2003 Kia Sorento
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 308 owner complaints filed for this model year. This is the 9th highest complaint count among 23 Sorento model years with reports.
Of the 2003 reports, 10 involved a crash and 3 involved a fire. 12 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsAug 4, 2005
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Campaign 05V353000 on NHTSA.gov
Representative owner complaints
308 reports, newest first.
Engine, May 8, 2015
I PURCHASED THIS CAR BRAND NEW FROM STEVENS KIA IN PATCHOGUE, NY AND HAD THEM REPLACE THE TIMING BELT @ 58K MILES AS PER THEIR GUIDE LINES. WHILE DRIVING THE CAR I LOST MY POWER STEERING AND ELECTRICAL CHARGING SYSTEM, I WAS GOING AROUND 45MPH, I LOST CONTROL OF THE CAR AND WAS ABLE TO GET IT ON THE SIDE OF THE ROAD WITHOUT ANY DAMAGE TO THE CAR OR ANYTHING ELSE. I CALLED CORPORATE KIA AND EXPLAINED THE PROBLEM AND WAS TOLD THE CAR IS OUT OF WARRANTY.(IT HAS 123K MILES ON IT). THEY TOLD ME IF I WANTED I COULD HAVE IT TOWED TO A KIA DEALER AND THEY WOULD LOOK AT IT FOR A DIAGNOSIS FEE, BUT IT WAS STILL OUT OF WARRANTY AND THEY ALSO TOLD ME MY VIN# DIDN'T FALL INTO THE RECALL THEY HAD CONCERNING THAT ISSUE. I HAD MY MECHANIC LOOK AT IT AND HE TOLD ME THE CRANKSHAFT DOWEL PIN SNAPPED ON THE TIMING GEAR CAUSING THE HARMONIC BALANCER TO FALL OFF THUS TAKING ALL THE BELTS WITH IT. IT COSTED ME OVER $2,000 TO HAVE THE CAR REPAIRED. AFTER DOING A GOGGLE SEARCH IT SEEMS THIS IS A COMMON PROBLEM WITH THESE CARS AND IS BEING IGNORED BY CORPORATE KIA. *TR
Fuel/propulsion system, Feb 24, 2015
TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND WITH THE FUEL TANK GAUGE AT 3/4 OR BELOW, THE VEHICLE BEGAN TO SPUTTER AND VIBRATE BEFORE STALLING. THE CONTACT INDICATED THAT THE FUEL TANK NEEDED TO BE AT LEAST 75 PERCENT FULL TO PREVENT THE FAILURE FROM OCCURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 209,000.
Engine and engine cooling, Feb 1, 2015
THE CRANK BOLT BROKE JULY 23, 2013. THE SECOND TIME WAS, THE CRANK BOLT AGAIN AND IT BROKE DECEMBER 19, 2014. THE ODOMETER WAS AT 133181 FOR THE SECOND BOLT BREAK. *TR
Steering, Power train, Engine, Jan 13, 2015
I HAVE SERVICE RECORDS SHOWING I HAD THE CRANKSHAFT PULLEY REPLACED AT 55,000 MILES UNDER WARRANTY BY KIA. THE CRANKSHAFT PULLEY BROKE OFF AT 105,000 MILES. I WAS ABLE TO HAVE THE VEHICLE REPAIRED COST $1500 OUT OF MY POCKET. ON 1/11/2015 THE CRANKSHAFT PULLEY BROKE OFF FOR A 3RD TIME, SHEARING THE THREADS TO THE ENGINE, AND CAUSING THE ENGINE TO NO LONGER WORK. ALL 3 EVENTS CAUSED LOSS OF POWER AND ABLE TO STEER THE VEHICLE. *TR
Engine, Jan 3, 2015
