2016 Subaru Outback
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 642 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Outback model years with reports.
Of the 2016 reports, 22 involved a crash and 3 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Air bags, air bag/restraint control moduleDec 19, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.
In the event of a crash necessitating passenger frontal air bag deployment, the air bag may not deploy properly, increasing the risk of injury.
Subaru will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began February 3, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUX-09.
Campaign 19V910000 on NHTSA.gov
Steering, columnDo not drive until repairedMay 11, 2016
Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.
The loss of steering ability would increase the risk of a crash.
Subaru will notify owners, and dealers will inspect the lot number on the steering column, replacing the steering column, as necessary, free of charge. The recall began May 13, 2016. Owners may contact Subaru customer service at 1-800-782-2783 or by visiting http://www.wtd65.service-campaign.com. Subaru's number for this recall is WTD-65. Note: Until the vehicles have been inspected, owners are advised not to drive their vehicles.
Campaign 16V292000 on NHTSA.gov
Power train, driveline, driveshaftNov 24, 2015
Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.
If the drive shaft detaches from the rear differential, it may strike the fuel tank and result in a fuel leak, increasing the risk of a fire.
Subaru has notified owners, and dealers will inspect the fastening nuts, and tighten or replace them, as necessary, free of charge. The recall began on December 10, 2015. Owners may contact Subaru customer service at 1-856-488-8500. Subaru's number for this recall is WQV-57.
Campaign 15V794000 on NHTSA.gov
Power train, driveline, driveshaftAug 10, 2015
Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Subaru Legacy 4-Door and Outback vehicles manufactured July 3, 2015, to July 27, 2015. Transmission oil may leak from a deformed seal cap on the propeller shaft yoke.
If the transmission oil leaks onto the exhaust pipe, there is a possible risk of fire.
Subaru will notify owners, and dealers will replace the propeller shaft, free of charge. The recall began on August 28, 2015. Owners may contact 1-800-782-2783. Subaru's number for this recall is WQU-56.
Campaign 15V502000 on NHTSA.gov
Representative owner complaints
642 reports, newest first.
Other or unspecified, Forward collision avoidance, Jan 23, 2022
I OWN A 2016 SUBARU OUTBACK. WHILE DRIVING APPROXIMATELY 40:MPH ON A LOCAL MAIN ROAD (CT RTE 10) THE EYESIGHT PRE-COLLISION BRAKE ASSIST SUDDENLY ACTIVATED AND CAUSED THE VEHICLE TO COMPLETELY STOP. THE BRAKES THEN RELEASED AND I WAS ABLE TO CONTINUE DRIVING. THIS IS THE SECOND INCIDENT WITH IN A MONTH THAT THIS HAS HAPPENED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000 THERE WERE NO PRIOR WARNING LIGHTS OR ENGINE LIGHTS ON. THE VEHICLE HAS NOT BEEN INSPECTED BY THE DEALER. THIS SUDDEN STOPPING CAN CAUSE AN ACCIDENT.
Electrical system, Jan 20, 2022
I Had to jump start battery on several occasions, leaving myself and my family stranded. I took the car to my dealer on 12/3/2018. Dealer (Glanzmann Subaru) could not identify problem, performed two software updates. I received no information or explanation of the nature of the problem. A month later the problem repeated. I took the car to dealer on 1/16/2019 (mileage 25,941).They tried to tell me that the battery was leaking, but it was not. They replaced the battery and I had to pay the cost for a new battery, $123.97. On 1/27/2021 (mileage 39,172) the new battery failed in a similar manner. The dealership insisted that there were no problems with the charging system. They replaced the battery ( no cost) and performed an ECM update. They were insistent that there were no systemic issues with the electrical system. After the fact, I discovered that this is a universal problem with a number of Subaru vehicles. During a recent visit to my Subaru dealership I inquired as to whether a solution has been determined and will my car be fixed before the new battery also fails. They were very vague and non-informing. I am hesitant to venture far from home with this vehicle since I cannot trust the car or Subaru's support. I can provide dealer service records in support of this issue.
