2005 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 307 owner complaints filed for this model year. This is the 10th highest complaint count among 23 Sorento model years with reports.
Of the 2005 reports, 17 involved a crash and 5 involved a fire. 20 people were injured and 1 person died.
What owners report most often
Recalls and investigations
No safety recalls on file.
Representative owner complaints: engine and engine cooling
44 reports, newest first. Show all
Steering, Engine and engine cooling, May 19, 2010
TL*THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING AT 15 MPH, THE CONTACT NOTICED THAT THE POWER STEERING SUDDENLY STOPPED FUNCTIONING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE CRANK SHAFT PULLEY BOLT NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 72,000. UPDATED 07/29/10 *BF THE CONSUMER ALSO STATED THE VEHICLE LOST STEERING. UPDATED 08/09/10*JB
Engine and engine cooling, May 4, 2010
TL*THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING AT 10 MPH AND MAKING A RIGHT TURN, THE BOLT THAT CONNECTED THE PULLEY AND CRANKSHAFT SNAPPED CAUSING THE CONTACT TO LOSE CONTROL OF THE STEERING. THE ENGINE TURNED OFF AND THE VEHICLE CAME TO AN ABRUPT STOP IN THE MIDDLE OF THE ROAD. THE CONTACT RESTARTED THE VEHICLE AND TOOK IT THE NEAREST REPAIR SHOP WHERE THE PULLEY FELL TO THE GROUND WHEN LIFTED FOR DIAGNOSIS. THE CONTACT CALLED BOTH THE DEALERSHIP AND THE MANUFACTURER BUT WOULD NOT COVER THE REPAIR EXPENSES. THE VEHICLE WAS AWAITING REPAIR AT ANOTHER REPAIR SHOP AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.
Engine and engine cooling, Power train, Apr 17, 2010
EARLIER RECALL DEFECTIVE!!! 2005 KIA SORENTO V6, HAD A RECALL OF BREAKAGE OF CRANKSHAFT ACCESSORY PULLEY BOLT. NEW BOLT FROM THE RECALL HAS ALSO FAILED. MY CRANKSHAFT PULLEY AND BOLT FELL OUT ON THE HIGHWAY WHILE IN OPERATION. KIA SERVICE REFUSES TO COVER THE NEW BOLT ON WARRANTY. HAD BOLT TIGHTENED AT LOCAL SHOP AND IT FAILED AGAIN IN 3 DAYS!!! KIA IS FAILING TO FIX THIS PROBLEM IN WHICH WILL RESULT IN FATALITY ACCIDENTS. *TR
Engine and engine cooling, Apr 13, 2010
MY 2005 KIA SORENTO CUT OFF WHILE I WAS DRIVING, THROWING ME INTO A SPIN AND LEAVING ME FACING THE WRONG WAY INTO ONCOMING TRAFFIC. COULD HAVE KILLED ME AND MY KIDS. HAD IT TOWED TO DEALERSHIP. THEY JUMP STARTED IT AND SAID THEY COULDN'T DUPLICATE THE PROBLEM. THEY DID NOTHING. IT SUBSEQUENTLY CUT OFF IN TRAFFIC 3 MORE TIMES. CALLED THE DEALERSHIP, THEY SAID IT WASN'T A WARRANTY ISSUE (THIS WAS THE MONTH OF THE WARRANTY EXPIRATION BUT IT HADN'T EXPIRED YET) AND SINCE THEY COULDN'T DUPLICATE THE PROBLEM THERE WAS NOTHING TO FIX. KIA IS PARKED AND I WON'T DRIVE IT. THEY DON'T HONOR THEIR WARRANTY AND KNOW ABOUT THIS DEFECT AND WON'T TRY TO FIX IT DURING WARRANTY PERIOD. *TR
