2002 Jeep Grand Cherokee
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,476 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Grand Cherokee model years with reports.
Of the 2002 reports, 75 involved a crash and 20 involved a fire. 97 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Air bags, frontalJan 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.
Campaign 15V046000 on NHTSA.gov
Air bagsNov 8, 2012
Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.
Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.
Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.
Campaign 12V527000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Seats, front assembly, seat heater/coolerApr 9, 2009
CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.
OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.
DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 09V117000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Engine and engine cooling, cooling system, fanJun 8, 2006
ON CERTAIN SPORT UTILITY VEHICLES, THE PLASTIC BLADES OF THE ELECTRIC MOTOR DRIVEN COOLING FAN MAY SEPARATE AND PENETRATE THE SHROUD.
IF THIS OCCURS WHILE THE HOOD IS OPEN, A PERSON IN THE VICINITY OF THE ENGINE COULD BE STRUCK BY THE BLADE AND INJURED.
DEALERS WILL REPLACE THE ELECTRIC COOLING FAN MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 4, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 06V199000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Service brakes, hydraulicMar 13, 2006
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Campaign 06E022000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 1, 2006
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.
Campaign 06E011000 on NHTSA.gov
Fuel system, gasoline, fuel injection system, injectorsApr 8, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
THIS COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V104000 on NHTSA.gov
Air bags, frontalMar 26, 2002
ON CERTAIN SPORT UTILITY VEHICLES, THE PASSENGER AIR BAG WIRING HARNESS WAS IMPROPERLY MANUFACTURED.
THIS COULD CAUSE IMPROPER AIR BAG DEPLOYMENT IN CERTAIN CRASH CONDITIONS.
DEALERS WILL ADD A WIRING JUMPER TO THE EXISTING CIRCUITRY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V099000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJan 31, 2002
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A FUEL TANK BRUSH GUARD FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) CONTROL VALVE CAN BECOME DETACHED DURING A CRASH, ALLOWING FUEL LEAKAGE.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DEALERS WILL EITHER REPLACE THE FUEL TANK BRUSH GUARD WITH A SKID PLATE OR REINFORCE THE EXISTING FUEL TANK BRUSH GUARD WITH A REINFORCEMENT BRACKET. OWNER NOTIFICATION WILL BEGIN MARCH 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 02V032000 on NHTSA.gov