DRIVING VEHICLE AT ABOUT 45MPH, ENGINE STARTED MAKING A SCREECHING NOISE AND GOT LOUDER WHEN ACCELERATING. THERE WAS A LOUD BANG FROM ENGINE AREA AND IMMEDIATELY LOST ALL POWER AND ABILITY TO STEER AND BRAKE. WE WERE APPROACHING A BUSY INTERSECTION AND HAD TO PULL THE EMERGENCY BRAKE TO AVOID RUNNING A RED LIGHT INTO ONCOMING TRAFFIC. HAD VEHICLE TOWED TO OUR DEALERSHIP. THE CRANKSHAFT PULLEY BOLT SNAPPED OFF AND THE BELT AND PULLEY FELL OFF. THE BOLT DID NOT BREAK FAR ENOUGH INTO THE ENGINE BLOCK SO REPAIR WAS ABLE TO REPLACE IT. AFTER THIS HAPPENED WE LEARNED OF THE SAFETY CONCERN WITH SAID VEHICLE AND KIA DENIES ANYTHING WRONG WITH THEIR SORENTOS. THERE IS A PENDING LAWSUIT AGAINST KIA FOR THIS KNOWN PROBLEM. THIS IS A VERY DANGEROUS SITUATION AND WE ADVISED THE DEALER THAT WE WANT TO TRADE THE VEHICLE AS IT POSES A VERY SERIOUS SAFETY PROBLEM. KIA SHOULD PROVIDE A MAJOR RECALL. NOW GETTING A HARD TIME FROM DEALER. WE ARE STUCK IN THE MIDDLE AND STILL OWE A LOT ON THIS HAZARDOUS VEHICLE. *TR
Structure, Dec 24, 2014
APPROX. A WEEK PRIOR HEARD A NOISE LIKE SOMETHING WAS LOOSE AND BEATING UNDERNEATH THE CAR ONLY AT TIMES. TOOK IT TO LOCAL GARAGE AND PUT IT ON RACK AND THE MECHANIC HAD ME TO COME LOOK FOR MYSELF. MY HEART DROPPED. THE FRAME IS SHOT. IT'S EAT UP. HE ASKED ME IF THERE WAS A RECALL ON THIS CAR? AND AS FAR AS I KNOW THERE ISN'T, BUT FOR SURE, SHOULD BE. THIS IS VERY DANGEROUS. ONE BIG BUMP AND THE WHOLE THING IS GONE. YOU CAN TOUCH IT AND THE METAL FLAKES OFF. THIS CAR RUNS SO GOOD AND STILL IS A GOOD LOOKING CAR. HAS ALWAYS BEEN IN A GARAGE NEVER LEFT OUT IN THE WEATHER. THE MECHANIC TOLD ME THEY DON'T MAKE CARS LIKE THEY USED TOO. MY ANSWER WAS MAYBE SO, BUT THIS IS WHAT GETS PEOPLE KILLED, I AM A PERSON THAT WHEN SOMETHING I KNOW IS NOT RIGHT OR HEAR A NOISE I KNOW THAT SHOULDN'T BE THAT WAY!! I GET IT CHECKED OUT. NOW SOME PEOPLE DON'T THAT'S WHY THERE'S SO MANY PEOPLE KILLED ON THE ROADS DUE TO DEFECTS ON CARS THEY PAID THOUSANDS OF DOLLARS FOR. I NEED HELP!! WHAT DO I DO NOW? I'M AFRAID TO DRIVE IT TO MAILBOX AND BACK. *TR
Fuel/propulsion system, Dec 10, 2014
I BOUGHT MY KIA SORENTO 2003 IN NOVEMBER 2013. IN JANUARY OF THE FOLLOWING YEAR I NOTICED A GAS SMELL. I LOOKED UNDER THE VEHICLE AND FOUND A FEW DRIPS ON THE GROUND UNDERNEATH, WHICH WAS GAS. I HAD THE LINE UNDER THE CAB ALONG SIDE DOOR REPLACED. I AM NOTICING A STRONG GAS SMELL COMING FROM THE SIDE TOWARD FRONT AND CAN'T SEE ANYTHING LEAKING. I SAW THAT THERE WAS A RECALL FOR THIS YEAR AND MAKE SO I CALLED KIA AND ASKED THEM IS MY VEHICLE COVERED UNDER THE RECALL AND THEY SAID NO AFTER GIVING THEM MY VIN NUMBER. I SEE THAT ITS NOT JUST THE 2003 VEHICLES WITH THIS ISSUE. JUST BECAUSE I DON'T HAVE THE RIGHT VIN NUMBER THEY SHOULD STILL HONOR MY COMPLAINT. REGARDLESS I'M STILL HAVING THE SAME FUEL ISSUES AS THE ONES ON RECALL. *TR
Structure, Service brakes, Nov 18, 2014
TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE EXITING THE DRIVEWAY WITH THE BRAKES ENGAGED, THE BRAKES FAILED TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS EXCESSIVE CORROSION THAT FRACTURED THE SUBFRAME AND DAMAGED THE BRAKE LINES. AS A RESULT, THE BRAKE LINES NEEDED TO BE REPLACED AND THE CENTER SECTION OF THE FRAME NEEDED TO BE CUT AND REPLACED. THE SUBFRAME WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.