Steering, Engine and engine cooling, Interior lighting, Oct 26, 2009, fire
WHILE RETURNING FROM OUR VACATION OUR KIA STARTED MAKING AT LOT OF NOISES IN AROUND THE AIRCONDITIONING HEATING SYSTEM, THE AIR COMING FROM THE VENTS DIDN'T SEEM TO BE WARM ENOUGH TO DEFOG THE WINDOWS, THEN THE NEXT DAY WHEN IT WAS WARMER IT STARTED MAKING A RATTLING FAN NOISE WHEN THE AIR WAS TURNED ON. WHEN THE SYSTEM WAS TURNED OFF IT DIDN'T MAKE THE NOISE ANYMORE. WE ARRIVED HOME UNLOADED OUR GEAR AND THEN WENT OUT AGAIN A WHILE LATER. THE FAN NOISE STARTED AGAIN AND THE WARNING LIGHT CAME ON AND THE POWER STEERING DIDN'T WORK, WHEN THE AIR WAS TURNED OFF EVERYTHING RESUMED TO NORMAL. WE ARRIVED AT OUR FRIEND HOUSE AND WENT INSIDE. AFTER SEVERAL MINUTES WE SMELLED SOMETHING BURNING AND WENT OUTSIDE TO SEE SMOKE COMING FROM THE ENGINE AREA. WE LIFTED THE HOOD TO INVESTIGATE WHERE WE SAW FLAMES COMING FROM THE ENGINE. WE IMMEDIATELY EXTINGUISHED THE FIRE AND HAD THE VEHICLE TOWED THE NEXT DAY. COME TO FIND OUT SEVERAL DAYS LATER THAT OUR VEHICLE WAS TOO BADLY BURNED TO REPAIR THE ENGINE. THE ENGINE HAD TO BE REPLACED DUE TO A TIMING BELT FAILURE. IF THIS IS AN ONGOING PROBLEM IT SHOULD BE MANDATORY THAT THEY SHOULD BE REPLACED BY WHOMEVER OWNS THE VEHICLE OR THE DEALER IF THE CAR HAS BEEN TRADED BECAUSE THE NEXT OWNER WOULD NOT KNOW ANY OF THE PREVIOUS REPAIRS SUCH WAS OUR CASE. AS IT STANDS NOW THERE ARE SOME INTERIOR ELECTRICAL PROBLEMS SUCH AS THE LIGHTS AN THE ELECTRONIC SEATS WE ARE HOPING FOR SOME KIND OF RECALL FOR THIS PROBLEM. THERE WAS ALSO A PROBLEM WITH THE FAN RUNNING ON AFTER THE CAR WAS TURNED OFF. THIS WAS STILL HAPPENING EVEN AFTER THE ENGINE HAD BEEN REPLACED AND WE WERE TOLD EARLIER THAT IT WAS A SENSOR PROBLEM WHICH STILL HAPPENED EVEN AFTER THE SENSOR WAS REPLACED. *TR
Engine and engine cooling, Aug 17, 2009
BALANCER BOLT HAS BROKEN OFF IN THE CRANK SHAFT PULLEY CAUSING THE ALTERNATOR NOT TO SPIN. REQUIRED TO DRILL OUT THE BOLT AND REPLACE THE BALANCER AND REMOVE AND REPLACE THE SPROCKET. *TR
Engine and engine cooling, May 4, 2009
TL*THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT THE ENGINE WAS MAKING A LOUD KNOCKING NOISE. WHEN SHE STARTED THE VEHICLE, IT BEGAN TO SHAKE SEVERELY AND MAKE A TICKING NOISE. THE VEHICLE COULD NOT BE DRIVEN AND WAS TOWED TO THE DEALER. THE TECHNICIAN FOUND PARTICLES THAT RESEMBLED METAL FRAGMENTS IN THE ENGINE. THE ENTIRE ENGINE HAD TO BE REPLACED. THE FAILURE MILEAGE WAS 62,000.
