2003 Subaru Forester
Problems, recalls and owner-reported issues
Fuel system is the leading concern among 191 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Forester model years with reports.
Of the 2003 reports, 17 involved a crash. 9 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, front, control arm, lower armSep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
Campaign 11V464000 on NHTSA.gov
Seat belts, front, buckle assemblyFeb 20, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES WERE IMPROPERLY MANUFACTURED.
IN THE EVENT OF A CRASH, THE FRONT SEAT BELTS COULD UNLATCH, WHICH COULD RESULT IN PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT SEAT BELT BUCKLE/LATCH ASSEMBLIES. OWNER NOTIFICATION BEGAN FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 03V047000 on NHTSA.gov
Power train, automatic transmissionOct 30, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.
THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 02V282000 on NHTSA.gov
Representative owner complaints
191 reports, newest first.
Suspension, Structure, Apr 6, 2012
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER.THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V464000 (SUSPENSION: FRONT: CONTROL ARM: LOWER ARM) WHEN THE CONTACT WAS ADVISED THAT THE FRONT END OF THE SUB-FRAME WAS CORRODED. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE WAS NOT COVERED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED FOR THE FRAME ISSUE. THE FAILURE MILEAGE WAS 157,000 AND CURRENT MILEAGE WAS 160,000. UPDATED 05/08/12*LJ
Structure, Apr 2, 2012
WE TOOK OUR 2003 SUBARU FORESTER IN TO THE DEALERSHIP FOR AN OIL CHANGE AND WAS TOLD THAT THE FRAME OF THE CAR WAS IN "SERIOUS" CONDITION AND NEEDED TO BE REPLACED. A PHOTO WAS TAKEN AND SENT TO THE DISTRICT MANAGER FOR HIS REVIEW. WE REPLACED THE CONTROL ARMS ON OUR OWN IN DECEMBER 2011. TOOK THE CAR IN TO OUR DEALERSHIP IN JANUARY 2012 FOR RECALL OF CONTROL ARMS AND NOTHING WAS SAID ABOUT THE FRAME AT THAT TIME. MECHANIC STATED YOU CAN PUT YOUR FINGER INTO THE HOLE IN THE FRAME OF THE CAR. FORESTER WAS NEVER DRIVEN OFF-ROAD AND WAS DRIVEN SOLELY IN THE CITY. THE FRAME SHOULD NOT HAVE RUSTED OUT THROUGH NORMAL WEAR AND TEAR. WINTER THIS YEAR WAS VERY MILD. PLEASE INVESTIGATE THIS AS FRAMES ON CARS SHOULD NOT DEVELOP HOLES. *TR
Engine and engine cooling, Mar 2, 2012
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT THE ENGINE EXHIBITED A LOUD, UNUSUAL NOISE WHEN THE VEHICLE WAS FIRST STARTED OR WHEN DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE ENGINE AND ADVISED THAT THE ENGINE MANUFACTURE WAS A FACTORY DEFECT AND WOULD NEED TO BE REPLACED. THE ENGINE WAS REPLACED BUT THE HEAD GASKET THEN BEGAN LEAKING. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT AND DENIED ASSISTANCE WITH REPAIRS TO THE VEHICLE BECAUSE THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 26,279 AND THE CURRENT MILEAGE WAS 83,300. UPDATED 04/05/12*LJ UPDATED 06/13/2012 *JS
Suspension, Structure, Mar 1, 2012