Fuel system, gasoline, deliveryDec 5, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL INLET CHECK VALVE COULD STICK IN THE PARTIALLY OPEN POSITION. THIS CONDITION COULD CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE DURING REFUELING.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE FUEL INLET CHECK VALVE. VEHICLES FOUND TO HAVE A STICKING FUEL INLET CHECK VALVE WILL HAVE THE FUEL TANK ASSEMBLY REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V374000 on NHTSA.gov
Engine and engine cooling, exhaust system, emission controlNov 13, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ONBOARD VAPOR RECOVERY SYSTEM VENT HOSE MAY HAVE BEEN MISROUTED. THIS COULD ALLOW WATER TO ENTER THE CANISTER WHICH CAN CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE WHEN REFUELING THE TANK.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT (AND REPOSITION AS NECESSARY) THE VENT HOSE. IF THE VENT HOSE IS FOUND IN THE BENT DOWN POSITION, AND THE VEHICLE HAS BEEN DRIVEN MORE THAN 20 MILES, THE CANISTER ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V348000 on NHTSA.gov
Electrical system, wiring, interior/under dashSep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V288000 on NHTSA.gov
Representative owner complaints: visibility
326 reports, newest first. Show all
Visibility, Oct 26, 2008
NO HEAT, POOR DEFROSTER PERFORMANCE. WAS TOLD THE PROBLEM IS THE HEATER BLEND DOOR HAS FAILED AND THE COST IS AROUND $`1,800.00 TO REPAIR. I STARTED LAST WINTER WITH NO HEAD ON THE PASSENGER SIDE, NOW THERE IS NO HEAT ON EITHER SIDE. DEFROSTERS NOT PROPERLY CLEARING WINDSHIELD. *TR
Visibility, Oct 25, 2008
BLEND DOOR ACTUATOR FAILURE, SAFETY ISSUE!! NO VISIBILITY!!! NO HEAT ON PASSENGER SIDE. *TR
Visibility, Oct 25, 2008
APPARENTLY THERE IS A HUGE NUMBER OF JEEP GRAND CHEROKEE OWNERS WITH DEFECTIVE BLEND DOOR ACTUATORS. I AM ONE OF THEM. I OWN A 2002 JEEP GRAND CHEROKEE LIMITED AND HAVE NO HEAT ON MY PASSENGER SIDE. NO DEFROST, BIG SAFETY ISSUE. DEALER QUOTES OVER $1,000 TO REPAIR. I CAN'T AFFORD THAT! *TR
Visibility, Oct 24, 2008
INABILITY TO SEE THROUGH THE WINDSHIELD DUE TO EXCESSIVE MOISTURE ON WINDSHIELD AND UNABLE TO CLEAR WINDSHIELD. *TR
Visibility, Oct 24, 2008
IN THE FALL OF 2007, THE HEAT ON THE PASSENGER SIDE OF 2002 JEEP GRAND CHEROKEE STOPPED WORKING. I DID SOME ONLINE RESEARCH AND THIS PROBLEM WAS SO COMMON THAT I EASILY FOUND PLENTY OF PEOPLE WITH THE EXACT SAME PROBLEM THAT WERE ABLE TO SELF-DIAGNOSE THE PROBLEM USING THE JEEPS INTERNAL COMPUTER TO OUTPUT THE SYSTEM FAULTS. USING THE SAME METHOD TO ENTER THE AZC SELF-DIAGNOSTIC MODE, THE CLIMATE CONTROL DISPLAY OUTPUT THE SYSTEM FAULT CODES 52-54-56. SINCE MOST OF THE CONSUMERS I'VE RUN INTO WITH THIS PROBLEM GET THAT EXACT CODE, OR HAVE HAD THE SAME PROBLEM DIAGNOSED BY A JEEP DEALERSHIP SERVICE DEPARTMENT, I ALREADY KNOW THAT IT WILL COST ANYWHERE FROM $1000+ TO