2016 Kia Sorento
Problems, recalls and owner-reported issues
Engine is the leading concern among 1,251 owner complaints filed for this model year. This is the 2nd highest complaint count among 23 Sorento model years with reports.
Of the 2016 reports, 29 involved a crash and 49 involved a fire. 19 people were injured.
What owners report most often
Recalls and investigations
Trailer hitchesPark outsideSep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
A fire while parked or driving can increase the risk of injury.
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Campaign 22V703000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftAug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
A vehicle rollaway increases the risk of a crash and injury.
Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Campaign 22V612000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Campaign 18V907000 on NHTSA.gov
Trailer hitchesNov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Campaign 16V862000 on NHTSA.gov
SeatsOct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Campaign 16V770000 on NHTSA.gov
Suspension, rearJun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Campaign 16V480000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Campaign 15V446000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Campaign 15V089000 on NHTSA.gov
Representative owner complaints
1,251 reports, newest first.
Power train, Exterior lighting, Engine, Jun 24, 2023
Vehicle is consuming an excessive amount of oil, I see this is a common issue with this make and model , even a TSB regarding this issue. Yet, dealership states it is normal. I’m sorry but I have never owned a vehicle where it is normal to have to add 4 qts of oil between oil changes. This is a serious concern for engine wear and tear. I would like to escalate this issue to seek resolution. Another issue I see is both rear window regulators failed at same time. This I believe is due to poor design and low quality parts being used. Plastic pieces are used to hold metal wire in place to raise and lower windows. This plastic easily breaks over time causing windows to fall down suddenly and potentially shatter sending glass and debris in rear passengers. Headlight switch is defective causing headlights to turn off randomly while driving and then not being able to turn back on immediately. Huge safety concern at night.
Power train, Engine, Fuel/propulsion system, Jun 21, 2023, fire
Recently, while driving on a busy multi-lane highway my 2016 Kia Sorento suddenly lost power, started shaking and slowed down causing traffic safety hazard. The engine stalled after slowing down. The car needed to be towed at my expense.my check engine light came on for my KSDS, the engine went limp mode and unable to accelerate over 50 miles and hour on the highway. My engine is blown. gasoline smell fumes came through vent causing me to have an attack car started to catch fire.
Engine, Jun 20, 2023
Im driving my car then my engine totally shut down.
Structure, Jun 19, 2023
I brought my car brand new from the KIA DEALERSHIP.. I started to notice paint that was missing which I thought maybe from a rock(2019)But the peeling continued to peel. At this point my hood is 35% peeled off now and the top of my Kia is now starting to peel . I have noticed a lot of Kia owners that have this exact same problem.
Engine, Jun 18, 2023
When accelerating at 70 miles an hour, the RPM went up to 5 and then all acceleration was lost. I was able to steer my vehicle to the side of the highway and at that point turned off the vehicle. When I tried to restart the vehicle, it would not start. The check engine light and battery light came on at that time. After having a mechanic look at the vehicle and the battery was replaced, it was discovered that the oil level was excessively low, even though an oil change had been performed less than 4000 miles ago. The oil light was never on alerting me that oil was a problem and there were no oil spots indicating a leak. As of now the vehicle engine is completely locked up and will not start. It needs a new engine.
Other or unspecified, Jun 16, 2023
Power Latch Assy. The rear hatch does not open Problem was reproduced at Tameron Kia, 10611 Boney Avenue, D'Iberville, MS. 39540 (228)679-5200 Problem was diagnosed as internal open/short making rear power tail gate inoperable. No warning lamp or signal advised of the failure. Problem was first noted in January 2023 assy.The rear Hatch latch does not open.
Electrical system, Service brakes, Engine, Jun 12, 2023, fire
I was traveling on the interstate, I heard a slight tapping noise, after about 5 miles, there was no warning light indicators, the car just died, I lost all power, there were no brakes, I was able to get pulled off the highway to the warning track that helped slow the vehicle down, smoke was coming from under the hood & into the cabin, then I saw flames, at about 20mph I knew I had to get out so I put it in park & it finally stopped. I had just enough time to grab my purse & suitcase out of the back & it was in engulfed in flames immediately. I had just had the car serviced 1 month prior for oil change & Anti theft recall but was advised that recall wasn't being done at this time. The engine light had came on the day before I took it in for the oil change, they reset it stating it was a CO2 sensor & if it came back on to let them know. It did not. It has been reported to my insurance& deemed total loss, I filed a claim with Kia & have not heard back, the Kia service dept. where it was taken said there was nothing they can do, that it will have to be investigated by insurance.
