOBER 13 2006, PASSENGER SIDE WINDOW STOPPED FUNCTIONING, ON DECEMBER 4 2006, DRIVER SIDE WINDOW STOPPED FUNCTIONING, IT WAS A LOUD POP AND THE WINDOW STOPPED WORKING AND WOULD SLIDE DOWN BY ITSELF. *JB
Visibility, Other or unspecified, Dec 5, 2006
HEATER NO LONGER WORKING.. DEALER FOUND TO BE "FAULTY BLEND DOOR" AND "RECIR DOOR". THE ISSUE CAUSES WINDOWS TO FOG MAKING IT DIFFICULT TO SEE WHILE DRIVING. I WAS QUOTED $1200-1600 TO HAVE REPAIRED AT DEALER.. IT'S TOO EXPENSIVE AS I'M ON A VERY LIMITED BUDGET... BUT VERY CONCERNED ABOUT THE SAFETY OF THIS VEHICLE*JB
Visibility, Dec 5, 2006
FAILED HVAC BLENDER DOORS HAVE CAUSED VEHICLE TO LOSE HEAT FUNCTIONALITY. THIS IS CAUSING THE CAR TO BE UNABLE TO DEFROST SO DURING POOR WEATHER CONDITIONS THE VEHICLE IS UNUSABLE. *NM
Visibility, Dec 4, 2006
WITHOUT ANY WARNING AND BEFORE I KNEW OF ITS COMMONALITY I NOTICED MY DEFROSTER NOT ABLE TO KEEP UP AND THEN I HAD NO HEAT FROM ANY VENTS..BLEND DOOR FAILURE IN 2002 JEEP GRAND CHEROKEE, NO HEAT AT ALL OUT OF ANY VENTS, TERRIBLE DEFROSTER FUNCTION, VERY DIFFICULT TO GAIN VISIBILITY IN ANY INCLEMENT WEATHER... I REPAIRED IT MYSELF TO A COST OF $300 OR SO AND AROUND TEN HOURS LABOR, ALL WITH OEM CHRYSLER PARTS, THEN ONE YEAR LATER ANOTHER FAILURE OF THE SAME PARTS.... *JB
Visibility, Dec 4, 2006
BLEND DOOR IN THE VENTILATION SYSTEM FAILED AFTER ONLY 40K MILES, CAUSING COLD AIR TO BLOW THROUGH THE VENTS ON THE PASSENGER SIDE, EVEN WHEN THE HEAT WAS ON. COST OF REPAIR WAS ~ $900 PARTS AND LABOR. *JB
Visibility, Dec 3, 2006
POWER WINDOW REGULATORS HAVE FAILED ON ALL FOUR WINDOWS ON MY 2002 JEEP GRAND CHEROKEE. I KNOW THAT I AM NOT THE ONLY ONE WITH THIS PROBLEM, AND IF ENOUGH PEOPLE HAVE BEEN AFFECTED, HOPEFULLY NHTSA WILL PRESSURE THE MANUFACTURER INTO RECALLING THESE VEHICLES. *JB
Visibility, Other or unspecified, Dec 2, 2006
MY JEEP GRAND CHEROKEE HAS A BAD VENTILATION SYSTEM. THIS IS A MANUFACTURING DEFECT WHICH AFFECTS ALL JEEP GRAND CHEROKEE'S MANUFACTURED WITH AUTO CLIMATE CONTROLS FROM 1999-2004. I HAVE HAD TO BRING MINE IN FOR REPAIR TWICE NOW, AND IT HAS ONCE AGAIN FAILED. THE LEVERS IN THE VENTILATION DUCTS HAVE PLASTIC COMPONENTS WHICH, OVER TIME, BREAK DOWN AND CRACK CAUSING COLD-ONLY OR HOT-ONLY AIR TO BLOW FROM THE VENTS. THIS ISSUE CAUSES MAJOR FOGGING OF THE WINDSHIELD AT TIMES DEPENDING UPON HOW THE LEVERS GET STUCK, WHICH IS A SERIOUS AND MAJOR SAFETY CONCERN- I HAVE TO PULL OVER AND WIPE THE WINDSHIELD DOWN SO I CAN SEE. I LEAD A GROUP COMPRISED OF OVER 1000 PEOPLE WHO HAVE