2016 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,251 owner complaints filed for this model year. This is the 2nd highest complaint count among 23 Sorento model years with reports.
Of the 2016 reports, 29 involved a crash and 49 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideSep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Campaign 22V703000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftAug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
A vehicle rollaway increases the risk of a crash and injury.
Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Campaign 22V612000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Trailer hitchesNov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Campaign 16V862000 on NHTSA.gov
SeatsOct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Campaign 16V770000 on NHTSA.gov
Suspension, rearJun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Campaign 16V480000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Campaign 15V446000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Campaign 15V089000 on NHTSA.gov
Representative owner complaints: engine
718 reports, newest first. Show all
Engine, Engine and engine cooling, Jan 5, 2024
Engine stalled while driving on highway. Took it to a Kia dealer and had it diagnosed as an engine block/head gasket failure. I have documentation of service. Service document reads “owner states vehicle runs rough when first started and a/c doesnt cool properly, started vehicle, a/c is currently working normally, upon inspection, found coolant about 3/4 gallon low and has bubbles coming up in reservoir tank, topped coolant, performed engine block test, photo of yellow fluid in tester indicates combustion gases are getting into cooling system and not going out exhaust as it is supposed to, took video of bubbles coming up into tank, advise more than likely due to overheating of engine either has crack in block or warped heads or a combination of the 2, advised recommended long block replacement as tear down is not cost effective , gave estimate, owner declined repairs at this time”. I have been made aware of other customers and people experiencing exact same issue with their Kia sorento models. We have only had this car for over a year from a reputable dealer.
Engine, Jan 3, 2024
To whom it may concern, I recently came across an article stating the NHTSA is investigating KIA about the faulty engine. I personally found out the hard way when my family vehicle, a 2016 KIA Sorento EX V6 3.3L V6 lost power on I75 while driving back from a trip to Disney World Orlando. I was able to pull aside but almost got hit by a speeding car. I looked in the engine bay and the coolant was overflowing from the reservoir and was very hot. I towed it back home and then followed up with my mechanic who said the head gasket was blown and that it needed to be replaced. The car is only shy of 50,000 miles and I got it with 4000 miles. I tried to get the engine replaced but KIA doesn’t have any engines for replacement. I have been looking to buy a car to get the engine from a newer KIA because I’m 100% sure this is a factory defect that they won’t fix on their own. I just received a letter stating to take the car to the dealer for a diagnostic on this exact issue and that they would fix it if they found the fault. Well, they said the issue was not about the head gasket and that the motor of the cooling fan was at fault. Yet I talked in person to the tech that diagnosed the car and only VERBALLY they would acknowledge the issue is the head gasket but not only that, they even said the entire engine needed replacing. Are they trying to get away from taking responsibility? Why they wouldn't state it in the paperwork? But if I send you the diagnostic they produced it would only say yellowing tires and wiper replacement to be necessary. This confirms there is a “cat in the bag.” But what they don’t know is that there was a prior inspection at another dealer that stated the head gasket was indeed blown. You are welcome to contact me at any time. My name is [XXX] . The vehicle is under my wife’s name [XXX] . My direct number is [XXX] . Thank you for your help and I hope you make KIA accountable for this really bad experience. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jan 3, 2024
The engine failed and stopped while driving on the highway going about 50 mph. Fortunately was able to pull off to side of the road without crashing. Took the vehicle to the kia dealer it was determined that the engine failed due to rod bearing failure. It stopped without any warning. It also appears that there is a current recall and class action lawsuit on v4 2.4 engines identifying the same problem. This needs to be checked into
Engine, Dec 27, 2023
I purchased this car in august of this year 2023. Since purchasing it has spent about half of the time I’ve had it at the dealership being repaired (all listed in carfax) Things that have been fixed are thermostat, car has been pressure tested multiple times due to hidden coolant leaks, Oring replaced, thermal module where coolant pipe connects & now it is having oil consumption issues & im in the process of testing. This car only has 60k miles and I’ve only put about 3500 of them on it. It has a good carfax showing it has been maintained properly. The dealership has told me that they are unsure if approval would be given for oil consumption. However this hadn’t been happening before all the coolant issues occured which leads me to believe this is somehow related. & now it is a huge concern to me as the idea that my engine could blow or catch on fire with two little kids in the car is extremely scary. Also there was no engine light on when car started having oil loss, luckily I was just checking fluids regularly and noticed & when we started this process the dealership had to put 3 qts of oil in.
Engine, Dec 27, 2023
Oil Consumption issue in which the oil is burning in in the engine. It's a known issue KIA acknowledges however; will not recall to replace the engine. My car has gone through the oil consumption test which they acknowledged it is consuming oil but would cost 1600 to correct a 92% success rate. I don't have the money to fix. Solution from the service dealer was to wait for the engine to go so it can be replaced in its entirety. I am having to check my oil every 1000 miles to top the oil off-quart low and change the oil every 3k. So unsafe to say wait for the engine to go. I am scared to drive my car any further than in the city limits. Is there anything that can be done. Where is the accountability on their end?