BE REPAIRED, THE MAJORITY OF IT BEING LABOR AS THE ENTIRE INSTRUMENT PANEL ASSEMBLY HAS TO BE REMOVED. TO ADDRESS THIS PROBLEM, DAIMLER-CHRYSLER RELEASED TSB 2400104 - NEW HVAC SUB-ASSEMBLY REPLACES BLEND OR RECIRC DOOR COMPONENTS. EACH NEW SUB-ASSEMBLY CONSISTS OF SEVERAL INDIVIDUAL COMPONENTS. THE NEW SUB-ASSEMBLIES IMPROVE COMPONENT RELIABILITY. IT IS RECOMMENDED THAT THE RESPECTIVE SUB-ASSEMBLY BE INSTALLED IF A BLEND AIR DOOR(S), A RECIRCULATION DOOR, A DOOR LINK, OR A SUB-ASSEMBLY HOUSING REQUIRES REPLACEMENT. THESE NEW PARTS COST LESS THAN $200 ACCORDING TO THE BULLETIN, BUT I FIND IT HARD TO BELIEVE THAT DAIMLER-CHRYSLER EXPECTS THEIR CUSTOMERS TO PICK UP THE TAB ON A DESIGN FLAW. ESPECIALLY A DESIGN FLAW THAT IS SO LABOR INTENSIVE THAT EVEN THOUGH THE PARTS ARE LESS THAN $200, THE FINAL BILL WILL BE MORE THAN $1,000. A JOB SO CONSUMING THAT IT WOULDN'T BE WISE TO HAVE IT SERVICED BY ANYTHING BUT A JEEP SERVICE TECHNICIAN. NOT TO MENTION SOME REPAIR SHOPS WONT EVEN TAKE ON THE JOB DUE TO THE TIME AND POSSIBLE ACCOUNTABILITY OF SUCH A PROJECT. THIS IS A MAJOR SAFETY ISSUE; NOT ONLY BECAUSE YOU LOSE THE ABILITY TO DEFROST BUT OF THE EFFECTS EXTREME COLD CAN HAVE ON A BODY TOO. THE NHTSB NEEDS TO ADDRESS THIS WITH DAIMLER CHRYLSER. *TR
Visibility, Equipment, Oct 21, 2008
MY 2002 GRAND CHEROKEE SUDDENLY HAS NO HEAT. THE DEFROSTER WORKS RANDOMLY AND SOMETIMES SHUTS DOWN ONLY BLOWING COLD, OUTSIDE AIR CAUSING THE WINDOW TO FOG UP WITH NO WARNING. AFTER RESEARCHING THIS ISSUE ONLINE THERE ARE THOUSANDS OF COMPLAINTS ABOUT THIS, THE DEALER FIX IS TO TAKE OFF THE DASH ($1000+ IN LABOR) TO FIX A $20 PART. THERE ARE PARTS AVAILABLE ONLINE TO DO THE FIX YOURSELF FOR $100. SEEMS TO ME THAT NOT ONLY DOES JEEP KNOW THERE IS A FACTORY DEFAULT WITH THEIR JEEPS, THEY RIP PEOPLE OFF BY CHARGING EXORBITANT AMOUNTS OF $$ TO FIX SOMETHING SIMPLE. I SEARCHED THROUGH YOUR DATABASE AND THERE ARE PAGES AND PAGES OF COMPLAINTS FOR THE SAME ISSUE. AT THIS POINT I AM GOING TO FIX IT MYSELF BECAUSE I CANT GO THROUGH THE WINTER WITHOUT HEAT, BUT IM SURE AS HECK NOT GOING TO TAKE IT TO THE DEALER AND GET CHARGED $2500. AND IM DEFINITELY NEVER BUYING ANOTHER GM CAR AGAIN. *TR
Visibility, Oct 20, 2008
THE A/C, AND HEATER DOES NOT WORK PROPERLY!!! ON MY 2002 JEEP GRAND CHEROKEE LIMITED (WJ), THE HEAT DOES NOT WORK ON THE DRIVERS SIDE, THERE IS A FLAP UNDER THE DASH THAT IS JAMMED SHUT, SO THE HEAT ONLY WORKS ON ONE SIDE!!! I GOT A QUOTE TO GET THIS PROBLEM REPAIRED, AND IT WAS 800-1200 MINIMUM!!!! *TR
Visibility, Oct 6, 2008
2002 JEEP GRAND CHEROKEE BLEND DOOR ACTUATOR BROKEN AND DEFROSTED IS NOW DISABLED I CAN NOT SEE. *TR
Visibility, Oct 6, 2008