Engine, Jun 7, 2023
Motor siezed while driving in the freeway
Engine, Jun 6, 2023
Vehicle was purchased used on 02-23-2023 from a dealership. One and a half months later, the temp gauge goes into the red. This was the only indication that there was an issue. The dealer found that the head gasket was blown, however upon further inspection it was discovered that the bolts were stripped inside and this was what started the problem. With no other warning other than the temp gauge, the vehicle could have seized up while driving down the highway causing a catastrophic failure and a safety hazard.
Engine and engine cooling, Jun 6, 2023
The contact owns a 2016 Kia Sorento LX. The contact stated that after the dealer completed remedies for Kia recalls SC234, SC249B, and CS2304, he was notified by the dealer that the vehicle's engine oil was 2 quartz low. The contact informed the dealer that he had just completed a scheduled oil change two weeks prior. No warning lights were illuminated on the instrument panel. The vehicle was taken back to the dealer, who advised the contact that the vehicle may be burning engine oil abnormally fast and began a 1,000-mile performance test to determine the oil burn rate of the engine; the test is still underway. The vehicle has not been repaired. The manufacturer was notified, and a case was opened. The failure mileage was 91,023. The dealer contacted the warranty company but was denied coverage for the vehicle.
Engine, Jun 5, 2023
On my way home from work I heard a knocking sound coming from the engine while on the highway the vehicle slowed down at 40 miles per hour then the from end dipped then return in an upright position. The vehicle suddenly lost power the engine would not turn over. There were no warning engine lights or anything before hand to indicate there was a problem before the engine power loss. I had to pay All County Auto Body $135.78 to two vehicle off the highway and then my insurance tow transported my vehicle to Queens. Galaxy Auto completed diagnostic test and informed me the engine is no good, basically the engine seized. I reached out to KIA headquarters via email no response to the situation at hand. On 05/12/2023 received notice from KIA recall for tow hinge on vehicle. KIA did not address the engine failure on the 2016 KIA Sorentia GDI which I just finish paying off. My vehicle is parked up no monetary funds to purchase an engine or to pay for labor cost. On 5/26/2023 vehicle towed KIA dealership service area for diagnostic test and I was informed by a representative that the vehicle has life time warranty on the engine. After the diagnostic test I was informed on June 1,2023 "that I can eliminate the $2000 core charge on there however there is a $2500 installation cost on top of the parts. The power-train warranty had expired May 8th of 2020." Also, there was an engine recall on this model no one can give me a date or year of the recall. Basically, KIA is not going to honor their mistake and failed to make necessary repairs on the engine. The entire situation is terrible and KIA is not being held responsible for their negligence . Upon close review of the engine failure posted on NHTSA. gov website there are over 300 plus vehicles reported on this site with the same engine failure. what is being done to help us the consumer from being duped by manufactures who preyed on hardworking consumers who purchased vehicles that are defective?
Engine, Jun 5, 2023
Vehicle had a slow engine oil leak which began just after 100,000 miles and mirrored symptoms of the "oil pressure switch" defect, which was replaced under warranty pursuant to a warranty extension campaign from Kia. Following the replacement of the oil pressure switch, the vehicle continued to slowly leak oil. Kia service manager took the engine apart and stated that the threads for the head bolts were stripped from the engine block, causing an oil leak from the head gasket. During a later in-person conversation, which was lawfully recorded, the service manager stated that it was a well known and established defect which Kia is refusing to officially acknowledge, and said that he has personally replaced over fifty (50) 2016 model year 3.3L V6 engines with stripped head bolts. The only solution was to replace the engine, and Kia refused to cover any repair or replacement costs. The vehicle is available for inspection (at the dealership), and although my vehicle did not have any symptoms other than the oil leak, in other instances it commonly causes engine overheating.