Structure, Service brakes, Oct 18, 2014
WHILE THE CAR WAS IN FOR AN OIL CHANGE THE TECH NOTICED A COUPLE OF BRAKE LINES LOOKED WET, WHEN THEY WHERE CHECKING THE LINES THEY NOTICED THE REAR SUB-FRAME WHICH THE LINES WERE CONNECTED TOO WAS TOTALLY RUSTED OUT. THE CAR IS NO LONGER DRIVABLE DUE TO THE FACT THAT THIS SUB-FRAME HOLDS THE REAR DIFFERENTIAL IN PLACE. *TR
Fuel/propulsion system, Oct 3, 2014
WHEN FUELING THE VEHICLE THE GAS PUMP AUTOMATICALLY SHUTS OFF CONSTANTLY. THE TANK CAN BE EMPTY AND THE PUMP WILL SHUT OFF AS SOON AS YOU START FILLING IT AND CONTINUE TO DO SO AS YOU FILL IT. IT WILL ALSO SPIT GAS OUT OF THE TANK WHILE YOU ARE FILLING IT. THERE SHOULD BE PLENTY OF ROOM FOR GAS AS THE GAS INDICATOR SHOWS EMPTY BUT EVEN AFTER PUTTING ONE GALLON IN THE TANK, THE PUMP WILL SHUT OFF AND/OR GAS WILL SPILL/SPLASH OUT. I HAVE TO STAND BACK WHEN FILLING THE TANK SO THAT I DON'T GET IT ALL OVER ME. THE DATE LISTED FOR INCIDENT IS WHEN IT FIRST STARTED HAPPENING BUT IT CONTINUES TO DO SO EVERY TIME I PUT GAS IN THE VEHICLE. *TR
Steering, Service brakes, Sep 22, 2014
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE MADE AN ABNORMAL NOISE WHEN THE BATTERY AND ANOTHER UNKNOWN WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES BEFORE THE VEHICLE WOULD STOP AND THE POWER STEERING STOP WORKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT PULLEY BOLT WAS HOLDING TOO MUCH WEIGHT CAUSING IT TO FRACTURE. THE VEHICLE HAD BEEN REPAIRED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.
