2004 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 286 owner complaints filed for this model year. This is the 6th highest complaint count among 25 Highlander model years with reports.
Of the 2004 reports, 32 involved a crash and 3 involved a fire. 23 people were injured and 47 people died.
What owners report most often
Recalls and investigations
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Latches/locks/linkages, doors, latchApr 15, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 04V181000 on NHTSA.gov
Representative owner complaints
286 reports, newest first.
Electronic stability control, Visibility, Nov 9, 2007
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING 25-40 MPH, THE TRACTION CONTROL WARNING SIGNAL ILLUMINATED AND THE BRAKES PULSATED. THE TRAFFIC CONTROL LIGHT SHOULD HAVE ILLUMINATED WHEN THERE WAS WHEEL SLIPPAGE. THE CONTACT STATED THAT THE FAILURE OCCURRED DURING DRY ROAD CONDITIONS AND ESPECIALLY WHEN TURNING AT LOW SPEEDS. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 70,700. UPDATED 03/10/08. *LJTHE DRIVER SIDE WINDSHIELD WIPER STOPPED WORKING.
Service brakes, Hydraulic, Oct 30, 2007
I PURCHASED A TOYOTA HIGHLANDER 4DR 4WD 4ECT AS A PREVIOUSLY OWNED VEHICLE WITH A PREVIOUSLY OWNED VEHICLE WARRANTY. AFTER OWNING AND USING THE VEHICLE FOR A FEW MONTHS WHILE DRIVING IN A TRAFFIC SITUATION, THE RIGHT SIDE REAR BRAKE SUDDENLY LOCKED UP INTERMITTENTLY ACCOMPANIED BY SWERVING, BY PANEL VSC LIGHT FLASHES AND AN AUDIBLE WARNING. THIS SITUATION FORTUNATELY OCCURRED NEAR OUR RESIDENCE ON DRY PAVEMENT. BY DRIVING VERY SLOWLY WE MANAGED TO GET THE VEHICLE TO A SAFE LOCATION. IT WAS THEN TOWED TO A LOCAL TOYOTA DEALER WHERE IT WAS INSPECTED AND THE FOLLOWING DIAGNOSIS OR SIMILAR WAS PROVIDED: CUSTOMER STATES THAT THE VSC LIGHTS ARE COMING ON AND THE BRAKES ARE LOCKING UP, YAW RATE SENSOR IS OUT OF CALIBRATION. RECALIBRATED YAW RATE SENSOR. THE VEHICLE WAS RELEASED TO US AS REPAIRED. THE PRECISE SAME VSC FAILURE SITUATION OCCURRED ON OCTOBER 11TH OF THIS YEAR AND AGAIN WE WERE LUCKY TO HAVE BEEN IN A REASONABLY SAFE LOCATION AND DRIVING UNDER GOOD ROAD CONDITION WHEN IT HAPPENED. THE VEHICLE WAS PICKED UP AND TOWED AGAIN TO THE DEALER FACILITY FOR ANALYSIS AND REPAIR. WE RECEIVED THE DIAGNOSIS: ?ELECTRICAL REPAIR, CUSTOMER STATES THAT THE VSC LIGHTS ARE COMING ON, AND THE BRAKES ARE LOCKING UP, YAW RATE SENSOR IS OUT OF CALIBRATION. RECALIBRATED YAW RATE SENSOR?. I WAS TOLD BY TELEPHONE THAT ?THE PREVIOUS REPAIR LASTED TWO YEARS?. ANY REASONABLE PERSON WOULD CONSIDER THAT THE POTENTIAL USEFUL