2018 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 1,025 owner complaints filed for this model year. This is the highest complaint count among 9 Model 3 model years with reports.
Of the 2018 reports, 102 involved a crash and 4 involved a fire. 44 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Suspension, frontMar 31, 2023
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.
Campaign 23V235000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Back over prevention, display functionMar 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.
Campaign 22V169000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Electrical system, wiring, rear compartment/trunkDec 21, 2021
Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.
A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.
Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.
Campaign 21V00D000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Seat beltsMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Campaign 21V389000 on NHTSA.gov
Representative owner complaints
1,025 reports, newest first.
Electrical system, Air bags, Seat belts, Mar 28, 2025
RCM_a021 alert: Front left safety restraint system fault. Seems like an issue caused by seat movement back & forth.
Power train, Engine, Mar 27, 2025
On March 21, 2025, my Tesla Model 3 Long Range entered "Power Reduction Mode" — a safety feature that limits power to protect the high-voltage battery from overheating or failure. Tesla later diagnosed a coolant leak near the battery area. Their own service advisor stated in writing that the failure was “most likely related” to the battery’s thermal management system — the very system responsible for regulating battery temperature and preventing damage. Despite the connection to the battery protection system and the vehicle being under the 8-year/120,000-mile battery warranty, Tesla has refused to cover the repair. The issue remains unresolved, and I have not picked up or approved any repairs on the vehicle. My concern is that driving the vehicle in this state — or leaving this failure unaddressed — could lead to further battery damage or pose a safety risk. I am requesting that NHTSA evaluate this issue as a potential safety concern, especially as the manufacturer is refusing to repair a system directly linked to high-voltage battery safety.
Steering, Suspension, Mar 20, 2025
While regularly driving I experienced a gradual squeaking sounds from the front suspension. A few moments later I noticed that my steering wheel was acting as if it didn’t have power steering. I’m lead to believe that due to the poor design of my Model 3, that the outside elements were easily able to make its way to my Universal power steering shaft leading Tesla to remove and replace my steering shaft and my Upper control arms as well. The rust on the U shaft was incredible, I’ve only driven in the snow one time and immediately the noises starting happening. I paid everything out of my own pocket due to the undeliverable conditions my steering wheels was in.
Air bags, Mar 8, 2025
I received and indicator noting that my front passenger safty system has a fault. They indicated that they will have to replace the seat sensor and the airbag. I believe this to be an innate fault of the cars construction. It is dangerous and should be fixed by Tesla and not charged to the customer.
Forward collision avoidance, Lane departure, Mar 7, 2025, crash
October 12, 2024. I was using the Tesla on autopilot. I was in the far right lane and the freeway was curving to the left. The car was following in the lanes, but then all of a sudden it stopped following the freeway and drove into the right guardrail. There were no alerts by the car. It did not warn to take over the vehicle or attempt to avoid the collision. The car drove directly into the guardrail without warning and was totalled.
Air bags, Mar 2, 2025
This is a widespread safety issue that requires a recall! This is not isolated. Model 3 passenger airbags are at risk of not deploying. Car alert: Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat Remedy: “Replace Front Passenger Airbag And Update Vehicle Configuration”
Seat belts, Feb 26, 2025
Vehicle displays Front Left safety restraint system fault/Service is required
Seat belts, Feb 26, 2025
Vehicle displays Front Left safety restraint system fault/Service is required
Forward collision avoidance, Feb 20, 2025
Car performed automatic emergency braking on driver's resumption of forward travel from a full stop when traffic light went from red to green. No oncoming vehicles or obstacles were present. Weather was clear and sunny and road was dry.
Steering, Suspension, Feb 20, 2025, crash
Right front upper control arm began making noise and was replaced under warranty at 42k miles in Sept 2019. Left front upper control arm failed around 50k miles and caused a wreck resulting in $8,365 in damages in April 2021. When fixing one side it is standard to replace the other and Tesla was negligent. Upon fixing the left side suspension at Blue Ash Auto Body in 2021, the brake caliper came loose while driving on the highway while on a vacation. This caused an additional $1500 or so in charges. Both of these incidents put my life and my son's life in danger. About a week or two after the caliper problem, Tesla issued a recall for that part stating that it is now single use only.
