2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints
614 reports, newest first.
Air bags, Structure, Sep 26, 2026, crash
On September 22, 2026, my 2019 Tesla Model 3 was involved in a very low-speed front collision. The Tesla Vehicle Data Report records the front collision event at approximately 23:21:26.933 and shows vehicle speed of approximately 2–3 mph at the time of the recorded collision. Despite the extremely low recorded vehicle speed, the vehicle’s airbags deployed. The airbag deployment caused an eyebrow/facial laceration that required six stitches and medical treatment. The Tesla vehicle data also shows an accelerator pedal position of approximately 70–75% around the collision event, while brake pressure was essentially zero at the recorded collision timestamp. Significant braking appears in the data after the collision event. I am concerned that the restraint system may have deployed the airbags during an unusually low-speed collision. I am requesting that NHTSA review whether the airbag/restraint system in this vehicle may have a safety defect or an inappropriate deployment threshold. I have retained the Tesla Vehicle Data Report, photographs of the vehicle and injury, and medical documentation. I am also requesting that Tesla preserve the vehicle’s crash data and all deployed airbag/restraint components for investigation.
Steering, Sep 23, 2026
The vehicle reported an error with steering. I brought the vehicle into tesla service. Upon inspection the connector to the steering rack was heavily corroded from water intrusion and had broken clean off upon removal. Confirmed with dealer that corrosion had caused the issue. If the connector had failed while driving the vehicle would have lost all power steering immediately and placed myself and others on the road in danger. The connector was corroded enough that the spade connector detached completely upon inspection. The steering rack is not easily accessible by the consumer and could not have been impacted by circumstances outside of normal driving.
Air bags, Forward collision avoidance, Lane departure, Sep 21, 2026, crash
On September 12, 2026, at approximately 2:05 PM, while operating on Full Self-Driving (FSD v14.1 Lite) on Hardware 3 (HW3), the vehicle experienced a critical, unprompted loss of path control. While traveling on the highway, the vehicle sharply veered off the left side of the roadway, caught air, and violently impacted an emergency barrier, resulting in the destruction of 9 steel poles and causing physical injuries to both the driver and front passenger. Despite the severe frontal impact and structural collision, neither the front nor knee airbags deployed, raising serious concerns regarding the vehicle's crash-sensing algorithms, structural impact detection, and restraint system integration under this software version. This incident highlights major safety risks associated with running computationally heavy FSD stacks on legacy HW3 architecture: 1. Uncommanded Steering Deviations: The system abruptly executed a violent, unprompted hard turn away from the path of travel, indicating severe lane-detection or path-planning failure. 2. Restraint System / Safety Failure: Critical secondary safety systems (front and knee airbags) failed to deploy in a high-impact structural collision involving multiple steel barrier poles. 3. Hardware Constraint Risks: The compounding computational and thermal load on HW3 hardware running v14.1 Lite continues to manifest in erratic vehicle control, latency, and hazardous tracking behavior. This severe safety defect requires an immediate federal investigation into both FSD trajectory control on legacy hardware and secondary restraint deployment failures.
Other or unspecified, Sep 13, 2026
Tesla FSD made Left Turn on Red Left-Turn arrow: On August 12, 2026, at approximately 4:30 PM, my 2019 Tesla Model 3 was operating in Full Self-Driving (FSD) mode at the intersection of US-71 West and Pedernales Summit Parkway in Austin, Texas, 78738. The vehicle proceeded to make a left turn while the left-turn traffic signal was displaying a red arrow. This was an unsafe traffic-control violation and created a potential collision risk. I had to monitor the vehicle and be prepared to intervene. I am reporting this as a safety issue with the vehicle’s automated driving/Full Self-Driving system. I also reported this issue to the Tesla through my Tesla APP but no action was taken from them. They have not even called and asked for this issue. I would request you to investigate this matter promptly and provide a detailed report on how this simple mistake could happen with the software.
