2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints: suspension
186 reports, newest first. Show all
Suspension, Structure, Other or unspecified, Apr 13, 2026
Following a professional suspension repair at a Tesla Service Center, critical underbody fasteners (bolts) became loose, causing the aero shield to sag and creating a potential road hazard. Upon inspection, the service technician confirmed the bolts were unsecured. The failure of these fasteners on a safety-critical system poses a risk of parts detaching while in motion or loss of vehicle control. The service center refused to acknowledge this as a workmanship failure under the 12-month repair warranty, despite the fasteners being last serviced by their technicians.
Steering, Suspension, Feb 26, 2026
The front lower lateral link (rearward lower control arm) fastener/bolt completely backed out and fell off the vehicle while in motion, causing the lateral link to separate entirely from the subframe. This is the exact mechanical failure described in Tesla Recall Campaign 23V-235 (Service Bulletin SB-23-31-001), however, my specific VIN was not included in that recall. The vehicle and components are currently at an independent EV repair facility and are available for inspection upon request. Photographic evidence of the missing bolt and separated control arm has been retained. The separation of the lower lateral link caused an immediate and violent collapse of the front passenger-side suspension geometry. The affected wheel was no longer anchored to the vehicle frame, causing it to fold backward and grind heavily against the wheel well. To keep the vehicle moving straight, the steering wheel had to be turned to an extreme 45-degree angle. This resulted in a near-total loss of steering control. Had this fastener failed while traveling at highway speeds instead of low speeds, it would have resulted in an uncontrollable, catastrophic collision. Yes. The problem was physically confirmed and documented by an independent, EV-certified repair facility (EVFixMe/Shocker Motors in Costa Mesa, CA) once the vehicle was placed on a lift. The vehicle was physically inspected by an independent service center. The manufacturer (Tesla) was contacted via the Tesla App; however, they refused to perform a physical diagnosis without pre-authorization of a 2,600 comprehensive suspension replacement estimate and stated the vehicle was out of warranty with no open recalls. There were no dashboard warning lamps, digital alerts, or error messages from the vehicle's computer system prior to the failure. The failure presented suddenly as a loud, painful metal-on-metal grinding noise accompanied by immediate, severe steering misalignment. Currently waiting on invoice from indy shop.
Suspension, Feb 6, 2026
2018 Tesla model 3 front chassis subframe welded nut to the chassis is come off now left side control arm keep getting loose
Suspension, Feb 4, 2026
My 2018 Tesla Model 3 started squeaking at 36k miles at the end of 2023 (5 year old) I took to the Tesla service center where they quoted me $570. The squeaky control arm issue in Tesla is well known on the internet with may forums complaining about it. Not sure if there is a safety issue but wanted to report this incase there is a pending case regarding this issue. I was happy to pay for parts but the $570 seem excessive for a 5 year car that had 36k miles.
Steering, Suspension, Jan 30, 2026
The front control arms are creaking and I’ve read that many of models built in 2018 have this problem as well. It is unknown if it is a safety concern or not.
Suspension, Jan 8, 2026
I purchased this car new in 2018 and recently replaced the front lateral suspension arm due to worn bushings. During the process, I discovered that one of the 14 mm bolt threads on the right side of the suspension arm had a helicoil inserted. While removal was straightforward, reinstalling the bolt proved difficult. I spent several hours reattaching it to the new suspension arm, but did not apply full torque, as I was concerned about damaging the helicoil or stripping the thread. My main concern is that the factory has stripped the original thread and used a helicoil instead of replacing the affected part. Although the repair has held so far, I am unsure if this is a safe long-term solution, as the helicoil could fail while driving. I contacted Tesla, who advised me to visit their service center. At the Centinela location in Los Angeles, the supervisor informed me that, since the warranty has expired, they can only perform a visual inspection.
Suspension, Jan 6, 2026
The front suspension began having grinding noises. This was especially pronounced during turning at low speeds. At 58k miles. Tesla charged for having a tech ride along. They then did a front suspension investigation and said the following parts all were damaged and required replacement. Lower Compliance Links Lower front suspension links Lateral links Subframe assembly It would be consistent with the following recall on the bolt which attaches the lateral link to the subframe [XXX] The make, model and manufacture time align with the recall. Tesla did not provide the damaged parts. Cost was in 4982.91 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Suspension, Dec 17, 2025
The front suspension control arm was completely detached due to unfastened bolts. While this happened on the parking lot at low speed, such detachment at highway speed would certainly lead to major damage, loss of control and injuries or death to the driver. Pictures attached show that the bolts did not have any thread lock applied and simply unscrewed themselves due to vibration. The vehicle was brought to Tesla service, where the owner was charged $3700 for repairs. The customer's complaints that this is a structural/manufacturing problem were ignored by Tesla representatives.
