2020 Subaru Outback
Problems, recalls and owner-reported issues
Visibility/wiper is the leading concern among 899 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Outback model years with reports.
Of the 2020 reports, 19 involved a crash and 7 involved a fire. 4 people were injured.
What owners report most often
Recalls and investigations
Air bags, sensor, occupant classification, front passengerMar 22, 2024
Subaru of America, Inc. (Subaru) is recalling certain 2020-2022 Outback and Legacy vehicles. A capacitor in the sensors for the Occupant Detection System (ODS) may crack and short circuit, which can prevent the front passenger air bag from deploying in a crash.
An air bag that does not deploy during a crash can increase the risk of injury.
Dealers will replace the ODS sensors on the front passenger seat, free of charge. Owner notifications were mailed February 3, 2025. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRA-24.
Campaign 24V227000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Jul 8, 2022
Subaru of America, Inc. (Subaru) is recalling certain 2020-2021 Outback and Legacy vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.
An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.
Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs will be performed free of charge. Owner notification letters are expected to be mailed August 24, 2022. Owners may contact Subaru's customer service at 1-844-373-6614. Subaru's number for this recall is WRK-22. This recall is an expansion of previous recall number 21V-955.
Campaign 22V485000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Dec 9, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2020 Legacy and Outback vehicles. A programming error in the Transmission Control Unit (TCU) may allow the clutch to engage before the drive chain is completely clamped.
An improperly secured drive chain may slip and break, causing a loss of drive power and increasing the risk of a crash.
Dealers will reprogram the TCU, inspect TCU data for chain slip, and visually inspect the chain guide. If evidence of chain slippage or damage is found, the transmission will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 19, 2022. This recall includes all vehicles previously recalled under 19V-855. Vehicles previously recalled under 19V-855 will need to have the new remedy performed for this recall once available. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRK-21.
Campaign 21V955000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpJul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
Campaign 21V587000 on NHTSA.gov
Back over prevention, display functionDec 10, 2020
Subaru of America, Inc. (Subaru) is recalling certain 2020 Legacy and Outback vehicles equipped with "high" grade and "mid" grade multimedia navigation. The August 2020 over-the-air software update may have timed out without completing the installation, corrupting the data, and causing the rearview display to shutoff intermittently. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
The intermittent loss of the rearview image reduces the driver's visibility and increases the risk of crash.
Subaru will notify owners, and dealers will reprogram the software and, if necessary, replace the Cockpit Control Module, free of charge. The recall began January 22, 2021. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WRH-20.
Campaign 20V766000 on NHTSA.gov
Service brakes, hydraulic, pedals and linkagesSep 18, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2020 Outback and Legacy vehicles. The brake pedal mounting bracket may have a missing or insufficiently tightened bolt.
A missing or loose bolt may cause the brake pedal mounting area to deform over time, which can reduce braking performance and increase the risk of a crash.
Subaru will notify owners, and dealers will inspect the brake pedal mounting bracket hardware and replace the hardware or brake pedal assembly, as necessary, free of charge. The recall began October 1, 2019. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUL-97.
Campaign 19V664000 on NHTSA.gov
Representative owner complaints
899 reports, newest first.
Visibility/wiper, Aug 11, 2023
When in reverse, the view behind the vehicle when using the rear camera display is poor when there is a shadow behind the vehicle making it difficult to see a person, especially a child. The rear view camera in my 2016 subaru Outback did not have this problem with shadows.
Other or unspecified, Visibility/wiper, Aug 9, 2023
Windshield developed a crack for no apparent reason on the lower passenger side. Car was parked. Only unusual circumstance is that was a hot day.
Visibility, Aug 7, 2023
The contact owns a 2020 Subaru Outback. The contact stated that while in the driveway, the vehicle was started and while driving out of the driveway, the windshield cracked without impact. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 38,000.
