2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints
1,025 reports, newest first.
Air bags, Mar 11, 2024
Two recent incidents/repairs related to both driver and passenger Curtain Airbag, replacement of Occupant Classification System, replacement of first row seat cushions, first row harness assembly, first row occupancy sensor, first row seat belt reminder sensor box. Total out of pocket cost of approximately $2,075!
Seats, Mar 11, 2024
Front passenger safety restraint system fault message due to workers not torquing the seat belts into place correctly or properly verifying specs during build.
Electrical system, Back over prevention, Mar 8, 2024
The contact owns a 2018 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention), 23V838000 (Electrical System), and 24V051000 (Electrical System); however, the dealer stated that to perform the upgrades, the contact needed to purchase a new computer before the software could be updated. The contact called the manufacturer and was informed that it would be necessary to complete the updates. The contact stated that the manufacturer was unreasonable in determining that to complete the software updates that he needed to purchase a new computer. The contact stated that the back over prevention camera image intermittently was blank. Additionally, the on-board cabin camera ceased to function as needed, causing the autosteer feature to become inoperable. The failure mileage was approximately 130,000. Parts distribution disconnect.
Air bags, Mar 7, 2024
First. the car gives Front Restraint System Fault message and Tesla fixed during warranty. No, it's out of warranty, and the car starts giving Front Passenger Restraint System Fault warning message. Regardless if it's under warranty or not, restraint system fault (I take it as seat belt) imposes safety concern and should be a recall item.
Air bags, Mar 3, 2024
Front passenger airbag and Seat sensor issues. The safety of front seat passenger was at risk due to faulty airbag or sensor. Tesla did confirmed that an alert was trigger on the car an they proceeded to replaced the airbag and sensor. Tesla verified the equipment after the repairs were done and everything since to be fine. We did get a warning on or around Feb 5th, 2024 and that when we proceeded to contact Tesla service and make an appointment. The reason for this complain is that we ended up paying for airbag and seat sensor repairs which should have been covered by Tesla since these parts are obviously defective. Please see uploaded documents for more details.
Power train, Electrical system, Other or unspecified, Feb 26, 2024
PTC Heater failed. This is a critical component that helps to maintain the battery's temperature within safe operating range. The only alternative is to replace this PTC Heater. Till the replacement is done, EVs battery may not maintain safe operating temperature range and could cause the car - not drive able. I consider this a significant safety risk. Cabin temperature cannot be maintained as well. Cause for PTC Heater failure is known - "change in temperature" could cause this item to fail per Tesla. i.e. when cold air blows over the heating element. Not sure if enough has been done to fix this from occurring for such a critical component with some hardware or hardware recall for several vehicles on the road. Else these cars must be considered for sales only for few states in the USA which have a stable operating temperature ranges for their PTC heaters to not run into the risk of failure due to big change in temperature.
Power train, Electrical system, Feb 25, 2024
The High Voltage Service Panel is part the battery which is part of the manufacturer warranty and drivetrain. A lot of Tesla cars had this problem and they are being charged $1800 to $2000 to “fix” this common failure. The problem is that the battery stop receiving the full amperage to charge the battery appropriately. In my case, I started charging more frequently on Superchargers during a long trip to different locations without a Level 2 homecharger and stopped several times into the Superchargers of Tesla. A diagram of the drivetrain and Battery system placed the High Voltage Service Panel as part of the battery. I had the problem since the past 2 years and did not fixed it, after I was sent an estimate cost of “repair”. I said that it was part of the battery system and they refused to accept it. As of 2024, I have search about this problem and most of the cars after 3-4 years are having the same problem. I am not sure what the repair consist of, but it might be a full battery replacement, and maybe opening the battery unit. In terms of safety, I feel unsafe about the possibility of the car catching fire during a supercharger session or even when plugged into my house Level 2 charger at 220 volts. Please inquire more about this frequently ongoing problem and safety, or any TSA related to this common issue. I included a picture found on the internet and the service panel is just on top of the battery
Other or unspecified, Feb 24, 2024
Horn stopped working. I see other people have this problem with Model 3. Tesla does not cover this after warranty period.