THIS IS IN REGARDS TO THE BLEND DOOR ISSUE ON JEEP GRAND CHEROKEE MODELS THAT HAVE THE DUAL CLIMATE CONTROL. THE FACT THAT THIS ISSUE IS IMMINENT IN NEARLY EVERY ONE OF THESE VEHICLES IS DISTURBING ENOUGH IN ITSELF, BUT WHAT IS DOWNRIGHT UNACCEPTABLE IS THAT THE AVERAGE COST TO REPAIR RANGES FROM 1000.00-1300.00!! THIS ISSUE IS SO PREVALENT THAT 3 DIFFERENT JEEP SITE FORUMS HAVE HAD SO MANY JEEP OWNERS BRING THIS UP THAT IT HAS BECOME A POSTED ISSUE. I HAVE RECENTLY PURCHASED A 2002 MODEL AND, KNOCK ON WOOD, HAVE NOT EXPERIENCED THIS ISSUE. I BELIEVE IT ACTUALLY MAY HAVE ALREADY BEEN TAKEN CARE OF, BUT IN THE EVENT THAT I AM WRONG, I CAN ONLY HOPE AND PRAY THAT DC/JEEP HAS STEPPED UP AND DONE WHAT IS RIGHT, AND, AT THE VERY LEAST, AS A RECALL/TSB, COVERS A LARGE PORTION OF THIS REPAIR. *TR
Visibility, Sep 29, 2008
VISIBILITY: DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER. *TR
Visibility, Sep 29, 2008
THE CAR DOES NOT BLOW HEAT ON THE PASSENGER SIDE. APPARENTLY THERE IS A WELL KNOWN PROBLEM WITH THE BLEND DOORS AND THE ACTUATORS. IT IS VERY DANGEROUS IN THE WINTER WHEN THE RIGHT SIDE OF THE JEEP DOES NOT DEFROST BECAUSE NO WORM AIR BLOWS OUT. NO VISIBILITY. *TR
Visibility, Sep 24, 2008
TWO YEARS AGO MY PASSENGER SIDE HEAT STOP WORKING. WHEN I TOOK IT TO THE DEALER, THEY STATED THAT IT WAS NOT COVER BY ANY WARRANTY AND IT WOULD COST $1500.00 TO REPAIR. SO THE PUT TAPE OVER THOSE VENTS AND ONLY HAD THE DRIVER SIDE WORKING. LAST MAY MY DRIVER SIDE STOP BLOWING HOT AIR ALSO. TOOK BACK TO THE DEALER, GUESS WHAT IT WILL COST $1200.00. I'M TRIED OF THIS, JEEP SHOULD HAVE A RECALL! *TR
Visibility, Sep 18, 2008
I BOUGHT MY 2002 JEEP GRAND CHEROKEE USED WITH 51,249 MILES I FOUND OUT AFTER 30 DAYS THAT MY BLEND DOOR NEEDED TO BE CHANGED OUT THE DEALER WHERE I PURCHASED IT WAS KIND ENOUGH TO SPLIT THE COST 50% MY PART $492. NOW IT HAS GONE OUT AGAIN AND YOU WOULD HAVE THOUGHT THAT IT WOULD LAST MORE THAN 2 YEARS WHAT CAN I DO BESIDES TRADE IT IN. *TR
Visibility, Sep 18, 2008
WHEN BLOWER MOTOR TURNED ON HIGH PANEL UNDER PASSENGER SIDE UNDER DASH GETTING EXTREMELY HOT. REMOVED PANELING UNDER DASH AND WIRES ARE MELTING, TOO HOT TO TOUCH! EXTREME FIRE HAZARD!!!! HUGE LIABILITY!! SCARED TO EVEN TURN ON BLOWER MOTOR ANY MORE DUE TO POSSIBILITY OF FIRE. DURING CURRENT RAIN STORM UNABLE TO GET WINDOWS DEFOGGED TO SEE TO DRIVE HAD TO PULL OFF TO SIDE OF ROAD. *TR
Visibility, Sep 17, 2008
BROUGHT MY 02 JEEP GRAND CHEROKEE IN NOVEMBER 2007 HAD PROBLEMS WITH THE HEAT MODE BLOWING COLD OUT THE PASSENGER SIDE VENTS. TO STOP THIS AND MAKE THE PASSENGER SIDE FEEL THE HEAT I HAD TO TAPE UP THE VENTS ON THE PASSENGER SIDE. WELL SUMMER OF 2008 BEGAN SO I REMOVE THE TAPE FROM THE VENTS. WITH THE AC ON THE AIR FLOW WAS WEAK THE AS WAS RECHARGED THE DRIVER SIDE BLEW COLD, BUT PASSENGER SIDE WAS WEAK. AROUND AUGUST TURN ON THE AC NOTHING BUT A VERY WEAK AIRFLOW FROM BOTH SIDES. THE POSSIBLE VILLAINS BLEND AIR DOORS AND THE AIR RECIRCULATION DOOR. COST FROM DEALER TO REPAIR 1,000.00 TO 1,200.00 THE WINTER OF 2008/ 2009 IS APPROACHING NO HEAT AND *NO DEFROST. COULD GET DANGEROUS. PLEAS HELP!!!!!!!! *TR