FORMED EXPRESSLY AS A RESULT OF THIS MATTER; ALL OF OUR VEHICLES ARE AILING, AND REST ASSURED, THERE ARE THOUSANDS MORE OUT THERE WITH THIS PROBLEM WHO PROBABLY AREN'T EVEN AWARE OUR GROUP UNITED AGAINST DAIMLER CHRYSLER EVEN EXISTS. IT WOULD BE IN DC'S BEST INTEREST TO ISSUE A RECALL OR SETTLEMENT AGREEMENT BEFORE THIS TURNS INTO ANOTHER CLASS-ACTION SUIT LIKE THEY EXPERIENCED WITH THE 99-03 JEEP GRAND CHEROKEE BRAKE ROTOR/CALIPER MATTER EARLIER IN THE YEAR. *JB
Visibility, Nov 30, 2006
BLEND DOOR ASSEMBLY AND HEATER CORE FAILED ON 2002 JEEP GRAND CHEROKEE. RESULTED IN LOSS OF DEFROSTER FOR FRONT WINSHIELD WHICH RESULTED IN LOSS OF VISION THROUGH WINDSHIELD. REPLACED HEATER CORE, BLEND DOOR ASSEMBLY, ACTUATOR, AND RECIRCULATION DOOR ASSEMBLY. *NM
Visibility, Other or unspecified, Nov 21, 2006
2002 GRAND CHEROKEE DUAL CLIMATE CONTROL LOST HEAT IN BOTH ZONES. *TS THE CONSUMER STATED THE PROBLEM WAS DUE TO THE WEAK BLEND AND RECIRCULATION DOORS IN THE HVAC SYSTEM. THE DOORS ARE TURNED BY A MOTOR ATTACHED TO THE BOTTOM OF THE DOOR AT THE END OF A HINGE SHAFT. THE MOTOR STOPS TURNING WHEN THERE IS ENOUGH PHYSICAL RESISTANCE FROM THE DOOR STOPPING AGAINST ITS HOUSING. THIS PUTS STRESS ON THE SHAFT/DOOR JUNCTION AND OVER TIME STRIPS THE SHAFT SO THAT IT SPINS ALMOST INDEPENDENTLY OF THE DOOR. THE MOTOR THEN EXPERIENCES LITTLE RESISTANCE AND KEEPS TURNING. *JB
Visibility, Nov 16, 2006
SEVERAL MONTHS AGO I LOST HEAT ON THE PASSENGERS SIDE IN MY 2002 JEEP GRAND CHEROKEE LIMITED 4X4 SPORT UTILITY 4DR. I HAD BEEN TRYING TO SAVE UP SOME MONEY TO GO HAVE THIS FIXED,AND HAD BEEN SEARCHING ALL OVER THE INTERNET LOOKING ON JEEP' WEBSITES EVEN, TRYING TO FIGURE OUT WHAT WAS WRONG WITH MY JEEP. THEN ON FRIDAY, NOVEMBER 10, 2006, THE DRIVER SIDE HEAT QUIT WORKING DURING A SNOW STORM. I LEFT WORK ABOUT 5:00 PM AND IT WAS SNOWING AND STARTING TO FREEZE. THE WINDOWS WERENT GETTING FOGGY OR ANYTHING THEY WHERE JUST ICING UP IT GOT TO THE POINT WHERE I COULD ONLY SEE OUT OF A LITTLE SPOT RIGHT WHERE THE FAN BLEW ON THE WINDOW. I WENT 35 MPH ON A 65 MPH SPEED ZONE BECAUSE ONCOMING TRAFFIC WOULD TEMPORARILY BLIND ME. I DON'T LIVE IN FLORIDA, I LIVE IN MONTANA. WHAT ARE PEOPLE AROUND HERE SUPPOSE TO DO WHEN THIS HAPPENS TO THEM. STOP ON THE SIDE OF THE ROAD TO SCRAPE THE ICE OF THEIR WINDOWS, AS ANOTHER VEHICLE PLOWS OVER THEM, DUE TO THE ICY ROAD CONDITIONS. IN MONTANA WE HAVE LONG COMMUTES, SOME PEOPLE DRIVE FROM RED LODGE ALL THE WAY TO BILLINGS. IT TAKES AN HOUR AND TO 2 HOURS DEPENDING ON THE