Other or unspecified, Feb 20, 2024
The rear camera often fails. Does this mean it is recording or not when driving. I think Tesla should have fixed this rear camera harness recall. I have been waiting over two years for this fix. It has been too long. Safety issues backing up or driving without the rear camera working properly.
Electrical system, Other or unspecified, Feb 20, 2024
The steering wheel horn stopped working about a month or so ago. I can use the Tesla app to make the horn sound but not by pressing the steering wheel. Fortunately, no safety of others or myself have been experienced. No one else has inspected it yet, though I am due to have my state inspection tomorrow and I don't think that it will pass. There were no warning lamps for messages prior to the failure. I think I first noticed that it wasn't working about a month or so ago. I reported the bug on the car texting service but have not heard from Tesla nor received a software update to fix the problem.
Seats, Feb 19, 2024
Get an error message - Front Passenger safety restraint system fault. - This is front passenger safety issue - This can put the front passenger to serious risk to injury or death - This message does not go away & Tesla acknowledges they need to fix it - Its not been inspected by police or insurance reps - Yes there is a warning message as noted above Tesla is failing to admit its their fault. They are giving me a quote of $2300 to fix this issue which I believe is a safety issue that Tesla did not manufacture properly leading to this issue. Please see the attached quote from Tesla - They need to "Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat" and many other related fixes to get rid of this issue. TESLA SHOULD BE RECALLING VEHICLES FOR THIS SAFETY ISSUE!
Power train, Electrical system, Forward collision avoidance, Feb 15, 2024
I don’t feel comfortable driving this car because it is unsafe when I am on autopilot on the highway it would randomly stop the car by breaking instantly out of nowhere when there isn’t any car in front of me?! Please give me another car that is more safe to drive!?
Electrical system, Feb 14, 2024
Vehicle touch screen will shut off while driving and take 5 minutes to reboot. I have taken it to Tesla multiple times since November and they said it’s a firmware issue and nothing is being done to resolve.
Electrical system, Forward collision avoidance, Lane departure, Feb 14, 2024, crash
While in FSD the car swerved to the left and hit a Tree. Youtube of the Crash.. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Wheels, Feb 13, 2024
Tesla Model 3 Performance (M3P) comes with unrealistic "thin" wall tires on 20" wheels that easily POP when they hit potholes, nails, gutters, median divides, gashes in the road, etc. American roads are poorly maintained if at all by transportation departments. Only thick walled tires are suitable for roads. Tesla Model 3 LR (Long Range) and SR (Standard Range) comes with 18" wheels and tires, giving it 2 inches more of padding for both a smoother ride and fewer replacements. Each tire on my M3P costs $400-$500 to replace! That's around $2,000 for a set of four tires! Whereas 18 inch tires are more common and cost about half of that, about $200 per tire, $800 for a set. The remedy here is at least 19 inch wheel and tire replacements as a recall provided for free by Tesla to provide more padding and fewer tire replacements to deal with typical crappy roads.