Electrical system, Jan 19, 2022
In January 2020 my Outback failed to start. Battery was totally discharged and had to be jumpstarted. Took the car to dealer where technician tested battery and said it was good.I had him recharge the battery and test it again. It failed and they installed a new exact same battery under warranty. I was very pleased. However, the battery failed several more times over the year and had to be jumpstarted every time.I am returning to the service dept on 01/18/22, when I am demanding a new stronger battery or fix the parasitic draw which I discovered is causing the problem. I will return here later to inform you of outcome. Thank you for providing a place to report this.
Other or unspecified, Jan 19, 2022
Multiple instances of the battery dying after being parked for a few days. New battery did not resolve the problem and diagnostics indicate that the battery is not the problem. Unable to use vehicle when it cannot be started. Most recent incident was 1/18/2022. First occurred shortly after I purchased the vehicle.
Electrical system, Jan 14, 2022
The contact owns a 2016 Subaru Outback. The contact stated that on multiple occasions, her vehicle would fail to start up without warning. The contact had taken her vehicle to the dealer numerous times and had several battery replacements performed; despite each replacement, the failure persisted. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 12,000.
Electrical system, Jan 10, 2022
I'm having continuing issues with premature discharging of the battery even though I now have a heavy duty battery and also carry an emergency jump start battery in case. My Outback is equipped with Onstar so it does draw power at all times, my relatively new Optima battery has shown being drawn down to 25% charge on the Optima battery charger after only 24 hours. Of non use.
Visibility, Jan 10, 2022
The contact owns a 2016 Subaru Outback. The contact stated while approaching the vehicle in the morning, she noticed a L-shaped crack in the windshield which originated on the passenger’s side of the windshield. The contact took the vehicle to the dealer and was informed that an issue with the windshield wiper had caused the fracture. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 46,000.
Power train, Jan 1, 2022
oil leak from power train
Electrical system, Dec 29, 2021
Replacement battery in under 35,000 mile Subaru discharged while sitting in garage for several weeks. There have been zero earlier problems with electrical system other than the original battery dying after about three years. When jump started the charging system seemed to work and the car started after sitting overnight. We are in a very cold northern environment and if the vehicle will not start it could strand us in an unsafe setting. Coming back to a parked car that may have been left at an airport parking lot to find it would not start would be very inconvenient and expensive to remedy.
Visibility/wiper, Dec 29, 2021
On November 15, 2021 my car was in the garage as normal. I started my car and I heard a "pop" I was headed out my driveway is when I notice a crack at the bottom of the windshield that is about 3" high and then curves for about 4".
Electrical system, Dec 27, 2021
Battery dies when parked for a few days or not driven enough. Needs to be jumped several times per week.
Electrical system, Dec 13, 2021
In my 2016 Outback, the OEM battery died after 3 years. AAA put in a replacement and gave me a 3 year full replacement warranty. That battery died after 2 years while in a gas station – had to get pushed away from the pump and luckily the guy behind me had jumper cables. That go me home and I got a brand spanking new AAA battery free of charge. One incident – stuff happens. Two? No way. I was at Subaru this morning for an unrelated item and the service guy said that everything electrically was okay. The problem is that if the car sits idle for more than 3 days the computer starts draining the battery and that can cause irreparable harm which can eventually lead to premature failure. SOLUTION: Make sure to run the car at least every three days. REALLY????
Latches/locks/linkages, Dec 13, 2021
The contact owns a 2016 Subaru Outback. The contact stated that while stationary or while in motion, the tailgate would independently open without warning. The contact stated that due to the failure, the battery was drained. The vehicle was towed to a dealer. The dealer was unable to duplicate or diagnose the cause of the failure. The manufacturer was notified of the failure and a case was filed; the contact was referred to NHTSA for further assistance. The vehicle was not repaired. The failure mileage was unknown.
Other or unspecified, Dec 13, 2021
Battery rapidly drains leaving me stranded. 4th battery that has been replaced by dealer and the same thing happens. No warning lights or low battery lights. Dies from 1 week to over nite. Remote won't even open the car. Dealer refuses to fix the battery drain and keeps saying it isthe battery that is bad but replaces with the same battery which fails ! I see where there are lawsuits against Subaru but I am not getting any help at all from corporate or dealer. Personal safety and being stranded and unreliable are my main concerns.