Visibility, Sep 11, 2008
IN THE FALL OF 2006, THE HEAT IN MY 2002 JEEP GRAND CHEROKEE STOPPED WORKING. I DID SOME ONLINE RESEARCH AND THIS PROBLEM WAS SO COMMON THAT I EASILY FOUND PLENTY OF PEOPLE WITH THE EXACT SAME PROBLEM THAT WERE ABLE TO SELF-DIAGNOSE THE PROBLEM USING THE JEEP'S INTERNAL COMPUTER TO OUTPUT THE SYSTEM FAULTS. USING THE SAME METHOD TO ENTER THE AZC SELF-DIAGNOSTIC MODE, THE CLIMATE CONTROL DISPLAY OUTPUTTED THE SYSTEM FAULT CODES 52-54-56. SINCE MOST OF THE CONSUMERS I'VE RUN INTO WITH THIS PROBLEM GET THAT EXACT CODE, OR HAVE HAD THE SAME PROBLEM DIAGNOSED BY A JEEP DEALERSHIP SERVICE DEPARTMENT, I ALREADY KNOW THAT IT WILL COST ANYWHERE FROM $1000+ TO BE REPAIRED, THE MAJORITY OF IT BEING LABOR AS THE ENTIRE INSTRUMENT PANEL ASSEMBLY HAS TO BE REMOVED. TO ADDRESS THIS PROBLEM, DAIMLER-CHRYSLER RELEASED TSB 2400104 - NEW HVAC SUB-ASSEMBLY REPLACES BLEND OR RECIRC DOOR COMPONENTS. EACH NEW SUB-ASSEMBLY CONSISTS OF SEVERAL INDIVIDUAL COMPONENTS. THE NEW SUB-ASSEMBLIES IMPROVE COMPONENT RELIABILITY. IT IS RECOMMENDED THAT THE RESPECTIVE SUB-ASSEMBLY BE INSTALLED IF A BLEND AIR DOOR(S), A RECIRCULATION DOOR, A DOOR LINK, OR A SUB-ASSEMBLY HOUSING REQUIRES REPLACEMENT. THESE NEW PARTS COST LESS THAN $200 ACCORDING TO THE BULLETIN, BUT I FIND IT HARD TO BELIEVE THAT DAIMLER-CHRYSLER EXPECTS THEIR CUSTOMERS TO PICK UP THE TAB ON A DESIGN FLAW. ESPECIALLY A DESIGN FLAW THAT IS SO LABOR INTENSIVE THAT EVEN THOUGH THE PARTS ARE LESS THAN $200, THE FINAL BILL WILL BE MORE THAN $1,000. A JOB SO CONSUMING THAT IT WOULDN'T BE WISE TO HAVE IT SERVICED BY ANYTHING BUT A JEEP SERVICE TECHNICIAN. NOT TO MENTION SOME REPAIR SHOPS WON'T EVEN TAKE ON THE JOB DUE TO THE TIME AND POSSIBLE ACCOUNTABILITY OF SUCH A PROJECT. TO MAKE A VEHICLE WHERE THE HEAT DOES NOT WORK CORRECTLY IS UNACCEPTABLE AND MOST LIKELY DANGEROUS. NOT ONLY BECAUSE OF THE EFFECTS EXTREME COLD CAN HAVE ON A BODY, BUT ALSO DUE TO THE HEAT BEING USED FOR DEFROSTING. IT COST $884.00 TO REPAIR. *TR
Engine and engine cooling, Visibility, Seats, Sep 10, 2008
TL*THE CONTACT OWNS A 2002 JEEP GRAND CHEROKEE. WHILE DRIVING AT AN UNKNOWN SPEED, THE SEAT FRAME SPONTANEOUSLY FAILED AND ALLOWED THE SEAT TO SUDDENLY RETRACT BACKWARDS. THE FAILURE INCREASED THE RISK OF A CRASH. THE DEALER STATED THAT THE ENTIRE SEAT FRAME NEEDED TO BE REPLACED AT THE COST OF OVER $400. HE IS IN THE PROCESS OF HAVING THE SEATS REPAIRED. SECONDLY, THE POWER WINDOWS WORKED INTERMITTENTLY. THE DEALER REPLACED THE WINDOW REGULATORS. THIRDLY, HE NOTICED THAT FLUID FROM THE HEATER COIL LEAKED INTO THE FRONT PASSENGER SIDE OF THE VEHICLE. THE MANUFACTURER WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIR BECAUSE THE VEHICLE EXCEEDED THE WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 94,000.