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER . THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V464000. (SUSPENSION: FRONT:CONTROL ARM:LOWER ARM) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REPAIRS. THE DEALER ADVISED THE CONTACT THAT THE REPAIR COULD NOT BE PERFORMED BECAUSE THE SUB FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 69,000. UPDATED 03/28/12*LJ THE CONSUMER STATED AFTER CONTACTING SUBARU OF AMERICA, THEY AGREED TO COVER ALL COSTS ASSOCIATED WITH THE REPAIR, INCLUDING THE REPLACEMENT OF THE SUBFRAME. UPDATED 03/30/12*JB
Air bags, Jun 13, 2011
I HAVE A 2003 SUBARU FORESTER AND HAVE HAD AN ONGOING PROBLEM WITH THE AIR BAG LIGHT COMING ON. SOMETIMES IT COMES ON AND GOES OFF BY ITSELF. MOST RECENTLY, IT WENT OFF AFTER I CHANGED THE PASSENGER SEAT POSITION. I HAVE BEEN ADVISED THAT IT IS DUE TO THE AIRBAG SENSORS UNDER THE FRONT SEATS BEING JOSTLED OR DETACHED EITHER BY CHANGING SEAT POSITIONS OR SLIDING SOMETHING DOWN ALONGSIDE THE SEAT (LIKE A MAGAZINE OR NEWSPAPER.) I'VE HAD THE SENSOR ON THE PASSENGER SIDE FIXED AT CONSIDERABLE COST TO ME. IT'S ANNOYING AND CLEARLY A DESIGN PROBLEM THAT SHOULD BE REMEDIED BY THE DEALER AT NO CHARGE. *TR
Air bags, Equipment, Jun 8, 2011
AIR BAG LIGHT HAS BEEN ON FOR ABOUT A MONTH. IT WENT OUT ONCE FOR A BIT BUT HAS BEEN ON SINCE. I HAD ONE SERVICE DEPT. SAY THE PROBLEM WAS IN THE PASSENGER SIDE AIR BAG SENSOR. THS SUBARU DEALERSHIP SAID IT WAS THE AIR BAG SENSORS UNDER FRONT SEATS.- CAUSED BY CHANGING THE POSITION OF THE SEATS FREQENTLY AND MADE THE WIRES BREAK. I HAVE 88.000 MILES ON MY CAR. I AM THE ONLY DRIVER SO I DO NOT CHANGE MY SEAT POSITION OFTEN. THERE WAS NOTHING NOTED AT TIME OF PURCHASE ABOUT LIMITING CHANGE OF SEAT POSITION. THIS IS ACTUALLY REDICULOS. THEY STATED IT WOULD COST $370 TO FIX AND THEY HAD PACKET PARS AVAILABLE AND COULD EASILY REPLACE THEM. THEY STATED THIS IS AN UNCOMMON PROBLEM - IF SO UNCOMMON PROBLEM WHY DID THEY HAVE TO COME UP WITH THESE REPLACEMENT PACKETS? I READ THEY REENGINEERED THIS PART FOR THE NEXT YEAR MODEL. I DID SOME CHECKING AND FOUND SERVERAL COMPLAINTS FROM OTHER OWNERS OF 2003 FORESTERS WITH THE SAME PROBLEM BUT NOT ENOUGHT COMPLAINTS TO FORCE A RECALL. . IT IS A DEFINITE "COMMON" PROBLEM. IN THE END THE DEALERSHIP CHARGED ME $150 AND REPLACED ONLY ONE SENSOR WHICH RESOLVED THE PROBLEM. I'VE READ THAT SUCH "SAFETY PARTS" SHOULD BE REPLACED AT NO COST? IS THIS TRUE? THEN I THINK I AM OWED A REFUND I AM PRINTING OUT A FEW OF THE SAME COMPLAINTS AND ALSO THE STATEMENT THAT THIS REPAIR SHOULD COST NOTHING AS IT IS A SAFETY ISSUE. COULD YOU PLEASE ADVISE. *TR
Engine and engine cooling, Mar 9, 2011
2003 SUBARU FORESTER ~114K MILES. DURING PASSING (~70 MPH)ENGINE HAS STALLED 2X IN PAST WEEK. AFTER COMING TO FULL STOP AND TURNING KEY IN IGNITION FULL "OFF", CAR RESTARTS WITH NO DIFFICULTY WILL TAKE TO DEALER THIS WEEK. HAD BATTER INSTALLED ~ 2 MONTHS AGO. *TR
Fuel system, Gasoline, Mar 3, 2011
TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE IN COLD WEATHER TEMPERATURES, THE VEHICLE WOULD EXHIBIT AN UNUSUALLY OVERPOWERING GASOLINE FUEL ODOR FROM THE INTERIOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS YET THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT UNDER RECALL AND WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.