Engine and engine cooling, Jun 26, 2008
DRIVING OUT OF MY OFFICE PARK AT LUNCH TIME, HEARD FAN NOISE LIKE LOOSE BELT, THEN WHEN TURNING WHEEL TO EXIT LOT, HEARD A LOUD "CLUNK" AND LOST POWER STEERING. ENGINE SITTING LOOSE IN COMPARTMENT LAND LOOSE BELTS EVERYWHERE. CALLED ROADSIDE ASSISTANCE AND HAD VEHICLE TOWED TO DEALER. TOLD 2.5 HOURS LATE, WHEN I CALLED TO THE DEALER, THAT THE CRANKSHAFT BOLT WAS BROKEN AGAIN. CONTACTED KIA CONSUMER AFFAIRS AND FOUND ALTHOUGH THERE IS AN ACTIVE CAMPAIGN TO RECALL THIS BOLT, MY VIN IS NOT ON THE LIST (THIS IS THE SECOND FAILURE). ALTHOUGH "SHORT BLOCK" WAS REPLACED AT LAST FAILURE (IN 4/07 AT 20,200 MI) THIS FAILURE REQUIRED MACHINING THE BOLT OUT AND ONLY REPLACING THE CRANKSHAFT SPROCKET, CRANK PULLEY AND CRANKSHAFT BOLT, THEN REINSTALLING OTHER COMPONENTS. CONTACTED KIA CONSUMER AFFAIRS 6/18/08 AND REQUESTED DIST SERVICE MGR APPROVAL SHORT BLOCK REPLACEMENT. NO RETURN PHONE CALLS ALTHOUGH MESSAGES WERE LEFT FOR AGENT ON 6/19 AND 6/20. AGENT CALLED ON 6/25/08 TO ASK "HOW IS THE VEHICLE RIDING?", BUT WE HAD NOT PICKED UP THE VEHICLE FROM THE DEALER, SINCE YET AGAIN NO ALTERNATE TRANSPORTATION WAS PROVIDED. SAFETY IS NOW A MAJOR CONCERN WITH THIS VEHICLE. NO CONFIDENCE IN REPLACEMENT PARTS TO SOLVE THIS PROBLEM. RESEARCH SHOWS MANY OTHER OWNERS REPORTING MULTIPLE FAILURES OF THE CRANKSHAFT BOLT. REPAIR TOOK 6 BUSINESS DAYS (8 CALENDAR DAYS) AND AGAIN NO ALTERNATE TRANSPORTATION WAS OFFERED OR PROVIDED. WWW.KIA-FORUMS.COM HAS INFORMATION FROM A KIA TECHNICIAN THAT THE CRANKSHAFT PROBLEM IS DUE TO A DESIGN FLAW THAT CANNOT BE FIXED BY REPLACING A BOLT EVERY 10,000 TO 20,000 MILES OR EACH FAILURE. NO OWNER SHOULD BE EXPECTED TO WAIT FOR ANOTHER FAILURE THAT DROPS THE BOTTOM HALF OF THE ENGINE. THIS IS A SERIOUS SAFETY CONCERN THAT NEEDS TO BE ADDRESSED. I HAVE BEEN FORTUNATE THAT THE FAILURES HAVE BEEN OUT OF TRAFFIC AND NOT ON THE INTERSTATES. LIVING IN METRO ATLANTA, GA MEANS I A FAR GREATER CHANCE OF THE NEXT FAILURE CAUSING INJURY TO ME OR OTHERS. *TR
Engine and engine cooling, Jun 26, 2008
CHECK ENGINE LIGHT CAME ON AND ENGINE IDLED VERY ROUGH. FEARING REPEAT OF CYLINDER MISFIRE THAT OCCURRED IN SEPTEMBER 2006 TOOK VEHICLE STRAIGHT TO DEALER. CAUSE DETERMINED TO BE A FAULTY EVAP PRESSURE SENSOR. REPLACED SENSOR UNDER WARRANTY. *TR
Engine and engine cooling, Jun 26, 2008
TURNING INTO THE DRIVEWAY FROM A SHORT TRIP TO THE CORNER GAS STATION, I HEARD A LOUD "CLUNK", LOST POWER STEERING AND VEHICLE WOULD NOT RESTART. CONTACTED KIA ROADSIDE ASSISTANCE AND HAD VEHICLE TOWED TO DEALERSHIP. DEALER INDICATED THE CRANKSHAFT BOLT BROKE. DEALER REPLACED THE "SHORT BLOCK" UNDER WARRANTY. REPAIRS TOOK 5 DAYS AND NO ALTERNATE TRANSPORTATION WAS PROVIDED. *TR
Engine and engine cooling, Jun 26, 2008
