2021 Tesla Model 3
Problems, recalls and owner-reported issues
Forward collision avoidance is the leading concern among 663 owner complaints filed for this model year. This is the 3rd highest complaint count among 9 Model 3 model years with reports.
Of the 2021 reports, 46 involved a crash and 5 involved a fire. 19 people were injured and 8 people died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsAug 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
The remedy is currently under development. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Campaign 26V507000 on NHTSA.gov
Back over prevention, softwareMay 5, 2026
Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.
Campaign 26V283000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsDec 17, 2024
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Driving with improperly inflated tires increases the risk of a crash.
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Campaign 24V935000 on NHTSA.gov
Latches/locks/linkages, hood, latchJul 24, 2024
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Campaign 24V554000 on NHTSA.gov
Seat belts, front, warning light/devicesMay 28, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Campaign 24V376000 on NHTSA.gov
Forward collision avoidance, warnings, external/pedestrian alertFeb 27, 2024
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Campaign 24V153000 on NHTSA.gov
Electrical system, instrument cluster/panelJan 30, 2024
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Campaign 24V051000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareDec 12, 2023
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Campaign 23V838000 on NHTSA.gov
Steering, automated/adaptive steeringFeb 15, 2023
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Campaign 23V085000 on NHTSA.gov
Seat belts, rear/other, anchorageOct 21, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.
An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.
Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.
Campaign 22V798000 on NHTSA.gov
Visibility, power window devices and controlsSep 19, 2022
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Campaign 22V702000 on NHTSA.gov
Forward collision avoidance, automatic emergency brakingMay 9, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model 3 and 2021 Model Y vehicles. The fisheye and narrow camera cable terminals were incorrectly installed in the cable harness connector, resulting in swapped camera views.
Swapped camera views can prevent the vehicle's cameras from detecting crossing objects and high-curvature lane lines, impairing the Autosteer and Automatic Emergency Braking (AEB) performance, and increasing the risk of a crash.
Tesla Service will correct the swapped terminals and recalibrate the cameras, free of charge. Owner notification letters were mailed July 8, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-17-007.
Campaign 22V317000 on NHTSA.gov
Electrical system, instrument cluster/panelApr 18, 2022
Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.
Campaign 22V263000 on NHTSA.gov
Electrical system, softwareApr 12, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Campaign 22V235000 on NHTSA.gov
Electrical system, softwareFeb 4, 2022
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Campaign 22V063000 on NHTSA.gov
Electrical system, softwareFeb 2, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Campaign 22V050000 on NHTSA.gov
Electrical system, softwareFeb 1, 2022
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Campaign 22V045000 on NHTSA.gov
Electrical system, adas, autonomous/self driving, softwareJan 27, 2022
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Failing to stop at a stop sign can increase the risk of a crash.
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Campaign 22V037000 on NHTSA.gov
Forward collision avoidance, sensing system, cameraOct 29, 2021
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Campaign 21V846000 on NHTSA.gov
Suspension, critical fastenersOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Campaign 21V835000 on NHTSA.gov
Air bags, side/window, curtainOct 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2020-2021, 2023 Model 3 vehicles. The left and/or right side curtain air bag may have been improperly secured to the roof rail, which could result in a twisted air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."
A twisted side curtain air bag may improperly deploy, increasing the risk of injury or occupant ejection during a crash.
Tesla Service will inspect and realign the left and right side curtain air bag as necessary, free of charge. Owner notification letters were mailed December 23, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-20-006.
Campaign 21V834000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperMay 25, 2021
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Campaign 21V387000 on NHTSA.gov
Representative owner complaints: electrical system
78 reports, newest first. Show all
Electrical system, Vehicle speed control, Forward collision avoidance, Feb 27, 2024
Complete computer failure leaving cars safety systems not working. Had to pay 3000$ for a new computer for a new car. Did not have car for three weeks. No systems would work.
Power train, Electrical system, Fuel/propulsion system, Dec 13, 2023
My 2021 Tesla Model 3 shuts/powers down WITHOUT warning while driving with a battery charge >0%. This unsafe event has occurred twice now! While the battery gauge displayed 10%, I was driving about 60mph when all of these warning messages appeared prompting me to pull over. As soon as these messages displayed, my car lost all propulsion and I was left stranded in the middle of the road. Both times I narrowly avoided being hit by other vehicles traveling at high speeds since my car died in the roadway. The car was towed to Tesla on both occasions, and they weren't concerned about my safety issue in the slightest. Instead, they said the battery just ran out; however my car displayed that I had about 6-10% charge remaining. So, if the battery were completely depleted (like Tesla says), then the meter should have displayed a 0% reading at the time of the breakdowns or, there is something defective with the battery/computer. Tesla service has refused to investigate the cause of the safety issue and, thus, refused to replace the EV battery (even though my car is still under the manufacturer's warranty). Electric vehicles should not die/run out of battery at 10% charge. However, my EV has done so TWICE! Tesla says that I just ran the car out of battery but has no response when I show them the pictures and video proving that the car died when there was, in fact, a decent amount of charge remaining on the vehicle (PLEASE SEE ATTACHED VIDEO AND PICTURES). If your phone died at 10%, then you would take it back to the manufacturer and demand that they fix the defective product. However, Tesla refuses to help fix my defective vehicle and just tells me that it is "operating as intended". EVs should not just lose all propulsion mid-drive. This creates an unsafe vehicle for me to drive, for my two young daughters in their car seats, and for other drivers who might hit me. I can provide other Tesla owners who have had a similar experience. Please force Tesla to take action!