Fuel system, Gasoline, Feb 17, 2011
WE'RE THE OWNERS OF A 2003 SUBARU FORESTER (ABOUT 90 000 MILES). FOR AT LEAST 6 MONTHS AFTER WE FILL THE GAS TANK, WE DETECT GAS FUMES NEAR THE REAR WHEELS - EXTERIOR ONLY. AS THE TANKS LEVEL GOES DOWN, THE SMELL WILL GO AWAY. WE ARE NOT OVER-FILLING; IN FACT WE WILL FILL BEFORE THE PUMP "CLICKS OFF". THERE IS NO DRIPPING OF GAS AND OUR MECHANIC HAS CHECKED FOR LEAKS/OVERFLOWS ETC AND HAS FOUND NOTHING. OBVIOUSLY SOMETHING IS WRONG AND WE ARE NOT THE ONLY OWNERS WHO HAVE COMPLAINED ABOUT THIS EXTERIOR SMELL (IT SEEMS TO HAVE BEEN VERY PREVALENT IN THE 2002 MODEL). THE DEALER HAS BEEN NO HELP. WE HOPE NHTSA CAN HELP US. THANKS. *TR
Fuel system, Gasoline, Jan 24, 2011
THE PREVIOUS NIGHT WAS -17, I DIDN'T DRIVE THE CAR ALL DAY. AT 6:30 PM I DROVE THE CAR FOR 1/2HOUR, ALL WAS WELL. 2 HOURS LATER (-3 DEGREES) I GOT IN THE CAR AND DROVE 15 MIN AT WHICH TIME I CAME TO A STOP SIGN AND TURNED RIGHT ONTO ANOTHER ROAD AND THE SMELL OF GAS INSIDE THE CAR BEGAN. I LOOKED UP THE SYMPTOMS ONLINE AND FOUND I'M NOT THE ONLY ONE. NO ACTION HAS BEEN TAKEN. *TR
Tires, Dec 25, 2010
I PURCHASED AND HAD INSTALLED 8 NEW HANKOOK TIRES FOR TWO VEHICLES AT L&M TIRE & WHEEL 185 W. KING ST. ABBOTTSTOWN, PA. 17301, 7172590567. THEY DID NOT RECORD THE TYPE OF VEHICLES, MILEAGE OF THE VEHICLES OR MY ADDRESS. ALL THAT WAS WRITTEN ON THE RECEIPT WAS MY NAME AND PHONE NUMBER. THIS INFORMATION WOULD NOT BE SUFFICIENT FOR ME TO BE NOTIFIED IF THERE WERE A RECALL OF THESE TIRES. THIS SHOULD BE A REQUIREMENT TO PROTECT THE PUBLIC. IF IT IS A REQUIREMENT WHAT AGENCY IS RESPONSIBLE FOR ENFORCING THE RETENTION OF THIS INFORMATION? *TR
Engine and engine cooling, Air bags, Dec 15, 2010, crash
FRONTAL IMPACT WHILE STRIKING A DEER AT THIS SPEED SHOULD HAVE DEPLOYED BOTH AIR BAGS. THE AIR BAG LIGHT SOMETIMES WOULD REMAIN ON, BUT MOSTLY IT WAS OFF. FROM WHAT I HAVE FOUND THROUGH OTHER COMPLAINTS IS THAT THIS YEAR VEHICLE IS KNOWN FOR THIS ISSUE, BUT A RECALL HAS NOT BEEN ISSUED. IS IT GOING TO TAKE A DEATH TO FORCE SUBARU TO CORRECT THIS ISSUE? THE OTHER ISSUE FOUND WHILE REPAIRING THE VEHICLE IS THAT BOTH HEAD GASKETS ARE SEEPING COOLANT, THE DRIVERS SIDE IS SEEPING MORE JUST LIKE THE RECALL DESCRIBES ON 1999-2002 MODELS. EVEN THOUGH THIS A 2003 IT WAS PURCHASED IN THE FALL OF 2002, SUBARU FAILED TO CONTACT ME AND ADVISE ME TO ADD THE $1.44 COOLANT ADDITIVE TO SAVE THE HEAD GASKETS. HOW IS A CONSUMER SUPPOSED TO KNOW THESE LITTLE DETAILS? NOW THE VEHICLE HAS TOO MANY MILES FOR THEM TO CARE, STICKING ME WITH THE ESTIMATED $2000 REPAIR.