Engine, Aug 31, 2014
THE OVERFLOW BOTTLE FOR THE RADIATOR HAS BEEN LEAKING AGAIN. THE FIRST ONE THAT CAME WITH THE CAR WAS REPLACED IN 2011 AND NOW WE ARE HAVING TO REPLACE THE RADIATOR RESERVOIR AGAIN. *TR
Visibility/wiper, Aug 31, 2014
THE WIPER MOTOR STRIPS OUT EASILY. TOOK IT IN TO HAVE IT FIXED AND IT STILL SLAMS DOWN INTO THE CAR. I WENT BACK IN AND IT STILL DOESN'T WORK. NOW IT COMPLETELY QUIT. *TR
Fuel/propulsion system, Aug 30, 2014
WE WERE ATTEMPTING TO FILL THE SORENTO UP WITH GAS WHEN IT SUDDENLY SPIT GAS OUT OF THE TANK WHEN WE HAD ONLY PUT $11 INTO TO. IT WAS CLOSE TO EMPTY WHEN WE GOT TO THE GAS STATION. WE TRIED A COUPLE TIMES WITH THE SAME RESULT. THE CAR WOULD NOT TAKE ANYMORE GAS. *TR
Engine, Aug 27, 2014
I WAS TOLD BY THE MECHANIC THAT "SOMETHING HAPPENED INSIDE THE ENGINE THAT CANNOT BE REPAIRED". PRIOR TO THE ENGINE FAILURE (MAY, 2014) THE REAR THROTTLE PLATE CAME APART AND LODGED IN THE LOWER INTAKE MANIFOLD. THE MECHANIC WAS UNABLE TO RETRIEVE THE SCREWS AND ONE WAS EVEN LODGED IN A CYLINDER HEAD. A THROTTLE PLATE ASSEMBLY WAS INSTALLED AND THE CAR WAS DRIVABLE BUT WITH AN AUDIBLE NOISE. AT THIS TIME I WAS TOLD THE SAME PROBLEM EXISTS WITH MANY KIA'S AND YET A RECALL HAS NOT BEEN ISSUED. MY CAR IS NOT DRIVABLE, IT'S A V6 AND THE LEFT SIDE OF THE ENGINE IS COMPLETELY SHUT DOWN AND I FEEL KIA COULD HAVE AVOIDED THIS WITH A RECALL WHEN THEY HAVE KNOWN FOR YEARS THAT THE PROBLEM EXISTS. *TR
Steering, Engine, Aug 26, 2014
I BOUGHT A 2003 KIA SORENTO FROM MY NIECE BACK IN NOVEMBER 2013 FOR $2000 AND NOT EVEN TWO WEEKS INTO OWNING THIS VEHICLE, THE CRANK SHAFT BROKE IN HALF! THE BOLT BROKE OFF IN HALF INSIDE THE CRANK SHAFT PULLEY AND THE OTHER HALF OF THE BOLT WAS INSIDE THE CRANK SHAFT CASE. TO MY UNDERSTANDING, THIS IS THE SECOND TIME THAT THE CRANK SHAFT NEEDED REPAIRING (MY NIECE, HUSBAND WHO WERE THE FIRST AND ORIGINAL OWNERS TO THIS KIA SORENTO HAD IT BREAK DOWN ON HIM ON THE FREEWAY AS WELL, HAD TO GET IT TOWED TO KIA THEN PAID THEM TO FIX IT WHEN THEY OWNED THE VEHICLE) BUT THIS TIME, WHEN THIS ISSUE HAPPENED AGAIN WHILE I OWNED THE VEHICLE, THE CRANK SHAFT FAILED IN A GREATER AND MORE COSTLY CONDITION THEN THE FIRST TIME THE CRANK SHAFT FAILED ON THEM. WHICH THEN CAUSED ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF THE CHARGING SYSTEM, LOSS OF THE COOLING SYSTEM AND LOSS OF CONTROL OF THE VEHICLE, EVERYTHING SHUT DOWN, VEHICLE WOULDN'T START UP AFTER THAT AND IT COULD HAVE BEEN A VERY DANGEROUS SITUATION AS IT HAPPENED WHILE ON THE FREEWAY AND WHILE MY HUSBAND, MY DAUGHTER AND MY GRANDDAUGHTER WAS IN THE VEHICLE TRAVELING. IT COULD HAVE JEOPARDIZE THEIR LIFE'S AS WELL AS OTHER! *TR
