2019 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 614 owner complaints filed for this model year. This is the 4th highest complaint count among 9 Model 3 model years with reports.
Of the 2019 reports, 60 involved a crash and 5 involved a fire. 30 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Equipment, other, labelsOct 10, 2019
Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Failure to provide the air bag warning information increases the risk of injury.
Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.
Campaign 19V719000 on NHTSA.gov
Representative owner complaints: suspension
82 reports, newest first. Show all
Suspension, Aug 3, 2026
Noise came from front left wheel while driving around a turn. Later the same day another noise when turning the wheel when leaving a parking spot. Steering felt strange. It was late at night, so left the vehicle until the morning. In the morning, discovered a large bolt in front of the vehicle. The front left wheel was turned differently than the right front wheel. Had to spend almost $400 to get the vehicle towed to a Tesla service center. They later confirmed, "The cause was detached links from the bushings and bolts. Technician replaced the front lower lateral links, front lower compliance links, and front stabilizer bar bushing brackets. Total cost for those repairs was $1,902.90. This could easily have resulted in an accident and even a fatality if we were not so lucky.
Suspension, Aug 3, 2026
Over a period of several weeks, the front suspension increasingly made noise (squeaking and groaning) and felt loose when turning and going over bumps. The front control arms were replaced 10/31/24. The problem has begun recurring over the last few months, with the same noise occurring and progressively worsening.
Suspension, Aug 1, 2026
The vehicle has quite a bit of noise coming from the suspension during normal driving. Creaks and groans.
Suspension, Jul 31, 2026
Between 2023 and 2026, I have had several clunking and creaking sounds from the suspension. These were then found isolated to "lateral and compliance link detachments" and Tesla noted these were "serious safety issues" and fixed them out of warranty at a cost of roughly $2500. When I pointed out that vehicles within this model range (manufactured April 2019 at the Fremont, CA plant) were flagged for a recall, they mentioned my vehicle was outside that range and insisted on an out-of-pocket repair. Further, I have similarly had to have the front left driver's side seat belt harness replaced because of a restraint control module failure. I have owned 3 other vehicles and have never had a restraint control module/seatbelt fail over just 82000 miles of use.
Suspension, Jul 31, 2026
Honestly since I took delivery the vehicle I did notice a clunking sound every time I would turn into a steep driveway. I reported the problem to Tesla on multiple occasions and they either could not replicate the sound or find the problem when they inspected the vehicle. So I lived with the on and off clunking sound. Years later while driving on the freeway I heard a really hard clunk and I began to lose control of the car luckily I was close to home and I was able to make it to my street. Upon arrival my tires completely fell off the control arm and I could move the steering wheel at all. I had to get it towed to the body shop. Long story short the lower control arm bolt completely fell off. I just happy this didn’t result in a major accident. But I had to get the car towed. I am pretty upset that Tesla pretty much said there is no issue. My family has Teslas and in all of them I hear the same clunking sound.
Suspension, Jul 31, 2026
About one month ago, my 2019 Tesla Model 3 developed a suspension issue that caused a noticeable vibration in the rear of the vehicle whenever I drove above 40 mph. At first, we suspected the problem was related to a tire. However, after the technicians at the Tesla Service Center lifted the vehicle for inspection, they discovered a much more serious issue. They brought me into the service area to show me that the right rear suspension was being held together by only the front portion of a bolt. The retaining nut had completely come off, leaving the bolt barely in place. Had that bolt shifted even a few millimeters while I was driving, it could have resulted in a catastrophic suspension failure and a serious accident. Tesla determined that the loose bolt had caused damage to the right rear (passenger-side) suspension assembly. The necessary repairs totaled approximately $1,800, which I paid to restore the vehicle to safe operating condition.