LIFE OF THIS VEHICLE SHOULD EXCEED TWO ADDITIONAL YEARS. FURTHERMORE, THE FAILURE COULD POTENTIALLY REOCCUR IMMEDIATELY. AFTER BEING TOLD IT WAS TEST DRIVEN AND PRONOUNCED SAFE TO DRIVE I THINK THAT THIS IS AN UNSAFE SITUATION WAITING FOR ANOTHER EVENT TO OCCUR AND THAT AN ACCIDENT COULD RESULT FROM ANOTHER INSTANCE OF THE VSC SYSTEM FAILURE. THE PROBLEM WAS NOT PROPERLY LOCATED OR PROPERLY REPAIRED IN EACH OF THE TWO OCCURRENCES. A PROPER REPAIR OF THE VEHICLE AFTER THE FIRST EVENT WOULD HAVE PREVENTED THE SECOND. *TR
Tires, Oct 21, 2007
OUR SUV STARTED SERIOUSLY SKIDDING ON THE ROAD SURFACE WHILE DRIVING, CHECK THE TREAD AND FOUND INSIDE AND OUTSIDE OF TIRES EDGES BALD, AND CENTER OF TIRE ALSO POOR TREAD. SO FOR THE SAFETY OF MYSELF AND FAMILY I HAD ALL 4 TIRES REPLACED. *TR
Steering, Oct 8, 2007
STEERING. *TR
Steering, Sep 13, 2007
2004 TOYOTA HIGHLANDER BRAKES ENGAGED WHEN ACCELERATOR WAS DEPRESSED. CUSTOMER STATES THAT HE WAS IN A PARKING LOT HIT THE ACCELERATOR AND THE BRAKES APPLIED, AND THAT MADE THE ENGINE STALL. HE WAS UNABLE TO START THE VEHICLE. *KB THE DEALER FOUND THE STEERING ANGEL SENSOR WAS NOT OUT PUTTING CORRECTLY WHICH CAUSED THE VSC TO ACTIVATE. *JB
Power train, Aug 2, 2007
2004 TOYOTA HIGHLANDER WITH AWD AND 4 CYL. VEHICLE IS LEAKING TRANSMISSION FLUID AT 67,500 MILES. DEALERSHIP SAY THAT TOYOTA WILL NOT HELP WITH THIS PROBLEM AS IT AS THE WARRANTY EXPIRED AT 60,000 MILES. I BOUGHT THIS VEHICLE DUE TO THE EXPECTED RELIABILITY OF A TOYOTA PRODUCT, BUT IT APPEARS THAT TOYOTA DOES NOT STAND BEHIND THEIR PRODUCT. MY OTHER VEHICLE IS A LEXUS RX 300 WHICH I LOVE, BUT I WILL BE HARD PRESSED TO BUY ANOTHER TOYOTA PRODUCT IN THE FUTURE AFTER THIS EXPERIENCE. *TR
Service brakes, Hydraulic, Jul 30, 2007
VARIATION IN BRAKE PRESSURE. SOMETIME BRAKES FEEL FINE AND BRAND NEW AND OTHER TIMES, BRAKE ALMOST GOES TO FLOOR. *TR
Power train, Jul 30, 2007
ACCELERATION LAGS ALL THE TIME, BUT IS ESPECIALLY APPARENT WHEN "FLOORING IT" UPON FREEWAY ENTRY, PASSING, ETC. I SEE THAT THIS IS ONE OF THE MOST FREQUENT COMPLAINTS ABOUT 04 HIGHLANDERS. OVERALL, QUITE DISAPPOINTED IN MY OVERPRICED SUV. *TR
Visibility, Jul 30, 2007
MOON ROOF BEGAN MAKING SLIGHTLY FUNNY SOUND ON OCCASION, THEN WAS FINE AND STOPPED MAKING NOISE, THEN VERY SHORTLY AFTER WARRANTY WAS UP IT STOPPED OPENING AND WON'T SHUT.*JB
Service brakes, Hydraulic, Jun 22, 2007
