2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints
1,025 reports, newest first.
Suspension, Aug 19, 2026
On July 10, 2026, while driving, I started to hear a rattling metal noise coming from under the right front side of the car. When making turns, the noise gets louder, less when driving straight. When I got home, I looked under the car and found a large metal piece hanging down adjacent to the right front tire. When the Tow Truck came to pick up the car, the right front tire started to get loose aiming to the right. Took the car to a Tesla Service Center and a new Correction Links - Lateral - Lower Front - Pair (Remove & Replace) Remove and Replace.
Forward collision avoidance, Aug 16, 2026
After Tesla pushed software update 2026.20.6.11 or “FSD 14 lite” the self driving feature stopped functioning. Also all of the driver assistance safety features stopped working at the same time, forward collision warning, emergency braking, lane keeping assist, adaptive cruise control, blind spot detection have all stopped working as well. It appears one of the two “self Driving” ECU was damaged or disabled by the update. Without these features the drive is not notified in advance of a collision and the emergency braking does not function to stop the car. The car is awaiting inspection and repair by the manufacturer.
Suspension, Power train, Aug 15, 2026
I am reporting a front suspension failure on my 2018 Tesla Model 3 Dual Motor, that appears relevant to NHTSA Preliminary Evaluation PE26006 and similar to Recall 23V-235. While driving slowly in a parking lot, I heard a clunk and felt the front wheel/steering alignment become slightly skewed. After entering the highway, the vehicle developed severe vibration and became unstable and difficult to control. I exited and stopped as soon as safely possible. While attempting to park it at a curb, during reverse, the suspension entirely collapsed and left front wheel was then severely displaced and the tire was rubbing the wheel well. Tesla inspected the vehicle and confirmed: “The left lateral link was found detached with missing hardware.” Tesla also found the left front halfshaft detached from the drive unit. Tesla replaced the front subframe, both front lower lateral links, both front lower compliance links, the left front halfshaft, and performed an alignment. Total cost was $6,328.96. The failed parts were replaced by Tesla; I do not know whether they remain available for inspection. This failure created a serious risk of loss of vehicle control at highway speed and could have endangered me and surrounding traffic. The problem was confirmed and inspected by Tesla Service. There was no collision or other discrete impact event that I recognized as causing the failure. There were **no warning lights, warning messages, or other vehicle alerts before or during the failure**. The first noticeable symptom was the clunk in the parking lot, followed by the skewed steering/wheel position and later severe highway vibration. I have pre-repair photos showing the displaced wheel, tire contact, and detached suspension component, as well as Tesla’s final repair documentation. I request that this incident be considered in connection with PE26006 and Recall 23V-235.
Power train, Service brakes, Aug 14, 2026
Description of the Safety Defect:My 2018 Tesla Model 3 AWD suffered an abrupt and catastrophic total loss of mechanical braking power while driving. The brake pedal went completely soft, and the vehicle lost hydraulic pressure.An independent mechanic inspected the undercarriage and confirmed that the factory steel hydraulic brake lines completely rusted through and ruptured, leaking all brake fluid from the system. This vehicle has 142,905 miles and has been operated in regions that use winter road salt.Tesla is aware of this severe corrosion defect under Service Bulletin SB-26-33-001, but they have categorized it as a service bulletin rather than a safety recall. A factory brake line rusting through to total fluid failure is an extreme and immediate safety hazard to occupants and the public. Furthermore, the vehicle simultaneously threw a "Front Motor Disconnected" warning. A federal investigation and mandatory recall are urgently required to ensure Tesla replaces these defective lines for all affected owners before a fatal accident occurs.
Air bags, Aug 13, 2026
Front Passenger Safety Restraint error This seems to be a faulty component on many Teslas and therefore is a design or manufacturing flaw. Several of my personal vehicles of different models and years have had the same issue so it's not just something that has worn out or been damaged by myself. As this involves the action of the airbag, it is an extreme safety concern and Tesla should recall this part and replace. Also, in attempting a critical safety repair, I had to drive for weeks without an airbag before they would fix.
