2003 Kia Sorento
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 308 owner complaints filed for this model year. This is the 9th highest complaint count among 23 Sorento model years with reports.
Of the 2003 reports, 10 involved a crash and 3 involved a fire. 12 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsAug 4, 2005
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Campaign 05V353000 on NHTSA.gov
Representative owner complaints
308 reports, newest first.
Air bags, Mar 20, 2025
For some reason, KIA has halted production of the Air Bag Clock Spring mechanism for 2003 Kia Sorento's EX with cruise control. In my opinion, this was a vital component of the Air Bag safety system for any vehicle. So why the halt in the production of this vital part. Kia part #93490-3E160. Maybe the NHTSA can get an answer to this. I'm sure I not the only one driving a 2003 with the Air Bag light illuminated.
Engine, Oct 1, 2019
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE VEHICLE STALLED AND LOST MOTIVE POWER WHILE DRIVING THE CONTACT WAS CONCERNED FOR HIS SAFETY WHEN THE VEHICLE STALL THE CONTACT WAS CONCERNED THAT IT WAS RELATED TO THE FUEL SYSTEM WHILE DRIVING AT APPROXIMATELY 60 MPH, THE SPUTTERED AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS WHERE THE FUEL PUMP WAS REPLACED, A TUNE UP WAS PERFORMED, THE CAMSHAFT SENSOR, AND TIMING BELT WAS ALSO REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED WAS CONCERNED THAT THE FUEL SYSTEM WAS THE CAUSE OF THE FAILURE. LAKESHORE KIA, 330 E HOWZE BEACH RD #2, SLIDELL, LA 70461, (888) 220-8645, WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED NOR INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Engine, Aug 30, 2019, crash
TL* THE CONTACT OWNED A 2003 KIA SORENTO. WHILE DRIVING AT 60 MPH, THE CONTACT STATED THAT SMOKE CAME FROM OUT OF THE VENTS. THE CONTACT PULLED OVER ON THE SHOULDER AND EXITED THE VEHICLE. THERE WERE SPARKS COMING FROM THE ENGINE AND THE VEHICLE CAUGHT ON FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOTALED AND TOWED AWAY. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. TH VIN WAS NOT AVAILABLE.
Engine, May 13, 2019
TL* THE CONTACT OWNS A 2003 KIA SORRENTO. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT A 'SNOW' WARNING LIGHT ILLUMINATED AS WELL. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 202,699.
Engine, Apr 26, 2019
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE RPMS WOULD NOT GO OVER 4,000 AND SMOKE APPEARED FROM THE ENGINE. THE CONTACT STATED THAT THE SPEED WOULD NOT EXCEED 40 MPH AND THE ENGINE WAS DRAINING THE OIL. THE VEHICLE WAS TAKEN TO PEAK KIA (5077 S WADSWORTH BLVD, LITTLETON, CO 80123, (303) 904-7800) WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED AN OIL CHANGE. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO CALL THE DEALER. THE FAILURE MILEAGE WAS 56,300. *DT
Fuel/propulsion system, Nov 6, 2018
WHEN PUMPING GAS THERE IS A SUDDEN SPEWING OF GASOLINE OUT OF THE TANK AND ALL OVER ME. I MANAGED SEVERAL TIMES TO GET A FEW GALLONS IN BY PUMPING SLOWLY BUT THE NEXT DAY THE GAS GAGE READS EMPTY AND HAS ACTUALLY RUN OUT OF GAS SEVERAL TIMES! SO NOT ONLY AM I HAVING A PROBLEM PUTTING GAS IN, IT IS IMMEDIATELY DRAINING OR LEAKING OUT!
Fuel/propulsion system, May 16, 2018
AFTER PURCHASING CAR FROM PRIVATE SELLER I DISCOVERED THAT WHEN TRYING TO PUMP GAS, MY FUEL SPRAYS BACK OUT ALL OVER MYSELF, MY VEHICLE, AND THE GROUND. HAVE EVEN HAD IT SPRAY INTO MY EYES. DID RESEARCH AND SAW THAT THIS IS A VERY COMMON OCCURRENCE FOR THIS YEAR/MAKE/MODEL. I BELIEVE ITS A FIRE AND SAFETY HAZARD AND SHOULD HAVE BEEN RECALLED YEARS AGO!