Air bags, Seats, Sep 10, 2026
The Restraint Control Module (RCM) fault code RCM_a056 intermittently appears and disappears on the vehicle's display. This code indicates a fault in the front passenger Occupant Classification System (OCS) — the sensor responsible for detecting passenger presence and weight to determine whether and how the passenger airbag deploys in a crash. Because the OCS sensor is malfunctioning, the passenger airbag may fail to deploy, deploy incorrectly, or deploy with wrong force in a collision, putting any front passenger at serious risk of injury or death. The fault is intermittent — it appears and disappears without any change in vehicle configuration or seating — which is consistent with a failing OCS sensor or degraded wiring harness connection under the passenger seat. No collision or injury has occurred. The vehicle has not yet been inspected by a dealer or service center. No independent inspection has been performed. Tesla has issued Service Bulletin SB-23-20-002, which has been revised at least seven times, acknowledging a known OCS sensor defect across multiple Model 3 vehicles. Despite this, no safety recall has been issued. The repair cost quoted by Tesla service is approximately $800–$2,000 out of pocket for what appears to be a widespread manufacturing defect in a critical safety system. Numerous other Model 3 owners have reported the identical fault code. The component is available for inspection upon request.
Air bags, Seat belts, Seats, Sep 5, 2026
Safety restraint system tsb technical service bulletin, a known problem with my 2019 Tesla model three
Air bags, Seat belts, Aug 25, 2026
Front passenger safety restraint system issue requiring replacement of Occupant Classification System and updating front passenger airbag to maintain compatibility with front passenger seat. Costing almost $2000. Many others have reported of multiple repairs
Air bags, Seat belts, Seats, Aug 25, 2026
Alert RCM_a021pretenLapFrontLeft. Caused by the seat harness wires being pinched and stretched when moving the seat back/forward/up/down. Eventually the wires are damaged by the seat movement. Tesla has touted a feature called "Easy Entry" which moves the seat to a preset position to allow the driver to get in and out of the car more easily. This moves the seat lower and farther back and then moves the seat back up to the driver's position when ready to drive. This increased seat movement, every time the driver gets in and out of the car, causes the wires to wear prematurely and the above fault to trigger. In the event of an accident the driver side airbag may not deploy and/or the seat belt pretensioner may fail to lock the seat belt in place, leaving the driver exposed to serious potential injury risk. This issue can be seen in 2019 Tesla Model 3s and I believe an investigation by the NHTSA is warranted, at the very least.
Air bags, Seat belts, Aug 13, 2026
To Whom It May Concern, I am logging a safety defect complaint regarding my 2019 Tesla Model 3, which displays active fault code RCM_a056 – Front passenger safety restraint system fault. This error deactivates the front passenger airbag and seatbelt pretensioners, creating an immediate, severe safety hazard. The Defect: The failure involves the Occupant Classification System (OCS) seat sensor and affects passengers in two ways: 1. Children (Current Stage): The fault triggers primarily when a child sits in the front seat. The degraded sensor mat cannot process lighter weight accurately, throwing an "implausible voltage" error that disables the airbag system. 2. Adults (Advanced Stage): online data shows this same code eventually locks out for adults due to internal wiring harness fraying or sensor circuit failure. Manufacturer Response: Tesla is aware of this fleet-wide defect and issued Service Bulletin SB-23-20-002 to address it. However, because my vehicle is out of warranty, Tesla refuses to cover this critical safety repair. Service centers are quoting owners $1,300 to $1,500+ out-of-pocket to fix an inherent manufacturing flaw in a federally mandated safety system. I urge the NHTSA to investigate the 2019 Tesla Model 3 OCS system and compel Tesla to issue a safety recall to fix this hazard at no cost to consumers. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Aug 12, 2026
Tesla recently introduced auto parking as part of its FSD technology (Software 2026.20.6.11). Whenever we set the car destination to “home”, the auto parking has been able to gradually maneuver the car and self park in our garage. On 8/11, around 8:30pm, the car made a mistake during the auto parking. During the auto reverse into garage, the car came too close to the side of the garage and the driver side mirror hit the wall and partially broke. The driver was monitoring the car. If the car has kept its angle, it would have made it through correctly. But looks like it miscalculated and in a fraction of a second, the car’s side mirror hit the garage wall. Given the “ park” feature is new, looks like it hasn’t been tested well. It should be recalled until it is fixed and impacted drivers should be compensated for their repairs.