WEATHER. WE DON'T HAVE TAXIS. THIS PROBLEM CAN HAPPEN AT ANY TIME. THIS MAY NOT BE A PROBLEM TO PEOPLE IN A WARMER CLIMATE, BUT IT IS TO PEOPLE UP NORTH. A VERY COMMON PROBLEM IN 1999-2004 MODEL GRAND CHEROKEES HAS BEEN WEAK BLEND AND RECIRCULATION DOORS IN THE HVAC SYSTEMS. IN JANUARY OF 2004 JEEP ISSUED AN INFORMATIONAL TSB (#24-001-04) WHICH INTRODUCED NEWLY DESIGNED SUB ASSEMBLIES. WWW.WJJEEPS.COM I HAVE FOUND THE ITEMS, THE REPAIR INSTRUCTIONS AND THE TSB # ON THIS WEBSITE HTTP://WWW.WJJEEPS.COM/HVAC_SUB_ASSEMBLY.HTM AND THERE IS STILL NO RECALL ON IT. THIS IS A THREATENING PROBLEM TO JEEPS CONSUMERS, ESPECIALLY THE ONES IN COLDER CLIMATES. I CAN'T AFFORD JEEPS MISTAKES, WHETHER IT'S FINANCIALLY FOR PHYSICAL. *NM
Visibility, Nov 3, 2006
ON 10-30-06 THE DRIVER SIDE WINDOW OF MY 2002 JEEP GRAND CHEROKEE FAILED. I WAS INFORMED BY THE DEALER THAT IT WAS PROBABLY A REGULATOR AND THE COST WOULD BE APPROXIMATELY $550.00. THE JEEP HAS 33,000 MILE ON IT AND HAS A 7 YEAR 70,000 MILE WARRANTY, THE DEALER STATED THAT THE PART WAS NOT COVERED BY THE WARRANTY. I HAD IT REPLACED AT SUPERIOR WINDOW GLASS, THE PART AND LABOR COSTS WERE $343.00. THIS SHOULD HAVE BEEN COVERED BY DAIMLER CHRYSLER CORPORATION. *JB
Visibility, Oct 23, 2006
FRONT DRIVERS SIDE WINDOW REGULATOR FAILED AND WINDOW FELL INTO DOOR. *NM
Visibility, Oct 20, 2006
I BOUGHT MY 2002 JEEP GRAND CHEROKEE NEW. SINCE THAT TIME I HAVE HAD TO REPLACE THE REGULATOR IN THE WINDOW MECHANISM THREE TIMES. THE FRONT DRIVER'S SIDE WINDOW WENT OUT WHILE THE VEHICLE WAS STILL UNDER WARRANTY. THE FRONT PASSENGER SIDE WINDOW WENT OUT AFTER THREE YEARS AND THE REAR DRIVER'S SIDE WINDOW WENT OUT SIX MONTHS LATER. IN ALL CASES WHEN THIS HAPPENED THE WINDOW FALLS DOWN INTO THE DOOR AND WILL NOT STAY IN THE UP POSITION. THE LAST TIME IT HAPPENED WAS DURING A FREEZING RAIN STORM WITH MY 16-MONTH OLD IN THE BACK SEAT. NOT BEING ABLE TO KEEP A WINDOW CLOSED IS A HAZARD IN MANY WAYS. THINGS CAN BLOW INTO THE VEHICLE, THINGS CAN BLOW OUT OF THE VEHICLE INTO THE ROADWAY, ETC. WHEN I MENTIONED TO THE DEALER THAT REPLACED THE MOST RECENT REGULATOR THAT THREE OF THE SAME COMPONENT GOING OUT WAS A LITTLE MORE THAN A COINCIDENCE, HE AGREED AND SAID THEIR SHOP HAD REPLACED QUITE A FEW OF THOSE LATELY. I HAVE LITERALLY ROLLED DOWN THE BACK WINDOW LESS THAN 20 TIMES EVER SINCE HAVING THE VEHICLE SO I KNOW IT IS NOT "WEAR AND TEAR." THIS IS OBVIOUSLY A COMPONENT DEFECT. *NM
Steering, Visibility, Equipment, Oct 18, 2006
