2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints: air bags
142 reports, newest first. Show all
Air bags, Seat belts, Sep 23, 2023
Front passenger safety restraint alert continuously stayed on with and without passenger seated. Took vehicle to solve problem immediately on 9/4/2023. After it was diagnosed, the occupancy sensor was faulting and the concerned technician had to retrofit the sensor system to address the problem. Technician replaced the front AIR BAG AND THE SEAT HARNESS for the new sensor costing approximately $1,300. This was thought to have been covered since it was seat belt/air bag issue but I had pay to have them replaced.
Air bags, Seat belts, Seats, Sep 20, 2023
The passenger safety restraint system fault message pops up when driving normally. The diagnostic came up to replace the whole airbag after communicating with service center.
Air bags, Sep 6, 2023
on 8/26/2023 @10:44AM, received a message on the vehicles display that stated, "Front Passenger Safety Restraint Fault, service is required". This fault is intermittent. Set up a service appointment and after diagnosing the problem remotely, received this response: there are currently no faults/alerts, so it is at your discretion as to when you would like to address this. When the alert is present, the front airbag deployment will not be optimized for the passenger weight. Airbag replacement is necessary to be compatible with the seat sensor update and will ensure better serviceability for the future if it becomes necessary. Let me know if you have any further questions about the repair. Estimate of repairs, $1760.00. I have another tesla model 3, 2017 model year with the same fault. First of all, I drive the vehicle as a commuter car, and 99% of the time I drive alone. Secondly, I am concerned that in the event of an accident, the passenger airbag either won't be deployed at all, or may not be deployed correctly and may injure a passenger by deploying too little or too much.
Air bags, Seat belts, Aug 11, 2023
2018 Tesla Model 3 shows “Front left safety restraint system fault”. My car was not identify as having the recall applied but have the same issue the recall or warranty would resolve. My care is out of warranty and Tesla want to charge estimated $1,500 to resolve this issue. Tesla has this issues with all makes and models and is a safety issue.
Air bags, Seat belts, Seats, Aug 1, 2023
The vehicle is reporting a right passenger restraint error message on the screen. Tesla "fixed the sensor" in 2021 under warranty. Now the same issue is present and Tesla says they have to replace the senor again with a newer one which is now no longer compliant with the OCS system or the air bag. They are charging customers $1600 to replace the sensor, OCS and airbag, all of which are safety specific requirements and is a product failure on their part. The error comes and goes at random, and at any speed. As low as 0-5 mph and as much as at 75mph
Air bags, Seats, Jul 30, 2023
Front passenger safety restraint system fault. Tesla refuses to fix unless I pay out of pocket.
Air bags, Service brakes, Jul 22, 2023, crash
My car left the road traveling at 60mph, and after leaving the road it was quickly approaching a metal pole. At this time it seemed that the breaks were not able to stop the vehicle. After totaling the car, and what I thought would be the loss of my life, my airbags did not deploy. To further explain the extent of the accident: the front bumper is destroyed, the hood is destroyed, the windshield is destroyed and caved in onto me, the roof was destroyed, the back glass was also destroyed, along with much more extensive damage to the build of the car. The pole involved in the accident came out of the ground and through the car. It is unfathomable how I am still alive with manageable injuries. Yet- no airbags. This could have ended much differently.
Air bags, Jul 11, 2023
I received an alert that there’s a problem with my airbag. I reported it to tesla and since my car is out of warranty, it will cost over $1300. Since it’s only an alert, I decided to not pay the $1300 but now I’m wondering how unsafe is it does it mean the passenger airbag will not work in the event of a collision?
Air bags, Jul 11, 2023
We had a warning light that says "“front passenger safety restraint system fault”. The Tesla dealership said that the airbag needs to be replaced. There were no incidences that led to this warning. It just appeared on its own.
Air bags, Seats, Jul 10, 2023
I received a random RCM_a056 safety alert message on my 2018 Tesla Model 3. The Tesla Service Center requires the following repairs: 1) replace front passenger airbag and update vehicle configuration and 2) retrofit SBR in OCS equipped front passenger seat. My vehicle has over 110,00 miles on it, so I am past the Supplemental Restraint System warranty period of 5 years or 60,000 miles. The cost to repair these safety alert is $1,257.76 as Tesla does not classify this safety failure as a recall issue; however, there are numerous Tesla Service Bulletins and complaints as early as 12/30/19 discussing this issue in online Tesla forums. Why is this known issue not classified as a Recall?