Suspension, Aug 3, 2026
Noise came from front left wheel while driving around a turn. Later the same day another noise when turning the wheel when leaving a parking spot. Steering felt strange. It was late at night, so left the vehicle until the morning. In the morning, discovered a large bolt in front of the vehicle. The front left wheel was turned differently than the right front wheel. Had to spend almost $400 to get the vehicle towed to a Tesla service center. They later confirmed, "The cause was detached links from the bushings and bolts. Technician replaced the front lower lateral links, front lower compliance links, and front stabilizer bar bushing brackets. Total cost for those repairs was $1,902.90. This could easily have resulted in an accident and even a fatality if we were not so lucky.
Suspension, Aug 3, 2026
Over a period of several weeks, the front suspension increasingly made noise (squeaking and groaning) and felt loose when turning and going over bumps. The front control arms were replaced 10/31/24. The problem has begun recurring over the last few months, with the same noise occurring and progressively worsening.
Seats, Aug 3, 2026
I am writing to report a serious safety incident involving my 2019 Tesla Model 3. My goal is not to assign blame, but to make Tesla aware of an incident that I believe warrants review from a safety perspective. While the vehicle was parked, my children were sitting inside watching TV, we were standing 5 ft from the vehicle. My younger son was seated in the front passenger seat, and my older son, not realizing his brother had leaned over the top of the seat, adjusted the passenger seat upward. As the seat moved up, it trapped my younger son's neck against the seat and obstructed his airway. Fortunately, we were a couple of feet away and heard the sound of glass breaking. We were able to free him, and he began breathing again and no serious injury occurs. It was an extremely frightening situation that could have had a much more serious outcome. During the incident, the panoramic glass roof also shattered from the pressure of my youngest son's head. I understand this may have occurred because of the force involved, but I wanted to include it as part of the overall event. I recognize that children should not play inside vehicles unsupervised, but they are 8 and 10 and were not rough housing just watching Netflix in the Telsa. However, this incident made me question whether additional safeguards could help prevent a similar situation in the future. Specifically, I wonder if there are opportunities to improve obstruction detection or pinch protection when a seat encounters resistance near a person's head or neck or making the seat unable to get so close to the ceiling an continue to rise. I wanted to bring this incident to your attention so safety teams can review it. If there is any additional information that would be helpful, including photographs, the vehicle VIN, or other details, I would be happy to provide them.
Suspension, Aug 1, 2026
The vehicle has quite a bit of noise coming from the suspension during normal driving. Creaks and groans.
Suspension, Jul 31, 2026
Between 2023 and 2026, I have had several clunking and creaking sounds from the suspension. These were then found isolated to "lateral and compliance link detachments" and Tesla noted these were "serious safety issues" and fixed them out of warranty at a cost of roughly $2500. When I pointed out that vehicles within this model range (manufactured April 2019 at the Fremont, CA plant) were flagged for a recall, they mentioned my vehicle was outside that range and insisted on an out-of-pocket repair. Further, I have similarly had to have the front left driver's side seat belt harness replaced because of a restraint control module failure. I have owned 3 other vehicles and have never had a restraint control module/seatbelt fail over just 82000 miles of use.