Electrical system, Feb 14, 2025
Power Coversion System (PCS) failed on vehicle Causing issues with charging No User facing errors to alert of issues prior to problem (hidden in service menu) - preventing owners from claiming under basic 50k mile warranty. Stated as not part of HV Battery warranty and replacement is ~$2000 Advised to replace or could leave car unusable.
Steering, Feb 11, 2025
- component or system failed or malfunctioned - Front Subframe Structure (Part Number 1044521-00-J) - the part failed with my car at approximately 55,000 miles. When it failed, the car didn't alert any problem and continue to drive the full-self-driving mode. I only noticed that it was very dangerous the next day when I tried to take my car out of the garage. - the problem was diagnosed by Tesla Service center which I had to toll my car to them because it was unsafe to drive. - The vehicle or component was not inspected by police or insurance, because there was no accident. - There was no warning lamps or indication other than noise.
Suspension, Jan 29, 2025
Vehicle Information: Make: Tesla Model: Model 3 Mid Range Year: 2018 VIN: [XXX] Mileage: 60,000 Issue Description: My 2018 Tesla Model 3 is experiencing premature wear of the front upper control arm ball joints and lower links at only 60,000 miles, despite the sealant fix from Tesla Service Bulletin SB-20-31-006 being previously applied. This premature wear suggests a defect in materials or design and poses a potential safety risk due to compromised handling. Request: I would like some information on the current situation, if tesla has already told their stance on the issue, if I qualify for any coverage even out of warranty. Anything that can help others when their suspension front goes out extremely prematurely. Contact Information: Name: [XXX] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Jan 28, 2025
The car started making a strange high pitched creak sound whenever I would turn the steering wheel, or go over bumps in the road. I brought the car to Tesla and they informed me that the following parts needed to be replaced. 1. Front Lower Compliance links (left and right) 2. Front Lower Lateral Link (left and right) I was notified that the failure of those components was a potentially serious safety issue, and that the parts needed to be replaced as soon as possible. I had Tesla replace the parts, so the issue cannot be inspected. The problem was verified by the Tesla Service Center, and was not seen by any other professionals. There were no real warnings, other than the annoying squeak sound whenever the sterring wheel was turned. The sound first appeared in November of 2024.
Suspension, Jan 22, 2025
The front suspension lateral link on our Model 3 came detached from the subframe as the bolts someone loosened. This is a known issue and Tesla has issued a recall (NHTSA Recall No: 23V-235) on this year Model 3, but our VIN is not included in the recall. It seems that this issue is wider than the cars the original recall has included. Upon detachment, the wheel steering did not work, and if it highway speeds, could have cause a fatal accident.
Electrical system, Seat belts, Jan 20, 2025
Warning message appeared on center screen stating: "Front left safety restraint system fault". This appears to be a safety related problem , Tesla dealer wants $500 to repair because the vehicle is "out of warreanty" . This is the second Model 3 we have had. Previous version also experienced this fault. Is this a safety problem and if so should the car manufacturer be responsible to repair at no cost to owner? I have receoved a notice from NHTSA dated 5-31-2024 stating recall 24V376 may affect my vehicle - Seat Belt warning Sustem. I have not receoved a specific recall from tesla for this recall. Is it the same as the fault referenced above?
Suspension, Jan 10, 2025
The suspension on this car developed a persistent noise that worsened over time, prompting me to schedule a service appointment at the Tesla dealership. Although my car has less than 40,000 miles and has been driven primarily on well-paved city roads, both front suspensions were found to require extensive repairs, a final bill of approximately $2,100. Safety Concerns: Frequent Suspension Issues in Teslas: Online research and data from the NHTSA indicate a disproportionately high number of suspension and steering complaints for Tesla vehicles. In 2023, Tesla owners filed over 260 complaints, significantly higher proportionally than Toyota, despite Tesla's much smaller sales volume. Such trends suggest potential systemic quality issues in Tesla’s manufacturing process. Simultaneous Suspension Failure: The need to replace multiple components in both front suspensions at just 30,000+ miles raises serious questions about the reliability and safety. A single suspension failure could be a bad luck, but simultaneous failures point to broader design or manufacturing problems. Risk of Accidents: Suspension failure compromises vehicle control, increasing the risk of accidents that endanger drivers, passengers, and others on the road. Transparency Issues in the Repair Process: The initial repair estimate of $200 excluded labor costs and was revised to $400 without prior clarity. After inspection, the cost escalated to $2,100, leaving me no option but to approve the repairs without the ability to verify their necessity. Lack of transparency in repair recommendations, coupled with Tesla’s track record of suspension complaints, undermines customer trust and raises concerns about the integrity of the repair process. In conclusion, my experience highlights potential safety risks and quality control issues with Tesla vehicles. Suspension defects not only burden customers with significant costs but also pose a serious hazard on the road.