THE STEERING SENSOR ON THE ANTI-SKID SYSTEM SHORTED OUT CAUSING THE ANTI-LOCK BRAKES TO ENGAGE WHILE THE CAR WAS IN MOTION. THIS CAUSED A VERY DANGEROUS SITUATION. CAR HAD TO BE PULLED OF TO THE SIDE OF THE ROAD IN A HEAVY TRAFFIC ENVIRONMENT. CAR COULD NOT BE DRIVEN WITHOUT THE ANTI-LOCK BRAKES ENGAGING. CAR WAS TOWED TO THE TOYOTA DEALERSHIP. I ASKED THE DEALER TO DISCONNECT THE ANTI-SKID SYSTEM, BECAUSE THIS SYSTEM WAS MORE DANGEROUS THAN THE PROBLEM IT WAS TRYING TO ADDRESS. THE DEALER SAID THAT WAS NOT POSSIBLE AND IF THE STEERING SENSOR WAS NOT REPLACED, THE CAR WOULD NOT BE DRIVABLE. IF A SENSOR IN A CONTROL SYSTEM FAILS, IT SHOULD NOT CAUSE A DANGEROUS DRIVING SITUATION. IF A SENSOR FAILS, THE BRAKES SHOULD NOT ENGAGE, THE SYSTEM SHOULD JUST BECOME INOPERABLE. THE LOGIC IN THEIR CONTROL SYSTEM IS FAULTY AND THE COMPUTER SHOULD BE RE-PROGRAMMED TO ELIMINATE THE PROBLEM. TOYOTA MOTORS WAS INFORMED OF THE PROBLEM AND THEY CHOOSE TO IGNORE MY COMPLAIN. THE DEALERSHIP REPLACED THE STIRRING SENSOR FOR A RIDICULOUS PRICE AND THE CAR IS ABLE TO MOVE FORWARD AGAIN WITHOUT THE ANTI-LOCK BRAKES ENGAGING. MY WIFE IS AGAIN DRIVING A CAR WHICH IS INHERENTLY UNSAFE. WE ARE CONSIDERING SELLING THE CAR BECAUSE OF THE ONGOING SAFETY PROBLEMS. *TR
Steering, Jun 20, 2007
I BOUGHT USED 2004 TOYOTA HIGHLANDER AND NOTICED A HEARD A THUMPING SOUND THAT COULD ALSO BE FELT IN THE STEERING WHEN TURNING THE STEERING WHEEL AT SLOW SPEEDS. HAD AN ACCIDENT A FEW MONTHS LATER, WHERE ANOTHER VEHICLE HIT MY FRONT LEFT WHEEL. THE THUMPING GOT WORSE SO I MENTIONED IT TO THE BODY REPAIR SHOP. THEY HAD IT TOWED TO A TOYOTA DEALER EVEN THOUGH I HAD DRIVEN IT FOR 6 WEEKS AFTER THE ACCIDENT, WHERE THEY WERE TOLD THAT IT WAS NORMAL WEAR , 85,000 MILE,) ON THE INTERMEDIATE STEERING SHAFT, AND IT NEEDED TO BE REPLACED AT A COST OF $380 +. THE DEALER SERVICE DEPARTMENT SAID IT WAS NOT ACCIDENT RELATED. I STILL HAVE NOT HAD IT REPAIRED. *AK
Vehicle speed control, Jun 15, 2007
1 MONTH AFTER PURCHASING THE TOYOTA THE HESSITATION ON ACCELERATION BEGAN. I HAD THE COMPUTER PROGRAM FLASHED NUMEROUS TIMES. THE DEALERSHIP CLAIMED THEY HAVE DONE ALL THEY COULD. ENTERING HIGHWAYS OR TURNING CORNERS THE CAR STALLE D UNTILL THE THROTTLE GRABBED, AND THEN TOOK OFF. IT JOLTED THE BODY AND MADE DRIVING THE TOYOTA HIGHLANDER VERY DIFFICULT. *AK
Service brakes, Hydraulic, May 16, 2007
WHILE DRIVING HOME FROM WORK PULLED UP TO STOP LIGHT WITH MANY OTHER CARS THE LIGHT TURNED GREEN AND I GOT UP TO 20 MPH AND THE BRAKES KICKED ON SLOWING ME DOWN TO ALMOST A STOP, AND CREATING A LOUD NOISE. THE CAR BEHIND HIT ME, BUT DID NOT CAUSE ANY DAMAGE. HE SAID I HAD NO BRAKE LIGHTS. IT WILL ONLY GO 15 MPH BEFORE THE VEHICLE TRACTION CONTROL WENT ON AND STOPPED THE CAR. THERE WAS NO WARNING. THE DEALER SAID THERE WAS A TECHNICAL SERVICE BULLETIN IN FOR THE PROBLEM. I THINK TOYOTA SHOULD FIX THIS IN A RECALL BECAUSE IT COULD CAUSE SERIOUS INJURY , ESPECIALLY SINCE IT WAS THE TRACTION CONTROL SYSTEM WHICH ACTIVATED FOR NO REASON AND NO BRAKE LIGHTS WENT ON. *AK
