2006 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 242 owner complaints filed for this model year. This is the 12th highest complaint count among 23 Sorento model years with reports.
Of the 2006 reports, 12 involved a crash and 8 involved a fire. 14 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, brake lights, switchApr 17, 2009
HUYNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Campaign 09V130000 on NHTSA.gov
Representative owner complaints
242 reports, newest first.
Electrical system, Exterior lighting, Sep 18, 2013
THERE HAS BEEN MULTIPLE TIMES OF ME CHANGING BOTH HEADLIGHTS AND TAILLIGHTS. NOW MY BRAKE LIGHTS ARE OUT AT THE SAME TIME ALONG WITH ONE HEADLIGHT. THE LIGHTS ARE NOT EVEN 2 WEEKS OLD. IT REALLY IS SCARY TO KNOW THAT MY LIGHTS CAN GO OUT AT ANY TIME. (WHICH HAS HAPPENED, THANKFULLY NOT WHEN IT WAS COMPLETELY DARK) AND TODAY, I ALMOST GOT INTO A WRECK BECAUSE I WASN'T AWARE THAT MY 2 WEEK OLD TAIL LIGHTS ARE OUT. MY DASH BOARD LIGHTS AND MY DOME LIGHT FLICKERS AND I HAVE TO HIT THE TOP OF THE DASHBOARD FOR THEM TO COME BACK ON. THIS HAS BEEN GOING ON FOR ABOUT 2 YEARS AND I HAVE SEEN A LOT OF THE SAME COMPLAINTS WITH THIS MAKE AND YEAR. KIA REALLY NEEDS TO DO SOMETHING ABOUT THIS. *JB
Other or unspecified, Sep 8, 2013
ABOUT A WEEK AGO, I WAS UNLOADING GROCERIES FROM MY KIA SORENTO. THE HATCHBACK HAS A HANDLE IN ORDER TO PULL DOWN THE HATCHBACK. IN THIS INSTANCE, I PULLED IT DOWN A LITTLE BIT AND IT FELT LIKE IT HAD BEEN JERKED OUT OF MY HAND AND FELL ON MY HAND. I HAVE SOME DEEP CUTS AND POSSIBLY A BREAK IN MY HAND. IT FELT AS IF THE HATCH ONCE I LET GO CONTINUED AS IF IT WAS PULLED DOWN.
Suspension, Sep 6, 2013
TL- THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHEN STARTING THE ENGINE, HE HEARD AN ABNORMAL NOISE COMING FROM THE REAR END OF THE VEHICLE AND ALSO WHEN BRAKING. THE CONTACT STATED THAT THE REAR FRAME AXLE WAS RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE STABILIZER REAR MOUNT HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 117,000. KMJ
Suspension, Aug 26, 2013
DURING A TURN IN A MALL PARKING LOT THERE WAS A LOUD NOISE FROM THE LEFT FRONT SIDE, IT TURNED OUT TO BE A RUSTED THROUGH LOWER CONTROL ARM FOR THE LEFT WHEEL. THERE WAS NO WARNING OF THIS, AND BECAUSE WE LIVE IN A NORTHERN STATE, WHERE ROAD SALT IS A CONCERN, THIS SHOULD BE SOMETHING THAT KIA ADDRESSES. *TR
Engine, Aug 9, 2013
WE ARE THE ORIGINAL OWNERS OF THIS VEHICLE.THE ENGINE SHUTS DOWN-QUITS AT ANY SPEED (EVEN IDLE) LAST TIME AT 60 MILES AN HOUR ON THE FREEWAY. LUCKILY WAS ABLE TO GET TO THE SHOULDER W/O BEING REAR ENDED. THE VEHICLE REFUSED TO START FOR ABOUT 10 MINUTES. THEN I GOT IT STARTED AND RAN ROUGH A COUPLE OF MINUTES THEN CLEARED UP THE REST OF THE WAY. ANOTHER OCCASION THE ENGINE QUIT IN THE MIDDLE OF AN INTERSECTION IN 5:00 TRAFFIC, CAUSING BAD CONJESTION. THE ENGINE LIGHT IS TRIGGERED OCCASIONALLY BUT NO REPAIR CODES ARE SEEN WHEN