2002 JEEP GRAND CHEROKEE. STEERING WHEEL BEGAN MAKING STRANGE SOUNDS. STEERING GEAR AND ASSOCIATED PARTS WERE REPLACED. SHORTLY AFTER, STRANGE SOUNDS RETURNED, THE STEERING BEGAN TO BECOME COMPLETELY UNASSISTED AT LOW SPEEDS FOR A BRIEF SECOND. THE PROBLEM CAUSES QUITE A SCARE AND CAUSES TEMPORARY LOSS OF CONTROL. THIS IS ASSOCIATED WITH LOW SPEED IDLE. DAMAGE IS IMMINENT WITHOUT REPAIR. THIS PROBLEM IS WELL DOCUMENTED AMONG JEEP CHAT ROOMS. SECOND WELL DOCUMENTED PROBLEM AMONG JEEP OWNERS. FAULTY POWER WINDOW UNITS THAT FAIL WITHOUT WARNING AND CAUSE WINDOW TO BE STUCK UP OR DOWN. THIS CAUSES DRIVER TO BE FORCED TO DRIVE WITH OPEN NON RESPONDING WINDOWS IN A VARIETY OF WEATHER CONDITIONS, OBVIOUS SAFETY AND HEALTH HAZARD. THIRD CHRONIC HAZARD WELL KNOWN TO JEEP OWNERS AS WELL AS JEEP. THE BLEND DOORS ON A/C CONSISTENTLY FAIL RIGHT AFTER WARRANTY PERIOD. THIS CAUSES A FAILURE OF THE DEFROSTER AND OBVIOUS DANGER, AS WELL AS DRIVERS ARE FORCED TO DRIVE WITH CONSTANT UNHEATED AIRFLOW UNTIL COSTLY REPAIR. JEEP IS WELL AWARE OF THESE PROBLEMS BUT REFUSES TO ACKNOWLEDGE A CONSISTENT PROBLEM AND OFFER CORRECTION FOR ALL AFFECTED VEHICLES. *NM
Visibility, Sep 15, 2006
FAILURE OF HEATING SYSTEM ON PASSENGER SIDE OF VEHICLE. THE FAILURE OF A BLEND DOOR CAUSED ONLY COLD AIR TO BE SENT TO ALL PASSENGER SIDE AIR DISCHARGES WHICH INCLUDE THE WINDSHIELD DEFROSTER. ON COOL MORNING THE PASSENGER SIDE WINDSHIELD WOULD NOT CLEAR COMPLETELY OF DEW, THIS PROBLEM COULD SEVERELY COMPROMISE SIGHT OUT OF THE RIGHT SIDE IN THE WINTER MONTHS. SEVERAL WEB SITES THAT WERE VISITED WHILE RESEARCHING CAUSE INDICATED THAT THIS IS A COMMON PROBLEM AND PARTS HAVE BEEN UPGRADED, ALSO STATED THAT DUE TO LABOR INVOLVED THAT IT WAS A VERY COSTLY REPAIR. SOME PEOPLE WRITING IN TO THESE SITES INDICATED THAT REPAIRS WOULD NO BE MADE. INDIVIDUAL DRIVING AS WELL AS THE REST OF THE PUBLIC THAT ARE ON THE ROADWAYS WITH THE AFFECTED VEHICLES. *JB
Visibility, Sep 7, 2006
DT*: THE CONTACT STATED THE PASSENGER SIDE FRONT AND REAR AND THE DRIVER SIDE FRONT POWER WINDOWS SLID DOWN ON THEIR OWN AND WOULD NOT COME BACK UP. THERE WAS A BROKEN WHITE PLASTIC PIECE NOTED INSIDE THE WINDOW. THE CONTACT REPLACED THE DRIVER SIDE FRONT WINDOW. THE DEALERSHIP WAS CONTACTED. ADDITIONALLY, ONCE WHILE DRIVING ON A DRY HIGHWAY AT 60 MPH, THE CRUISE CONTROL WAS SET AT 60 MPH; WHEN THE CONTACT DEPRESSED THE BRAKE, THE CRUISE CONTROL DID NOT DEACTIVATE AND ACCELERATED UNTIL THE GAS PEDAL WENT TO THE FLOOR. THE CONTACT APPLIED THE BRAKE AGAIN AND THE VEHICLE SLOWED TO A STOP.