Fuel/propulsion system, Aug 25, 2014
TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT EXPERIENCED DIFFICULTY PLACING FUEL IN THE VEHICLE. THE FUEL WOULD NOT ENTER THE TANK AND LEAKED OUT WHILE THE CONTACT ATTEMPTED TO INSERT FUEL. AN INDEPENDENT MECHANIC STATED THAT THE VEHICLE NEEDED A NEW CANISTER FILTER, FUEL CAP, AND FILLER PIPE. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE MANUFACTURER WAS CONTACTED. THE MANUFACTURER STATED THE VEHICLE WAS OUT OF WARRANTY. THE CONSUMER WAS NOT NOTIFIED OF ANY RECALLS DUE TO BEING THE SECOND OWNER. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. UPDATED 3/24/2015 *JS
Steering, Air bags, Service brakes, Aug 16, 2014
I WAS COMING HOME FROM WORK ONE DAY ,WHEN THE CRANKSHAFT BOLT CAME OUT OF MY CAR .I BARELY MADE IT HOME .BUT THE FRONT END WAS JARRING MY AIRBAG LIGHT CAME ON MY BREAKS LIKE SAME ONE AND I DID NOT HAVE NO CONTROL OF MY STEERING .THEN IT COST ME 1700 .THEN ONE DAY I WAS IN TOWN AND THE CRANKSHAFT BOLT CAME OUT OF MY CAR AGAIN WHICH THIS TIME I DID NOT HAVE NO CONTROL OF THE STEERING IT TOOK EVERY MUSCLE THAT I HAD TO KEEP IT IN THE ROAD THE FRONT AND SHOOK SO BAD IT JARRED EVERYTHING I LOSE MY AIRBAG LIGHT CAME ON MY BRAKE LIGHTS CAME ON SEAT BELT LIGHT CAME ON IT WAS A HAZARDOUS ON THE HIGHWAY SERIOUSLY KILLED ME OR SOMEONE ELSE OR REALLY BADLY HURT THEM.THEN I TOOK IT BACK TO THE MECHANIC AGAIN AND HE SAID WELCOME IT'S GOING TO COST YOU 1700 MORE WHICH I DID NOT HAVE SO I LET THE BANK HAVE IT BACK WHICH NOW IT HAS RUN MY CREDIT BECAUSE I DIDN'T HAVE THE MONEY TO GET IT FIXED AND I LOST MY CREDIT BECAUSE OF THISSO YES THEY NEED TO DO A RECALL ON THE CRANKSHAFT BOLT BEFORE IT DOES KILL SOMEONE IS THAT WHAT THEY'RE WAITING FOR FOR SOMEONE TO DIE BEFORE THEY DO SOMETHING ABOUT.AND I KEEP ON REPLACING BUGS BRAKE LIGHTS HEADLIGHTS AND EVERYTHING THEY KEEP ON BLOWING IN THIS IN THE KIA AND I KEEP ON PUTTING MONEY IN IT FOR ME TO GET IT INSPECTED IT COST ME A HUNDRED SIXTY TWO DOLLARS AND 22 DISH TO REPLACE BULBS THAT I JUST REPLACE NOT EVEN A MONTH BEFORE THAT I HAVE RECEIPTS I AM SO TIRED OF PUTTING MONEY INTO THIS KIA I DIDN'T HAVE NO OTHER CHOICE BUT TO LET THEM TAKE IT BECAUSE IT C AND THE TIRES AT 8 MY TIRES UP AND I PUT NEW TIRES ON WHICH COST ME 800 800 AGAIN TO PUT IN800 AGAIN TO PUT INAND WHEN THIS BIT WHEN THIS HAPPENED I CALLED KIA IN CHARLOTTESVILLE VIRGINIA AND THEY SAID THEY PUT A NEW CRANK BOLT IN AT THE KIDS EMBRACE CHEVROLET BEFORE I BOARDED SO THIS WOULD MAKE THREE TIMES THE CRANKSHAFT BOLT HAD BEEN REPLACED I WANT THIS KIA..................