THE COMPUTER IS HOOKED UP. THIS IS HAPPENING ABOUT EVERY 3 -4 DAYS AND MAYBE 2 X'S IN A DAY. THIS HAS HAPPENED EVER SINCE THE DEALER CHANGED THE TIMING BELT-REGULAR MAINTENENCE ABOUT 80,0000 MI. THE VEHICLE WAS RUNNING AND SOUNDING JUST GREAT BEFORE THE KIA DEALER DID THIS. ON THE WAY HOME, THE VEHICLE WENT DEAD AND HAD NO POWER. GOT THE DEALER TO TAKE IT BACK. THINGS WERE NOT PLUGGED IN--ALTERNATOR ETC. THE MECHANIC WAS IN A HURRY TO LEAVE FOR THE WEEKEND. NOW LEFT LIFTER BANK CLATTERS UPON STARTUP A CODE WAS GIVEN THAT THE DEALER DID NOT CLEAR THE COMPUTER WHEN THE BELT WAS CHANGED. WE CLEARED IT AND THE ENGINE STILL QUITS. THE DEALER WENT OUT OF BUSINESS (GO FIGURE). ALSO THE AIR CONDITIONING QUIT DUE TO A LINE THAT WAS SPLIT POSSIBLY WHEN THE MECHANIC WAS WORKING ON THE TIMING BELT. SOMEONE IS GOING TO GET HURT (ACCIDENT) IF THIS VEHICLE CONTINUES TO DO THIS.NO ONE SEEMS TO KNOW WHAT IS WRONG. *TR
Steering, Power train, Engine, Jul 30, 2013
I WAS MERGING ONTO A HIGHWAY WHEN ALL OF A SUDDEN I HEARD A LOUD THUD AND MY BATTERY LIGHT & E BRAKE LIGHT CAME ON AND I LOST POWER STEERING. I WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL MECHANIC WHO INFORMED ME THAT THE HARMONIC BALANCER HAD FALLEN OFF DUE TO THE CRANKSHAFT BOLT SHEARING OFF. ONCE IT WAS FIXED BY AN ASE CERTIFIED MECHANIC, APPROXIMATELY 8000 MILES LATER I WAS DRIVING TO WORK AND THE CAR STARTED SHAKING LIKE I WAS DRIVING ON RUMBLE STRIPS. I TOOK IT BACK TO A SERVICE GARAGE AND AFTER REPLACING THE HARMONIC BALANCER AND CRANKBOLT AGAIN THEY CAME TO THE CONCLUSION THAT THE CRANKSHAFT WAS BENT. THE GARAGE SUGGESTED REPLACING THE ENTIRE CRANKSHAFT AND BALANCER AND THEN HAVING THE ENGINE REBALANCED OR A COMPLETE ENGINE REPLACEMENT BOTH OF WHICH ARE GREATER THAN $3500 TO REPAIR ON A VEHICLE THAT'S WORTH ABOUT $5500..IT'S BEEN APPROXIMATELY $2000 THAT I'VE ALREADY SPENT TO CORRECT THIS PROBLEM AND THE PROBLEM STILL EXISTS. IT'S AT A LOCAL KIA DEALERSHIP NOW, WHERE I PURCHASED THE VEHICLE AND THEY TOLD ME THAT IT'S NOT FIXABLE AND THEY CAN ONLY RECOMMEND TO REPLACE THE ENGINE WHICH WOULD COST $6,700 FOR A USED ENGINE WITH 71,000 MILES ON IT. IT SEEMS THAT THIS SAME ISSUE HAPPENS ON THESE MOTORS BETWEEN 60K AND 90K MILES THEN FROM DOING SOME RESEARCH, IT SEEMS AFTER REPAIRS ARE DONE THE SAME PROBLEM HAPPENS APPROXIMATELY 6K-10K MILES LATER. AFTER LOOKING INTO IT, IT LEADS ME TO BELIEVE THAT THE ONLY CAUSE OF THIS PROBLEM WOULD BE MANUFACTURER DEFECTS AND FAULTY PARTS. THIS HAS CAUSED ME TO BE OUT OF A VEHICLE SINCE MID NOVEMBER OF 2012. IT'S DISTURBING WITH HOW MANY OTHER COMPLAINTS I'M READING ON THIS SITE ABOUT THE SAME EXACT THING! *TR
Engine and engine cooling, Engine, Jul 26, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKE AND BATTERY LIGHTS ILLUMINATED AS THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART MOMENTS LATER. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT A BOLT IN THE CRANK SHAFT WAS FRACTURED AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,440. 8/26/13 *CN THE CONSUMER ALSO STATED THE BELTS AND CRANK PULLEY BROKER