CHECK ENGINE LIGHT CAME ON WHILE TRAVELING WITH 100 MILES OF HOME ON 9/22/06. CALLED KIA ROADSIDE ASSISTANCE, THEY RECOMMENDED CONTACTING THE DEALER. TOOK TO DEALER SAME DAY, THEY RESET THE LIGHT AND RECOMMENDED USING A HIGHER OCTANE FUEL AND RETURN FOR SERVICE IF LIGHT RETURNS. RETURNED TO DEALER ON 9/26/06 WITH LIGHT ON AGAIN. TESTING SHOWED CYLINDER #3 MISFIRED AND CAUSED INTERNAL ENGINE DAMAGE. ENGINE REPLACED AT 12,149MILES UNDER WARRANTY AND 9/27/06. *TR
Engine and engine cooling, Aug 2, 2007
WHILE DRIVING THE VEHICLE THE MOTOR STARTED KNOCKING EXTREMELY LOUD. DID NOT OVERHEAT AND OIL LEVEL WAS FINE. ON JULY 31 I RECEIVED A PHONE CALL FROM MS STEVENS (CENTRAL KIA) TO AUTHORIZE FOR THE DIAGNOSIS OF THE VEHICLE. THE COST TO DIAGNOSE THE PROBLEM WILL BE $80.00 IF NOT COVERED UNDER WARRANTY. ON AUGUST 1ST I RECEIVED A CALL FROM MS. STEVENS STATING THE TECHNICIAN SAW SIGNS OF ?SLUDGE? WHEN HE REMOVED THE OIL CAP. MS. STEVEN QUESTIONED IF THERE WAS KNOCKING NOISE PRIOR TO THE FAILURE. I EXPLAINED THERE WAS NO NOISE PRESENT AND THE LAST OIL CHANGE WAS APPROXIMATELY 3,800 MILES AGO. MS. STEVENS SAID SHE HAD TO GET AUTHORIZATION TO PROCEED TO GO ANY FURTHER BECAUSE OF THE EVIDENCE OF ?SLUDGE?. IF THE FAILURE WAS DUE TO ?OIL STARVATION? IT WOULD NOT BE COVERED UNDER WARRANTY AND THE FURTHER DIAGNOSIS WOULD COST APPROXIMATELY $500.00. I QUICKLY DISMISSED THE POSSIBILITY THAT THE ENGINE HAD BEEN ?OIL STARVED?. IF THE ENGINE WAS OIL STARVED THE FAILURE WOULD MOST LIKELY HAPPEN OVER TIME. THIS FAILURE WAS IMMEDIATE. MS. STEVENS AGREED AND EVEN MENTION THAT SHE HAS SEEN AND THE TECHNICIAN AS EXPERIENCED A MALFUNCTION WITH A WING NUT AND BOLT BREAKING AND FALLING INTO THE LOWER PART OF THE MOTOR. SHE BELIEVED THAT IS WHAT HAPPENED IN THIS CASE WHICH WOULD BE COVERED UNDER THE 100,000 MILE WARRANTY. ON THURSDAY AUGUST 2ND AT APPROXIMATELY 11:00AM I WENT TO CENTRAL KIA IN PLANO AND MET WITH MS. STEVENS. MS STEVENS TOLD ME THE WORK ON MY VEHICLE HAD NOT BEGUN. AT APPROXIMATELY 1:30 PM I RECEIVED A PHONE CALL FROM MS. STEVENS STATING A MALFUNCTION IN THE MOTOR OCCURRED INVOLVING A FAILED PART (BOLT). MS. STEVENS NOW IS REQUESTED FOR ME TO PRODUCE MAINTENANCE RECORDS OR THE DEFECTIVE ENGINE WILL NOT BE COVERED UNDER WARRANTY. IT IS VERY FRUSTRATING TO ME TO KNOW THAT KIA KNEW OF THE FAULTY PART PRIOR TO THE DIAGNOSIS, THEN FINDING THE PROBLEM THEN PLACING THE MONKEY ON THE CONSUMERS BACK BEFORE THEY WILL COVER IT UNDER WARRANTY. *JB
Engine and engine cooling, Jul 18, 2007
AT UNDER 20,000 MILES I WAS TOLD I NEED A NEW ENGINE. THEY HAVE HAD THE CAR FOR TWO WEEKS AND WON'T GIVE ME A RENTAL IN THE MEANTIME.*AK
Steering, Engine and engine cooling, Apr 18, 2006
2005 KIA SORENTO V6, BREAKAGE OF CRANKSHAFT ACCESSORY PULLEY/VIBRATION DAMPER BOLT, CAUSING LOSS OF POWER STEERING DUE TO POWER STEERING BELT TO BECOME INOPERATIVE. THIS PROBLEM EFFECTS 2003 TO 2006 KIA SORENTO V6 ENGINES MANY OWNERS HAVE HAD MULTI FAILURES OF THIS BOLT, THE UPDATED BOLTS FAIL TOO. KIA IS TRYING TO HIDE THIS SERIOUS PROBLEM AND HAS NO INTENTION OF A REAL FIX. MY VEHICLE AND OTHERS ARE AFRAID TO DRIVE OUR KIA SORENTO'S. *NM
Engine and engine cooling, Sep 13, 2005
