2016 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,251 owner complaints filed for this model year. This is the 2nd highest complaint count among 23 Sorento model years with reports.
Of the 2016 reports, 29 involved a crash and 49 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideSep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Campaign 22V703000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftAug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
A vehicle rollaway increases the risk of a crash and injury.
Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Campaign 22V612000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Trailer hitchesNov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Campaign 16V862000 on NHTSA.gov
SeatsOct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Campaign 16V770000 on NHTSA.gov
Suspension, rearJun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Campaign 16V480000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Campaign 15V446000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Campaign 15V089000 on NHTSA.gov
Representative owner complaints
1,251 reports, newest first.
Steering, Lane departure, Back over prevention, Dec 6, 2023
When driving down the road at any speed in a striaght line steering sticks requiring constant over correction. This is becoming a big problem at highway speeds as vehcile will jerk and on an icy road Im affaid I my lose control
Steering, Dec 6, 2023
Steering sticking,
Structure, Dec 4, 2023
Large area of paint peeled off the hood while washing the vehicle
Engine, Dec 2, 2023
I’ve had my 2016 KIA Sorento for a month. The engine locked up. So, I would like for it to be repaired at no cost to me since it was within the 30 period of purchase. I need to know what to do at this point. My car is at the dealership where I bought it from. Thank you for a speedy response.
Structure, Dec 1, 2023
Paint delamination happening to my Kia Sorento, paint is peeling exposing primer
Engine, Dec 1, 2023
The contact owns a 2016 Kia Sorento. The contact stated while driving 25 MPH, the vehicle stalled. The contact was able to push the vehicle off the roadway. There were no warning lights illuminated. The vehicle was towed to the residence. The contact called the local dealer and was informed that the vehicle needed to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the vehicle needed to be diagnosed. The approximate failure mileage was 100,000.
Engine, Nov 29, 2023
Last year before my 100,000 mile warranty was up, my vehicles engine light and oil light came on. This was following an oil change which was approximately 3000 in. I checked the oil to find out there was no oil. After adding oil, I took it to the Kia dealership and was told the place who changed the oil didn’t tighten my oil filter which was not true because there was no oil on the garage floor where it was parked. They then proceeded to tell me this engine uses a quart of oil every 1000 miles. Fast forward, to last week, I was driving on the highway when my car all the sudden had high RPM but wouldn’t accelerate. The vehicle started stalling and died. I pulled over and again tried to start the car which it died again. The oil level was fine. I took it to a mechanic to find out the engine had 3 cylinders misfiring due to not getting the compression needed resulting in the engine failing. The oil consumption resulted in needing a new engine and now outside of warranty.
Engine, Nov 28, 2023
My 2016 Sorento LX is consuming 3quarts of oil in 1000 miles, I have asked the dealership and mentioned this to them and now after warranty is over they finally did oil consumption test and my car needs a new engine, I was told it could blow up at anytime, I have all maintenance papers and was told I would have to pay $7,000 to replace engine
Engine, Nov 27, 2023
Does not show low oil light when the car has no oil in the engine
Vehicle speed control, Engine, Forward collision avoidance, Nov 21, 2023
My car started jumping while driving we had put oil in my car 3 weeks prior. It also smelt like my car was burning while the heat was on I had 2 babies in the back seat and I was scared to death. I haven’t received anything in the mail about any recalls what so ever. I had to hear by a family friend the day of the incident that he thinks they’re recalls on my call so I looked it up. My car is currently not working now and I have work and doctors appointments for babies I got to Kia tomorrow they’re saying I don’t have any recalls on my car and I looked it up on here and I do. I’m pretty sure they’re just not wanting to pay for it. They said if I have a warranty they could do. I just don’t know what to do I have no car and I ave 2 children I can’t afford to not have a vehicle.
Steering, Exterior lighting, Other or unspecified, Nov 21, 2023
Issues with headlights turning off while I'm driving in the dark. Sometimes happens when I use turn signal other times just driving on a straight road in the dark country. Also transmission slips every so often but enough that passengers notice and want to know what is happening. Now car can not be shifted out of park even with foot on brake and steering will lock up and key can't be turned. Of course dealer says would cost over 1k to check it all out and even with 2 warranties nothing is covered. Please advise me what to do next. Lights have been doing this for at least 4 years. Can't remember on the trans issue for sure. Steering locking up about a year and just recently can't shift.