Suspension, Structure, Jul 5, 2026
Summary of the Problem Rear subframe assembly and multiple rear suspension links required full replacement due to failure/wear at approximately 51,890 miles, on a vehicle with no history of collision or accident damage. Tesla diagnosed the issue as an interior rattle/squeak reproducible over bumpy roads and speed bumps, which led to replacement of the rear subframe and nearly the entire rear suspension link set. Total repair cost was approximately $7,667.65, entirely out of pocket, as Tesla stated no recall applies to this VIN. Full Description (detailed narrative field) In December 2025, I began noticing a rattling/squeaking noise from the rear of my 2019 Tesla Model 3, reproducible on bumpy roads, speed bumps, and rail tracks. The vehicle has never been in an accident and has no history of collision damage. I brought the vehicle to Tesla Service (Fremont, CA) on 07-Jan-2026 at 51,890 miles. Tesla's diagnosis found it necessary to replace: The rear subframe assembly Rear toe link assemblies (left and right) Rear upper fore link assemblies (left and right) Rear lower fore link assemblies (left and right) Rear upper aft link assemblies (left and right) Front lower compliance links (left and right) Front lower lateral links (pair) A four-wheel alignment This amounted to nearly a full rear (and partial front) suspension rebuild, at a cost of $6,843.34 for this job alone, and $7,667.65 total, entirely at my expense. Tesla confirmed there is no open recall covering this VIN or this failure. I am concerned this represents a premature structural/suspension component failure unrelated to accident damage or normal wear, at a mileage (51,890) that suggests a potential defect in the subframe or suspension hardware/corrosion resistance for this model year, rather than an isolated wear item. I am filing this complaint so NHTSA can evaluate whether this is part of a broader pattern for 2019 Model 3 vehicles.
Suspension, May 19, 2026
these cars have a defective control arm system and they are prone to messing up over and over, they have replacement revisions but try to charge you for labor and parts if youre out of warranty even though they know the parts were a problem and revised them. Tesla does nothing to help you and will even try to charge you $200 just to diagnose the issue.
Suspension, Mar 14, 2026
Suspensions. I know there’s been known defects with the suspensions and they’ve only recall 422 vehicles so far (2018-2019 Tesla model 3, I feel more vehicles in those years are affected.
Suspension, Feb 17, 2026
While driving, the front driver-side suspension collapsed due to a complete detachment of the front lower lateral link. The fastener (bolt) backed out entirely and fell onto the road/under-shield. This matches the failure mode described in NHTSA Recall 21V-835, although Tesla has previously claimed my specific VIN was not included. The failure caused an immediate loss of steering control and structural instability. I am reporting this as a potential 'recall bypass' where the defect exists outside the currently identified recall population
Suspension, Feb 4, 2026
At approximately 30,000 miles, the front left suspension lateral link/control arm separated while driving due to a missing mounting fastener (bolt), resulting in sudden steering instability and abnormal front wheel movement. Vehicle handling became unpredictable and felt unsafe to control, creating risk of loss of steering control. I stopped driving immediately. There was no collision, curb strike, pothole, or road hazard at the time of the incident. No warning lights or messages appeared prior to the failure; it occurred suddenly without advance notice. Tesla Service inspected and confirmed the separation and missing fastener. Suspension components and the front subframe assembly were replaced —4,400 out of pocket. Tesla documented they could not make a formal cause determination. The recovered bolt is intact and available for inspection upon request. Insurance also reviewed the incident and classified it as mechanical rather than collision-related. Because this involves a safety-critical steering/suspension fastener failure without warning, I am submitting this report for safety tracking. I am aware of similar owner reports describing suspension fastener or lateral link separation on this vehicle generation in case this reflects a broader pattern.