Air bags, Seat belts, Seats, Jul 1, 2023
I am writing to report a safety concern with my Tesla Model 3 vehicle. The issue pertains to a persistent warning message that displays "Front Passenger Safety Restraint System Fault". This warning suggests a potential malfunction in the safety restraint system, which could pose a significant risk to the passenger in the event of an accident. The warning message first appeared in July 2019 and has since been a recurring issue. Last December 2023, I paid out of pocket to get this serviced. The warning disappeared for a few months but reappeared recently. I have scheduled a service appointment with a Tesla service center to diagnose and hopefully rectify the issue. However, I felt it was necessary to report this to the NHTSA due to the potential safety implications for other Tesla Model 3 owners if this is a widespread issue.
Air bags, Seat belts, Jun 27, 2023
My vehicle recently depicted warnings on my screen showing " Front Left Safety Restraint System Fault" " Service is Required". I also sometimes get a visual warning showing a depiction of an airbag. Now I don't know if anything is wrong, but Tesla is going to charge me $400 to fix this problem. My cars warranty expired in April of this year. My concern is, if this is an airbag problem shouldn't it be coved by a recall? Or does your agency need to receive a large number of complaints to issue a recall? To answer your general questions, the warning messages started one month ago, late May. Beside the warning message, the airbag warning lamp would sometimes appear. I have a service appointment with the Tesla Service Center on July 1, so I should know more then.
Air bags, Seats, Jun 24, 2023
Got an error code "RCM_a056" that indicates that there is a fault with the Front passenger safety restraint system. Looking at this problem online it seems that is not very unique and many owners of 2018 Model 3 have suffered the same issue. I was quoted for a service that changes the OCS sensor, but then they also have to replace the airbag due to "compatibility" reasons.
Air bags, Seat belts, Seats, May 22, 2023
Driver received alert "front passenger safety restrain system fault." Tesla advised that airbag may not deploy when occupant in passenger seat due to seat pressure sensor malfunction. Added "filter" and issue corrected. Issue has returned and Tesla is asking for $2,000 to replace the entire seat due to pressure sensor not being otherwise accessible. I would like to alert the NHTSA to this issue since I do not feel as though a safety issue such as this should exist on a 4 year old car and, in addition, the cost of repair should not be left to the consumer to cover. I feel as though a safety recall is warranted. Thank you.
Air bags, Apr 25, 2023, crash
Side airbags did not deploy in a major side impact.
Air bags, Seats, Apr 24, 2023
I was experiencing intermittent Bluetooth connection issues along with vehicle not powering off and the gear shifting to park when moving the vehicle at (very) low speed without the seatbelt buckled. I noticed the Bluetooth connection problem after a bad software installation in Jan 2023, however the other two issues have been noticed since at least 2020. When I took the car for a second time, Tesla diagnosed the problem as a faulty seat occupancy sensor (SOS). Tesla told me that the driver side seat SOS is “sticky” that the car didn’t consistently know there was a driver in the car when I sit on the seats (which explained why the car would put itself in park when driven at low speed (<3mph) without seatbelt on, and why the engine kept running even after I stepped out of the car when the car wasn’t locked ( like, when the car is parked in the house’s garage). Further research on the web (https://www.carproblemzoo.com/tesla/model3/2018/seats-problems.php ) shows that other teslas had faulty seat occupancy sensors at both driver side and passenger side. Faulty sensors may lead to improper, or failed, airbag deployment. This is a safety issue that Tesla had known and should have performed a recall and fixed, or the very least sent a billeting to its service centers so that they would check the seat sensor when someone’s complaining about any of the three symptoms I had. When I took the car to Tesla in Feb 2023 their (mis)diagnosis was that I had too many wires plugged into USB ports and that’s why the Bluetooth didn’t connect. I didn’t complain about the vehicle going to park by itself - as I thought it was a “safety feature”. I didn’t care to report the motor running after exiting, as I thought it was the battery mgmt system running to cool the battery!
Air bags, Seats, Apr 11, 2023
My 2018 Tesla Model 3 Long Range abruptly parks itself when a seatbelt is not used. The car does not wake up when sitting into the driver seat and the likely culprit is the driver side occupant sensor. To wake up the car one must press the brake or tap on the screen multiple times. If the sensor is faulty this means the airbags on the driver side will not deploy due to the car thinking there is no occupant. Tesla wants to charge customers $1300 for a replacement seat, which is unfair as it compromises the cars air bags and safety system. The car is drive able even when the sensor is not working. I am scared that if an accident were to occur the airbags will not deploy.
Air bags, Vehicle speed control, Forward collision avoidance, Feb 21, 2023, crash
While attempting to park the car in a parking lot, the car did not respond to the release of the accelerator or the press of the brake but just continued. Car continued to jump the curb and run into a concrete wall without slowing or stopping. No auto functions were enabled on the car. Car was attempting to park in the spot on the right side of the photo but just continued on and ran into the stone wall.