Fuel system, Gasoline, Dec 13, 2010
2003 SUBARU FORESTER XS - FUEL SMELL IN CABIN DURING COLD WEATHER. SIMILAR TO THE MANY POSTS OUT THERE, THERE IS AN UNBEARABLE SMELL OF GAS IN THE CABIN OF MY CAR. I HAVE TO ROLL WINDOWS DOWN IN THE FREEZING WEATHER TO CONTINUE TO DRIVE. I'VE READ IT IS DUE TO CONTRACTING FUEL LINES THAT THEN LEAK. FIRE HAZARDS ARE OBVIOUS, BUT THE NOXIOUS GAS IS ENOUGH TO AT LEAST DISTRACT YOUR DRIVING IF NOT KNOCK YOU UNCONSCIOUS. I WILL VISIT MY DEALER THIS WEEK TO COMPLAIN. *TR
Vehicle speed control, Apr 21, 2010, crash
TL*THE CONTACT OWNS A 2003 SUBARU FORESTER. WHILE PULLING OUT OF THE DRIVEWAY, THE VEHICLE SUDDENLY BEGAN TO ACCELERATE UP TO 35 MPH AFTER THE CONTACT RELEASED THE ACCELERATOR PEDAL. THE VEHICLE CRASHED INTO A TREE AND WAS TOTALED. THE CONTACT WAS INJURED AS A RESULT OF THE CRASH. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000.
Vehicle speed control, Mar 8, 2010, crash
TL* THE CONTACT OWNED A 2003 SUBARU FORESTER. WHILE DRIVING AT SPEEDS OF LESS THAN 20 MPH AND ENTERING HER DRIVEWAY, THE VEHICLE ABNORMALLY ACCELERATED AT A RAPID SPEED. THE VEHICLE CRASHED INTO HER HOME CAUSING CONSIDERABLE DAMAGES TO THE VEHICLE AND HER HOME. THE AIRBAGS DID NOT DEPLOY AT THE TIME OF IMPACT, HOWEVER SHE DID NOT SUSTAIN ANY INJURIES. THE MANUFACTURER WAS NOT CONTACTED AND REPAIRS WERE PAID BY HER INSURANCE COMPANY. ON A SEPARATE OCCASION, WHILE DRIVING AT SPEEDS OF LESS THAN 15 MPH AND ENTERING HER DRIVEWAY FROM THE MAIN STREET, THE VEHICLE AGAIN ABNORMALLY ACCELERATED AT A RAPID RATE OF SPEED, CRASHING INTO THE REAR WALL OF HER HOME. THE VEHICLE DID NOT STOP AND PROCEEDED TO CRASH INTO HER GARAGE AND INTO THE REAR WALL OF A NEIGHBORING HOME. SHE DID NOT RECALL IF SHE ATTEMPTED TO DEPRESS THE BRAKE PEDAL AT THE TIME BECAUSE THE INCIDENT HAPPENED WITHIN A MATTER OF SECONDS. THE POLICE WERE CALLED TO THE SCENE AND A REPORT WAS FILED ACCORDINGLY. THE VEHICLE WAS DESTROYED. THE NIGHT BEFORE THE INCIDENT THE VEHICLE WAS TAKEN IN FOR REGULAR SCHEDULED MAINTENANCE. SHE WAS NOT ADVISED THAT THERE WERE ANY ISSUES WITH THE VEHICLE. THE INITIAL FAILURE MILEAGE WAS UNKNOWN, HOWEVER THE MILEAGE WAS 49,000 WHEN THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE.