Fuel system, Gasoline, Jul 24, 2014
FUEL LINE LEAKING. FIXED AND NOW LEAKING AGAIN SOMEPLACE ELSE. *TR
Fuel/propulsion system, Jul 22, 2014
WHILE PUMPING, THE FUEL SPITS BACK OUT FROM THE TANK. IT IS RATHER ANNOYING AS I LOSE MONEY FUELING AND IT TAKES FOREVER TO FUEL. NORMALLY WHEN I REACH ABOUT $15.00 IN GAS IT BEGINS REGURGITATING. THIS HAPPENS EVERY TIME I ATTEMPT TO FUEL. *TR
Engine, Jul 11, 2014
MY CHECK ENGINE LIGHT CAME ON 2 MONTHS AGO AND I BROUGHT IT TO A KIA DEALERSHIP WHO TOLD ME IT WAS THE CYLINDERS THAT WERE MISS FIRING AND THE BELTS NEEDED TO BE REPLACES AND THEY FIXED THAT. I ASKED ABOUT THE CRANKSHAFT AND THEY TOLD ME IT WAS FINE. WHEN I LEFT THE LIGHT CAME BACK ON AND THEY TOLD ME I NEED NEW SPARK PLUGS, FIXED THAT AND THE LIGHT CAME BACK ON AGAIN. WHILE DRIVING ON THE HIGHWAY THE BREAK LIGHT AND BATTERY LIGHT CAME ON AND THE CAR BEGAN TO LOOSE POWER. NOW THE CAR IS AT ANOTHER DEALERSHIP AND THEY ARE TELLING ME IT'S THE CRANKSHAFT. AFTER READING WHAT HAS HAPPENED WITH MANY OTHER PEOPLE I CAN SEE THE ORIGINAL PROBLEM WAS THE CRANKSHAFT.I HAVE SPENT OVER $4K ON FIXING THE CAR AND THE CAR IS NOT WORTH IT. *TR
Fuel system, Gasoline, Electrical system, Engine, Jul 10, 2014
I AM SINGLE OLD LADY, LATE JAN.2014 , DRIVING BACK FROM ORLANDO,FL. TO MY HOME<2 HRS AWAY> ON I-95 CAR SLOWS DOWN, ALL LIGHTS GO ON DASHBOARD. GET HOME AT 40 MILES AN HOUR.NEXT DAY GO TO TIRE PLUS, CAN NOT FIX CAR, ENGINE TROUBLE..GO TO DEALER BEV SMITH KIA, FT.PIERCE, FL, I AM A REGULAR THERE,WITH CAR PROBLEMSELL ME CAN NEEDS NEW LOWER ENGINE, $7000 I ALMOST FAINT, , CAR NOT SAFE, I LEFT ANYWAY, THEY WOULD NOT EXACTLY TELL ME WHAT WRONG WITH CAR...COWORKER AT WALMART, TELLS ME OF MECHANIC,CAN FIX IT...TAKE IT THERE, HE TELLS ME WHAT REALLY IS WRONG WITH CAR..SCREW THAT HOLD HARMONY PART, HAD BROKEN OFF, HALF OF IT WAS STILL STUCK INTO LOWERE ENGINE< BY THE WAY, THIS WAS A RECALL BACK 3 YEARS AGO, IN WHICH I HAD COMPLYED WITH KIA AND THEY HAD REPLACED NEW HARMONY SCREW>...THIS HONEST MECHANIC, TOLD ME LEAVE KIA OVER THE WEEKEND, WILLPUT PUT SCREW SOFTENER ON SCREW STILL IN ENGINE, SEE IF IT COMES OUT...IT DID, THEY PUT NEW SCREW, GIVE ME ALL NEW BELTS, I PAID $1,800 OF MY OWN MONEY, ..I GO AHEAD AND DRIVE TO MIAMI, FLL< 2 HRS AWAY> DAY LATTER I DRIVE TO ORLANDO ,FL.< 3 HRS AWAY>...IN I 95....NEXT DAY,TRY TO GET OUT OF MY DRIVEWAY, SAME THING HAPPENED...GOOD MECHANIC COMES OVER TO MY HOUSE, SAID SAME SCREW CAME OFF...HE FIXES IT AGAIN, $1,500, ...HE TELLS ME, GET NEW CAR, DO NOT KEEP THIS KIA SORENTO 2003, CAR HAS FLAW, CAN NOT BE FIXED....IF KEEP IT, JUST FOR AROUND TOWN DRIVE, UNDER 50 MILES AN HOUR, DO NOT TAKE TURNPIKE OR INTERSTATE HIGHWAYS...I CONTACTED KIA MOTORS, BEV SMITH KIA, TOLD THEM ABOUT RECALL SCREW REPLACEMENT , TELL ME OUT OF WARRANTY, NEITHER WILL REALLY ANSWER BACK...NO MONEY, NO NEW CAR....KIA MOTORS IS A CROOK,...TELL ME CAR OUT OF WARRANTY, THAT WHAT DO I WANT WITH OLD CAR...CAN NOT FIND ANY OTHER PRIOR COMPLAINTS I MADE WITH CAR, SINCE FIRST YEAR I BOUGHT IT... *TR