Electrical system, Exterior lighting, Feb 13, 2024
The is WATER in my right front FOG lamp and I don't know how it got in there, but Tesla says they can't get water out of it and can't reseal it, but is willing to let me pay $504 to replace a light... this is yet another Billionaire abusive practice by Elon Musk to generate cash flow and revenue for his failing company. Telsa also asked for $15,000 for a new battery, which the "software" said it started reducing the range JUST after the 120,000 mile battery warranty was up. Just like Apple does with reducing iPhone battery performance for so called "safety" reasons to make people pony up to the latest model. Which Tesla has been emailing me and texting me to try to get me to buy a new Tesla LOL. This is clearly an abusive "sales tactic". If they actually care about helping customers, they would figure out how to fix each issue. Clear out the water and seal the headlight. Figure out which battery cells need replacing and replace them. Simple and cheap solutions. Not "customer pay astronomical prices" for every damn issue Tesla forces upon people. Including "customer pay tows" after "Tesla's software" decides to randomly shut the car down in the middle of the road, rather than Tesla taking responsibility for their software malfunctioning preventing the driver from reaching their destination. These are clearly misguided attempts by an AWOL CEO [XXX] about his $55B pay package, trying to claw back money from customers to reward himself to pay for Twitter/X. Make[XXX] Musk and Tesla do the right thing by customers and REPAIR these issues, rather than [XXX] poor customers' cashflow. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Forward collision avoidance, Lane departure, Feb 13, 2024
I got a recall notice from Tesla and Tesla is still in safety violation and is refusing to fix the issue, so I need your help to force Tesla to fix their abusive ways. The recall 23V-838 is related to "when Autosteer is engaged". Autosteer/Autopilot/FSD now DISABLES even when NOT engaged, alleging "improper use" when it wasn't even being used. It also disengages Autosteer/Autopilot/FSD while driving if it detects "improper use" (even if it's detection system itself is buggy), forcing the car to slow down like in the middle of the freeway! When the battery is low and there's only a mile or two to go to a charger, the software will slow down and force the car to pull over to get a tow, taking on average 2 hours to get a tow truck to go 2 miles, rather than allowing the driver to reach the charger with the remaining battery it shows. Tesla keeps changing the battery percentage for when it shuts down. It used to be 0%, then 3% and recently 6%. This randomness creates "range anxiety" and distrust in the battery percentage being a useful indicator. Tesla should use 0% as "shut down" and leave the rest of the battery as "drivable" to reach a charger to have an accurate indicator. It also flashes alerts on the SCREEN to "Pay attention to the road", which is ironic to have a screen display to distract attention to the screen... rather than pay attention to the road. Tesla took AWAY my Autosteer/Autopilot improperly, and no one in the Service Center or Support at Tesla knows how to fix this BUG or give it BACK to me, so I can drive SAFELY like with lane centering. I paid $10,000 for this "safety" that Tesla takes away at random, claiming they can do whatever they want because they've now labeled it BETA software! This is an abusive practice the NHTSA should force Tesla to stop doing and give the power back to responsible drivers like me. Tesla abuser names include [XXX] and [XXX] . Teslas also don't detect cars in blind spots and still phantom brakes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Feb 13, 2024
Full service history is detailed below. Since purchasing the Model 3 in April 2018, we have had three different instances of issues with control arms/suspension system. The most recent instance occurring this week (February 12, 2024) required the whole suspension system to be replaced with only 63,900 miles on the vehicle. The suspension system should not need replacing on a vehicle with only 63,900 miles on it. We have now had to pay Tesla $1,357.57 to continuously fix the issue with the suspension system on a car that is not even 6 years old with less than 64,000 miles on it. During an interaction with a Tesla technician for the second instance noted below, we were told that Tesla undersized the control arm leading to failures. He commented that they replace control arms on Model 3s on nearly a daily basis. This is clear negligence by Tesla and we would urge the NTSB to take immediate action. I know we are not the only Tesla Model 3 owners that have experienced control arm/suspension issues. Car Purchase Date: 4/7/2018, ~25 miles on vehicle Service Visit 1 on 7-23-2021 Odometer 42,790 Cause for visit: Creaking noise when turning or going over bumps Items replaced: 1) Front Upper Control Arm Left Parts = $0 (under warranty) Labor = $0 (under warranty) Service Visit 2 on 8-25-2022 Odometer 51,321 Cause for visit: Creaking noise when turning or going over bumps Note: Was told by service technician that Tesla undersized the control arm leading to failures. Commented that they replace control arms on Model 3's on nearly a daily basis. Items replaced: 1) Front Upper Control Arm Right Parts = $92.48 Labor = $0 Service Visit 3 on 2-12-2024 Odometer 63,898 Cause for visit: Car violently shudders when turning and felt like the front end side was going to collapse one time on a turn Items Replaced 1) 2x Lower Lateral Link Front - 2) 2x Lower Compliance Link - 3) Front Upper Control Arm Left Parts = $1019.99 Labor = $245.10
Seat belts, Feb 13, 2024
On Feb 12 2024 the error code RCM_a021 appeared. “Front left safety restraint system fault Service is required.” The service center confirmed that it was an issue related to seatbelt safety during a crash. They said “The specific part that would fail in this case would be the seatbelt pretensioner. When in an impact this deploys and pulls the seatbelt tightly against the driver. This will likely not deploy in an accident if not repaired as the wires going to this component are broken. We are replacing it with a new updated part that will not wear and have this same issue.” Although a known safety issue, it was NOT a repair under warranty. I am putting in this claim and appeal that it should be an under warranty repair. Parts and Labor for 1 seatbelt assembly replacement would have been $450. As it is a known safety issue, I opted to proactively repair both front seat seatbelt assemblies so the cost increased to $650. The cost estimate is attached. Also attached is the text communications with Tesla service center.