Vehicle speed control, Feb 26, 2010, crash
ON MONDAY, FEBRUARY 22, 2010, I HAD AN INCIDENT OF "UNINTENDED ACCELERATION" ON POOKS HILL ROAD AND WISCONSIN AVENUE. I WAS STOPPING FOR A RED LIGHT WHEN I PUT ON THE BRAKES AND THE CAR ACCELERATED INSTEAD OF SLOWING AND STOPPING. TO AVOID HITTING THE CAR IN FRONT OF ME, I SWERVED INSTEAD TO MY RIGHT INTO A SNOW BANK. IT WAS APPROXIMATELY 2:45 P.M. I WAS DRIVING A SUBARU FORESTER "ALL WHEEL DRIVE" 2003 VEHICLE. DESPITE THE ALL WHEEL DRIVE, I COULD NOT GET OUT OF THE ICY SNOW BANK AND HAD TO BE TOWED OUT BY AAA. IT WAS A FRIGHTENING EXPERIENCE. *TR
Fuel system, Gasoline, Jan 31, 2010
MY 2003 SUBARU FORESTER HAS A FUEL LEAK SMELL THAT ENTERS THE CAR INTERIOR.. IT'S NOT A RICH FUEL MIXTURE EXHAUST SMELL, IT'S THE SMELL OF RAW FUEL INSIDE THE CABIN. IT COMES AND GOES. I SEE ONLINE OTHERS ARE HAVING THIS PROBLEM. SUBARU SHOULD BE HELD ACCOUNTABLE AND FORCED TO HAVE A RECALL TO FIX THE PROBLEM ONCE AND FOR ALL. *TR
Wheels, Jan 3, 2010
I PURCHASED A SUBARU FORRESTER WITH 38 K MILES IN AUGUST. DURING THE THANKSGIVING HOLIDAY, I NOTICED A RUBBING NOISE, CONSISTENT AND LOUDER WHILE TURNING IN THE REAR PASSENGER SIDE OF THE VEHICLE. WARRANTY FROM THE DEALERSHIP ONLY LASTED ONE THOUSAND MILES AND THEY TOLD ME TOUGH LUCK. A FRIEND WHO IS A "SUBARU GUY" TOLD ME I HAD A BAD BEARING, AND TO BE CAREFUL, IT WAS A COMMON PROBLEM THAT COULD GET WORSE QUICK. IT DID, AND I HAVE HAD MY VEHICLE PARKED FOR THE PAST FEW WEEKS AS THE NOISE LOUD ONE DAY AND THE WHEEL WAS ACTUALLY LOOSE. THE VEHICLE IS CURRENTLY IN THE SHOP, HAVING THE REAR WHEEL BEARING REPLACED. THE COST OF THE REPAIR IS 390 DOLLARS, POSSIBLY 150 MORE IF THE MECHANIC FINDS OUT THAT A CAP OR SEAL FOR THE AXLE IS PITTED AND NEEDS REPLACEMENT. I HAVE NEVER DRIVEN THE CAR IN ANY EXTREME CIRCUMSTANCES, MOSTLY FOR A THIRTY MILE HIGHWAY COMMUTE TO WORK, NO STOP AND GO OR ANY SORT OF EXTRAORDINARY DRIVING. I HAD HEARD NOTHING BUT GOOD THINGS ABOUT SUBARU, BUT THIS IS NO GOOD AS THE WHEEL SEEMED TO HAVE LOOSENED TO A POINT OF DANGER AND I HAD IT TOWED IN TO THE SHOP. *TR
Air bags, Aug 28, 2009
MY CHECK ENGINE LIGHT CAME ON AND I BROUGHT MY CAR TO MY LOCAL SUBARU DEALER. THE SERVICE TECHNICIAN EXAMINED THE CAR AND DETERMINED THAT THE ENGINE LIGHT HAD COME ON BECAUSE OF A PROBLEM WITH MY AIRBAG. HOWEVER, UPON EXAMINATION, HE WAS UNABLE TO FIND ANYTHING WRONG WITH THE AIRBAG AND THE ENGINE LIGHT WENT OFF. I WAS THEN TOLD NOT TO WORRY ABOUT IT SINCE IT WAS PROBABLY NOTHING. LUCKILY, THE MANAGER OVERHEARD THE CONVERSATION AND