Suspension, Aug 12, 2026
While driving, I noticed that the vehicle suddenly began pulling to the right. There were no warning lights, warning messages, or alerts displayed on the vehicle's screen before I noticed the problem. I took the vehicle to the Tesla Service Center and reported that the vehicle was pulling to the right. The service center determined that the issue was likely related to the front suspension and recommended replacement of the front lower lateral links, front lower compliance links, and front upper control arms, along with a four-wheel alignment. The vehicle had approximately 80,000 miles at the time of the repair. The service center explained that these suspension components can wear at higher mileage, particularly because of the weight of the vehicle and its battery. I paid out of pocket for the recommended suspension repairs and four-wheel alignment. The repair invoice is available for inspection upon request. Before the repairs were completed, I was driving the vehicle without knowing that there was a potential problem with the front suspension. The vehicle pulling to the right affected its handling and steering and created a safety concern for me and others on the road. There were no warning lights, messages, or other indications from the vehicle alerting me to a potential suspension problem. I was also not warned by the Tesla service center that the issue could be related to a known or potentially widespread suspension problem. A few days after having the repairs completed, I became aware of an NHTSA investigation concerning front suspension issues involving Tesla vehicles, including the same make, model, and model year as my vehicle. I had already paid out of pocket to have the affected front suspension components replaced. I am submitting this complaint to document the suspension problem, the safety risk I experienced, and the out-of-pocket expense I incurred to correct the issue. I am concerned that I was placed at risk by a potential su
Air bags, Aug 11, 2026
The vehicle displays a critical 'Front Passenger Safety Restraint System Fault' warning on the dashboard, indicating that the airbag system may not function as designed in a crash. After googling the error code, it appears to be isolated to either frayed wiring harness under the seat or the faulty Occupant Classification System sensor. The issue occurred on June 11 and again on Aug 11 while driving the car. The warning appeared intermittently and I tried to "reset" the car computer. Tesla Service has diagnosed the issue as wiring harness failure/sensor failure and quoted $3000 for repairs, claiming it is out of warranty. This is a safety-critical system failure that poses a significant risk of injury or death to front-seat passengers due to potential airbag non-deployment. Given the high frequency of this specific failure across the Model 3 fleet, this appears to be a design or manufacturing defect rather than normal wear and tear. I am requesting an investigation into this safety defect.
Suspension, Aug 10, 2026
Lots of creaking and grinding noises coming from both front upper control arm bushings. Steering starting to become less stable.
Forward collision avoidance, Aug 5, 2026
I getting the Tesla phantom braking almost every week.
Suspension, Aug 3, 2026
When driving in a parking lot a bolt came out on the drivers side suspension. The body of the car dropped on the tire and I could no longer drive the car. I was only going about 5mph but if I was going faster I can see this putting somebodies safety at risk. When I took it to Tesla they said is was not under warranty and had me replace the lower lateral link on the driver and passenger side of the vehicle. There were no warning lamps that came on.
Suspension, Aug 2, 2026
I am filing this complaint in direct relation to NHTSA Preliminary Evaluation PE26006 regarding Tesla front suspension lower lateral link failures. I am the owner of a 2018 Tesla Model 3. On XXX, at approximately 101,728 miles, my vehicle experienced a severe suspension issue. The vehicle began producing a loud, frequent squeaking and rattling noise originating from the front passenger-side wheel area while driving under 40 mph. Due to the clear mechanical risk and safety concerns associated with a suspension failure, I brought the vehicle to the Tesla Service Center in [XXX]. Tesla technicians diagnosed the problem and confirmed a failure in the front suspension. The repair required the complete removal and replacement of both front lower lateral links (Tesla Part Number: 1044341-00-E) and accompanying hardware. Because the vehicle was past its standard warranty mileage, I was forced to pay $1,291.75 out of pocket for the total repair, which included $583.68 explicitly for the lower lateral link parts and associated labor/alignment. While my lower lateral link did not completely separate while driving at high speed, the component failed prematurely and exhibited the exact structural degradation currently being investigated by the NHTSA Office of Defects Investigation. I have retained the official Tesla service invoice (Invoice # XXX) to verify this failure, the diagnosis, and the out-of-pocket repair costs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Aug 1, 2026
Car suspension failed on front driver wheel. Lower lateral link failure. Car was not drivable. Car towed and fix for $4k.