Steering, Suspension, Wheels, Oct 31, 2025
We noticed that one of our tires was leaning inwards and the alignment was completely shot. There was no event that caused this but just noticed it one day driving. After having to replace two new tires, we took it into the Tesla dealership and they found that the control arm and suspension as well as the frame underneath is broken. The car has a clean tittle and this problem use to be covered by Tesla but for some reason now is not and this is a big steering and safety issue! We should not be responsible for the cost to fix the car if this has happened so often in the past!
Steering, Suspension, Power train, Oct 21, 2025
The front upper control arms on my 2018 Tesla Model 3 have failed multiple times, producing loud clunking, popping, and binding noises during steering. The issue has worsened and poses a serious risk of loss of control while driving. Tesla replaced these parts under goodwill in the past, but the failures have returned. The most recent incident occurred around 03/05/2025 at approximately 106,867 miles. The failure has been confirmed and documented by Tesla Service Centers, and I have multiple invoices showing repeated replacements of the same components. The problem directly affects steering and suspension safety.
Suspension, Sep 28, 2025
Front suspension creaking noise, took in for service, techs ultimately found the front subframe captive welded nuts that secure the front links had sheared off, requiring a replacement of the subframe and some other suspension components. Nuts, which were initially welded to the subframe during assembly, were loose on both sides. No associated damage or impact, normal use over 7 years of ownership. This is also a common issue, and is already associated with a very limited recall (21V-835) but for whatever reason, this failure is still occurring quite often in the wild - normally with far more extreme consequences than in my case.
Suspension, Sep 18, 2025
The first time the lower Lateral Links on the front right side just broke and luckily it didn't happen on the highway with passengers Right now I hear the same noises again coming from the driver's left side from the lower Lateral Links I am afraid that it will happen again and that’s really scary I drove many cars before and never felt so unsecured I don't understand how such a safety problem is not being addressed. I hear and read that other Tesla owners are also reporting the same problem.
Suspension, Sep 9, 2025
The front passenger side upper control arm is squeaking and causing vehicle to drift to right, vehicle only has like 60k miles and the upper control arms have been replaced by Tesla before
Suspension, Jul 23, 2025
The contact owns a 2018 Tesla Model 3. The contact stated that while his wife was driving at slow speeds, after completing a right turn, there was an abnormal sound coming from the front passenger’s side suspension. The contact stated that increased effort was required to maneuver the vehicle. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that the passenger’s side control arm had disconnected. The contact was informed that two bolts that secured the control arm to the frame were missing. The contact also stated that the bolts were found by the tow truck driver while loading the vehicle for towing. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 95,000.
Suspension, Jun 25, 2025
My car started having loud noises and suspension on both side of my car started making noises and both control arms along with sway barrings and struts are gone bad.
Suspension, Lane departure, Jun 23, 2025
Front suspension creaking & rattling going over bumps Tesla took days & days & never called me w/ problem I kept calling in!! Finally decide it is a KNOWN recall problem w/ Suspension bolts & sub frame! They told me they torqued them & would test drive for noise & I never heard from them! I had to call in. Suddenly I had a $4200 estimate for repairs including $322 1.24 hours of diagnosis??? A known problem other 2018 Tesla’s have been recalled for ??? Very suspicious?? How do I know they didn’t torque it too far & strip bolt themselves??
Steering, Suspension, Wheels, Jun 4, 2025
The bolt/fastner holding the control arms almost backed all the way out. I was driving and heard metal sound it got worse on the drive home. I also noticed the alignment to get worse and when I got home I looked and the bolt/ fastner almost came out. There is a tesla recall for only a small percent for my year with that issue. Tesla wants 4k to replace it. It is a huge safety issue. I have a family and it could have been serious if it detached not only to me and my family but other vehicles other pedestrians.
Suspension, Other or unspecified, Apr 18, 2025
Front suspension is making very weird and loud noises. Issue is associated with the front suspension links becoming loose.
Steering, Suspension, Mar 20, 2025
While regularly driving I experienced a gradual squeaking sounds from the front suspension. A few moments later I noticed that my steering wheel was acting as if it didn’t have power steering. I’m lead to believe that due to the poor design of my Model 3, that the outside elements were easily able to make its way to my Universal power steering shaft leading Tesla to remove and replace my steering shaft and my Upper control arms as well. The rust on the U shaft was incredible, I’ve only driven in the snow one time and immediately the noises starting happening. I paid everything out of my own pocket due to the undeliverable conditions my steering wheels was in.