Electrical system, Feb 9, 2024
A charging warning error msg appeared that there maybe something wrong with the cable leading to charging the battery and may lead to a fail charging and this the 2nd time. The first time I had a failed charging with no warning that it was failing amd that lead to the entire battery wouldn’t charge leaving me stranded and the car had to be towed to a Tesla service center., this time 02/08/2024 it’s sending me a notification that there is something wrong internally and I need to see service asap so this time it did send me a msg warning me there’s something wrong
Suspension, Wheels, Feb 8, 2024
Clunk and popping sound while driving, especially while turning the wheel or going over bumps in road. Maneuverability and control of vehicle felt impacted which could have resulted in an accident, damage to property, and injury and/or death of people. The issue was reproduced at the vehicle's Service Center and identified as a lose bolt that connects the front suspension lateral links to the subframe. This issue sounds very similar to a previous recall for the same make, model, and year of this vehicle, but the VIN for this particular vehicle was not included in that recall.
Seat belts, Feb 7, 2024
I was driving when I received a service prompt on my Tesla Model 3 stating that there was a fault with my front passenger safety restraint. When I looked around the area, I noticed that the cable securing my seat belt to the vehicle was sticking out of the enclosure by about 6 inches. The car has not been involved in any violent collisions and the seatbelt has not otherwise been abused in any way. The car only has 23,163 miles on it.
Electrical system, Seats, Other or unspecified, Feb 7, 2024
My bluetooth has not been connecting in my car. To preface this, my car was in twice this year alone, with a near $3000 bill, to replace the MCU, on a car with only 26k miles. Now this bluetooth connection issue is still a problem. After opening a service ticket with Tesla, I am told for an additional $180, I would need to replace my seat sensor. This means my seat (while I am driving) does not recognize that someone is on it and driving. My concern is the manufacturer remedy does not replace failed parts with improved design and that this has the potential to cause other safety issues if occupant detection compromised by faulty sensors. What if I am in an accident and the airbags don't deploy?
Steering, Feb 6, 2024
The steering of my model 3 became more difficult and clunky like I had to apply extreme amounts of force to turn. When I turned the wheel I could feel the wheel stop in each gear or grove of the steering mechanism. It got so bad at freeway speeds of 75 mph that it became extremely difficult to keep the car going in a straight line. As described before I would apply very heavy force to the wheel to turn it, when it did turn I would feel it clunk into the next stoping point and I would have to clunk back and forth this way to keep it going in a somewhat of a straight line. There was on time while using Full self driving on the freeway at 75 mph on a turn the full self driving was not able to turn the wheel and almost ran into the cement barrier. I was able to take control of the wheel and correct the car as soon as I saw the car cross the solid line. I took my car in for repair at the Tesla service center October 2023. I was charged $5k to replace the full steering unit in my 5 year old car at that time. I have owned 14 vehicles over my years of car ownership, vehicles age ranging from 1984 - 2018 and I have not once ever had to replace the full steering unit for any of those cars.
Structure, Feb 2, 2024
The rear bumper fell off on [XXX] on the [XXX] of the [XXX] bound for [XXX] toward Long Beach Airport when driving in the rain through a puddle of water. It’s a serious safety hazard for the model 3 and the cars behind. This is a widely reported known design flaw, but Tesla refused to cover the repair cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)