REMEMBERED A SERVICE BULLETIN (#17-07-04) THAT HAD BEEN ISSUED BY SUBARU REGARDING THIS VERY PROBLEM FOR 2003 SUBARU FORESTERS. HE EXPLAINED TO ME THAT OXIDATION ON THE CONTACTS IN THE WIRING HARNESS FOR THE AIRBAG SENSOR WAS CAUSING THE AIRBAG LIGHT TO COME ON AND THAT I NEEDED TO HAVE THE NECESSARY WORK COMPLETED (PER THE SERVICE BULLETIN) OR ELSE THE AIRBAGS MIGHT NOT ACTIVATE IN AN EMERGENCY. SINCE THIS IS A PROTECTED PART LOCATED INSIDE THE VEHICLE I FEEL THAT IT WAS NOT DESIGNED APPROPRIATELY TO RESIST OXIDATION AND THAT SUCH A FACTORY DEFECT COULD POTENTIALLY RESULT IN A VERY SERIOUS SAFETY ISSUE TO OWNERS OF THIS MODEL SUBARU CAR. (WE HAVE A 2001 FORESTER WITH 112,000 MILES AND HAVE NEVER EXPERIENCED ANY PROBLEM OF THIS NATURE.) I LOOKED ONLINE AND FOUND NUMEROUS SIMILAR COMPLAINTS ' ALL RELATED TO THE 2003 FORESTER AND ONLY TO THE 2003 FORESTER. IN FACT, THERE IS A COMPLAINT ON THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ASSOCIATION WEBSITE HTTP://WWW-ODI.NHTSA.DOT.GOV/CARS/PROBLEMS/COMPLAIN/COMPLAINTSUMMARY.CFM?ODI_ID=10' DATING BACK TO 2005, INVOLVING A DEATH WHEN THE AIR BAGS IN A 2003 FORESTER FAILED TO ACTIVATE. BASED UPON ALL THE SIMILAR COMPLAINTS FOR THIS VERY MODEL CAR THAT I SEE ONLINE, I AM CONCERNED THAT THIS COULD POTENTIALLY BE A SERIOUS SAFETY ISSUE. WHEN I CALLED SUBARU TO EXPLAIN MY CONCERN, THEY REIMBURSED ME FOR THE COST OF THE REPAIR, WHICH WAS $186.47. HOWEVER, I FEEL THAT I NEED TO ADVISE THIS ASSOCIATION OF THE MATTER AS WELL SINCE I FEAR THIS COULD BE MORE WIDESPREAD THAN IS NOW KNOWN. *TR
Engine and engine cooling, Aug 26, 2009
MY 2003 SUBARU FORESTER - PURCHASED NEW - CURRENTLY HAS 55,000 MILES ON IT. IT WAS LAST SERVICED 3 MONTHS AGO. AT THAT TIME, NOTHING WAS MENTIONED ABOUT COOLANT PROBLEMS OR LEAKS. LAST WEEK, ON THE TURNPIKE, THE RPM NEEDLE STARTED SWINGING WILDLY AND I LOST POWER. I MANAGED TO GET TO THE SHOULDER OF THE TURNPIKE AND SHUT DOWN AND BY THAT TIME SMOKE WAS POURING OUT FROM THE ENGINE. THE PROBLEM DIAGNOSED IS THAT THE COOLANT HAD LEAKED AT THE HEAD GASKETS - A PROBLEM THAT I AM NOW LEARNING SUBARU HAS KNOWN ABOUT FOR SOME TIME. I HAVE TO REPLACE THE ENGINE AT A COST OF AT LEAST $2600. I WAS NEVER CONTACTED BY SUBARU OR THE DEALERSHIP TO INFORM ME THAT THIS MAY BE A PROBLEM ALTHOUGH I CONSISTENTLY HAVE RECEIVED NOTIFICATIONS ABOUT REPURCHASING AN EXTENDED WARRANTY. OBVIOUSLY, A 2003 VEHICLE WITH 55,000 MILES ON IT HAS NOT BEEN DRIVEN EXCESSIVELY. COMMENTS I HAVE HEARD ARE THAT "YOU'RE STILL BREAKING IN THE ENGINE". *TR