Air bags, Jan 7, 2025
I received an onboard alert that says ‘Safety Restraint System Issue/Service is required.’ According to online Tesla Forums, this is a very common issue with the Model 3 drivers side air bag system. Although some relate it to a wire under the seat that becomes worn with movement of the seat, Tesla gives an estimate of over $1,000 to fix the problem. There repair estimate involves updating the front passenger airbag ($444), and replacing the occupant classification system ($426).
Back over prevention, Jan 7, 2025, crash
Tesla 3 was self parking backwards and failed to stop when the car in the adjacent parking spot started moving. The result was a small scratch, but this is definitely a bug in Tesla self-parking software: it had to stop when another car moves into the stop Tesal selected for self-parking. Here is link to 30 sec video: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Structure, Jan 2, 2025
The contact owns a 2018 Tesla Model 3. The contact stated that on several occasions while making left or right turns, there was a loud clanking noise emanating from the front of the vehicle. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the lower control arm bushings had deteriorated and needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer several months later where it was diagnosed that the bushings and one of the well nuts had sheared off, and the subframe needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
Vehicle speed control, Service brakes, Fuel/propulsion system, Dec 28, 2024, crash
I was at a stoplight behind a Toyota Tacoma. I must have stopped around 8 feet behind it. I was not using FSD and I was not one-pedal driving. My foot was on the brake. I must have been at a complete stop for approximately 10 seconds when my Model 3 suddenly accelerated full throttle on its own and rear ended the Tacoma, directly hitting its trailer hitch, causing my car's driver-side airbags to deploy. When it happened, the light was still red and my foot was still on the brake. I never touched the accelerator. Luckily I was driving alone. After the inital contact, my car sort of bounced off of his hitch then slowly lurched forward before it stopped. After that, it was immobile, leaving me stuck in traffic until it was towed away.
Suspension, Dec 28, 2024
Control arm of the left front suspension system detached with no warning other than an occasional noise that started about 2 weeks before the incident, usually when turning the front wheels at slow speed. This was a potentially dangerous situation for the driver, passengers, and any other vehicles on the road as the tire could have come off at any time. Fortunately the car was being parked (0-1 mph) in a non-congested area when the control arm detached. The vehicle (total mileage approximately 42k) was towed to a Tesla Service Center 2 days later where the problem--first diagnosed by the tow truck driver--was confirmed by a Tesla service representative. There was no warning of any problem other than the occasional noise mentioned previously. If this parts failure had occurred at high speed on an interstate highway, it would likely have been deadly!
Suspension, Dec 27, 2024
Under-torqued Lateral link bolt These bolts are known to fall out or cause damage to bushings from being installed improperly Failure of the suspension would result in the suspension collapsing and the car becoming uncontrollable, with serious risks at higher speeds Out of pocket repair has been made by Tesla Component has been inspected and tightened to spec No warning sings, other than loud, clunking noises At 40k miles on smooth roads, this is not a driver issue, but a manufacturer assembly issue. They already have a recall for other VINs in other years, but I believe this should be expanded to more VINs and years, as this appears to be a common issue.
Service brakes, Forward collision avoidance, Dec 27, 2024
On December 24, 2024 I was driving on Freeway 5 South and all of the sudden my vehicle came to an abrupt breaking without any reason. The traffic ahead of me was of normal traffic. This abrupt breaking happened twice within 5 minutes of time span. I have notified Tesla Service Center and the service center gave me a quote of $137.50 for diagnostic and to schedule the service. I felt that this issues should be taken care of by Tesla with no charge to me. This is a safety issue. I have experienced the abrupt breaking issues with my vehicle on many occasions since I own the vehicle in 2018. Each time I was told there's no problem with the vehicle when I notified Tesla Service Center.
Suspension, Dec 27, 2024
Control arm issue and linkage cable.