Air bags, Jan 29, 2018
TAKATA RECALL. MY CAR WILL NOT PASS INSPECTION DUE TO A PROBLEM WITH ONE OF THE AIRBAGS. THE CAR HASN'T BEEN IN AN ACCIDENT BUT THE AIRBAG LIGHT IS ON AND I'M TOLD IT WILL NOT INFLATE. I WAS TOLD TO CHECK FOR RECALLS.
Steering, Nov 23, 2017
TAKATA RECALL THE CRANKSHAFT PULLEY BOLT KEEPS COMING LOSE AND THIS CAUSES THE STEERING WHEEL TO BECOME STIFF. THIS HAPPENED IN THE MIDDLE OF TRAFFIC AND HAD TO GET IT TOWED TO A FRIENDS HOUSE. CURRENTLY THE CAR IS NOT DRIVEABLE FOR OVER TWO WEEKS.
Power train, Electrical system, Fuel/propulsion system, Nov 6, 2017
MY 2003 KIA SORENTO DRIVES FOR 15 MINUTES AND STALLS OUT. I WAIT 5 MIN AND IT'LL START AND DRIVE FOR A BLOCK OR 2AND CONTINUES TO THAT UNTIL I GET IT TOWED HOME
Engine, Oct 26, 2017
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER AND CRANKSHAFT BOLT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL TIMES. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
Engine, Jun 29, 2017
ENGINE CRANK SHAFT HAS BROKEN FOUR TIME , AIR COMPRESSER TWO TIME
Suspension, Mar 21, 2017
RUST AND CORROSION REAR AXLE BRACKET AND TRAILING ARM MOUNT. REAR AXLE BRACKET BROKE AT HIGHWAY SPEEDS.
Suspension, Other or unspecified, Fuel/propulsion system, Mar 20, 2017
THE 2003 KIA SORENTO HAS A PROBLEM WITH EXTENSIVE FRAME RUSTING, TO THE POINT WHERE SOME OWNERS HAVE HAD THE SUSPENSION DETACH FROM THE FRAME. ONE OWNER IN PARTICULAR HAS HAD ISSUES WITH THE GAS TANK NEEDING TO BE REPLACED, AND KIA MOTORS REFUSES TO DO ANYTHING ABOUT THE PROBLEM. THEY BUILT THE CAR, SOLD IT TO PEOPLE, AND WHEN CONSUMERS HAVE COMPLAINTS ABOUT THEIR VEHICLE, THEY (KIA) SAYS THAT THEY'RE NOT RESPONSIBLE. YOU NEED TO EXAMINE THIS, BECAUSE PEOPLE COULD GET KILLED BY OPERATING AN UNSAFE VEHICLE. DO SOMETHING ABOUT THIS NOW, BEFORE IT BECOMES THE NEXT PINTO. MAKE KIA FIX THE [XXX] VEHICLES NOW!!! PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Power train, Mar 18, 2017
VEHICLE BROKE DOWN IN TRAFFIC. FROZE UP,STALLED. LOSS OF STEERING. HAD IT TOWED TO SHOP & WAS TOLD THE CRANK SHAFT SENSOR & RELATED PARTS TO THE CRANK SHAFT HAD TO BE REPLACED. COST FOR TOWING & REPAIRS WERE OVER $700.
Fuel/propulsion system, Mar 13, 2017
WHILE FUELING UP THE SORENTO, THE FUEL SPIT OUT EVERY TIME EVEN WHILE FUELING AT SLOW SPEEDS. VERY FRUSTRATING , AND DANGEROUS, ESPECIALLY WHEN THE FUEL GETS ON MY SKIN & CLOTHES, THE VEHICLE, AND AT TIMES LEAVES A HUGE PUDDLE ON THE GROUND WHICH COULD BE A FIRE HAZARD. THE DEALERSHIP WAS CONTACTED AND WILL NOT HELP ME EVEN THOUGH THERE WAS A RECALL ISSUED FOR THE FUEL FILTER, WHICH I MENTIONED.