Engine, Dec 21, 2023
Daughter was traveling at highway speeds (60 mph) when engine loss all power and hard to merge over in lanes due to loss of speed and other traffic. Once to side of road found coolant blowing out of reservoir under hood. Towed to service station where they said head gasket blown on back cylinder bank. Replacement motor needed to make repairs as 7 of 8 head bolts found loose and 3 threads striped from aluminum block which they said is common issue with Kia engines.
Engine, Dec 20, 2023
On the morning of October 31st, 2022 I used my remote starter to warm the engine in my driveway for approximately 10 minutes, when I got into the car I noticed the air blowing was ice cold and when looked at the temperature gauge the needle was in the red. I allowed the engine to cool down for about an hour, checked the coolant level and found it empty. I looked all around and under the engine for signs of leaks, none were found. I purchased a gallon of coolant, topped off the system and brought the car to my local garage to check the problem. They replaced the thermostat and bled the cooling system. About a week later it started overheating again so I topped off the coolant again and took the car to the nearest Kia dealer. After keeping my car for a week they concluded that the head gaskets were leaking and the repairs would be more than the value of the car and they'd be happy to trade what's left of my car for a new Kia. I had my car towed to a reputable independent shop and ended up paying a total of $12, 274.84 for a re-manufactured engine and for labor involved in stripping down the old engine for the extended warranty who inspected the engine and denied the claim. I purchased this vehicle on 1/9/2021 with extended warranty from and authorized Kia Dealer for $20,522.78. I have since found out that this is an ongoing issue with the Kia/Huyndai V6 engines from 2016-2019. As a Mercedes-Benz employee for 30 plus years I am appalled at Kia for their unwillingness to stand by their products.
Power train, Engine, Fuel/propulsion system, Dec 18, 2023
Car when into a low power mode,could not keep it running ,took 5 times to go thru a very busy intersection and motor was making a knocking noise,smells like burnt oil-motor ,misses out..The car was towed into a KIA dealership,3 weeks later they said it was fixed,drove off and didn’t even make it a mile until it started knocking and having the same smell like burnt motor,went into a reduce power.now it’s been 3 more weeks or more and still nothing is getting resolved. Yes the dealership knows about this issue. Yes warning messages came on when it went into low power mode. This is motor number two as the motor was replaced less than 12 months ago.
Engine, Dec 17, 2023
Been dealing with oil issues for over a year. With a closely monitored oil level the car engine blew a hole and is now not drivable. There was never a low oil light or any warning.
Engine, Dec 17, 2023
There is a common issue with these year model Sorentos that poses a dangerous safety hazard for those in the car as well as others on the road. This model has a manufacturers defect that causes the head bolts to strip from the block, causing overheating engine, power loss, and other symptoms. A car that overheats and has these symptoms while on the road could cause a fire, cause hot steam or coolant to burn skin, and risks lives if it happens while on a fast paced roadway. The issue is common and pretty much guaranteed to happen to these model Sorentos. There are thousands of people complaining and report the issue. KIA is aware and not concerned of the issue. The only solution offered is an engine replacement, which most people can’t afford so will more than likely keep driving the vehicle regardless of the risks. My Sorento has been at the dealership already. I’ve contacted KIA corporate as well as attorneys seeking litigation of the issue. My insurance completed a full investigation by U.S. Forensic and determined the cause to be two of my head bolts stripped the threads out of the block. I have the final report from the investigation. We had no early warnings of the issue. We first noticed something was wrong when the car started over heating. You could, then, smell coolant and there was white smoke from the exhaust. There was a loss of power and bubbling in the coolant reservoir. The car would drive without overheating as long as you kept the radiator full of coolant. In summary, this is a common issue that has been ignored by KIA. It is clearly a safety concern and could pose life threatening risks. KIA won’t care and will never do anything about this unless they are forced to.
Engine, Dec 13, 2023
At an ODO of 87,337 the Sorrento turned off while at a speed of >45 mph on a highway, luckily near an exit. There were no warnings before the car turned off. The car allowed for a slow crawl off the highway. The Sorrento could not be restarted. After towing it to an independent mechanic we were told that the car engine had seized, likely due to low oil. The car did not indicate anything before the catastrophic event. This was a danger to the young driver and everyone on the highway at the time due to the sudden slowing of the car, likely without brake lights. This occurred after dusk which added totes danger.
Engine, Dec 13, 2023
while driving engine suddenly got hot and blew radiator hose causing overheating to engine cylinder head and leaking coolant. No warning light or gauge indicating coolant overheating. Car was towed to dealership and they indicated no safety recalls on this engine exists despite known common problems of head gasket failures and head bolts coming undone.
