2000 Subaru Outback
Problems, recalls and owner-reported issues
Power train is the leading concern among 207 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Outback model years with reports.
Of the 2000 reports, 17 involved a crash and 5 involved a fire. 7 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, fuel pumpNov 29, 2013
Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.
A fuel leak in the presence of an ignition source increases the risk of a fire.
Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.
Campaign 13E065000 on NHTSA.gov
Suspension, rearApr 22, 2003
THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.
IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.
Campaign 03V153000 on NHTSA.gov
Representative owner complaints
207 reports, newest first.
Child seat, Jan 9, 2002
HARNESS MATERIAL ON CAR SEAT IS TOO SOFT TO RETAIN FLAT CONFIGURATION; ROLLS UP INTO ROPE-SHAPE INSIDE SHOULDER PADS, BUNCHES AND BINDS IN HARNESS HARDWARE. SEEKING A WAY TO GET INITIATE A REPLACEMENT BY MANUFACTURER. DID CONTACT MFGR., COSCO, WHO SAID STRAPS ARE SOFT MATERIAL INTENTIONALLY FOR KIDS' COMFORT. I DON'T BUY IT; SEATBELT MATERIAL IN CARS IS SOFT, BUT DOES NOT COLLAPSE LATERALLY. IF CAR SEATBELTS FOLDED, BUNCHED AND ROLLED THIS WAY, THEY WOULD BE RECALLED IMMEDIATELY, I SUSPECT. THANKS VERY MUCH FOR YOUR ATTENTION, AND PLEASE LET ME KNOW HOW I CAN HELP.*AK
Engine and engine cooling, Jan 2, 2002
4TH TIME FOR THIS RADIATOR OVERHEATING; SUBARU IS REPLACING ENGINE. *AK
Engine and engine cooling, Dec 8, 2001
FIRST RADIATOR FAILED AT APPROX. 21,000 MILES AND OEM REPLACEMENT RADIATOR FAILED AT APPROX. 44,000 MILES. BOTH RADIATORS 10 MOS. OLD.*AK
Tires, Dec 7, 2001
PHOTOS OF THE TIRE DAMAGE ARE POSTED AT HTTP://WWW.SPEAKEASY.ORG/~DERVISH/FIRESTONE/FIRESTONE.HTML. I REPLACED ALL FOUR TIRES DESPITE THE SUBSTANTIAL TREAD LIFE REMAINING ON THE FIRESTONES. THE FIRESTONES WERE WELL-MAINTAINED: ROTATED, INFLATED, ETC.*AK (DOT NUMBER: W2X0W66070 TIRESIZE: P225/60R16)
Power train, Sep 26, 2001
THIS IS THE 2ND CLUTCH ON THE VEHICLE. CAR STILL UNDER WARRANTY, DEALER WILL NOT ADMIT PROBLEM!!*AK
Tires, Sep 15, 2001
WHEN I WENT TO CHANGE A TIRE THAT I HAVE BEEN NURSING A SLOW LEAK ON FOR A FEW WEEKS, I NOTICED THAT THERE WAS A NICE SMOOTH HALF CIRCLE IN THE COVERING ABOUT WHERE I THINK THE TIRE MEETS THE TREAD. IT APPEARED TO ME AS THE FIRST SIGN OF TREAD SEPARATION.*AK (DOT NUMBER: W2XOW66140 TIRESIZE: P22560R169)
Seat belts, Aug 31, 2001
REAR SEAT SELDOM USED .IN AUG. 2000 MY PASSENGER TRIED TO USE THE SEAT BELT BUT WAS UNABLE TO EXTEND IT AROUND HER BODY. I DISCOVERED THAT THE BELT WAS STUCK ON THE ROOF GUIDE AND WAS FRAYED FOR ABOUT ONE INCH. I REMOVED IT FROM THE GUIDE BUT IT STILL WOULD NOT EXTEND AROUND HER BODY. NO MATTER WHAT I DID THE BELT WOULD NOT EXTEND ENOUGH TO GO AROUND A WOMAN OF 125 POUNDS.TWO ISSUES 1: HOW DID THE BELT FRAY ? 2: WHY WOULDN'T IT EXTEND ?