Electrical system, Lane departure, Forward collision avoidance, Aug 5, 2023
I purchased the lease for the vehicle in January 2020. I first notified Subaru in Austin of an obvious "glitch" with the computer operating system in April 2020. The "glitchy" OS challenges came and went, I would notify Subaru and they would remedy the issue with a "patch" update at the service center. On April 29 2022 a clear night and a suitably clean vehicle, the RAB system completely failed to recognize/notify/respond to a mailbox behind me, upon impact the mailbox broke the rear windshield. on June 28 2022 the vehicle fails to start, and is "surging" completely draining a new jumper box, and then promptly burning it out, the box will no longer operate. Put in a new battery(#1), make an appointment for service on the vehicle. The dealership replaces the battery(#2), computer updates are completed. Vehicle goes to the body shop for the rest of the work to be completed. 28 days later, I arrive to pick up my vehicle, all work is complete. However the vehicle will not start (again) Auto body shop replaces the battery(#3).on 9/23/2022 after dark, my Subaru Outback 2020 Limited, stops and puts its Parking break on., all dials spike, then dies, rear hatch signal goes off continuously, regardless of its actual state of open/close. The vehicle refuses to jump with a new jumper box. Outback 2020 is successfully jumped by a newer vehic. New battery installed(#4). 9/29/2022 another appointment at Subaru service center to look at my vehicle, they swap out the battery(#5) and update computer. Upon pickup vehicle is without trailer lights, 3 airbag lights on, ABS light on/off. 10/17/2022 appointment at a different service center for an Oil change service, 10/18/2022 diagnostic check appt, 3 blown fuses found. 11/16/2022 Austin service, found many lost comm. codes.- reprograms , engine control module. Outback 2020 intermittently has problems opening and closing hatch/windows, display loading issues, many warning/hazzard lights & signals on/off (from April 2022- present day.)
Engine, Jul 26, 2023
At one year and 7,358 an engine oil leak had to be repaired, and still seepage and monitor is recommended. Then at three years and 28,175 the coolant bypass valve failed and was repaired. Both problems were covered by warrently, but as I live 60 miles from the dealer it was a hassle. I bought the car new in March 2020. I can not recommend Sabaru to people who ask about it and it is highly unlikely I would purchase another Subaru. However it is comfortable and practical and do not plan to sell or trade it for another car at this time. Now at four months after the latest repair it appears to be doing well, and I monitor the oil level.
Other or unspecified, Visibility/wiper, Jul 24, 2023
The windshield in my 2020 Subaru Outback has cracked spontaneously twice. I had 75K Bumper to Bumper Warranty, which the dealer would not honor the first time the window broke. He said that it was warranted for repair, not replacement. I argued until he gave me a 50% discount. My windshield broke again today. I had just pulled out onto the street and was traveling about 10MPH. No rocks or stone touched the windshield. The sound of the crack startled me. I thought that there had to be an issue. Consequently as I looked online, I have discovered this is a design flaw or something as the problem is widespread. Two cracks in year is not right and it is expensive.
Power train, Electrical system, Jul 24, 2023
Car lurches when put into gear, Transmission make loud chirping noise when place into gear from park, transmission shudders when turning. Car has had all recalls updated. Symptoms have been reported to dealer numerous times. Currently vehicle is at Subaru Dealer in Temecula Calif. Dealer states a know transmission problem is being addressed thru a Subaru Engineer. Have been without the vehicle for approx 3 weeks.
Visibility, Jul 17, 2023
The contact owns a 2020 Subaru Outback. The contact stated that while seated in the parked vehicle in the garage with the vehicle turned off, the contact watched as the passenger’s side windshield cracked without impact. The contact stated that the crack extended approximately two feet. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The contact stated that the front windshield had previously been replaced due to the same failure. The failure mileage was 42,000.
Electrical system, Jul 16, 2023
My vehicle stalled abruptly as I came to a stop while driving on a slope. Shortly afterward I determined that this was caused by a loose battery terminal; the battery had been replaced a day earlier. This much was the fault of the mechanic, not the manufacturer. My complaint is with respect to the state which the vehicle failed into: 1. The gear shift was stuck in drive and could not be moved into park. 2. It was not possible to engage the parking break, as it can only be controlled by an electronic switch. 3. The steering wheel column was locked. As a result of this, the only way to prevent the vehicle from rolling backward down the hill was to continuously keep my foot on the brake. It also was not possible, as a result of the locked steering wheel column, to guide the vehicle downhill safely. I was stuck holding the brake and unable to get out of my vehicle until another motorist stopped to give me a jump and enable me to engage the parking brake.
Firerelated, Jul 13, 2023, fire
The contact owned a 2020 Subaru Outback. The contact stated that while coming to a complete stop at a red light, an abnormally loud noise was heard coming from the vehicle, and then black smoke came from underneath the driver's side hood. Additionally, a fuel odor was detected while driving. No warning light was illuminated. The contact parked and exited the vehicle with two minor passengers while flames erupted from the engine compartment. No injuries were sustained, and no medical attention was received. The fire department arrived on the scene and extinguished the fire. A fire department report was filed. The vehicle was towed to a tow yard, where it was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was 44,882.