Steering, Suspension, Aug 1, 2026
Concern: Suspension Noise - What location is the noise coming from? Front. Suspension or Steering. What best describes the issue? Noise from suspension when driving on uneven roads. Repair Notes: Inspected Front Suspension for Activity 01 (Front suspension noise). Found torn bushings on Front Lateral Links and Compliance Links. Heavily torn on LH side. Safety concern. Both LH and RH Front Lower Compliance link and Lateral Links replacement recommended. Wheel alignment required for Lateral Link replacement.
Suspension, Jul 31, 2026
Lower links replaced ~69k miles due to squeeking
Steering, Suspension, Jul 31, 2026
The contact owns a 2018 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the vehicle was shaking uncontrollably. The contact pulled over and had the vehicle towed to the dealer. The dealer determined that the front control arm had detached from the front passenger’s side wheel. The dealer replaced the front control arm, lateral link, and steering column. The contact stated that there was no impact to the vehicle to have caused the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 76,000.
Electrical system, Air bags, Seats, Jul 26, 2026
Component/system: The front passenger Occupant Classification System (OCS) in my 2018 Tesla Model 3. The vehicle is available for inspection on request. Description of the failure: The vehicle intermittently displays "Front passenger safety restraint system fault — service required]" on the center touchscreen. The alert first appeared on or about 4 years ago and has recurred approximately ~50 times since. The failure is strongly correlated with cabin temperature. It appears after the vehicle has been parked in direct sun in warm weather, and clears on its own once the cabin cools. It has not occurred in cooler ambient conditions. Safety risk: On this vehicle the front passenger seat uses a capacitive Occupant Classification System rather than a simple occupant-detection pad. The restraint control module uses OCS output to determine both whether the passenger airbag deploys and at what force. When the system faults, I have no way to know whether the passenger airbag is suppressed, will deploy at an inappropriate force for the occupant, or will deploy at all. This directly compromises frontal crash protection for anyone in that seat. I have been avoiding seating passengers there as a result. Inspection and confirmation: The vehicle is outside the basic warranty. Per Tesla's own service documentation, the passenger-side OCS sensor is not individually serviceable; the remedy requires replacing the seat cushion assembly and running a proprietary calibration routine that requires a cabin temperature near 68°F. The vehicle has not been inspected by police, insurance, or any independent shop. Prior warning symptoms: The touchscreen alert described above is the only symptom. There was no prior indication. There is no open recall for this condition on my VIN. Given the number of similar owner reports and the cost of the remedy, I believe many affected vehicles remain unrepaired and in service.
Parking brake, Jul 20, 2026
The rear passenger side break would not release. Had to be towed because the vehicle was non operational.
Suspension, Jul 18, 2026
As I was backing out of the driveway I heard a strange noise and the steering started feeling crunchy. I parked the car and when I got out I saw a very large bolt on the ground that appears to have dropped out of the car. This seems to be the same issue as described in safety recall 23V-235. Tesla is saying my vin isn’t included and not covered despite the safety recall expiring including this manufacturing date range.
Electrical system, Air bags, Other or unspecified, Jul 13, 2026
Vehicle displayed a “Safety Restraint System Issue - Service Required” alert (fault codes RCM_a056 and RCM_a032). Tesla diagnosed an open circuit between the driver-side curtain airbag and the left airbag controller, requiring replacement of the left body harness. Tesla quoted approximately $1,800–$2,200 for the out-of-warranty repair. This is a known, recurring pattern — multiple other 2018 Tesla Model 3 owners report experiencing this identical fault at nearly the same mileage (~78,000 miles), suggesting a design or component wear issue rather than isolated damage, similar to a prior Tesla trunk-harness recall (NHTSA campaign 21V-00D) that also stemmed from a wiring/harness defect on this same vehicle. I am requesting NHTSA investigate whether this represents a safety-defect trend warranting a recall.
Latches/locks/linkages, Jul 9, 2026
The contact owns a 2018 Tesla Model 3. The contact stated that while driving on a highway at approximately 70–80 MPH, the hood latch failed, causing the hood to unexpectedly open and strike the windshield, obstructing the driver's visibility. Both the hood and the windshield were damaged. No warning lights illuminated and no unusual sounds occurred prior to the failure. The contact was able to safely pull over to the shoulder of the road. The contact temporarily secured the hood using tools kept in the vehicle and drove to the residence. An appointment was scheduled with a Tesla Collision Center for inspection and repairs. The manufacturer was notified of the failure and referred the contact to the collision center. The failure mileage was approximately 58,700.
