2022 Thor Motor Coach Palazzo
Problems, recalls and owner-reported issues
Structure is the leading concern among 4 owner complaints filed for this model year. This is the 3rd highest complaint count among 6 Palazzo model years with reports.
What owners report most often
Recalls and investigations
Equipment, recreational vehicle/trailerFeb 23, 2023
Thor Motor Coach (TMC) is recalling certain 2015-2023 Palazzo recreational vehicles. The front lower cap brackets that support the front fiberglass panel may become loose and detach from the vehicle while in motion.
A detached bracket can become a road hazard, increasing the risk of a crash.
Dealers will inspect and replace the front lower brackets, as necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000291.
Campaign 23V113000 on NHTSA.gov
Representative owner complaints: structure
2 reports, newest first. Show all
Structure, Sep 19, 2025
The contact owns a 2022 Thor Motor Coach Pallazo RV built on a 2022 Freightliner XC-S Chassis. The contact stated that while driving approximately 55-60 MPH, the front cap was shuddering, and the contact noticed that the windshield was abnormally moving from side to side. Additionally, a prior crack on the windshield was expanding due to the failure. The contact stated that upon arriving at the residence, the contact became aware that the windshield had cracked significantly. The RV was taken to an Auto Glass Shop, and the windshield was replaced. The contact was informed that upon installing the windshield, the windshield was 1-2 inches too low due to defective brackets. The RV was taken to the dealer. The dealer determined that the brackets needed to be reglued, and new bolts needed to be installed and tightened on the vertical side rails. The dealer performed the repairs according to the Manufacturer's instructions; however, the windshield continued to move abnormally from side to side while driving. The RV was not repaired. The failure mileage was approximately 13,160.
Structure, Nov 18, 2022
The Thor Palazzo has 2 braces in the front "nose" area of the coach-these braces are metal brackets that attach the front fiberglass nose to the area that contains the generator and fans for the air conditioner and other front-end components. These braces attach at both ends: the front part of the brace attaches w/ screws to a piece of wood that is then screwed into the fiberglass on the very front of the motorhome. The back side of the brace is attached w/ screws to a metal piece. This bracket acts as a support to the front windshield of the coach. This piece of metal on the passenger side of the motorhome came completely off & was drug under the front of the motorhome. Luckily, we were at an intersection when this happened and were able to retrieve the piece of metal. Had this piece came off when we were driving on the interstate, it could have been deadly. The piece measures about 15" in length & is heavy metal. It could have damaged the motorhome, tow vehicle, cars driving around us or become a projectile and flew into the windshields of cars behind us injuring others. We found the other bracket on the driver's side to be detached on one side and it pulled off with little resistance using one hand, so it was close to coming off as well. The brackets are attached with screws that had either come loose, had been sheared off or were missing. We had a couple of screws that were hanging underneath the front fiberglass nose. We have taken this to our dealership where it is currently being worked on and Thor Motor Coach has been notified. In searching this online, this has happened to several other Palazzo owners, but the design is still being used. We had no notice that this was an issue until it happened to us. Without the brackets, the windshield is not supported as it should be and driving to the dealership we had quite a bit of movement in the motorhome windshield.