2003 Kia Sorento
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 308 owner complaints filed for this model year. This is the 9th highest complaint count among 23 Sorento model years with reports.
Of the 2003 reports, 10 involved a crash and 3 involved a fire. 12 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsAug 4, 2005
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Campaign 05V353000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
82 reports, newest first. Show all
Engine and engine cooling, Power train, Sep 6, 2005
I HAVE CONSISTENTLY HAD PROBLEMS WITH MY CAR FROM THE 1ST MONTH OF PURCHASE. THE MAJOR PROBLEMS HAVE BEEN: CHECK ENGINE LIGHT KEPT COMING ON AND A PROBLEM WITH THE DRIVE SHAFT. THE CHECK ENGINE LIGHT PROBLEM WAS RESOLVED APPROXIMATELY 2 ATTEMPTS AFTER IT FIRST APPEARED. IT WAS DIAGNOSED AS A PROBLEM WITH THE TSP. THE PROBLEM WITH THE DRIVE SHAFT HAS NOT YET BEEN RESOLVED AS IT STILL CONTINUE TO VIBRATE AT SPEEDS HIGHER THAN 65 MPH. THESE PROBLEMS CONCERN ME AS IT MAY INTERFERE OR HINDER WITH MY DRIVING ABILITIES AND CAUSE AN ACCIDENT. *JB
Engine and engine cooling, Jun 20, 2005
HARMONIC BALANCER BOLT BROKE. TRAVELING LESS THAN 5MPH. VEHICLE STARTED TO VIBRATE. UPON INVESTIGATION, FOUND THAT THE MAIN BOLT HOLDING THE HARMONIC BALANCER IN HAD SHEARED OFF. THERE WERE SOME RUST DEPOSITS AT THE BREAKAGE POINT. THIS OCCURED WHILE ON AN OFFROAD TRIP. THE VEHICLE WAS LEFT IN THE BACKCOUNTRY. I WILL HAVE TO ATTEMPT TO MAKE REPAIRS IN THE FIELD IN ORDER TO GET IT TO THE DEALER. THERE IS NO WAY TO TOW THE VEHICLE OUT OF ITS CURRENT POSITION.
Suspension, Engine and engine cooling, Power train, Electrical system, Exterior lighting, Mar 15, 2005
WHILE DRIVING, THE ENGINE BLEW OUT THE FIRST TIME ON 10-04-04. IT WAS REPLACED AND IT BLEW AGAIN ON 01-21-05. THE VEHICLE IS ON ITS THIRD ENGINE. *AK THE KEY BECAME STUCK IN THE IGNITION, THE VEHICLE SHIFTED OUT OF PARK. THE CONSUMER STATED HE HAS HAD TRANSMISSIONS AND ENGINE PROBLEMS SINCE HE PURCHASED THE VEHICLE. THE FRONT WHEEL BEARINGS WERE DAMAGED. THE FOG LIGHT WAS INOPERATIVE. *JB
Engine and engine cooling, Air bags, May 28, 2004
I WAS DRIVING MY VEHICLE TO WORK. FOR THE PAST 2 TO 3 DAYS, I NOTICED SOME NOISE FROM MY ENGINE THAT SOUNDED LIKE A LOOSE BELT. NO PROBLEM, I COULD REPLACE IT ON THE WEEKEND. ON THE WAY TO WORK, MY POWER STEERING WENT AND THE ENGINE LIGHT FLICKERED ON AND OFF. I DIDN'T WANT TO BE STUCK ON A BACKROAD IN MAINE WITH NO CELL SERVICE SO I CONTINUED, SLOWLY, TO WORK. AFTER REACHING WORK, I HAD THE 24 HOUR SERVICE TOW MY KIA SORENTO TO THE NEAREST DEALER. THIS VEHICLE IS 18 MONTHS OLD AND THEY TELL ME THE BOLT HOLDING THE CRANKSHAFT TO THE PULLEY HAS SHEARED OFF. THEY CANNOT REMOVE THE BOLT PIECES FROM THE CRANKSHAFT AND HAVE TO REPLACE IT. TO TOP IT OFF, THE AIRBAG LIGHT WAS ON, FOR THE SECOND TIME, AND THE RADIO HAS BEEN REPLACE TWICE. *LA
Engine and engine cooling, Nov 12, 2003
WHILE DRIVING , THE ENGINE LIGHT ILLUMINATED AND THE BRAKE PEDAL WENT TO THE FLOOR. THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE ENGINE COILS BURNED OUT. *AK ENGINE PROBLEMS WITH O-RING LEAKING GAS INTO THE AIR VENTS. *LA *JB
Engine and engine cooling, Power train, Aug 1, 2003
THE SORENTO SUV WAS BOUGHT IN JUNE 2003. WITH LESS THAN 1000 MILES IN JUNE 2003 THE SORENTO WAS BROUGHT TO THE DEALER'S SERVICE TO CHECK AN OIL LEAK ON THE FRONT AXLE. THE DEALER CITED AN OVERFILLED GEAR OIL AND THE GEAR OIL LEVEL WAS CORRECTED. AFTER FEW WEEKS, IN JULY 2003, THE SORENTO WAS BROUGHT BACK AGAIN TO THE SAME DEALER BECAUSE THE GEAR OIL LEAK WAS STILL THERE. THE DEALER KEPT THE SORENTO, CITED NON-DRIVABLE AND HAVE TO ORDER THE PART. THE GASKET WAS REPLACED AND SORENTO WAS TEST DRIVEN. THE GEAR OIL LEAK STILL SHOWED UP. NOW THE DEALER SAID THAT THEY GOT HOLD OF KIA AND CITED THAT THEY HAVE TO REPLACE THE BLEEDER TUBE. THE BLEEDER TUBE WAS REPLACED AND THE GEAR OIL LEAK DID NOT GO AWAY. AT THIS TIME, THE WHOLE UNIT OF THE FRONT DRIVE AXLE WAS ORDERED AND REPLACED THE ORIGINALLY INSTALLED UNIT OF THE SORENTO. AFTER THE DEALER TEST DROVE THE NEWLY INSTALLED FRONT AXLE, THE GEAR OIL WAS STILL LEAKING. AT THIS TIME, FOR ALMOST A MONTH, THE SORENTO IS STILL IN THE REPAIR BAY OF THE DEALER AWAITING DIRECTION FROM KIA. *AK
Engine and engine cooling, Vehicle speed control, Apr 24, 2003
VEHICLE WOULD NOT START/HAS BEEN IN SHOP 4 TIMES IN LAST WEEK/1ST TRIP REPLACE THROTTLE BODY 2ND RECALIBRATE ENGINE 3RD TRIP EGI UNIT FAULTY ENGINE LIGHT ON /REPLACE EGI UNIT 4TH TRIP REPLACED THROTTLE BODY(AGAIN) CALIBRATED. CHECKED IDLE SET ..VEHICLE WAS KEPT FOR 2 DAYS ON 2 OF THE VISITS. *NLM