Suspension, Other or unspecified, Jan 3, 2026
I am reporting a safety defect involving a welded rear subframe component. The welded section snapped under normal driving conditions, and this is a safety-critical structural suspension component. There was no collision, misuse, or accident prior to this failure. The vehicle is currently not safe to drive due to the compromised rear suspension structure. I have included photos showing the snapped weld and overall rear subframe area. This appears to be a premature structural defect, not normal wear. I am requesting that this failure be documented and reviewed as a potential safety defect. Additional Notes: This component is part of the rear suspension and is expected to last the life of the vehicle. The failure created a serious safety hazard, and I am not driving the vehicle. I have scheduled a service appointment, but I am filing this complaint to ensure the defect is officially reported.
Steering, Suspension, Dec 28, 2025
After 3 prior repairs 2 of which were recalls of the front suspension, control arms. I was driving when me and my 3 children’s life’s were almost taken. While driving on the expressway immediate loss of control of the car shaking while driving to work, I stopped immediately thank God no cars around next to me to crash into. We called for a ride and walked off the expressway. Immediately car was taken to Tesla where they told me they couldn’t help and come back in a few days. The car was later inspected by Tesla where instantly knew the issue and later the report came back where the lateral links on both sides of the front where completely out of socket, the compliance links bushing completely torn. This is critical failure and breakdown of critical safety components that almost took our life. We had moments before this happened and thank God we made it out before imminent life changing things happened. No warning no alerts in the car at any time.
Suspension, Dec 8, 2025
The two bolts that hold the front lower control arm on fell out (driver side). Luckily this happened when we were backing out of the driveway and not at speed. There were no warnings lights, just a loud noise from the wheel when it failed. There is already a recall about this problem for the same year and model of my car, but the dealer is saying my car is not part of the recall. Here is a link to the recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Nov 18, 2025
Lower lateral link , and front lower compliance link and upper control arm assembly all broken and needed repair. Tesla service shop confirmed lower links were broken on both side, causing major safety concerns. They said it needed to be fixed or car could not be driven. This is a WELL DOCUMENTED issue all over the internet. The shop confirmed and said this repair is made all the time, and typically needs to be performed every 30,000-50,000 miles. The car has not been abused, only normal driving. The problem started as a squeak coming from the upper control arms and turned into a clunk when accelerating. How has a recall not been issued? People have been talking about this issue for years. Tesla acts like the front suspension is a consumable part like a spark plug in a ICE car. really? the front suspension should be rebuilt as often as every 30k miles?
Suspension, Oct 20, 2025
My car has same symptoms as previous recall and Tesla is denying repair
Suspension, Aug 20, 2025
Front suspension has lost lower lateral link and bolt. There was a recall on this back in 2023 for our year and model but our car was no selected. Clearly it should have been as the suspension has failed. Please see invoice from Tesla attached. This should be taken care of by Tesla as it is a known issue.
Suspension, Air bags, Aug 4, 2025
The contact owns a 2019 Tesla Model 3. The contact stated that the passenger's side air bag warning light was illuminated. The vehicle was taken to the Tesla Service Center, where it was diagnosed and determined that the passenger's side seat sensor had failed. The seat was replaced with a new seat; however, the air bag warning illuminated after the repair. The vehicle was taken back to the service center, where the contact was informed that the technician had failed to install the module connected to the air bag during the previous repair. The seat replacement was performed a second time; however, the failure persisted, and the contact noticed that the seat was not installed correctly. The contact requested for another service through the Tesla App, but the request was denied. The contact was informed that the vehicle was repaired, and the notification of the failure was due to a glitch in the system. Additionally, while driving at various speeds, there was an abnormal creaking sound coming from the front suspension. The contact stated that the sound became louder while turning. An appointment was scheduled with the Tesla Service Center. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Steering, Suspension, Service brakes, Jul 30, 2025
The vehicle’s front suspension began making loud squeaking noises and felt unstable while driving, especially when turning or going over uneven surfaces. At times, the vehicle does not make a proper turn and almost feels like it loses grip, which is extremely unsafe. I brought the vehicle to a Tesla service center. After inspection, Tesla provided a service estimate and documentation confirming the failure of the front lower lateral links — the exact part and condition described in NHTSA Safety Recalls 21V835000 and 23V235000, which cover defective front suspension lateral link fasteners on this vehicle make, model, and year. Despite the clear match, Tesla did not recognize the repair as recall-related and categorized it as a customer-pay service. This raises concern that some affected vehicles are being excluded from proper recall coverage, despite experiencing the same safety defects. There were no warning lights or alerts prior to the failure. The issue was confirmed by Tesla and the part is available for inspection upon request.