Engine, Jul 22, 2013
FROM 9/2011 TO 7/2013 MY 2006 KIA HAS HAD THIS PROBLEM 3 TIMES AND IS CURRENTLY IN THE SHOP. WHILE DRIVING I HEAR A WEIRD NOISE AND THEN ALL THE DASHBOARD WARNING LIGHTS COME ON AND I LOSE POWER STEERING. WHEN CHECKING UNDER THE HOOD, THE BELTS HAVE ALL FALLEN OFF, A PULLEY IS LAYING UNDER ENGINE AS IS A BOLT. THE LAST TIME THE BOLT HAD BROKEN OFF CAUSING THE PULLEY TO FALL OFF. MECHANIC FOUND THAT THE CRANKSHAFT SPROCKET WAS BROKEN. I'M NOT SURE ABOUT TODAY AS THE CAR IS AT THE SHOP WITH THE BOLT LAYING UNDER THE ENGINE, BUT THE DRIVE PIN THAT GOES INTO THE SPROCKET OF THE PULLEY FELL OUT THE BOTTOM WHEN BEING LIFTED ONTO THE TOW TRUCK. *TR
Electrical system, Exterior lighting, Jul 20, 2013
I PURCHASED THIS CAR IN NEW IN 2006 I HAVE REPLACE FOUR TAIL LIGHTS AND AS OF TODAY WHEN THE HEAD LIGHT WENT OUT THIS WILL BE THE FIFTH HEADLIGHT, I AM AFRAID FOR MY DAUGHTER TO PARK IN THE GARAGE IN CASE IT SHOULD SET THE HOUSE ON FIRE,THERE IS OBVIOUSLY A SHORT IN THE ELECTRICAL SYSTEM. *TR
Power train, Exterior lighting, Jun 24, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT THE BRAKE LIGHTS STOPPED ILLUMINATING INTERMITTENTLY. ADDITIONALLY, WHILE ACCELERATING THE VEHICLE JERKED AND DECELERATED SUDDENLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 09V130000 (EXTERIOR LIGHTING) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. *TR
Engine, Jun 1, 2013
I WAS DRIVING AND NOTICED THE 4-WHEEL LIGHT CAME ON. I STOPPED THE CAR AND WAITED A FEW MINUTES. WHEN I TURNED THE CAR BACK ON IT WAS MAKING A NOISE. UPON FURTHER INVESTIGATION, I FOUND THE CRANKSHAFT VERY LOOSE. THE CAR IS PRESENTLY AT THE REPAIR GARAGE AWAITING AN ESTIMATE. *TR
Air bags, May 14, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT THE PASSENGER AIR BAG LIGHT ILLUMINATED WHILE THE FRONT PASSENGER SEAT WAS OCCUPIED. THE VEHICLE WAS TAKEN TO HAVE A DIAGNOSTIC PERFORMED WHICH LOCATED THE FAILURE AT OCCUPANT CLASSIFICATION SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V473000 (AIR BAGS). THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 90,000. UPDATED 06/18/13*LJ UPDATED 06/21/2013 *JS
Power train, Apr 12, 2013
WHILE DRIVING IN BUSY CITY TRAFFIC, HEARD A LOUD CLUNKY NOISE, LOSS OF POWER STEERING CAPABILITIES IMMEDIATELY ALONG WITH BRAKE AND BATTERY LIGHTS APPEARING ON DASH. VEHICLE TAKEN TO LOCAL DEALERSHIP SERVICE DEPARTMENT WHERE IT WAS FOUND THAT "CRANK BOLT BROKEN OFF THE CRANKSHAFT, REMOVED CRANK BOLT WITH EASY OUT, REPLACED DAMAGED CRANK SPROCKET, DAMPER PULLEY, AND CRANK BOLT." NOW TEN (10) MONTHS LATER AND 7000 MILES (APPROXIMATELY) WE HAVE THE SAME ISSUE IDENTICAL TO THE ORIGINAL. AM CURRENTLY WAITING FOR RESOLUTION FROM DEALERSHIP WHERE THE VEHICLE WAS PURCHASED AND SERVICED. IT IS CURRENTLY THERE WAITING REPAIR OR REPLACEMENT. SEEMS THIS IS AN ISSUE THAT IS NOT FIXED BY SIMPLY REPAIRING OR REPLACING THE CRANK BOLT AS IT HAS HAPPENED TWICE WITH MY VEHICLE, LEADING ME TO BELIEVE THAT THERE IS A STRESSOR ELSEWHERE! MORE THAN LIKELY A MANUFACTURERS DEFECT OF THE ENGINE BLOCK SOMEWHERE. *TR