Visibility, Sep 4, 2008
2002 JEEP GRAND CHEROKEE. BLOWER CONTROLLER CONNECTOR IS OVERHEATING AND MELTING CONNECTOR AND NOW NOT WORKING. REPLACEMENT WITH NEW CONNECTOR IS POSSIBLE FROM DEALER WITH MORPAR REPAIR KIT #05102406AA . HOWEVER... THIS DOES NOT FIX THE PROBLEM AS IT WILL HAPPEN AGAIN AND AGAIN. THIS IS DUE TO STRAIN ON THE BLOWER MOTOR DRAWING HIGH AMPS BECAUSE THE COMMON PROBLEM WITH THIS JEEP IS WITH THE AC "BLEND DOORS" WHICH WAS THE FIRST PROBLEM FOR ME....AS WITH MANY JEEP CHEROKEE OWNERS. IT COSTS OVER $1000 TO FIX A SIMPLE PROBLEM WITH THE BLEND DOOR BECAUSE THE ENTIRE DASH HAS TO BE REMOVED! SO, THE BLEND DOORS ARE A COMMON PROBLEM WITH AN EXPENSIVE FIX, AND IF YOU DON'T FIX IT, THE BLOWER MOTOR AND CONTROLLER WILL OVERHEAT, LEAVING YOU WITH NO AIR CONTROL TO REMOVE MOISTURE IN DAMP WEATHER. THE CONTROLLER COULD OVERHEAT, POSSIBLY CAUSE A FIRE, OR IF THE CONTROLLER AND BLOWER DON'T WORK, YOU HAVE NO WAY OF CLEARING FOGGY WINDOWS....BAD THING! VERY FRUSTRATED AS THIS SHOULD BE PART OF A MAJOR RECALL. WHY SHOULD SO MANY JEEP OWNERS HAVE TO PAY FOR A SIMPLE, YET EXPENSIVE FIX? *TR
Visibility, Aug 31, 2008
3 OUT FOR 4 REGULATORS HAD TO BE REPLACED ON MY 2002 GRAND JEEP. *TR
Visibility, Aug 28, 2008
BLEND AND RECIRCULATION DOOR FAILURES IN HVAC UNIT. FAILURE IS EXTREMELY COMMON, AND COSTS OVER $1,000 IN REPAIRS. *TR
Visibility, Aug 24, 2008
AIR CONDITIONING BLOWER WOULD QUIT WORKING. FOUND A JEEP FORUM ON LINE. DETERMINED THE PROBLEM WAS THE BLOWER MOTOR RESISTOR WIRING CONNECTIONS OVERHEATING. THIS IS A VERY COMMON PROBLEM WITH THESE GRAND CHEROKEES. SEEMS LIKE JEEP SHOULD HAVE DONE A RECALL. *TR
Visibility, Aug 20, 2008
2002 JEEP GRAND CHEROKEE LIMITED (V8) WENT OUT TO CAR THIS MORNING AND DRIVER SIDE WINDOWS WAS HALF DOWN IN DOOR - TRIED TO ROLL IT UP - NOTHING. WINDOW THEN FELL INTO DOOR FRAME COMPLETELY - REGULATOR PROBLEM WITH PLASTIC PART. *TR
Visibility, Aug 17, 2008
VISIBILITY: DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER HAVING A VISIBILITY PROBLEM WITH THE HEATER/AIRCONDITIONG IN CAR HEATING/AIRCONDITIONING NOT CLEARING WINDSHIELD. *TR __________________
Visibility, Jul 30, 2008
BLEND DOOR FAILURE ON '02 GRAND CHEROKEE. *TR
Visibility, Jul 7, 2008
THE HEAT ON THE PASSENGER SIDE OF THE JEEP IS BLOWING COLD AIR IN WINTER, EVEN WHEN IT IS SET TO MAXIMUM HEAT. THE DEALER TOLD ME THAT THERE IS A SERVICE BULLETIN ON THE BLEND DOOR AND THEY WANT OVER $700 DOLLARS TO FIX IT. MY QUESTION IS IF THEY KNOW THERE IS A PROBLEM WITH IT FROM DESIGN HOW COME THEY DON'T FIX IT FOR FREE AND WHY SHOULD I PAY FOR IT WHEN THEY KNEW THEY SOLD ME A BAD DESIGN. ALSO NOW THE AC IS BLOWING HOT AIR AND THEY ARE TELLING ME IT IS THE SAME PROBLEM WITH THE BLEND DOORS. THIS IS A SAFETY ISSUE SINCE IN THE WINTER I CAN NOT DEFROST THE FRONT WINDSHIELD AND HAVE TO PULL OVER TO CLEAN THE ICE AND FOG BUILD UP FROM INSIDE THE WINDOW. *TR