2016 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,251 owner complaints filed for this model year. This is the 2nd highest complaint count among 23 Sorento model years with reports.
Of the 2016 reports, 29 involved a crash and 49 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideSep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Campaign 22V703000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftAug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
A vehicle rollaway increases the risk of a crash and injury.
Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Campaign 22V612000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Trailer hitchesNov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Campaign 16V862000 on NHTSA.gov
SeatsOct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Campaign 16V770000 on NHTSA.gov
Suspension, rearJun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Campaign 16V480000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Campaign 15V446000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Campaign 15V089000 on NHTSA.gov
Representative owner complaints: exterior lighting
67 reports, newest first. Show all
Exterior lighting, Structure, Aug 20, 2026
See attached document for complaint.
Electrical system, Exterior lighting, Mar 2, 2026
All tail lights of suv go in an out randomly.
Exterior lighting, Aug 15, 2025
Lights shut off by themselves at night in auto mode in dark environments!
Exterior lighting, Jul 26, 2025
Not recall
Exterior lighting, Jul 10, 2025
I have now replaced the headlight bulbs in my 2016 KIA Sorento 6 times and it's getting worse as it gets older. I believe it is a safety issue since the last time I was out of town, traveling in the middle of the night when it went out. I had to wait until morning to find an auto parts store to buy and replace the bulb. No inspections have been done by anyone. Yes, the warning lamp comes on and stays until reset.
Electrical system, Exterior lighting, Oct 23, 2024
I am having an issue with my Kia headlights when on dim. The lights are so dim I am afraid to drive the car at night because I am scared I will hit a person, animal or object. I am replacing light bulbs frequently. Cars are flashing their lights at me (when I need to drive at night) because of the dimness. I took my car to a Kia dealer and they could not diagnosis the problem. They advised to replace the entire headlight assembly with a cost of $2,600.00. I am on Social Security and can't afford to have the repair made. I have read a lot of complaints of other Kia lighting issues. I feel a recall should be made immediately due to the seriousness of the issue.
Exterior lighting, Aug 11, 2024
I own a 2016 Sorento SXL AWD and this issue just started. I work evening shift and get off at 11pm. I always have the lights set to "auto", while driving home on a rural road at night and the headlights switch off on their own. I have to manually switch the lights off and back to auto for them to come back on. Potentially dangerous situation and Kia should issue a recall. Can find any recall but have done research and find it is an on going issue seems be be a multi function switch.
Electrical system, Exterior lighting, Aug 7, 2024
My left headlamp always goes off. The lights go off all the time. I changed the bulb but its Not it. It the faulty light cable connections. I replace higher lights 12000k and the left light cable never stays on. Cause the left light cable is crap and never probably done. So i bought a lemon new off the lot
Exterior lighting, Aug 1, 2024
while driving at night the headlights will go out. it has done so several times in the past. it is very scary when it happens on the freeway. Also the brake lights, specifically the drivers side, will stop working about every 2 weeks or so. I replace it and shortly after, it will stop working.
Exterior lighting, Jul 1, 2024
The contact owns a 2016 Kia Sorento. The contact stated that while driving at undisclosed speeds, the rear brake lights became inoperable on several occasions. The contact was pulled over due to the rear lights being inoperable. The contact noticed that the sockets for the bulbs had overheated. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who replaced the bulbs. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.
Exterior lighting, Feb 29, 2024
While driving the auto lights shut off and I must turn on lights. This has happened a few times
Steering, Exterior lighting, Other or unspecified, Nov 21, 2023
Issues with headlights turning off while I'm driving in the dark. Sometimes happens when I use turn signal other times just driving on a straight road in the dark country. Also transmission slips every so often but enough that passengers notice and want to know what is happening. Now car can not be shifted out of park even with foot on brake and steering will lock up and key can't be turned. Of course dealer says would cost over 1k to check it all out and even with 2 warranties nothing is covered. Please advise me what to do next. Lights have been doing this for at least 4 years. Can't remember on the trans issue for sure. Steering locking up about a year and just recently can't shift.
Exterior lighting, Nov 7, 2023
The contact owns a 2016 Kia Sorento. The contact stated that on several occasions while driving at various speeds, the headlamps became inoperable. The contact stated that the light switch was jiggled, and the lamps illuminated. The vehicle was taken to a dealer however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 152,000.
Exterior lighting, Aug 27, 2023
At various times the headlights shut off while in "auto" mode. Since it is "auto" mode it is always at night and you suddenly cannot see the road. We have found when this happens that the system goes to the "Parking" light mode. Rotating the multi-function switch to a different position other than "auto" and back allows the headlights to come back on. We have not found a pattern in this dangerous event where we are able to repeat the failure.