Engine and engine cooling, May 8, 2009
I PURCHASED A NEW SUBARU FORESTER XS IN JULY 2003 AND HAD IT SERVICED REGULARLY AT NOW DEFUNCT SUBARU DEALERSHIPS. WHILE I WAS DRIVING ONE DAY, THE CAR SUDDENLY OVERHEATED. THE FOREIGN AND DOMESTIC AUTO SERVICE MECHANIC I WAS ABLE TO REACH SHOWED ME THAT THE ENGINE WAS LEAKING COOLANT IN 3 PLACES, REQUIRING A COSTLY REPAIR OF THE HEAD GASKET. I LEARNED FROM HIM THAT THIS HEAD GASKET FAILURE WAS A COMMON PROBLEM WITH SUBARUS. I HAD THE CAR UNDER WARRANTY WITH SUBARU FOR 60,000 MILES. AT NO TIME WAS I NOTIFIED BY THE DEALER FROM WHOM I PURCHASED THE CAR OR BY ANY SUBARU SERVICE CENTER, THAT SPECIAL COOLANT WAS REQUIRED TO MITIGATE THIS DEFECT. I HAD THE CAR REPAIRED AT A COST OF OVER $2,000. *TR
Fuel system, Gasoline, Feb 20, 2009
CABIN HAS STRONG FUEL SMELL WHEN STARTING IN THE MORNING. THE SMELL IS LIKE SOMEONE POURED A CUP OF FUEL ON THE FRONT SEAT. THE DEALER STATED THERE WAS AN ISSUE WITH THE FUEL LINE LEAKING. MANY OTHER SUBARU OWNERS ARE COMPLAINING ABOUT THIS ISSUE ON THE SUBARU OWNER WEBSITES. *TR
Fuel system, Gasoline, Jan 16, 2009
TODAY, I STARTED MY 2003 SUBARU FORESTED, AND LET THE CAR RUN WITH THE HEAT ON FOR ABOUT 15 MINUTES WHILE I SCRAPED THE FROST OFF OF MY WINDOWS. WHEN I OPENED THE DOOR TO GET IN, THE CABIN WREAKED OF GAS FUMES. THIS IS THE THIRD TIME THIS HAS HAPPENED. ONCE EACH IN JAN 2006 AND JAN 2007 I REPORTED THIS TO THE DEALERSHIP. IN 2006 THEY ATTEMPTED TO REPLACE THE CLAMPS, IN '07 THEY REPLACED SOME HOSES. APPARENTLY THESE FIXES ARE STILL NOT SUFFICIENT TO SOLVE THE PROBLEM. THE ONLY CURRENT SOLUTION TO THE PROBLEM IS TO OPERATE THE CAR AT WARM TEMPERATURES OR LET IT WARM UP BEFORE DRIVING. THE GAS FUMES ARE STILL GETTING IN TO THE CABIN WHEN IT IDLES, THOUGH. *TR
Engine and engine cooling, Jan 9, 2009
I HAD REGULAR SERVICE DONE TO MY CAR AT CLAY SUBARU OF NORWOOD MASSACHUSETTS. THE REPRESENTATIVE STATED THAT THE MECHANIC NOTICED SOME OIL SEEPAGE FROM THE HEAD GASKET. THEY RECOMMENDED THAT I GET THE HEAD GASKETS REPLACED WITHIN A YEAR. SINCE THAT TIME I HAVE MONITORED THE OIL LEVEL AND HAVE HAD TO REPLACE ABOUT A QUART IN BETWEEN REGULAR OIL CHANGE INTERVALS. I AM CONCERNED BECAUSE I KNOW THIS REPRESENTS MAJOR ENGINE WORK. THEY QUOTED THAT IT WOULD COST ABOUT $2,000.00 TO REPLACE THE HEAD GASKETS. THE CAR ONLY HAD ABOUT 115,000 MILES ON IT. IT IS A 2003 SUBARU FORESTER THAT I PURCHASED NEW IN DEC 2002. *TR
Engine and engine cooling, Jan 4, 2009
EXHAUST/FUEL SMELL IN INTERIOR CAB DURING USE IN COLD WEATHER/ USE OF HEATER IN 2003 SUBARU FORESTER. *TR