Electrical system, Nov 27, 2023, fire
Car was charging in garage overnight when an interior dash electrical fire started. Fire burnt dash and smoke damaged the interior or car. Fire smoldered itself out, and car was considered a total loss. Collision center that picked up vehicle stated that they believed the fire started from an electrical charging fault at the harness in the dash.
Electrical system, Fuel/propulsion system, Nov 6, 2023
I was driving home from work on a two-lane highway when my car suddenly (and without any warning) lost all driving power and shut down while there was still battery left on the vehicle (roughly 10%). I could no longer maneuver the vehicle due to lack of propulsion, so my car died in the middle of the road. It was towed directly to Tesla service center where diagnostics were supposedly run. Their conclusion was the car died due to insufficient charge (even though there was about 10% battery left at the time of the incident). About a week later, the same EXACT thing happened! The car lost all power and shut down mid-drive without any warning with about 7% remaining. Both times, I had my home address in the car GPS (so it knew the exact distance I was traveling) and it never indicated once that I needed to stop and charge the battery. Again, I had the car towed to the service center where they reached the same "conclusion" that the car died due to simply running out of battery. When I showed them proof (pictures and videos) that the car died with charge left on the battery, they did not investigate the issue further. They simply stuck to their original conclusion and no longer wanted to help remedy my defective battery. I have video and pictures proving that my car dies without warning (on multiple occasions) while there is still charge left on the battery, but Tesla refuses to fix/warranty my car (let alone try to investigate or replicate the issue). They tell me that my car is "operating as intended" and is safe to drive, all the while knowing it is definitely not safe to drive. I'm especially concerned due to the fact that I drive my two daughters in my car. They both are very young and use car seats. What happens in the event that I am driving on the interstate with them in the backseat and my car randomly dies without warning? There would be no way to safely remove them from the vehicle (let along myself) before being involved in a serious high-speed accident.
Electrical system, Engine, Oct 11, 2023
I was driving to work that all of sudden heard warning sound and the monitor displayed the "Shutdown" sign as well. The car lost its power and came to complete stop in the middle of the street. Luckily there was no car near me. I was not able to drive the car and had to tow it to the dealership. According to mechanic “the rear drive unit has failed internally”. This was extremely scary and dangerous and may have caused a fatal accident. The problem has been fixed.
Steering, Electrical system, Sep 21, 2023
The contact owns a 2021 Tesla Model 3. The contact stated while driving out of a parking space, the steering wheel seized. The message "Front Motor Disabled. Continue Driving" was displayed. The manufacturer was contacted and provided remote assistance, but the failure persisted. The contact stated that the vehicle regained power steering functionality after an hour. The contact stated that the failure recurred while driving out of a parking space on another occasion. The vehicle was towed to a Tesla Service Center however, the failure could not be duplicated; however, the circuit board was replaced. The contact stated that the failure recurred while pulling out of a parking space on a third occasion. The vehicle was towed to a second Tesla service center, Tesla Sales (750 E El Camino Real, Sunnyvale, CA 94087) who informed the contact that an unknown software update was needed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 17,000.
Electrical system, Forward collision avoidance, Aug 16, 2023
While the car was parked in a parking lot, I get two notification stating “Sentry mode has turned off due to a sentry system error.” When I checked out the car, the car has completely failed to do any of the computer related task, leaving only the gear, AC, and Bluetooth was working. None of the cameras, GPS, sensors, brightness mode and many others were completely stuck. This continued until the next day. This happened without prior symptoms or warnings. I would have been in deep trouble if I have been driving at the time of the incident. When I took the car to the shop, tesla didn’t update the status for a week. After a week, Tesla told us that the Turbo A, Autopilot main processor chip failed. This caused the autopilot to go on loop. Therefore the whole motherboard needed to be replaced. This happened to a brand new purchased Tesla 2021 standard range. Which cost me $2404.00.