Engine, Jun 5, 2023
I became the proud owner of a 2016 Kia Sorento, which I got from Jerry Smith KIA in Burlington, Washington, in February 2020. This car has received prompt service for every maintenance item at the dealership where I bought it. Other than the expected wear and tear, I have never experienced any unneeded problems with the car. It's driven 143,928 miles. I had no warning what so ever that there was an issue with the motor. I had the car inspected and had the regular oil changed on April 20th, 2023, and everything was fine. On April 22, 2023, I drove the Kia while out to dinner with my daughter and her friends. On the way home, however, after dropping the girls off, the car cut out and died, but I was still able to make it to the side of the road. The engine knocked like a rod and wouldn't stay turned over for more than ten seconds when I tried to start the car again. All the dash lights lit up and engine sounded like a rattle can. I had the car towed the following morning to the dealership where I have it serviced. After a week, they were able to identify the problem. It appears that the engine's bearings failed. They estimated that a replacement engine would cost $18,000. The vehicle has a negative equity of $13,000, which is too high for me to trade in. Spending that much money on it is not worthwhile. It is currently yard art in my driveway. Despite my attempts to rectify the situation, I am still left with a sense of dissatisfaction and regret over this purchase. It's a lesson learned, but one that comes at a steep cost. After doing some extensive research I have found numerous owners of the same type of vehicle have similar issues.
Engine, Jun 5, 2023
The contact owns a 2016 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle overheated. No warning lights were illuminated. The vehicle was taken to the dealer, who informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 143,000.
Suspension, May 31, 2023
Rear control arm weld broke drivers side. 18 year old lost control on interstate at 70 miles per hour. Was spinning around and avoiding hitting a steal fence, steal beam and wall. I have pictures of the broken weld. If no recall yet their needs to be before it kills someone!! [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Power train, Engine, Fuel/propulsion system, May 31, 2023
This is the second very similar incident with the engine of this vehicle. On Monday, May 29, 2023, the engine failed at a stop light in Fort Wayne Indiana. A few miles before it failed, it suddenly got very noisy and wouldn’t go over about 15 mph. It wouldn’t really react to the accelerator pedal. At the stop light it just quit at a major intersection leaving me stranded in the middle of the road. It has been towed to the Kia dealer in Fort Wayne. They have not diagnosed the problem yet but I have read many reports on line and my experience was similar: vehicular just quit, engine lost oil, accelerator pedal not responsive, and loud ticking sound. I’m afraid the repair will be thousands of dollars and I’m a senior citizen on Social Security. This is a second incident. On October 20, 2022, my daughter in law drove my car to IU Health Hospital in Indianapolis to visit me in the hospital (major surgery). In an hour and a half she used a full tank of gas and 3 quarts of oil — the car slowed to 40 mph, accelerator pedal didn’t work and she was on Route 69 a 4 lane major highway and was very scared. She pulled off at the next exit. The car had to be towed from Indianapolis to Fort Wayne. My mechanic worked on it, got it running ok but it had a major oil leak. I was recovering from my surgery so drove it little. I now find out that the engine in my car has major problems just like what I have experienced and that Kia is refusing to fix them unless people pay in excess of $6000. This is a safety issue!!!! Having the car fail and just quit while on local or interstate roads leads to accidents and injuries. This engine needs to be recalled. Kia knows it and has settled claims out of court so they don’t have to admit responsibility. This is a serious safety hazard. The recent date of May 29, 2023 is provided but the previous date this happened is October 20, 2022. So there were two incidents.
Engine, May 30, 2023
It has 120,000 miles on it. No warning lights. No “low oil” light or anything. My ex-husband hooked up a code reader to it and no codes were being given. It’s currently sitting at dealership, I still owe $3500 on the car and I can’t drive it. Will cost more to put an engine in then to pay off of my car. The dealership can’t look at it for another week. I have no means of another car. And Kia says they can’t do anything.
Other or unspecified, Engine, May 30, 2023
My vehicle is still leaking oil bad after paying over $700 to get the oil pressure switch and gasket replaced on March 1, 2023. I was promised a reimbursement of my funds spent to fix the issue and have not heard back for over a month nor have they addressed the issue with the vehicle still leaking badly. As others are having the same issue it is not fair to us costumers we are left with a defective vehicle. I have small children and this is my only vehicle which is not safe to operate. I need help just like the others who are being ignored. I have included the estimate of the other issue as well.