Electrical system, Dec 12, 2021
This is the 6th time this week the car starts fine in the morning, I stop at a gas station or store come out and its dead! Concerning safety this is a major deal for me as I take care of my mother whom is on oxygen at 2L if this happens with her in the car or by herself,, it could very easily turn into a life or death situation! This issue seems to be a recurring issue as I have replaced the battery already and used AAA more than a few times in the past year. Car was purchased new off the lot in 2016. There is currently less than 35000 miles on the odometer. This is beyond upsetting and a very dangerous situation living in Colorado. Hypothetically if it was below zero peoples lives are 100% at risk due to a issue that I feel is being covered up by subaru. What options do I have? Is this a potentially very serious issue that I should start thinking about getting lawyers involved?
Other or unspecified, Dec 1, 2021
Windshield got a very large crack from me trying to kill a bug inside the car. Windshield is thin. I didn’t hit it that hard with my hand. Had to be replaced. The repair service tech explained that the only replacements for my model are of the same thinness as the original, and to seek the recall glass replacement should it be thicker and safer.
Other or unspecified, Nov 30, 2021
Key sticks in ignition and won’t release. Takes from a few attempts to several minutes of restarting the car, putting car in drive and then park, turning the wheel etc.
Electrical system, Nov 23, 2021
Battery is dead every morning
Electrical system, Nov 20, 2021
New battery, less than 10K miles completely drained when vehicle was not used for 3 days. Similar problem with previous battery, died with 10minutes or radio use.
Power train, Electrical system, Nov 15, 2021
Battery corrosion on terminal post and drained for no reason, failed battery test and had to be replaced. Windshield has imperfections throughout and cracks easily. Shift mechanism will not release the vehicle key while in park. Squeaking sound emanating from passenger seat belt buckle. Excessive exhaust noise and odor from exhaust pipe. Rear hatch will not close completely unless slammed very forcefully. Belts under the hood squeak very loudly when started and subside when warmed up.
Structure, Nov 3, 2021
Our vehicle has factory-installed child safety locks incorporated into the rear passenger doors. The safety lock on the rear passenger-side has failed in the "engaged" position, and cannot be disengaged using the small black switch in the door. Consequently, the only way the door can be opened is by using the outside handle. We see this as a serious safety issue, since in an emergency egress situation, the only way a passenger in the right rear seat can exit the vehicle is if someone opens the door from the outside. Looking on online forums, there are many incidents of this same problem. However, Subaru has not chosen to correct this problem for cars that are outside of vehicle warranty.
Electrical system, Oct 29, 2021
The battery in my car has been replaced 3 times (twice by the dealer and once by me) and the alternator once due to deep discharge, in addition I have had to "jump" the car one or more times. Subaru has paid the cost of all repairs for this issue despite the fact they don't admit there is an issue. In addition to the battery replacement there was an ECM update done this last time to reduce battery drain. There is no warning or indication that a failure is about to occur. This last time I moved the car from my garage to my driveway and 4 hours later, the car would not start and the battery measured 4.25 volts--no lights were left on, doors open, seat heaters on etc. The concern is that it is impossible to tell if the car has drained the battery and it can leave us stranded anywhere we have turned it off. I contacted Subaru of America this last time and they said not even to "jump" it as it would possible loose valuable error codes. I have their roadside assistance and even though I received a call confirming that a flatbed would arrive within 60 mins. it never showed. This car has the potential to leave us stranded anywhere at any time and if locked the key fob does not work and even if I can get in, the car can't be moved due to no power to release the parking break.
Electrical system, Oct 26, 2021
Battery dies after car is parked for more than 3 days. Car is available for inspection. I have been stranded/inconvenienced at least 5 times. Problem was solved through AAA, family jumpstart help, etc. Verbally reported to dealer, service writer comment made it sound like it must have been my fault or just the needs of the computer components. No warnings or symptoms.
Visibility/wiper, Oct 20, 2021
Windshield cracks easily. On my 5th windshield, just replaced 2 weeks ago and it’s cracked again. The windshield cracks easily even with minor rock chips. This is the 5th windshield on this car.
Electrical system, Oct 19, 2021
I have just had to put my fifth battery in my 2016 Subaru outback. I have experienced a dead battery twice. The first time this happened I was at a remote campsite and had the stock battery in the car. That battery lasted 25k miles. I brought my car to the dealer and they did a software update. Since then I have had two new batteries.