Air bags, Nov 11, 2022
I have been receiving the following message: Front Left safety restraint system fault. (Error notice: Notice: RCM_a021) Proposed repair: 1ST ROW SEAT HARNESS ASSEMBLY - RIGHT HAND - SBR(1489060-05-D) 1ST ROW SEAT HARNESS ASSEMBLY - LEFT HAND - SBR(1489060-02-F) It seems that this is the same problem that they repaired under warranty. Now they are repairing again at a very high price (quote. Work pending). If this problem is repeating, it seems likely other cars would be encountering this defect.
Air bags, Seats, Oct 3, 2022
I believe the front passenger occupancy sensor has failed or malfunctioned again. The first instance of issue took place on 03/05/2020 and a second instance of the same issue has occurred again on 09/29/2022. It is available for inspection upon request. Front passenger safety is put at risk because the vehicle may not deploy the front passenger airbags if it is not able to detect the occupancy status of the front passenger seat. The problem was reproduced by the Tesla dealer after the first instance of failure. The vehicle was inspected by the manufacturer after the first instance of failure. The system warning that displays on screen - "Front passenger safety restraint system fault/Service is required".
Air bags, Seat belts, Seats, Aug 18, 2022
In 2021 the vehicle reported – “Front passenger safety restraint system fault/Contact Tesla Service”. Tesla performed OCS rework installing an Occupant Classification System (OCS) Filter Module (part SERVICE KIT – OCS REWORK (1479982-00-C)). In 2022 the vehicle reported “RCM_a056 Front passenger safety restraint system fault service required”. Tesla’s proposed correction is to replace seat (part 1ST ROW SEAT ASSEMBLY – RIGHT HAND – PUR BLACK (7654324-91-C)). The safety risk may be serious and alert RCM_a056 is being reported by other owners on the web so the problem is not isolated. My understanding is the Occupant Classification System (OCS) Filter Module is part of the airbag system and weighs occupants in the front seat. The OCS Filter is used to determine if the front seat is occupied and possibly classify occupants by weight to determine if and/or by how much airbags should be deployed. The safety of a person in the front passenger seat maybe at risk because of this faulty OCS which could result in airbags failing or deploying dangerously based on erroneous OCS inputs. The problem was identified by two faults reported by the vehicle, the first OCS failure was confirmed by a Tesla Mobile Technician and the component was replaced (part SERVICE KIT – OCS REWORK (1479982-00-C)). The Tech said the seat heater was causing interference with the OCS’s unshielded wires. The second fault the vehicle reported was also confirmed by a Mobile Service Technician who said the replacement OCS filter module “can’t be calibrated”. Please note that this is the second failure of the same component. Tesla has the OCS Module replaced in March of 2021. No other parties have inspected any of the OCS Filter Modules. I will make an effort to retain the seat being replaced. Only two fault with “RCM_a056” code and “Front passenger safety restraint system fault” text were reported by the vehicle. There were no other symptoms related to this faulty module.
Air bags, Back over prevention, Jul 5, 2022, crash
This car was hit in a T bone on March 15th 2022 by a Toyota RAV4 on the driver side , the driver side was completely smashed and the car spun 2 times and came in the middle ramp. In spite of this heavy impact there were no airbags deployed , after several follow ups with Tesla I have no answer so far. The car was deemed total loss last month and even after consistent follow ups I have no answer from. Tesla. The impact was very heavy that my wife had whiplash and she went through chiropractic treatment for 2 months .. I’m very worried as the impact was so bad that this is a fatal flaw in Tesla and they do not have the airbag curtain deploy to protect the driver side at all - my wife was lucky and she is alive but this could happen to anyone .. I need an answer from Tesla and I found I could get it through this website and need the right measures take so that no one will get injured or cause life in any accident in future
Air bags, Seat belts, Jul 1, 2022
Driver Side Supplemental Restraint system reported an issue and need for service. Service department blames faulty electrical harness under the seat. A search of the web shows this is a common failure, leading me to believe that it is a design or a quality control issue. Tesla declines to repair under warranty because warranty expired 610 miles prior to notification.
Electrical system, Back over prevention, Air bags, May 20, 2022
The contact owns a 2018 Tesla Model 3. The contact stated while driving 35 MPH, the warning message "Front Left Safety Restraint System Fault. Service Required." The contact continued to drive. The contact stated that the next day, the air bag warning light illuminated. The manufacturer was notified of the failure and informed the contact that a field mechanic would be sent to his residence to repair the vehicle however, the repair appointment was rescheduled several times. The vehicle was not diagnosed or repaired. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The failure mileage was approximately 21,000. Parts distribution disconnect. Defective airbag warning sign in red is also active. After repeated requests to Tesla they refuse to fix the issue and keep postponing the repair dates.
Air bags, Apr 9, 2022
screen shows "Front passenger restraint system fault Service is required" Tesla technician confirmed that "Occupant Classification System(OCS) Filter Module" needed to be replaced and the technician replaced it. Please see attached files.