Suspension, Jul 31, 2026
Honestly since I took delivery the vehicle I did notice a clunking sound every time I would turn into a steep driveway. I reported the problem to Tesla on multiple occasions and they either could not replicate the sound or find the problem when they inspected the vehicle. So I lived with the on and off clunking sound. Years later while driving on the freeway I heard a really hard clunk and I began to lose control of the car luckily I was close to home and I was able to make it to my street. Upon arrival my tires completely fell off the control arm and I could move the steering wheel at all. I had to get it towed to the body shop. Long story short the lower control arm bolt completely fell off. I just happy this didn’t result in a major accident. But I had to get the car towed. I am pretty upset that Tesla pretty much said there is no issue. My family has Teslas and in all of them I hear the same clunking sound.
Suspension, Jul 31, 2026
About one month ago, my 2019 Tesla Model 3 developed a suspension issue that caused a noticeable vibration in the rear of the vehicle whenever I drove above 40 mph. At first, we suspected the problem was related to a tire. However, after the technicians at the Tesla Service Center lifted the vehicle for inspection, they discovered a much more serious issue. They brought me into the service area to show me that the right rear suspension was being held together by only the front portion of a bolt. The retaining nut had completely come off, leaving the bolt barely in place. Had that bolt shifted even a few millimeters while I was driving, it could have resulted in a catastrophic suspension failure and a serious accident. Tesla determined that the loose bolt had caused damage to the right rear (passenger-side) suspension assembly. The necessary repairs totaled approximately $1,800, which I paid to restore the vehicle to safe operating condition.
Service brakes, Jul 30, 2026
My brake lines have corroded to the point where half a liter of brake fluid has leaked out rendering the vehicle unsafe. Tesla admits that this is a design flaw but says that it does not affect this particular VIN number but the damage is exactly as described: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Forward collision avoidance, Lane departure, Jul 28, 2026
Tesla rolled out FSD 14 Lite to hardware, including to my vehicle and it’s become extremely unsafe.The past several days the vehicle will suddenly slow down/break causing people to almost crash into me, make sudden and indecisive lane changes, and constantly rocking the steering wheel left and right. I hope someone takes this seriously and has Tesla revert back to the old software or make changes before someone is killed.
Electrical system, Air bags, Seats, Jul 28, 2026
The Front Passenger Safety Restraint System failed prematurely on my 2019 Tesla Model 3 at only 23,105 miles, triggering the alert 'Alerts - Seats - Front passenger safety restraint system issue/Service is required' and disabling passenger airbag functionality. Upon inspection, Tesla Service quoted $1,285.13 out-of-pocket to repair the system. While the root failure involves a $12 occupant occupancy sensor (Part #1099592-00-F), Tesla's mandatory service procedures require a full subsystem revision cascade to fix it. Specifically, under 'Replace Occupant Classification System (OCS) of Front Passenger Seat while Servicing Subcomponents' and 'Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat,' Tesla requires replacing the right-hand seat harness assembly (Part #1489060-03-G) and the complete Front Passenger Airbag (Part #1077823-00-G) solely to maintain hardware compatibility with the revised sensor. Because Tesla redesigned subcomponent hardware without offering a backwards-compatible replacement sensor for earlier Model 3 production units, restoring a critical primary safety system creates an exorbitant financial barrier, forcing the vehicle to be operated with disabled airbags.
Electrical system, Jul 22, 2026
I was locked inside my tesla model 3 two stories down in a parking garage with no internet access to find out where the emergency release was for my door. I KICKED my driver side window to survive. It wasn't until after I was told that the doors are tied to a 12v battery that had died without warning. I did not know the doors tied to that nor that there was a secret emergency release. There are no clear indicators within the car that this is how it operates and you SHOULDN'T NEED INTERNET ACCESS AND ELECTRICITY TO SURVIVE EXITING A CAR.