Visibility, Jul 6, 2023
The contact owns a 2020 Subaru Outback. The contact stated that two months after purchasing the vehicle new, the windshield cracked upon sustaining a light impact. Additionally, the contact stated that the windshield had also cracked from cold air inside the vehicle and the hot air outside the vehicle. The contact also stated that a tiny crack on the windshield would significantly expand within hours. The contact stated that the windshield had been replaced three times by the dealer, and the repair was covered by the insurance; however, the failure kept recurring. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 35,500.
Visibility, Jul 5, 2023
The contact owns a 2020 Subaru Outback. The contact became aware of a crack on the center of the front windshield. The contact stated that there was no impact to the windshield to cause the crack. The vehicle was not inspected, and the windshield was not replaced. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was 47,900.
Service brakes, Jul 5, 2023, fire
I had a fault/issue with the Electronic Parking Brake on my 2020 Subaru Outback that resulted in a vehicle fire. I had set the electronic parking brake, and received a warning light. I retracted the electronic parking brake and the warning light disappeared. I did this twice. The warning light stayed off. I drove the car and the passenger rear brakes caught on fire, damaging the brakes, the electronic parking brake motor, the brake caliper, the wheel bearing, the ABS sensor and all wiring to that wheel. I had the vehicle towed to the dealer. The dealer had the vehicle for over 2 months. In that time, my insurance inspected the vehicle. The dealer inspected the vehicle. The dealer had a Subaru (Subaru of America) factory tech visit and inspect. Subaru factory sent out a second tech (from quality control) to inspect the vehicle. The dealer tech and both Subaru factory techs could not determine the root cause of the failure. Subaru replaced all components damaged in the fire (at my cost) and sent me on my way without a determination of what caused the issue. Issue was well documented here... https://www.subaruoutback.org/threads/parking-brake-fault-caught-on-fire.551030/ I have attached a scan of the Subaru Dealer repair order.
Visibility/wiper, Jun 12, 2023
I am replacing 3rd windshield since September 2022. This was definitely caused by a rock chip but had been resin repaired. With defroster blowing on a cool morning the windshield cracked across the lower portion. The replacement windshield cracked for no reason other than it was cold during a December night and was replaced in April. That windshield cracked spontaneously while driving in the rain one month after install. A Subaru dealer took photos or I have sent photos to them of all incidents for submission to my Subaru insurance. I have now met the maximum allowed for windshield replacement. All windshields were replaced at an authorized Subaru dealer.
Electrical system, Vehicle speed control, Forward collision avoidance, Jun 7, 2023
While driving my Subaru Outback, I encounter a problem where the Starlink Multimedia system abruptly goes black. Shortly after, the driver information center also goes black. Although the car continues to run, the cruise control, if engaged, and the EyeSight safety system shuts off as well. Both systems then undergo a reboot.
Power train, Vehicle speed control, Engine, Jun 4, 2023
While driving on the NYS Thruway (I90), I started to pass a Tractor Trailer, I put my blinker on and began moving to the right to pass. There were 2/3 cars in back of me also passing. I was using cruise control and I began to put my foot on the accelerator to finish my passing and move over to the right hand lane to let the other vehicles pass me. However, upon accelerating, my car started to drop power, multiple lights displaying simultaneously indicating a potential problem. (Eyesight Assist, Vehicle Dynamic Control, Brake & Engine Lights), the vehicle started jerking back and forth and I lost all but maybe 5 miles of power. My choice at that time was put my blinker on and try and move to the right - letting the Tractor Trailer pass me on the right and HOPE there was not another vehicle behind so I could move over safely at that crawling speed or go to the left into the gully. This could have been a multiple car collision and maybe fatalities due to the speed and loss of control of my vehicle. After towing to the nearest dealer, they determined it was the Thermo Control Valve. I see now that there is a "service bulletin" and design change of this component and that other Subaru drivers have been affected the same way. This is a very serious situation. I ask, why no recall from Subaru. I have been without my vehicle now for 4 days and may not have it back until next week. I am very fearful of driving that vehicle again.