Exterior lighting, Air bags, Jul 8, 2026
In the last 18 months I have had 8 service visits relating to electrical issues. In the last 30 months: - I had my car computer replaced after it shorted out, and then had to have it replaced again the next week. - I had the same taillight short out twice in a row. - I have had the 12V battery replaced three times. - I have had multiple low voltage controllers short out over multiple service visits. - The sound system has shorted out once as well. - One time, I was unable to shift to drive because a heater had shorted out. Now, I have to replace my right headlight and passenger airbag occupancy sensor due to shorts as well. The right headlight goes out intermittently and the passenger airbag alert fires sometimes. Tesla Corte Madera submitted a buyback request on my behalf after witnessing all these issues, but Tesla corporate denied it. I am sure the electrical issues will continue to affect the safety and drivability of my car. Thank you for your help.
Seat belts, Jul 7, 2026
The contact owns a 2018 Tesla Model 3. The contact stated that while driving at various speeds on multiple occasions, the message "Front Left Safety Restraint System Issue RCM_a021" was displayed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 102,000.
Suspension, Jul 3, 2026
My car experienced a loud clunking noise when turning for the past few weeks. After doing some research and inspecting behind the front right tire, I found a front suspension lateral link bolt nearly falling off. It was only being held on by a few threads. It was so loose I could unscrew it completely or tighten it more by hand with no resistance. It sounds related to an existing recall for 2018 Tesla model 3’s (my year and model), but my car is not included in the recall. The other joints around it appear prematurely worn as well. See picture to show exactly how loose it was upon inspection. Requesting to review and likely expand the existing recall to more 2018 Tesla Model 3s
Seat belts, Jun 27, 2026
Tesla notification that front left safety restraint system has an issue. Service is required. Who isn't going to take their car in when there is an alert saying the safety restraint system has an issue. Then $232 in parts and $484. in labor. After taking in it was diagnosed that seat harness being pinched against the outboard shield causing the pretensioner to fault. Need to replace the seat harness and the pretensioner. Ended up being $232 in parts and $484 in labor. My safety was at risk because this system affects the seatbelt and airbags. Problem was diagnosed, confirmed, and repaired at my cost. Tesla dealership inspected. Thousands of tesla owners repairing at their own cost- maybe should be recall.
Suspension, Other or unspecified, Jun 23, 2026
My vehicle should've been included in a recall. While exiting my garage to pick up my son from school, a loud mechanical banging noise came from the front of my car. I abruptly stopped and proceeded to reverse back into my garage to inspect my vehicle. While inspecting my vehicle and the surrounding area, I discovered a large bolt on the ground. A quick image search says "on a Tesla Model 3, this specific high-strength 10.9 Class metric hex flange bolt is a critical structural component that almost certainly backed out of [my] front suspension lower control arm/ lateral link assembly or the front subframe structural mounts." So the loud banging noise came from my suspension falling apart after the bolt fell out. Upon further inspection, I confirmed that this was the issue and that a second bolt on the same side had partially backed out as well. My vehicle was not safe to drive, so I had to have my vehicle towed to the nearest service center for repairs. I took photos and video of the areas, as well as the bolt, which showed no signs of any damage to the head or threads - so the bolt simply backed out and appears to be a manufacturing/ assembly issue. After a quick search, we learned that there were previous NHTSA recalls (ie Part 573 Safety Recall Report 23V-235) for this particular issue, including for my same vehicle make, model, year (2018 Tesla Model 3) and production dates (Jan 5, 2018 - Mar 30, 2019). Unfortunately, I never received a recall notice. I barely drive my car, so bolts shouldn't just be backing out on their own. Unfortunately, my car is no longer under warranty, but was advised by the service managers to file a report and to get reimbursed thru NCDS. This is a huge safety issue. I had no warnings or alerts from the car. My alignment was checked a year ago. My wheels and tires get checked often and are well maintained, so I didn't even need air or rotation, yet my suspension just fell apart on its own before 60K miles.