Electrical system, Forward collision avoidance, Lane departure, Jul 17, 2023
Electrical system rebooted in the middle of driving: screen went off couldn't signal i swayed to the side and waited till the screen came back on after 3 minutes.
Electrical system, Visibility/wiper, May 22, 2023
This same event has happened to me approximately 3-4 times since owning the vehicle. It occurs randomly without warning. The vehicle screen will randomly and suddenly freeze up and render itself inoperable. Eventually, the screen will reset itself or I will have to manually force a reset. After about 5-10 minutes, the screen will reset and the problem goes away. During the 5-10 minutes of the screen not operating, I cannot see or change any of the vehicles controls; loss of HVAC control, cannot turn on windshield wipers, cannot see vehicle speed, don't know if turn signals are on/off (also lose audible sounds when turn signals are on) are the major safety related losses; you essentially lose all control over the vehicle settings/controls. Vehicle continues to drive as normal, and all functions are restored after reset is complete.
Electrical system, Service brakes, May 17, 2023, crash
The contact owns a 2021 Tesla Model 3. The contact stated while driving approximately 25 MPH as he was exiting a highway and slowing for a traffic signal at the bottom of the off-ramp his brakes failed to engage. The contact stated the brake pedal was stiff and he had attempted to use full leg force to depress the brake pedal. The contact's vehicle ran the traffic signal and the contact stated he hit the right front end of a vehicle that was across traffic from him. The contact stated no warning light was illuminated. The contact stated that the crash stopped his vehicle and the other vehicle. The contact said that the air bags had been deployed and that the left front end of his vehicle was crushed into the left wheel well. The contact stated that the other vehicle received only light damage to the right end of the bumper due to it being higher than his vehicle. The contact stated that the police were on the scene and filed a report. The other vehicle was able to drive away, and the contact's vehicle was towed to an impound lot. The contact stated that his insurance provider declared the contact's vehicle a total loss. The vehicle had not been diagnosed or repaired. The contact stated that prior to the crash he had attempted to engage his cruise control while on the highway and it would not work. The contact stated that when he engaged the cruise control the windshield wipers would activate and he stopped attempting to use cruise control. The manufacturer had been informed of the failure. The failure mileage was approximately 18,000.
Electrical system, Jan 25, 2023
While charging Model 3 the amperage went from 32amps and was capped at 16amps. This is a wide spread issue with Tesla’s model 3 Power conversion system (PCS). There is 3 controllers in the PCS system. When all 3 are working correctly it will charge at 48amps. If one stops it will drop to 32 amps or drop to 16 amps if two fail or not even charge if 3 fail. This is a known issue and and costly repair as Tesla refuses to fix these under the battery warranty.
Electrical system, Visibility/wiper, Dec 28, 2022
The supermanifold failed, causing the front defroster to not work properly, resulting in loss of visibility in freezing temperatures. This is a common problem with 2021/2022 model 3/model y with the new heat pump that was supposed to be fixed with a software update, but was not. I now have a $3900 repair bill on a 1 year old car with 56,000 miles. The warranty expired at 50,000 miles. The failure was not a result of negligence.
Electrical system, Forward collision avoidance, Dec 23, 2022
The contact owns a 2021 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 22V235000 (Electrical System, Forward Collison Avoidance) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Parts distribution disconnect.
Electrical system, Dec 14, 2022
The contact owns a 2021 Tesla Model 3. The contact stated while driving 20 MPH, the vehicle inadvertently made a sudden stop and then lost motive power. There was no warning light illuminated. The contact attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer, and the contact was informed that the inverter failed and needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was 9,000.
Electrical system, Dec 5, 2022
The contact leased a 2021 Tesla Model 3. The contact stated upon starting the vehicle, the center display failed to operate as designed. The contact was able to drive the vehicle; however, while driving 25 MPH, the vehicle stopped abruptly in the middle of the road. A message indicating that the trunk was opened was displayed. There was also a question displayed whether the contact wished to continue driving. The contact tapped the option YES however, the touch pad center display failed to respond. The contact exited the vehicle and attempted to close the trunk several times; however, the trunk reopened independently. The contact was able to close the trunk after eight attempts. The contact was able to continue driving to her residence. The contact stated that upon parking the vehicle, the trunk reopened independently. The manufacturer was notified of the failure and assisted the contact with towing the vehicle to the local Tesla Service Center where it was diagnosed that an unknown software had failed. The vehicle was not repaired. The manufacturer declined to provide additional information. The failure mileage was approximately 15,460.