Power train, May 24, 2023
I would like to confirm if the recall for 2016 Kia Sorento Transmission Shift Level Assembly also covers all of us who have reported complaints about having to use a screw driver to engage our vehicles out of park? This is a safety concerns just as well as the cars that are impacted by the shift lever slipping out of park while engine off. using a screw driver because Kia refuses to replace the part they have acknowledged is faulty, is something that customers should not be responsible for fixing. If there was an issue identified (and clearly there was) the exact same year, make and model and part (the shift lever itself) then the investigation either needs to be expanded or Kia needs to just own that these parts need replaced in a larger span than the recall currently covers. please let me know as I am getting no assistance with these issues from my dealership - Shawnee Mission Kia in Kansas. thanks
Engine, May 24, 2023, fire
The car lost power while driving and the engine caught fire.
Trailer hitches, May 19, 2023
The contact owns a 2016 Kia Sorento. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer had not been made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Engine, May 18, 2023
MY 2016 KIE SORENTO USE OIL I CAN ONLY GO 2000 MILES AND HAVETO ADD OIL TOO IT DEALER DOES OILS CHAGES AND SAY IM GOOD FOR 600O MILES IS THERE A SOLITION TOO THIS ISSUE
Electrical system, May 17, 2023
Saw a news report that the Tow Hitch Harness electric may start on fire. Received a notice from Kia November 1, 2022 regarding the possible fire. Parked car outside as instructed in notice Called local Kia Dealer re: issue (January 16, 2023) NO remedy per [XXX] Asked [XXX] if car can be parked inside garage and if it was advisable to NOT drive the vehicle and he said that the fire issue is only if the hitch electric is used that there is a fire concern and it is ok to park in garage. So we started parking in garage and did not use hitch electric. I contacted. Kia and was put on hold so was unable to share my concerns with the Called again 2/16/2023 still no remedy Asked again if we needed to park outdoors and was there danger is we drove the car. Was told the fire concern is only if the hitch electric was being used and it's ok to park in garage. Called again 3/28/2023 still no remedy Asked again if we needed to park outdoors. Was told no as the fire concern was only if hitch electric was being used and its ok to park in garage. Received another Interim Notice Update today(5/17/2023) dated May 8, 2023 stating that there was an interim fuse fix for the fire issue. Called local Kia Dealer in Waukesha Wisconsin and was able to schedule an appointment for June 6, 2023. Again I asked if we needed to park outside and if it was safe to drive the Sorento. Did not know...follow the letter instructions. My concern is that the dealer is giving different information than what is outlined in the letter from Kia regarding our 2016 Sorento. I am concerned, so we again are parking outside away from our home and other vehicles and will not drive the car until the interim fuse fix is taken care of. Why does the Kia service department tell us it is ok to park in the garage? Why does the Kia service department tell us it is ok to drive the vehicle? I am concerned that mixed messages are being given out by Kia Dealer Service Dept and information from Kia. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Electrical system, Other or unspecified, May 15, 2023
I called Kia to replace fuse per their safety recall information. They are really uninterested in fixing these recalls or allowing me to speak to a manager to fix the issue. What's the point?
Engine, May 14, 2023
On my way home from work I heard a knocking sound coming from the engine while on the highway the vehicle slowed down at 40 miles per hour then the from end dipped then return in an upright position. The vehicle suddenly lost power the engine would not turn over. There were no warning engine lights or anything before hand to indicate there was a problem before the engine power loss. I had to pay the highway tow truck to get me off he highway and then my insurance tow transported my vehicle to Queens. Galaxy Auto completed diagnostic test and informed me the engine is no good, basically the engine seized. I reached out to KIA headquarters via email no response to the situation at hand. On 05/12/2023 received notice from KIA recall for tow hinge on vehicle. KIA did not address the engine failure on the 2016 KIA Sorentia GDI which I just finish paying off. My vehicle is parked up no monetary funds to purchase an engine or to pay for labor cost. Not having a vehicle is causing undue hardship for me and my children. Getting to work and my doctors appointment for chemo treatments is financially difficulty. It is a shame that KIA is allowed to duped consumers and put our lives at risk for profit without any consequences. I would never purchase another KIA vehicle and I warned my friends and family to stay away from KIA brands. Shame on you KIA. Shame on you KIA.