Electrical system, Engine, Nov 20, 2023
A lot of oil in the floor. Oil Pressure Sensor Fail Lock of all doors are crazy (lock and unlock so many times)
Engine, Nov 20, 2023
Engine light come on and had someone to check it and they said recall on motor car has been using a lot of oil I put in one quart every two weeks the car is stalling and missing also
Engine, Nov 20, 2023
due to low oil pressure the timing chain failed causing immediate loss of power. The call was then rolled off the highway at idle speed creating a hazard while this was being done. There were no warning lamps prior to incident. This was inspected by the dealer "Team KIA El Cajon".
Engine, Nov 18, 2023
While driving car sputtered, was able to get to side of road. Turned car off, waited and then turned on again and was able to proceed, engine light on - got occasional performance issues. Kia dealer checked out and servicing, informed me of the oil was depleted issue and in need of substantial engine repair. (Provided written estimate, approx $4800). Able to continue driving but risk of stalling, told eventually timing belt will fail. Got estimates for repairing, and total engine replace to compare options. (Have not done either option as yet).
Engine, Nov 16, 2023
The engine has not worked properly in over a year and has problems accelerating and skipping. Engine light remains on at all times.
Engine, Nov 16, 2023
Engine began regularly overheating. Problem began in May 2023. No warning lights, other than the temperature gauge going up. Thermostat was replaced, radiator was cleaned and checked, without defects found. No leaking hoses. Problem continued to get worse, requiring coolant be added every time the car was driven. Mechanic decided the head gasket was failing. Due to the nature of the head bolts, the recommendation was to replace the engine. This has not been done and the car is unusable and unsellable due to the failure.
Power train, Engine, Nov 15, 2023
17-year-old daughter driving 65 mph down the highway when engine just gave out. Loss drive power but was able to make it to the side of highway, once stopped coolant find blowing out. There was no overheating warning or light luminated on dash. Once towed to shop and inspected told head gasket blown out dur to loose head bolts & possible head crack due to lost coolant.
Engine, Nov 15, 2023
2016 Sorento 3.3L with approximately 136,000 miles on it. Did not have heat. Diagnosed with low coolant and possible head gasket leak due to loose head bolts. No warning lights. Seems to be a common manufacturing issue with these engines.
Engine, Nov 14, 2023
Engine stalled when merging in the freeway. Mechanic said that the engine stalled because there was not enough oil. I did an oil change a month prior, and no oil light indication came on until after the car broke down.
Steering, Electrical system, Nov 12, 2023
At 45mph or faster, when turning left.. the steering sticks briefly and the EPS (electric power steering) over-corrects it. Makes the steering wheel jump. So the driver has to perform constant corrections. I believe it’s very serious safety issue.
Engine, Nov 10, 2023
2016 Kia Sorento SX 3.3l engine failure at 87k miles. Head bolts backed out. Kia dealership verified the issue. The engine could have seized why driving which is a safety risk. No warning lights at all.
Power train, Nov 8, 2023
I was unable to to get my gear out of park. I took to Kia immediately to inspect this issue. My safety is at risk if a collision occurs because I can’t change gears or if I have my children in the car and I get stuck in a remote location. The problem is currently being inspected by a Kia dealership & no one else has been notified just yet. I was given no warning or message before this began on Nov. 7, 2023. After a thorough internet search it seems there are several KIA owners that have experienced the same problem.
Engine, Nov 8, 2023
I was taking my mom to her knee appointment after her surgery, and my temperature gauge started to rise. No lights or warnings came on in the car what so ever. I pulled over before it reached the red, let it cool and checked fluids. From what I could see the oil, and coolant were fine. The heat in the car stopped working, and the car kept wanting to over heat in the lower gears. I got it to Lion Country Kia in St.College and diagnosed it as finding a cylinder head gasket. My car could no longer be driven, from St.College to my home in St.Mary’s. I had to have it towed, as well as checked here as well to find they were right with a cylinder head gasket issue. I was under the assumption I had the power train warranty as well because it’s under 10/100,000 but unknown to me I didn’t. I could’ve been in an awful accident if I wasn’t paying attention to my gauges and my car overheated and locked up while driving. If anything would’ve happened to my children and my mom in the car that day, all because of a fault in the car manufacturing, Id be knocking on doors! To see all the recalls on the years previous to this for the same issue, you would think it would’ve either been taken care of, or a recall put on this year as well. From what I’ve been reading it’s been happening all too often. Something needs done.
Exterior lighting, Nov 7, 2023
The contact owns a 2016 Kia Sorento. The contact stated that on several occasions while driving at various speeds, the headlamps became inoperable. The contact stated that the light switch was jiggled, and the lamps illuminated. The vehicle was taken to a dealer however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 152,000.