Service brakes, Hydraulic, Air bags, Aug 30, 2001, crash
BRAKE PEDAL GOES 1/2 WAY DOWN BEFORE BRAKES ENGAGE AT ALL. PEDAL CAN BE PUSHED TO FLOOR WITHOUT MUCH EFFORT BY MY 120LB WIFE. ABS DID NOT ENGAGE. NEITHER AIRBAG DEPLOYED - IMPACT SPEED WAS 30 TO 35 MPH. DEALER INSISTS BRAKES ARE OK. 2001 MODEL HAS 13 INCH DISCS AND IT STOPS GREAT! (OUR RENTAL IS A 2001 OUTBACK WAGON). WE LOVE THE CAR, IT JUST WORRIES US THAT IT DOESN'T STOPPROPERLY AND THE AIRBAGS DON'T GO OFF - APPARENTLY THE 'COMPUTER' DEEMED IT "UNECESSARY" ALTHOUGH IT WAS A HEAD-ON, SMACK IN THE MIDDLE OF THE FRONT, COLLISION!*AK
Tires, Aug 14, 2001
TIRE COULD NOT BE BALANCED, TREAD FOUND TO BE SEPARATED. *AK (DOT NUMBER: W2X0W66070 TIRESIZE: P225/60R16)
Seat belts, Aug 6, 2001, crash
CAR HIT ON DRIVER'S SIDE (DOOR) UNABLE TO REMOVE DRIVER FROM DRIVER'S SIDE...CAR TOTALED....DRIVER DIED AS RESULT OF INJURIES SUSTAINED IN THE CRASH...DRIVER WAS WEARING SEAT BELT. *AK
Latches/locks/linkages, Apr 13, 2001
WHEN INSIDE OF THE VEHICLE AND DOORS ARE LOCKED FROM INSIDE OF VEHICLE, DOORS WILL OPEN WITHOUT PRIOR WARNING. DOORS ON DRIVER'S SIDE WILL OPEN. PASSENGER'S SIDE DOORS ARE DOING SAMETHING. DEALERSHIP FIXED DEFECT THE FIRST TIME, BUT VEHICLE IS STILL HAVING SAME PROBLEM. *AK
Structure, Mar 15, 2001
WHILE DRIVING AT 70 MPH BUG DEFLECTOR, A PIECE OF EQUIPTMENT THATIS ATTACHED TO FRONT OF HOOD WITH SOME LITTLE CLIPS, FLEW OFF CRACKING WINDSHIELD OF VEHICLE IN REAR. SUBARU HAS BEEN CONTACTED.*AK
Vehicle speed control, Mar 7, 2001, crash
WHILE AT DRIVEWAY PUT VEHICLE IN REVERSE AND JUST TAPPED ACCELERATOR PEDAL, AND ENGINE OVER ACCELERATED, CAUSING CONSUMER TO CRASH INTO DRIVEWAY.*AK *SLC
Seat belts, Mar 1, 2001
WHEN DISENGAGING THE SEAT BELT, OR WHEN MOVING FORWARD THEN BACK, THE SEAT BELT RETRACTOR IS SUPPOSED TO TAKE UP THE SLACK. AS THE BELT RETRACTS IT HAS A TENDENCY TO CURL UP AND GET JAMMED IN THE GUIDE LOOP ABOVE MY SHOULDER. SO MY DRIVING IS DISTRACTED BECAUSE I AM TRYING TO UNJAM THE BELT. I HAVE REPORTED THIS PROBLEM TO SUBARU AND THE DEALER AND THEIR RESPONSE IS THAT THERE IS NO FIX FOR THE PROBLEM. SEVERAL OF THEM SAY THEY HAVE THE SAME PROBLEM. THIS PROBLEM OCCURS 80% OF THE TIME. I HAVE ALSO SEEN BELTS JAMMED IN OTHER SUBARUS. *AK
Vehicle speed control, Feb 26, 2001
ON THREE OCCASSIONS, WHILE VEHICLE WAS IN DRIVE WITH FOOT APPLIED TO BRAKES, VEHICLE ACCELERATED 5- 10 FEET, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
Tires, Feb 22, 2001
AFTER PUTTING 1000 MILES ON THE TIRES THE CONSUMER NOTICED A DARK BROWN RING ABOUT 1 INCH FROM THE TOP OF THE OUTSIDE TREAD WALL, FIRESTONE COULD NOT IDENTIFY THE PROBLEM AND OFFERED TO REPLACED THAT TIRE, THE CONSUMER DECIDED TO REPLACE ALL TIRES WITH A DIFFERENT BRAND(FIRESTONE WILDERNESS TIRES P225/60R16 97H M+S). NLM
Visibility, Feb 15, 2001
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Service brakes, Hydraulic, Jan 26, 2001
THE CONSUMER BELIEVES THE DESIGN OF THE BRAKING SYSTEM ALLOWS FOR EXCESSIVE AMOUNT OF BRAKE PEDAL TRAVEL AND FORCE TO ACTIVATE THE BRAKES IN NORMAL USE COMPARED TO OTHER VEHICLES, THE DEALERSHIP STATED THAT THIS WAS NORMAL OPERATIONAL AND WITHIN THE MANUFACTURERS SPECIFICATION. *MJS
Exterior lighting, Jan 25, 2001