Engine, Apr 10, 2013
MY 22 YEAR OLD DAUGHTER WAS DRIVING THE CAR AT COLLEGE WHEN IT SUDDENLY LOST POWER STEERING AND THEN SHUT DOWN IN TRAFFIC IN THE MIDDLE OF AN INTERSECTION. LUCKILY SHE WAS NOT ON A CURVY ROAD WHEN THE POWER STEERING WENT OUT. WE HAD THE CAR TOWED AND AFTER MECHANIC'S INSPECTION WERE TOLD THAT THE CRANKSHAFT BOLT "WOBBLED" LOOSE AND DISRUPTED THE TIMING BELT ASSEMBLY SHUTTING DOWN THE ENGINE. THIS $2 BOLT HAS CAUSED AN ESTIMATED $3500 REPAIR BILL OR EVEN AN ENGINE REPLACEMENT. OUR RESEARCH HAS UNCOVERED TO US THAT THIS IS A COMMON PROBLEM WITH THIS 3.5L ENGINE. THIS BOLT EITHER BREAKS OR WOBBLES OUT OF IT'S THREADING TO CAUSE TIMING BELT PROBLEMS AND REQUIRES EXTENSIVE AND EXPENSIVE REPAIR TO THE ENGINE. THIS INDICATES TO US A MANUFACTURER'S DESIGN FLAW AND PROBABLE SAFETY ISSUE THAT SHOULD BE ADDRESSED BY KIA WORLDWIDE. *TR
Engine, Apr 5, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE MOTOR PULLEY FAILED ON THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 78,000.
Exterior lighting, Apr 2, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT THE BRAKE LIGHTS ERRONEOUSLY ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V130000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS 41,000
Electrical system, Exterior lighting, Vehicle speed control, Feb 28, 2013
THE DAY AFTER WE PURCHASED THIS VEHICLE I HAD TO CHANGE THE RIGHT BRAKE LIGHT, SINSE THEN I'VE HAD TO CHANGE THE HEADLIGHTS BOTH AT LEAST TWICE, ASSORTED TAIL LIGHTS EACH SIDE AT LEAST THREE TIMES, THE FRONT DOME LIGHT WILL NOT COME ON WHEN YOU OPEN THE DOORS BUT CAN BE SWICHED ON, NOW DASH LIGHTS ARE GOING OFF ONE AT A TIME SOME CAN BE WIGGLED AND COME ON FOR A FEW SECONDS. THIS HAS GONE FROM ANNOYING TO A SAFETY ISSUE, AND I READ A LOT OF PEOPLE ON LINE WITH 06 SORENTOS HAVE THE SAME PROBLEM AND HAVE BEEN TOLD BY THE DEELER THAT IT WILL COST THEM A LOT OF MONEY TO FIX. I FEEL LIKE ALL THE OTHERS THIS SHOULD BE KIA'S RESPONIBILITY TO FIX. *TR
Steering, Engine, Jan 14, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE ALTERNATOR, BRAKE AND TEMPERATURE WARNING LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS MOVED TO THE SHOULDER. UPON INSPECTION, THE CONTACT NOTICED THAT THE CRANKSHAFT BOLT FRACTURED AND CAUSED THE FAN BELT AND THE WATER PUMP TO BECOME INOPERABLE. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTICS. THE FAILURE MILEAGE WAS 83,500. UPDATED 3/20/13 *CN THE CONSUMER STATED THE ALTERNATOR AND ENGINE LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE CRANK SHAFT BOLT BROKE AND CAUSED THE STEERING DAMPER TO SHIFT SIDEWAYS, WHICH CAUSED THE TWO BELTS ON THE DAMPER PULLEY TO BE THROWN OFF.