Exterior lighting, Aug 9, 2023
"Auto" mode on headlights sometimes causes the headlights to turn off while in use in dark conditions. Auto mode also sometimes causes the lights not to turn on automatically or turn on randomly, even when the car is not in use and key is not in the ignition. Lights can turn on randomly when not occupied or being driven.
Exterior lighting, Jul 16, 2023
When driving at night with the light switch in auto position, headlight will turn off. Sometimes, turning the switch to off and back to auto will make them work. Sometimes wiggles the switch will make them work. Sometimes you have to switch them to on to make them work.
Power train, Exterior lighting, Engine, Jun 24, 2023
Vehicle is consuming an excessive amount of oil, I see this is a common issue with this make and model , even a TSB regarding this issue. Yet, dealership states it is normal. I’m sorry but I have never owned a vehicle where it is normal to have to add 4 qts of oil between oil changes. This is a serious concern for engine wear and tear. I would like to escalate this issue to seek resolution. Another issue I see is both rear window regulators failed at same time. This I believe is due to poor design and low quality parts being used. Plastic pieces are used to hold metal wire in place to raise and lower windows. This plastic easily breaks over time causing windows to fall down suddenly and potentially shatter sending glass and debris in rear passengers. Headlight switch is defective causing headlights to turn off randomly while driving and then not being able to turn back on immediately. Huge safety concern at night.
Exterior lighting, Feb 15, 2023
My headlights go completely out, pitch black, going over 50mph, several times now. I have turned them off the automatic setting as this has happened more than 5 times over the past year. Everything out front goes black including fog lamps, meeting cars, not meeting cars, lights, no lights on the roadway, no rhyme or reason. No warning lights, no sensors covered. My children have been in the car everytime but once. Nobody knows what's going on with it as it happens intermittently and no codes appear.
Electrical system, Exterior lighting, Engine, Jan 12, 2023
The contact owns a 2016 Kia Sorento. The contact stated that the exterior lights failed to operate as needed. There was no warning light illuminated. The contact stated that the headlamps and brake light bulbs had been changed approximately 2 - 3 times per year. Additionally, the horn failed to sound off while being depressed. The contact stated that the oil pressure warning light failed to illuminate to notify the contact that the oil level was low. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was jump started. The vehicle was started and there was an abnormal knocking sound coming from the engine with the check engine warning light illuminated. The vehicle was taken to the dealer and the contact was informed that there was no oil in the engine. The mechanic performed an oil change on the vehicle. The cause of the failure with the exterior lighting was not yet determined. The contact stated that the bulbs were replaced at Walmart. The manufacturer was made aware of the failure. The approximate failure mileage was 20,000.
Exterior lighting, Dec 1, 2022
When lights are turned to automatic setting they often turn on during daylight or off at night. They have now turned off while driving at night on unlit roads and highways and we are lucky we did not have an accident. Typically jiggling the knob on light lever will reset the lights to be correct, but this leads to distracted driving often while not being able to see the road.
Exterior lighting, Nov 15, 2022
Drive side brake light keeps burning out, even after several replacements. The bulb becomes black each time. Not sure if it's related, but headlight will intermittently turn off when in Auto light mode, even at night.
Exterior lighting, Visibility/wiper, Oct 21, 2022
There was an instance where I was driving in heavy rain and the windshield wipers just stopped working. I had to drive about 5 more miles without them working. They worked the next time it rained a couple of days later. There has been 2 instances in the last week where I have had my car parked in my driveway off and locked. In the middle of the night, the headlights and taillights come on on there own. The headlights setting has been set to auto. I end up having to go out and start and turn off my car, then when I lock it back the lights go off.
Exterior lighting, Sep 19, 2022
This has been an ongoing issue, headlights set in automatic mode will turn off at night with no warning. They will also turn on in direct sunlight. This is an intermittent issue. Have taken to Kia service on two separate occasions, told they can not find issue or replicate problem. Have video of lights at night turning completely off set in auto mode.There is no warning when headlights turn off, which has happened to us in the rain and on roads that have no overhead lighting creating very dangerous situations.
Exterior lighting, Aug 25, 2022
When I make a left-hand turn, the right-hand signal light will come on as I'm making the turn. My vehicle is available for inspection. This puts me and the drivers around me in immediate danger of an auto accident. I have not taken the vehicle to a dealer for this problem. The vehicle has not been inspected. There were no warning lamps, messages or other symptoms of the problem prior to it first appearing three or four months after I purchased the vehicle in May of 2020. I don't want to get rear-ended or accidently pitted because of this problem (especially with passengers in my vehicle).
Electrical system, Exterior lighting, Lane departure, Feb 9, 2022
Unknown. The blind spots warning sometimes works and sometimes it doesn’t. The same goes for the backing warning. The car will not lock itself with the key control or manually. This problem has happened a few times already. One of the lights at the driver side isn’t working. (Inside light)