Steering, May 8, 2007
STEERING SHAFT ON THE 2004 TOYOTA HIGHLANDER DID NOT FEEL SAFE, FELT LOOSE AND NOISY WHEN TURNING. TOYOTA REFUSESD TO FIX THE PROBLEM UNDER WARRANTY, A TSB WAS ISSUED IN JANUARY 2006, WHICH INDICATED TOYOTA'S AWARENESS OF THE PROBLEM, BUT DID NOT WANT TO PUBLICLY ADMIT IT. WHILE DRIVING IT FELT LIKE THE STEERING COLUMN COUD BREAK OFF, AND IF THAT HAPPENED, IT COULD HAVE CAUSED MANY DEATHS.*AK
Steering, Apr 26, 2007
TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHEN MAKING A LEFT TURN THE CONTACT HEARD A CLICKING NOISE NEAR THE STEERING COLUMN. THE CONTACT STATED THAT UNDER NORMAL DRIVING CONDITIONS THE VEHICLE SWERVED WHILE DRIVING FORWARD. THE DEALER REPLACED THE STEERING SHAFT AND THE CLICKING STOPPED, HOWEVER, THE SWERVING CONTINUED. THE DEALER STATED THAT THE POWER STEERING RACK NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 46,000 , AND FAILURE MILEAGE WAS 41,000. *AK
Steering, Mar 21, 2007
NOISY STEERING SHAFT CAUSED ME TO TAKE CAR TO DEALERSHIP, WHERE I WAS TOLD THE SHAFT WAS 'WORN' (TINY BEARINGS WITHIN THE SHAFT WERE WORN) AND THE SHAFT WAS REPLACED. DEALER INFORMED ME THEY'D SEEN THIS PROBLEM ON OTHER TOYOTA HIGHLANDERS, AND ON THEIR ECONOMY TOYOTA PRISMS AS WELL, BUT MANUFACTURER HAD NOT ISSUED ANY RECALLS. I PAID THE BILL USING MY EXTENDED WARRANTY.*AK
Steering, Mar 4, 2007
LOOSE AND NOISY STEERING SHAFT, DOES NOT FEEL SAFE TO DRIVE. *JB
Steering, Dec 30, 2006
2004 TOYOTA HIGHLANDER BEGAN MAKING A NOISE WHICH COULD BE FELT IN THE STEERING WHEEL, PARTICULARLY WHEN TURNING OR GOING OVER A BUMP AT SLOW SPEED. TOYOTA HAS A TSB OUT ON THIS BUT IT IS NOT KNOW TO OWNERS, AND IS NOT WELL KNOW AT THE DEALERSHIP. THIS DESPITE HUNDREDS IF NOT THOUSANDS OF COMPLAINTS ON THE WEB. FURTHERMORE, TOYOTA REPS AND THE DEALER'S SERVICE WRITERS WILL TELL YOU FACE TO FACE IT IS NOT A SAFETY ISSUE, BUT WON'T PUT IT IN WRITING. WHEN THE PROBLEM WAS FINALLY REPAIRED BY REPLACEMENT OF THE STEERING SHAFT, I BECAME AWARE THAT PRIOR TO THE REPAIRS THE CAR WAS PULLING TO THE LEFT AND THE STEERING WHEEL WAS HARD TO TURN AS THE VEHICLE NOW TRACK STRAIGHT AND THE WHEEL EASY TO TURN. WITH SUCH SYMPTOMS I FEEL VERY STRONGLY THAT TOYOTA SHOULD BE COMPELLED TO NOTIFY VEHICLE OWNERS. *NM
Tires, Dec 9, 2006