Other or unspecified, Visibility/wiper, May 24, 2023
Over the course of the nearly three years I have owned my vehicle, the windshield has either spontaneously cracked or cracked from a very very small chip three times. Two of these occurred while I was driving, with no debris impact with the vehicle windshield. There have been several suits filed against Subaru for similar cases, including for the 2020 Outback model. This has been three times in about two and a half years, quadruple the amount for my previous vehicle. Not only is this a vision impairment while driving and a financial burden to fix, I also worry about more catastrophic failure should anything significant impact the windshield while driving. I have had the glass repaired twice, and both times the repair technicians could not understand how such a significant crack had occurred.
Electrical system, May 24, 2023
The contact owns a 2020 Subaru Outback. The contact stated that while attempting to start the vehicle, the battery was completely drained. The contact stated that he was able to jumpstart the vehicle and continued to operate the vehicle. The contact stated no warning light was illuminated. The contact stated that the failure was intermittent but had become more frequent. The contact stated that he had not replaced the battery which was the original OEM battery. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that he needed to drive the vehicle more frequently. The vehicle had not been repaired. The failure reoccurred and the contact took the vehicle back to the same dealer who advised that there were no electrical failures and that he should return after one month to reprogram the computer. The manufacturer had not been informed of the failure. The failure mileage was approximately 8,000.
Other or unspecified, Visibility/wiper, May 23, 2023
While driving on I-26, a small rock made an initially small crack in the windshield. Over time, while still driving, we watched the crack expand larger and larger, spreading with multiple new arms across the entire passenger side of the windshield. After parking at home in the garage and scheduling windshield replacement for the next day, we continued to notice the crack continuing to propagate further into the driver side. The incident happened on 5/21/23 and the windshield was replaced on 5/23/23.
Visibility/wiper, Forward collision avoidance, May 22, 2023
-The windshield has cracked in the same place for no apparent reason. -The cracked windshield can affect the use of the safety systems built into the windshield. -I'm not sure how this can be "reproduced" as we are talking about a broken windshield although the windshield has been fixed already once and now, the second break has occurred. -Not inspected but replaced once. It is currently broken and can be inspected again if need be. -The first one appeared in August 2022, the second in May 2023
Visibility/wiper, May 7, 2023
On May 3, 2023 (~12:30pm local time) I was driving on the highway at approximately 60mph and there was a 'pop' sound. I looked at my windshield and an L-shaped crack appeared from the base of the windshield near the wipers up to half-way on the windshield. There was no damage to the windshield to indicate a rock had hit it or the car in any way. Given the poor quality OEM windshields that Subaru has installed in past models (2015-2016) that also have had this problem, I would like to notify the NHTSA so that Subaru can be notified. When I called my dealer directly, there was not much help on the cause.
Visibility/wiper, Forward collision avoidance, Apr 25, 2023
A crack has spontaneously appeared at the base of my windshield after no apparent damage. The crack is spreading across my windshield and will affect my adaptive cruse control and automatic emergency breaking if it interferes with the Subaru eye-sight system at the top of my windshield. I have not taken the vehicle in for service but I did see this was an issue that lead to recalls on previous outback models but not currently a recall for the 2020 Subaru Outback. I do not have any current warning lamps or messages.
Visibility/wiper, Apr 24, 2023
I'm currently on my third windshield for this vehicle. The first windshield was replaced by Subaru due to a random crack that developed on the passenger side and traveled to the driver side. No visible damage caused this to occur. The second windshield was hit by a tiny stone driving down city streets. 3 days later the same type of crack, like the first windshield, developed and moved from from passenger to driver side. We'll see how long this third windshield lasts. I've had numerous cars without this problem. Stone chips were easily repaired without major cracking occurring. There is something very odd about how fragile the windshields on Subaru vehicles are. This is not a cheap replacement due to their driver assist technology. Subaru will not replace this once they see and sign of a stone impact.
Visibility/wiper, Apr 18, 2023
Purchased my 2020 Outback only about two months ago. Just this last week two separate cracks started from the edge of the window on the left and lower sides. Cracks appeared out of nowhere while parked with no contact from rocks or other debris. Over the course of the last few days has spread so much that it obstructs my vision while driving. This is a common problem with this model and is a safety hazard that needs to be recalled/fixed. Have an appointment with my dealer to see if this qualifies as a manufacturer defect. However the fact is this will most likely happen again if it’s the same glass being used.
Visibility/wiper, Apr 16, 2023
While driving in light rain, with no visible strike, a crack appeared on the passenger side windshield; starting below the wiper and extending upwards in an arc towards the center. This is the 3rd time a crack of significance has appeared. Coincidentally, this crack appeared less than 2 weeks after having the windshield replaced by a Subaru dealership.