Electrical system, Dec 2, 2022
The cabin heater stopped working. I received an error code "VCFRONT_a447" recommending to take the vehicle in for service. This issue is a problem in sub-zero climates where the windshield will not defrost before and during driving. I have found 67 other cases from reddit and tesla motors club describing the same issue, on new or <2 years old cars. My components have not been inspected. I tried a full hard reboot of the software and no fix. Tesla service estimates $1,792 repair. Replacing a Supermanifold ($450.37) & A/C compressor ($1273.53) +tax =$1792. I am out of warranty by milage, car is 1.5 years old. 60,200 miles.
Electrical system, Visibility/wiper, Dec 1, 2022
I'm getting a notification that says " cabin climate control system requires service cabin heating/cooling limited or unavailable". As a result of this failure the defroster is not working properly. The windshield defroster will only blow cold air very slowly. This causes the windshield to fog up very quickly in cold temperatures. I cannot see out of the windshield properly.
Electrical system, Other or unspecified, Nov 25, 2022
It has been weeks and Tesla has still not provided a fix for this issue. It was supposed to be resolved over the air but we have called Tesla for weeks and they have no idea when the fix will be available. Do they have a time limit to resolve? Sep 19,2022 Manufacturer Recall NumberTBD NHTSA Recall Number22V702 Recall StatusRecall Incomplete
Electrical system, Other or unspecified, Oct 15, 2022
Driver side window fails to lock completely upon locking the car manually and/or using auto walk away function. This leaves the car very much unsecure and open to being vandalized. Additionally, the driver sides window fails to close fully when auto close button is pressed. The driver side window button has to be fiddled with few times to get a complete window seel.
Seats, Other or unspecified, Electrical system, Oct 13, 2022
Seat sensor fail and was able to drive in the middle of the intersection to make a left turn. Since the sensor fail if vechicle is driven less the 5 mph the car will go in park- very scary when in the middle trying to turn left
Electrical system, Service brakes, Forward collision avoidance, Oct 6, 2022
Since owning this car in January 2022, there have been issues of phantom braking during cruise control or autopilot. However, today 10/6/22 during an hour and a half time frame my car has had phantom braking episodes at least 5 times in the middle of the highway where it's speed suddenly drops by 20mph.
Electrical system, Seat belts, Forward collision avoidance, Aug 12, 2022
Tesla Model 3 main computer system failure. Failure was not cause by any negligence by the operator. The vehicle was parked over night and upon attempting to operate the vehicle the following day there was no power to the screen. There were no warnings prior. The screen which displays vehicle speed, vehicle battery level, seatbelt warning indicators was inaccessible. Also as a result of the computer failure the vehicle did not emit the required pedestrian safety sound, the front and rear collision warnings were disabled, charging was not possible, the ability to disable passenger airbags in case of a child needing to be transported in the front was inaccessible, if the vehicle was operated during winter the ability to defrost the windshield would be impossible and all safety and security features were disabled. The screen/computer has been an issue for several owners as easily viewed by a simple google search. The vehicle is only a year and a half old and was purchased new. The issues that occurred from the defective computer could of easily have caused of an accident or a caused disabled pedestrian to have been hit. The computer was deemed the cause by Tesla’s service professionals.
Steering, Electrical system, Service brakes, Jul 7, 2022
This "self driving" Model 3, with FL License Plate [XXX], attempted to merge onto I95 south from an on-ramp, and very nearly caused a major accident. The vehicle had a bumper sticker on the back that said something like "please be patient, I am a self driving vehicle." The vehicle was merging from a left side on-ramp, at a VERY LOW SPEED, and crossed two lanes of interstate traffic, very erratically accelerating, then braking, then accelerating again, and then braking. My vehicle was directly in its path, and I had to brake hard, and take to the shoulder to avoid the collision. If this vehicle's trips are logged, it needs to be investigated. If it weren't for the humans paying attention, the actions of the Tesla car/driver would have caused a major accident, and most likely bodily injury or death. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Forward collision avoidance, Electrical system, Jun 29, 2022
The contact owns a 2021 Tesla Model 3. The contact stated while driving approximately 65 MPH with the self-driving feature activated, the vehicle experienced phantom braking. There was no warning light illuminated. The contact stated that there were no other vehicles nearby in the lane. Additionally, the contact was unaware of any shadows or anything else in the lane. The contact stated that the vehicle slowed down and then resumed a higher speed. The contact stated that he disengaged the self-driving feature and manually drove the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact stated that he attempted to notify the manufacturer thru the vehicle App but was unable to leave a full detailed report. The approximate failure mileage was 10,445.
Electrical system, Forward collision avoidance, Jun 6, 2022
The contact owns a 2021 Tesla Model 3. The contact stated while driving 70 MPH with the cruise control activated, the vehicle applied the brakes independently. The contact stated no warning light was illuminated. The contact stated he experience the failure three times while using the cruise control feature that same day. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 7,000.