I HAD A TIRE GO VERY NEARLY FLAT AND THE LOW TIRE INDICATOR ON MY 04 TOYOTA HIGHLANDER NEVER ILLUMINATED. A PASSING MOTORIST MADE ME AWARE OF THE TIRE CONDITION. I BARELY WAS ABLE TO MAKE IT TO A STATION WITHOUT RUINING THE ALMOST NEW TIRE. I HAD JUST CAME INTO TOWN, AND WAS PREVIOUSLY AT HIGHWAY SPEED WITH 2 ELDERLY PASSENGERS BESIDES MYSELF. MY LOCAL TOYOTA DEALER HERE IN MCKINNEY TX SAID THAT TOYOTA TECH SUPPORT SAYS THERE IS NOTHING THEY CAN DO. EVEN THOUGH I HAD JUST DRIVEN ABOUT 5 MILES TO THE DEALERSHIP WITH ONE TIRE PURPOSELY UNDER INFLATED BY 10 POUNDS TO PROVE TO THEM THAT IT WAS NOT WORKING, THEY ARE TELLING ME THAT TOYOTA WILL DO NOTHING ABOUT IT, EXCEPT TO VERIFY THAT THERE IS NO CODES SET IN THE COMPUTER! *JB
Power train, Dec 1, 2006
TRANSMISSION SHIFT HESITATION ON ACCELERATION AT LOWER SPEEDS. JUST ENOUGH LAG TIME TO SCARE ME A FEW TIMES THAT I WOULDN'T MAKE IT ACROSS TRAFFIC. *JB
Power train, Nov 22, 2006
TRANSMISSION FLUID LEAKING FROM DIFFERENTIAL - 2000 MILES OUT OF WARRANTY - DEALER SAID THEY HAVE AT LEAST TWO OTHER VEHICLES THAT HAVE HAD SIMILAR PROBLEMS THIS VEHICLE IS A 2004 TOYOTA HIGHLANDER. *NM
Vehicle speed control, Nov 13, 2006
DT*: THE CONTACT STATED AT VARIOUS SPEEDS, THE VEHICLE HESITATED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. ALSO, THE VEHICLE SHIFTED ERRATICALLY. THE DEALERSHIP HAD REPROGRAMMED THE COMPUTER MULTIPLE TIMES, BUT THE PROBLEM PERSISTED.*AK
Other or unspecified, Sep 15, 2006
DEALER (GREEN'S TOYOTA, LEXINGTON, KENTUCKY) MAKING RECALL REPAIRS ON MY 2004 TOYOTA HIGHLANDER (RECALL # 06V253000) FAILED TO COMPLY WITH REQUIREMENTS OF NHTSA RECALL, BY REPLACING DEFECTIVE RETAINING CLIPS WITH VELCRO. NO REPLACEMENT CLIPS WERE USED.
Service brakes, Hydraulic, Sep 1, 2006
DT*: THE CONTACT STATED AFTER THE VEHICLE WAS PARKED FOR AN EXTENDED PERIOD OF TIME, WHILE BRAKE PRESSURE WAS APPLIED AT VARIOUS SPEEDS, THERE WAS AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY A DEALER WHO DUPLICATED THE PROBLEM, YET WAS UNABLE TO REPAIR THE BRAKES DUE TO THE DESIGN. THE DEALER DETERMINED THE CONTACT NEEDED TO WARM UP THE ENGINE BEFORE DRIVING, BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS ALERTED. UPDATED 11/9/2006 - THE CONSUMER CONTACTED TOYOTA WHO SAID THE ARE STILL WORKING ON A FIX FOR THE PROBLEM. *NM
Tires, Aug 22, 2006
DURING REGULAR MAINTENANCE IN MY TOYOTA HIGHLANDER 4X4 2004 WITH A 20000 MILES, THE DEALERSHIP INFORM ME THAT THE TIRES NEED TO BE REPLACE AND TOLD ME THAT WARRANTY DOES NOT INCLUDE TIRES. I STRONGLY BELIEVE THAT TIRES SHOULD HOLD MORE THEN 15000 MILES. THE TIRES ARE BRIDGESTONE DUELER H/T 687. *NM