Steering, Service brakes, Hydraulic, Power train, Electrical system, Visibility, Equipment, Aug 17, 2006
AFTER READING ALMOST ALL COMPLAINTS WITH OTHER 2002 JEEP GRAND CHEROKEES, I HAVE TO PUT IN MY TWO CENTS WORTH. I CAN RELATE TO ALMOST EVERY COMPLAINT THAT THERE IS. I JUST HAD BOTH MY FRONT LEFT AND RIGHT WINDOW REGULATORS REPLACED A MONTH AND A HALF APART, ONE JUST TODAY AT $327.00 WITH MY EMPLOYEE DISCOUNT. (I WORK FOR A CAR DEALERSHIP) LAST MONTH, I HAVE HAD ALMOST $500.00 WORTH OF REPAIRS FOR MY POWER STEERING PUMP PROBLEMS. I HAVE HAD MY BRAKE ROTORS TURNED AND RESURFACED AND AM IN NEED OF DOING IT AGAIN. THEN ON THE OTHER HAND, I HAVE EXPERIENCED PROBLEMS WITH MY DUAL CONTROL PANEL NOT WORKING CORRECTLY WHICH I HAVE NOT HAVE REPAIRED YET BECAUSE I DON'T HAVE THE MONEY FOR THAT ONE AND DIDN'T KNOW AT THE TIME THAT IT WAS A PROBLEM. THEN WHEN MY JEEP WAS UNDER WARRANTY I HAVE HAD THE AIR CONDITIONER COMPRESSOR REPLACED, NEW BATTERY(FOR HARD OR NO STARTING), AMONGST OTHER REPAIRS THAT I CAN'T THINK OF AT THE MOMENT. I HAVE ALSO BEEN EXPERIENCING HARD STARTS WITH MY TRUCK AND ALSO THE TRANSMISSION NOT ENGAGING OR JUMPING (ACCELERATING) WHILE SWITCHING GEARS THAT THE JEEP DEALER HAS NOT BEEN ABLE TO RECOGNIZE AS A PROBLEM. I FEEL THAT THOSE NEW CHRYSLER COMMERCIALS ARE NOT UP TO PAR AS AMERICAN AND GERMAN ENGINEERING. THOSE GERMANS KNOW HOW TO BUILD VEHICLES IN THE FIRST PLACE AND HELP REPAIR THEM AS THE PROBLEM SEEM NECESSARY. *NM
Visibility, Aug 9, 2006
I SHUT THE PASSENGER DOOR AND MY WINDOW FELL. THIS IS THE THIRD TIME THIS YEAR FOR THIS TO HAPPEN. FIRST IT WAS THE DRIVER SIDE AND THEN THE DRIVER SIDE PASSENGER WINDOW. THE GUY AT THE JEEP PLACE SAID THAT THIS IS A COMMON FAILURE WITH THE GRAND CHEROKEE. THIS IS $450 FOR EACH TIME. *NM
Visibility, Aug 3, 2006
I HAVE A 2002 JEEP GRAND CHEROKEE AND I HAVE NOW HAD THE THIRD DIFFERENT POWER WINDOW FAILURE SINCE I BOUGHT THE VEHICLE NEW. THE WINDOW, WHEN FAILS, FALLS DOWN IN ITS TRACK AND ON ONE OCCASION HAPPENED WHILE I WAS DRIVING AND IT STARTLED ME. I HAVE SPENT HUNDREDS OF DOLLARS ON THE PREVIOUS TWO FAILURES ONLY NOW TO HAVE A THIRD FAILURE. BOTH FRONT WINDOWS FAILED AND NOW THE REAR LEFT HAS FAILED. *JB
Visibility, Jul 25, 2006
2002 JEEP CHEROKEE, DRIVER AND PASSENGER SIDE WINDOW REGULATORS FAILED. THE DRIVER SIDE REGULATOR HAD TO BE REPLACED TWICE. *KB *NM***NAR***
Visibility, Jul 9, 2006
DRIVERS AND PASSENGER SIDE WINDOWS HAVE FELL INSIDE THE DOOR WHILE PARKED. CHRYSLER NEEDS TO REPLACE THIS DEFECTIVE PART THAT CONTROLS THE WINDOW. WHEN THIS HAPPENS IT LEAVES YOUR CAR UNPROTECTED TO THIEVES AND WEATHER CONDITIONS. *JB