CHECK ENGINE LIGHT,NEEDED CANISTER CLOSE V CANISTER ASS/CHECK ENGINE INSTALL CCV FILTER AND SPLASH SHIELDS/CHECK ENGINE SENSOR FUEL TANK/ STILL WAITING FOR SENSOR. NOW CANNOT PUT GAS IN VEHICLE, KEEPS BACK SPLASHING OUT, ON 1/4 TANK AND CANNOT PUT GAS IN,STILL WAITING FOR PART. *NM
Engine and engine cooling, Electrical system, Air bags, Seats, Aug 9, 2005
DT: 2005 KIA SORENTO. THE AIRBAG LIGHT STAYED ON. THEY HAVE REPLACED THE SEAT, T AND SENT THE SEAT OFF TO HAVE THE SENSOR REPLACED. THE DEALERSHIP SAID THERE WAS NOTHING ELSE THEY COULD DO. THE CHECK ENGINE LIGHT CAME ON AND THE VEHICLE STALLED. THIS HAPPENED TWICE IN ONE DAY. THE VEHICLE WILL RESTART AFTER WAITING A WHILE. ALSO, THE CLOCK HAD TO BE REPLACED TWICE. *AK
Engine and engine cooling, Jun 8, 2005
1) SLOWED CAR TO PUT INTO PARK & CAR LUNGED FORWARDED, BACKED OFF, LUNGED FORWARD, BACKED OFF, ETC. TAPPING SOUND CAME FROM ENGINE. 2) CAR ENGINE STOPPED AND WOULD NOT RESTART (STALLED ON ROADWAY) 3) IT IS CURRENTLY IN THE DEALERSHIP FOR REPAIRS, AFTER THEY TOLD ME THEY COULDN'T GET IT TO DUPLICATE THE PROBLEM (ALTHOUGH THE 1ST DAY IT WAS IN THE DEALERSHIP, THEY ANKNOWLEDGED IT WAS "MISFIRING".) THEY HAVE NOW STATED THAT A CLIP ON THE INTAKE MANIFOLD COMES DISLODGED AND END UP IN THE CATALYTIC CONVERTER, AND THIS COULD HAVE CAUSED THE PROBLEM. MY CAR HAS BEEN OUT OF SERVICE FOR 3 DAYS, AS OF THIS WRITING, AS THEY HAVE ORDERED A NEW INTAKE MANIFOLD.
Steering, Service brakes, Hydraulic, Engine and engine cooling, Air bags, Jan 19, 2005
2005 KIA SORENTO EX DEVELOPED PROBLEMS WITH THE POWER STEERING.***NO ANSWER REQUIRED***. *MR WITHIN A FEW DAYS OF OWNING THE VEHICLE, THE CONSUMER NOTICED THE CLOCK WAS NOT WORKING PROPERLY, THERE WAS A NOISE WHILE THE VEHICLE WAS COLD, WHILE TURNING RIGHT OR BACKING AND PULLING FORWARD, A SHUDDER IN THE BRAKE PEDAL, A CUT IN THE LEATHER PASSENGER SEAT. ON 4 OCCASIONS THE PASSENGER AIR BAG SENSOR LIGHT DASH LIGHT DID NOT ENGAGE PROPERLY WITH 3 DIFFERENT PEOPLE OF DIFFERENT WEIGHTS/HEIGHTS WERE SITTING IN THE SEAT. THE POWER STEERING FAILED 3 TIMES. THE CONSUMER WAS TOLD THE SHUDDER IN THE BRAKE PEDAL WAS NORMAL AND WAS A PART OF THE ABS. *JB
Engine and engine cooling, Equipment, Jan 16, 2005
WHILE DRIVING A LIGHT ON THE DASH ILLUMINATED AND THE VEHICLE SUDDENLY LOST POWER. *NM THE VEHICLE HAD A SENSOR ISSUE WHICH CAUSED THE PANEL LIGHT TO FLASH AND THE POWER TO BE LOST. THE PANEL LIGHT FLASHED TWICE AND STAYED ON THE SECOND TIME. THE CONSUMER WAS TOLD IT WAS AN EMISSION LIGHT AND THERE WAS NO OTHER EXPLANATION. THE CONSUMER TRIED TO HAVE THE VEHICLE JUMP STARTED BUT IT DID NOT START THE VEHICLE. THE CONSUMER WAS GIVEN A CHOICE TO TAKE ANOTHER VEHICLE SAME MAKE AND MODEL AS AN EXCHANGE FOR HER PURCHASED VEHICLE THAT FAILED. THE CLOCK DID NOT KEEP TIME AND THE LIGHT SWITCH DID NOT TURN ON THE INTERIOR LIGHTS. THE CONSUMER WAS TOLD THAT THE CLOCK FOR THE SECOND VEHICLE WAS ON BACK ORDER. THE CLOCK HAS TO BE RESET EVERY TIME THE CONSUMER GETS IN THE VEHICLE. *TC *JB