Steering, Electrical system, Engine, Jul 7, 2014
AS MY FAMILY AND I DROVE DOWN 146 TOWARDS BAYTOWN, TX FROM DAYTON, TX I HEARD A LOUD "THUD". IMMEDIATELY FOLLOWED BY A LOSS OF A/C, POWER, AND STEERING. I PULLED ONTO THE SHOULDER IMMEDIATELY AND POPPED THE HOOD. I SAW THE HARMONIC BALANCE LYING ON THE SPLASH GUARD AND A BELT LYING BESIDE IT, AS WELL AS ANOTHER BELT LOSS BUT STILL HANGING ON THE OTHER PULLEYS. I GOT A FRIEND TO TOW ME BACK TO MY STUDIO. I BEGAN SEARCHING ONLINE FOR WHY THE BOLT THAT HOLDS THE BALANCE COULD JUST BREAK. I FOUND NUMEROUS REPORTS OF THIS PROBLEM, AS WELL AS LAW SUITS FILLED IN OTHER STATES FOR THIS VERY ISSUE. *JS
Steering, Other or unspecified, Jun 13, 2014
WHILE DRIVING AT A SAFE SPEED (35MPH) WITH MY CHILDREN IN THE CAR MY POWER STEERING FAILED AND ALL MY DASH LIGHTS CAME ON. I WAS ABLE TO PULL OVER THIS TIME OUT OF HARMS WAY. ONCE I GOT THE CAR TO THE SIDE OF THE I HAD NOTICED THAT ONE OF MY BELTS CAME OFF. I GOT IT TOWED TO THE MECHANIC FIRST THING THE NEXT MORNING AND TOLD ME A BOLT CAME OFF THE PULLEY AND THE PULLEY WAS OFF. THEY FIXED THE CAR AND I WAS GOOD UP UNTIL IT HAPPENED 4 MORE TIMES. LUCKILY I WAS THE ONLY IN THE CAR AT THE TIME IT HAPPENED THE LAST TIME DUE TO THE FACT I WAS ON A HIGHWAY AND GOING 70MPH. ONCE AGAIN I MANAGED TO GET TO THE SIDE OF THE ROAD TO SAFETY. WITH THIS HAPPENING NUMEROUS TIMES NO ONE WANTS TO FIX THE CAR ANYMORE AND I DON'T UNDERSTAND WHY A RECALL HAS YET TO BE MADE ON SOMETHING SO SIMPLE. ALSO IN MY STATE MY CAR IS NOT PROTECTED UNDER THE LEMON LAW. *JS
Steering, Power train, Engine, Jun 10, 2014
THE BOLT ON THE CRANKSHAFT PULLEY AS WELL AS THE PIN BROKE OFF CAUSING THE MOTOR TO STOP AND OVERHEAT DUMPING ALL THE ANTIFREEZE AND STOPPING ALL BELTS. MY MOTHER COULD HAVE BEEN INJURED WHILE DRIVING BUT IT ENDED UP BEING SHE WAS JUST BLOCKING TRAFFIC THANKFULLY AND NOT ON THE HIGHWAY. THIS SEEMS TO BE A VERY COMMON ISSUE WITH HUNDREDS IF NOT THOUSANDS COMPLAINING ABOUT THE CRANKSHAFT PULLEY BOLT AND PIN. KIA SAYS THEY WON'T DO ANYTHING AS IT IS OUT OF WARRANTY AND I AM NOT THE ORIGINAL OWNER. THIS MAY HAVE BEEN FIXED ONCE BEFORE ON THE VEHICLE DUE TO FAILURE AND I AM VERY WORRIED THIS MAY HAPPEN AGAIN WITH WORSE CONSEQUENCES. MY MECHANIC WAS ABLE TO PROVIDE A TEMPORARY/PERMANENT FIX BUT WE REALLY DODGED A BULLET AND IT COULD HAVE CAUSED IMMEDIATE CATASTROPHIC DAMAGE. I'M DISAPPOINTED WITH ALL OF THE SERIOUS COMPLAINTS THAT KIA STILL HAS NOT RECALLED IT FOR 2002-2009 SORENTO MODELS. *TR