TAIL LIGHTS LEAKS LARGE AMOUNT OF WATER. IN COLD WEATHER TAIL LIGHTS BULBS WOULD BLOW. PLEASE PROVIDE FURTHER INFORMATION. *AK
Structure, Jan 10, 2001
VEHICLE SHIMMIED WHEN ICE DEVELOPED UNDER CARRIAGE.*AK
Service brakes, Air, Dec 23, 2000, crash
BRAKES ARE VERY SOFT OR MUSHY AND ARE SLOW TO RESPOND. THEY DO NOT EFFECTIVELY ENGAGE UNTIL THE PEDAL IS DEPRESSED VERY CLOSE TO THE FLOOR, THUS REQUIRING AN INORDINATE AMOUNT OF TIME AND DISTANCE TO STOP. THE INADEQUACY OF PERFORMACE CONTRIBUTED SUBSTANTIALLY, IN MY JUDGMENT, TO THE ACCIDENT IN WHICH I WAS INVOLVED BECAUSE THE BRAKES SIMPLY FAILED TO START SLOWING THE CAR DOWN UNTIL THE PEDAL WAS ALMOST COMPLETELY DEPRESSED TO THE FLOOR. I HAVE JUST REPORTED IT IN WRITING TO THE DEALERSHIP FROM WHICH I PURCHASED THE VEHICLE. I ADVISED MY INSURANCE AGENT AND THE CARRIER OF MY CONCERNS REGARDING THE BRAKES' PERFORMANCE IMMEDIATELY UPON MY REPORT OF THE ACCIDENT ON THE DAY IN WHICH IT OCCURRED.*AK
Visibility, Dec 11, 2000
WINDOW HAS CRACKED TWO TIMES FROM THE LOCATION OF THE WINDSHIELD WIPER HEATING ELEMENT WITH NO EVIDENCE OF IMPACT
Power train, Nov 29, 2000
TRANSMISSION COMPUTER FAILED, CAUSING VEHICLE TO LOSE CONTROL AND JOLT ONTO THE ONCOMING LANE, LUCKILY THERE WAS NO ONCOMING TRAFFIC AND NO ACCIDENT. *SLC
Tires, Oct 14, 2000, fire
TIRE SEAM BLEW OUT IN PERFECT CIRCUMFERENCE ACCOMPANIED BY PROFUSE SMOKE. EXTREMELY DANGEROUS SITUATION SINCE I COULD NOT SEE WHAT WAS HAPPENING TO MY CAR DUE TO THE SMOKE. I THOUGHT I BLEW A GASKET. BROUGHT TIRE TO FIRESTONE DEALER WHERE THEY DID A SOAP TEST. NO PUNCTURES WERE THERE EXCEPT THE COMPLETE BREAKDOWN OF THE SEAM ON THE OUTSIDE OF THE TIRE. THEY REPLACED IT, HOWEVER THEY REPLACED IT WITH ANOTHER WILDERNESS TIRE. IN THE 28 YEARS OF DRIVING I HAVE HAD, I HAVE NEVER EXPERIENCED A BLOW OUT LIKE THIS OR EVEN SEEN ONE. THE DEGREE OF SMOKE AND PERFECT FAILURE OF THE SEAM POINT TO A PROBLEM WORTHY OF YOUR INVESTIGATION. PLEASE NOTIFY ME, IN KIND, OF THE PROCEDURE YOU WILL UNDER TAKE TO INSURE THAT THE THOUSANDS OF PEOPLE DRIVING THE NEW 2000 OUTBACK EQUIPPED WITH THE WILDERNESS TIRES WILL BE SAFE FROM HARM. I BELIEVE WITH ALL MY HEART THAT THERE IS A SERIOUS PROBLEM HERE. THANK YOU FOR YOUR ASSISTANCE AND SUPPORT IN THIS MATTER. *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*734292
Tires, Oct 14, 2000, fire
TIRE SEAM BLEW OUT, IN A PERFECT CIRCUMFERENCE, ACCOMPANIED BY PROFUSE SMOKE. EXTREMELY DANGEROUS SITUATION SINCE I COULD NOT SEE WHAT WAS HAPPENING TO MY CAR DUE TO THE SMOKE. I THOUGHT I BLEW A GASKET. BROUGHT TIRE TO FIRESTONE DEALER, WHERE THEY DID A SOAP TEST. NO PUNCTURES WERE THERE EXCEPT THE COMPLETE BREAKDOWN OF THE SEAM ON THE OUTSIDE OF TIRE. THEY REPLACED IT, HOWEVER, THEY REPLACED IT WITH ANOTHERK WILDERNESS TIRE. IN THYE 28 YEARS OF DRIVING I HAVE HAD, I HAVE NEVER EXPERIENCED A BLOW OUT LIKE THIS, OR EVEN SEEN ONE. THE DEGREE OF SMOKE, AND PERFECT FAILURE OF THE SEAM POINT TO A PROBLEM WORTHY OF YOUR INVESTIGATION., PLEASE NOTIFY ME, IN KIND, OF THE PROCEDURE YOU WILL UNDER TAKE TO INSURE THAT THE THOUSANDS OF PEOPLE DRIVING THE NEW 2000 OUTBACK EQUIPED WITH THE WILDERNESS TIRES WILL BE SAFE FROM HARM. I BELIEVE WITH ALL MY HEART THAT THERE IS A SERIOUS PROBLEM HERE. THANK YOU FOR YOUR ASSISTANCE AND SUPPORT IN THIS MATTER. (DOT NUMBER: W 2XOW66 TIRESIZE: P225/60R16)