Air bags, Jul 21, 2026
Front passenger Occupant Classification System (OCS) failed on its own, without accident, misuse, or modification, at low mileage. The fault disables proper airbag deployment logic for the front passenger seat. Tesla has issued multiple service bulletins acknowledging this as a known condition. **Vehicle Identification Number (VIN):** [XXX] **Model Year:** 2019 **Make:** Tesla **Model:** Model 3 **Mileage at time of failure:** Approximately 27,800 miles **Date of incident/failure:** XXX (date alert was first detected, per invoice) **Component:** Air Bags / Occupant Classification System (Front Passenger) **Crash involved:** No **Fire involved:** No **Injuries:** None **Number of injuries/fatalities:** 0 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Air bags, Seats, Jul 10, 2026
I am getting an electrical fault which has disabled my front passenger seat airbags. They need to replace the wiring, which means they also now need to replace the passenger airbag itself because wiring has changed and the old airbag is not compatible with the new wiring. Replace Occupant Classification System (OCS) of Front Passenger Seat while Servicing Subcomponents Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat I had this same error 4 months ago and it ended up shorting out the entire electrical system, which disabled autosteer and eventually completely disabled power steering which made the car unusable. Tesla service center called it a water intrusion problem and had to replace the entire front electrical harness system and steering rack costing $4500. Now the problem has resurfaced and I'm afraid I might lose power steering again which is extremely dangerous and could happen any time, in addition to my airbags potentially not deploying.
Suspension, Structure, Jul 5, 2026
Summary of the Problem Rear subframe assembly and multiple rear suspension links required full replacement due to failure/wear at approximately 51,890 miles, on a vehicle with no history of collision or accident damage. Tesla diagnosed the issue as an interior rattle/squeak reproducible over bumpy roads and speed bumps, which led to replacement of the rear subframe and nearly the entire rear suspension link set. Total repair cost was approximately $7,667.65, entirely out of pocket, as Tesla stated no recall applies to this VIN. Full Description (detailed narrative field) In December 2025, I began noticing a rattling/squeaking noise from the rear of my 2019 Tesla Model 3, reproducible on bumpy roads, speed bumps, and rail tracks. The vehicle has never been in an accident and has no history of collision damage. I brought the vehicle to Tesla Service (Fremont, CA) on 07-Jan-2026 at 51,890 miles. Tesla's diagnosis found it necessary to replace: The rear subframe assembly Rear toe link assemblies (left and right) Rear upper fore link assemblies (left and right) Rear lower fore link assemblies (left and right) Rear upper aft link assemblies (left and right) Front lower compliance links (left and right) Front lower lateral links (pair) A four-wheel alignment This amounted to nearly a full rear (and partial front) suspension rebuild, at a cost of $6,843.34 for this job alone, and $7,667.65 total, entirely at my expense. Tesla confirmed there is no open recall covering this VIN or this failure. I am concerned this represents a premature structural/suspension component failure unrelated to accident damage or normal wear, at a mileage (51,890) that suggests a potential defect in the subframe or suspension hardware/corrosion resistance for this model year, rather than an isolated wear item. I am filing this complaint so NHTSA can evaluate whether this is part of a broader pattern for 2019 Model 3 vehicles.
Air bags, Seat belts, Seats, Jun 18, 2026
It was raining and my passenger got in the car (slightly damp). When he sat down, I reveived an error message on the screen saying "Front passenger safety restraint system issue". The airbag light is red indicating that it won't work for my passenger. You should be able to get into a car wet without your airbag no longer working. My understanding is that this is a common problem. Tesla wants > $1000 to replace the seat sensor + requires me to pay to have my airbag replaced so the part matches the sensor. According to Tesla Service Bulletin SB-23-20-002, the new style of seat sensor is strictly incompatible with the older style of airbag (known as a "Full Suppression" airbag). $182 (Diagnostic Fee) $475 (OCS Replacement) $318 (Airbag Update) + Labor + Tax The internet is full of reports of this issue. Just google "Front passenger safety restraint system issue". I do not have an invoice for the repair yet. Tesla's service center's first available appt is in 25 days. This means I have to go 25 days without a passenger in my front seat.