Fuel/propulsion system, Feb 13, 2017
WHEN I PUMP GAS INTO MY CAR, THE FUEL SPITS BACK OUT AT ME. I HAVE TO PUMP REAL SLOW FOR THIS NOT TO HAPPEN. THIS IS DANGEROUS, GAS GETS ON MY HANDS AND CAR,I HAVE TO CARRY SOAP AND WATER TO WASH THIS OFF OF MY CAR. I CALLED ABOUT THIS AND WAS TOLD BECAUSE MY CAR VIN # WAS NOT ON THE THEIR LIST THERE WAS NOTHING THEY COULD DO FOR ME
Engine, Fuel/propulsion system, Jan 25, 2017
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE DECELERATED AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. IN ADDITION, WHEN THE CONTACT INSERTED FUEL IN THE VEHICLE, FUEL SPEWED OUT THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
Suspension, Structure, Jan 4, 2017
TAKATA RECALL...REAR SUSPENSION ALWAYS ROTS OUT. THE SUB FRAME IS BAD.
Engine, Jul 31, 2016
WHILE UNDER MOTION ON HIGHWAY AT 65+ MPH, LOST POWER STEERING DUE TO CRANK SHAFT BOLT AND PULLEY FAILURE, RESULTING IN COMPLETE LOSS OF ACCESSORY FUNCTIONS.
Fuel/propulsion system, Jul 21, 2016
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHEN REFUELING THE VEHICLE, FUEL EJECTED OUT OF THE REFUELING HOLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,300.
Air bags, Jul 14, 2016
AIR BAGS COIL SPRING HAS BEEN REPLACED 4 TIMES. THE AIR BAG WARNING LIGHT IS ALWAYS ON AND KIA REFUSES TO FIX THE PROBLEM. I DON'T KNOW IF THE AIR BAGS WILL DEPLOY IN CASE OF A ACCIDENT. THIS IS BEEN A PROBLEM FROM THE DAY I PURCHASE THE CAR. I DON'T KNOW THE MAKER OF THE AIR BAG SISTEM.
Fuel/propulsion system, Jun 25, 2016
EVERY TIME I HAVE TO FILL THE GAS TANK ON MY KIA SORENTO 2003 IT SHOOTS BACK THE GASOLINE LIKE A PROYECTILE. IT TAKES AN ETERNITY TO FILL THE GAS TANK IF YOU DON'T WANT TO HAVE GAS ALL OVER YOU. I HAVE EVEN BEING KICKED OUT OF SOME SERVICE STATIONS BECAUSE SPILING SO MUCH GAS IS A HAZARD. IS THERE ANY SAFETY RECALL FOR THIS PROBLEM? I HAVE NOT HEARD A WORD FROM KIA.
Electrical system, Jun 25, 2016
THE DRIVER DOOR CANNOT BE OPENED FROM INSIDE OR OUTSIDE. I UNDERSTAND THIS IS A COMMON PROBLEM WITH KIA SORENTOS.
Steering, Suspension, Structure, Jun 21, 2016
WHILE DRIVING I HEARD A CLUNK AND A THE CAR BEGAN ROLLING SIDE TO SIDE. I LIMPED TO A MECHANIC AND WAS TOLD THAT THE FRAME WHERE THE SUSPENSION AND ALL PARTS CONNECT WAS RUSTED OUT. FRAME REPAIR SAID THIS CAN NOT BE FIXED AS THE FRAME IS RUSTED OUT. WHERE THE STABILIZER AND SUSPENSION CONNECTS. TEH CAR ONLY HAS 149,OOO MILES AND IS IN NORTH CAROLINA. I HAVE READ OTHER REPORTS OF A RUSTED OUT SUPPORT FRAME ON THIS SITE. WILL THE MANUFACTURER REPLACE THIS FRAME.