Exterior lighting, Jan 7, 2013
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DECELERATING, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED INTERMITTENTLY AND THE BRAKE LIGHTS ERRONEOUSLY ILLUMINATED WHEN NOT DECELERATING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V130000 (EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH). THE APPROXIMATE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 66,000. UPDATED 03/01/13*LJ
Engine, Sep 17, 2012
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED WHILE TRAVELING 40 MPH THE ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. WHEN THE POWER STEERING MALFUNCTIONED THE BRAKES FAILED TO STOP THE VEHICLE WHEN THEY WERE APPLIED. THE CONTACT MERGED ONTO THE EMERGENCY LANE; HOWEVER, HE WAS ABLE TO CONTINUE DRIVING TO HIS DESTINATION WHERE THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER CONFIRMED THAT THE BOLT TO THE HARMONIC BALANCER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WERE 59,800. UPDATED 10/02/12*LJ
Engine, Aug 16, 2012
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED WHILE DRIVING 40 MPH THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND ATTEMPTED TO RESTART THE VEHICLE BUT THE VEHICLE WOULD NOT TURN OVER. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO SUGGESTED THE CONTACT TAKE THE VEHICLE TO AN AUTHORIZED DEALER. THE VEHICLE WAS THEN TOWED TO THE DEALER WHO STATED THAT THE CRANK SHAFT BOLT WAS FRACTURED, AS WELL AS THE PUSH RODS. THE DEALER ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE ENGINE REPLACED. THE FAILURE MILEAGE WAS 46,400.
Fuel/propulsion system, Aug 13, 2012
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT SHE SMELLED FUEL COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS, WHO STATED THAT THE FUEL TANK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED BUT REFUSED ANY ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS 72,900 AND THE CURRENT MILEAGE WAS 73,100.
Power train, Jul 16, 2012
WHILE DRIVING HEARD A LOUD NOISE FROM ENGINE CAUSING LOSS OF POWER STEERING. CAR TOWED TO MECHANIC. DIAGNOSIS: CRANK BOLT BROKEN AND LAYING IN SKID PLATE; PART OF BROKEN CRANK BOLT IN CRANKSHAFT. CRANK PULLEY SHEARED PIN AND MOVED FORWARD CAUSING POWER STEERING BELT TO COME OFF AND OTHER BELT MISALIGNMENT. UPON REMOVAL OF BROKEN CRANKSHAFT BOLT, DAMAGE WAS FOUND TO CRANK GEAR AND BALANCER PULLEY. THE TIMING BELT, TENSIONER AND CRANKSHAFT BOLT HAD ALL BEEN REPLACED AT 91,000. LESS THAN TWO MONTHS AFTER REPLACING THE CRANKSHAFT BOLT, IT SHEARED OFF CAUSING MAJOR DAMAGE. LOSING POWER STEERING WHILE DRIVING IS EXTREMELY DANGEROUS. THIS IS A KNOWN DEFECT TO KIA THAT HAS NOT BEEN CORRECTED CAUSING A MAJOR SAFETY ISSUE TO ALL MOTOR VEHICLE DRIVERS AND PASSENGERS. IN ADDITION, THIS IS A VERY EXPENSIVE REPAIR ISSUE. *TR
Power train, Engine, Jul 9, 2012
DRIVING 65MPH ON TURNPIKE HEARD A LOUD SCREECHING NOISE BRAKES WERE HARD TO APPLY STEERING WAS DIFFICULT AND DASH BOARD LITE UP PULL TO THE SIDE OF THE ROAD AND WAS TOWED TO THE NEAREST KIA DEALERSHIP TO BE TOLD THAT CRANK SHAFT BOLT BROKE. AT 60000 MILES WE DID THE REQUIRED MAINTENANCE TO THE TUNE OF 663.65 AND HAD THE TIMING BELT REPLACED. THERE WAS ALSO A MEMO TO THE DEALERSHIPS TO REPLACE THE BOLT WHEN REPLACING THE TIMING BELT. ACCORDING TO MY ITEMIZED STATEMENT THE BOLT WAS NOT REPLACED. I FEEL THIS SHOULD BE COVERED SINCE I FOLLOWED THE RULES AND GOT THE REQUIRED SERVICE THEY WERE NEGLIGENT NOT REPLACING THE BOLT. HOWEVER THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THERE MISTAKE. NOW I AM STUCK WITH A CONSIDERABLE BILL. *TR
Engine, Jun 18, 2012
TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AFTER WAITING A FEW MOMENTS. THE FAILURE OCCURRED TWO TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.