Steering, Suspension, Feb 20, 2025, crash
Right front upper control arm began making noise and was replaced under warranty at 42k miles in Sept 2019. Left front upper control arm failed around 50k miles and caused a wreck resulting in $8,365 in damages in April 2021. When fixing one side it is standard to replace the other and Tesla was negligent. Upon fixing the left side suspension at Blue Ash Auto Body in 2021, the brake caliper came loose while driving on the highway while on a vacation. This caused an additional $1500 or so in charges. Both of these incidents put my life and my son's life in danger. About a week or two after the caliper problem, Tesla issued a recall for that part stating that it is now single use only.
Suspension, Jan 29, 2025
Vehicle Information: Make: Tesla Model: Model 3 Mid Range Year: 2018 VIN: [XXX] Mileage: 60,000 Issue Description: My 2018 Tesla Model 3 is experiencing premature wear of the front upper control arm ball joints and lower links at only 60,000 miles, despite the sealant fix from Tesla Service Bulletin SB-20-31-006 being previously applied. This premature wear suggests a defect in materials or design and poses a potential safety risk due to compromised handling. Request: I would like some information on the current situation, if tesla has already told their stance on the issue, if I qualify for any coverage even out of warranty. Anything that can help others when their suspension front goes out extremely prematurely. Contact Information: Name: [XXX] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Jan 28, 2025
The car started making a strange high pitched creak sound whenever I would turn the steering wheel, or go over bumps in the road. I brought the car to Tesla and they informed me that the following parts needed to be replaced. 1. Front Lower Compliance links (left and right) 2. Front Lower Lateral Link (left and right) I was notified that the failure of those components was a potentially serious safety issue, and that the parts needed to be replaced as soon as possible. I had Tesla replace the parts, so the issue cannot be inspected. The problem was verified by the Tesla Service Center, and was not seen by any other professionals. There were no real warnings, other than the annoying squeak sound whenever the sterring wheel was turned. The sound first appeared in November of 2024.
Suspension, Jan 22, 2025
The front suspension lateral link on our Model 3 came detached from the subframe as the bolts someone loosened. This is a known issue and Tesla has issued a recall (NHTSA Recall No: 23V-235) on this year Model 3, but our VIN is not included in the recall. It seems that this issue is wider than the cars the original recall has included. Upon detachment, the wheel steering did not work, and if it highway speeds, could have cause a fatal accident.
Suspension, Jan 10, 2025
The suspension on this car developed a persistent noise that worsened over time, prompting me to schedule a service appointment at the Tesla dealership. Although my car has less than 40,000 miles and has been driven primarily on well-paved city roads, both front suspensions were found to require extensive repairs, a final bill of approximately $2,100. Safety Concerns: Frequent Suspension Issues in Teslas: Online research and data from the NHTSA indicate a disproportionately high number of suspension and steering complaints for Tesla vehicles. In 2023, Tesla owners filed over 260 complaints, significantly higher proportionally than Toyota, despite Tesla's much smaller sales volume. Such trends suggest potential systemic quality issues in Tesla’s manufacturing process. Simultaneous Suspension Failure: The need to replace multiple components in both front suspensions at just 30,000+ miles raises serious questions about the reliability and safety. A single suspension failure could be a bad luck, but simultaneous failures point to broader design or manufacturing problems. Risk of Accidents: Suspension failure compromises vehicle control, increasing the risk of accidents that endanger drivers, passengers, and others on the road. Transparency Issues in the Repair Process: The initial repair estimate of $200 excluded labor costs and was revised to $400 without prior clarity. After inspection, the cost escalated to $2,100, leaving me no option but to approve the repairs without the ability to verify their necessity. Lack of transparency in repair recommendations, coupled with Tesla’s track record of suspension complaints, undermines customer trust and raises concerns about the integrity of the repair process. In conclusion, my experience highlights potential safety risks and quality control issues with Tesla vehicles. Suspension defects not only burden customers with significant costs but also pose a serious hazard on the road.
Suspension, Structure, Jan 2, 2025
The contact owns a 2018 Tesla Model 3. The contact stated that on several occasions while making left or right turns, there was a loud clanking noise emanating from the front of the vehicle. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the lower control arm bushings had deteriorated and needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer several months later where it was diagnosed that the bushings and one of the well nuts had sheared off, and the subframe needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.