Engine and engine cooling, Dec 12, 2023
The contact owns a 2016 Kia Sorento. The contact stated after pulling into the driveway, he noticed an abnormal burning oil odor. The contact stated that he inspected the engine compartment and underneath the vehicle, but no oil leak was found. The contact stated the failure recurred several times while at a complete stop. There was no warning light illuminated. Additionally, the contact stated that he noticed that a significant amount of oil had leaked on the undercarriage of the vehicle and onto the ground. The vehicle was taken to an independent mechanic, where it was diagnosed that the turbo oil intake lines were damaged. The mechanic informed the contact that the failure could cause oil to leak onto the manifold, which could cause a fire. The contact stated that he replaced the turbo oil intake lines himself. The vehicle was repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 143,000.
Electrical system, Engine, Fuel/propulsion system, Dec 9, 2023
Knock sensor goes bad. Car does not receive fuel to engine. Cuts off while driving and will not accelerate over 20 mph
Engine, Dec 8, 2023, fire
The contact owned a 2016 Kia Sorento. The contact stated that as he had parked and shut the vehicle off, he saw smoke emitting from under the hood. The contact exited the vehicle and saw flames from under the front of the vehicle. As the contact was stepping away from the vehicle he saw that flames were issuing from the rear passenger side wheel well where the fuel filler door was located. The contact stated that there was no warning light. The fire department was called and extinguished the flames. The police were on the scene and issued a report. The vehicle was towed away to an impound lot and later declared a total loss by the contact's insurance provider. The manufacturer was informed of the failure. The failure mileage was approximately 99,000.
Engine, Dec 2, 2023
I’ve had my 2016 KIA Sorento for a month. The engine locked up. So, I would like for it to be repaired at no cost to me since it was within the 30 period of purchase. I need to know what to do at this point. My car is at the dealership where I bought it from. Thank you for a speedy response.
Engine, Dec 1, 2023
The contact owns a 2016 Kia Sorento. The contact stated while driving 25 MPH, the vehicle stalled. The contact was able to push the vehicle off the roadway. There were no warning lights illuminated. The vehicle was towed to the residence. The contact called the local dealer and was informed that the vehicle needed to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the vehicle needed to be diagnosed. The approximate failure mileage was 100,000.
Engine, Nov 29, 2023
Last year before my 100,000 mile warranty was up, my vehicles engine light and oil light came on. This was following an oil change which was approximately 3000 in. I checked the oil to find out there was no oil. After adding oil, I took it to the Kia dealership and was told the place who changed the oil didn’t tighten my oil filter which was not true because there was no oil on the garage floor where it was parked. They then proceeded to tell me this engine uses a quart of oil every 1000 miles. Fast forward, to last week, I was driving on the highway when my car all the sudden had high RPM but wouldn’t accelerate. The vehicle started stalling and died. I pulled over and again tried to start the car which it died again. The oil level was fine. I took it to a mechanic to find out the engine had 3 cylinders misfiring due to not getting the compression needed resulting in the engine failing. The oil consumption resulted in needing a new engine and now outside of warranty.
Engine, Nov 28, 2023
My 2016 Sorento LX is consuming 3quarts of oil in 1000 miles, I have asked the dealership and mentioned this to them and now after warranty is over they finally did oil consumption test and my car needs a new engine, I was told it could blow up at anytime, I have all maintenance papers and was told I would have to pay $7,000 to replace engine
Engine, Nov 27, 2023
Does not show low oil light when the car has no oil in the engine
Vehicle speed control, Engine, Forward collision avoidance, Nov 21, 2023
My car started jumping while driving we had put oil in my car 3 weeks prior. It also smelt like my car was burning while the heat was on I had 2 babies in the back seat and I was scared to death. I haven’t received anything in the mail about any recalls what so ever. I had to hear by a family friend the day of the incident that he thinks they’re recalls on my call so I looked it up. My car is currently not working now and I have work and doctors appointments for babies I got to Kia tomorrow they’re saying I don’t have any recalls on my car and I looked it up on here and I do. I’m pretty sure they’re just not wanting to pay for it. They said if I have a warranty they could do. I just don’t know what to do I have no car and I ave 2 children I can’t afford to not have a vehicle.
Electrical system, Engine, Nov 20, 2023
A lot of oil in the floor. Oil Pressure Sensor Fail Lock of all doors are crazy (lock and unlock so many times)
Engine, Nov 20, 2023
Engine light come on and had someone to check it and they said recall on motor car has been using a lot of oil I put in one quart every two weeks the car is stalling and missing also
Engine, Nov 20, 2023
due to low oil pressure the timing chain failed causing immediate loss of power. The call was then rolled off the highway at idle speed creating a hazard while this was being done. There were no warning lamps prior to incident. This was inspected by the dealer "Team KIA El Cajon".
Engine, Nov 18, 2023
While driving car sputtered, was able to get to side of road. Turned car off, waited and then turned on again and was able to proceed, engine light on - got occasional performance issues. Kia dealer checked out and servicing, informed me of the oil was depleted issue and in need of substantial engine repair. (Provided written estimate, approx $4800). Able to continue driving but risk of stalling, told eventually timing belt will fail. Got estimates for repairing, and total engine replace to compare options. (Have not done either option as yet).