Suspension, Jan 31, 2025
Some 2019 Tesla model 3’s recalled due to lateral and control link issues. Problem seems to be more wide spread. Exactly same problem is apparently happening with my car - also a 2019 Tesla model 3, but not covered for some reason.
Suspension, Jan 14, 2025
Sep 2022 Tesla Model 3 brought in for noise when steering wheel is turned. Was told it was the control arm. Left and right arms both replaced. Mileage - 53247 Jan 2025 Tesla Model 3 brought in for heating issue and for similar noise when steering wheel is turned. Service rep said lateral links needed replacing. Mileage - 85321 Control arms and lateral link replacement at 53K and 85K, respectively, seems highly irregular. I have checked several online forums and found many other Tesla Model 3 owners having similar complaints. I have now replaced a significant portion of this vehicle's front suspension. We have owned 7 other vehicles, all purchased new, over the last 20 years. We have kept those cars between 150k - 200k miles and only 1 of those cars required this type of work, which was performed on a 2011 Jaguar XF at 160k+ miles
Suspension, Forward collision avoidance, Jan 7, 2025
Two major safety issues need to be reported: 1) The left front lower control arm falling off in the middle of driving, caused car wheel stuck on a traffic street (luckily it was off the freeway 5 minutes ago). The long bolts connected the lower control arms were loss due to the defective design (the bolts are screwed upward vertically, falling off is definitely just a matter of time). I found there was a class action against Tesla due to this problem (it is referred to Model X and S) 2) The other major safety issue I encountered as I turned on the “advanced autopilot “ feature, the car could break suddenly without warning on the freeway. There were no cars or obstacles in the front. I researched online and found many Tesla owners have experienced this so called “phantom breaking” problem as I had (I had experienced this unsafe auto breaking randomly since I have driven this car)
Suspension, Nov 19, 2024
The contact owns a 2019 Tesla Model 3. The contact stated while driving at an undisclosed speed, there was an abnormal squeaking sound coming from the front suspension. The sound was heard while making a turn. The vehicle was taken to the dealer where it was diagnosed with a failed upper control arm. The contact was informed that the upper control arm needed to be replaced. The vehicle was repaired. The contact stated that five days later the failure reoccurred. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that while the vehicle was at the dealer for a scheduled service appointment in May 2024, the vehicle was diagnosed with a failed suspension lateral link needed to be replaced. The contact was informed that the suspension lateral link needed to be replaced. The vehicle was not repaired. The contact was informed of two recalls, NHTSA Campaign Number: 23V235000 (Suspension) and NHTSA Campaign Number: 21V835000 (Suspension); however, the VIN was not included in the recalls. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 40,775.
Suspension, Other or unspecified, Oct 19, 2024
Upper control arm unit is defective on most model 3's. This has been reported by thousands of Tesla owners. After 50,000 miles the upper control arm will fail due to being assembled incorrectly, which causes a hard time driving the car and causing a strange sound in the suspension which can cause a risk in driving and increase the likelihood of an accident.
Suspension, Oct 1, 2024
Lateral links failed. It was exactly what was described in this recall. However my car was not part of the recall because it was manufactured outside the date range. Recall affected until Mar 2019. My car was produced maybe a month or two afterwards. [XXX] The fastener became loose and the entire lateral link popped off. This happened in the parking lot and the entire car dropped 3 inches. Had this happened on the freeway it would have been much more dangerous. Problem was inspected by Tesla and Tesla said they were not at fault. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)