2005 Toyota Highlander
Problems, recalls and owner-reported issues
Power train is the leading concern among 225 owner complaints filed for this model year. This is the 13th highest complaint count among 25 Highlander model years with reports.
Of the 2005 reports, 35 involved a crash and 4 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Engine and engine coolingNov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V539000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V112000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderOct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Campaign 10V499000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 06V253000 on NHTSA.gov
Representative owner complaints
225 reports, newest first.
Power train, Feb 21, 2006
MULTIPLE TIMES, I HAVE TRIED TO ACCELERATE THE VEHICLE AND THERE HAS BEEN "HESITATION" WHEN I DEPRESSED THE GAS PEDAL--THE CAR SEEMED TO BE IN NEUTRAL, THERE WAS NO RESPONSE. THIS HAS HAPPENED MANY TIMES AT DIFFERENT SPEEDS/GEARS--IT IS NOT PREDICTABLE. I HAVE ALMOST BEEN REAR ENDED ONCE; IN THAT INSTANCE THE CAR ACTUALLY "BUCKED" AND STOPPED. I HAD TO TURN OFF THE ENGINE, RESTART, AND DRIVE A SHORT DISTANCE TO A SAFE PLACE TO STOP. AT OTHER TIMES, I HAVE BEEN ON A RELATIVELY EMPTY STREET AND IT HAS NOT BEEN AS MUCH OF A PROBLEM SINCE NO ONE WAS BEHIND ME. HOWEVER, THIS IS AN ACCIDENT WAITING TO HAPPEN AS I HAVE A LONG COMMUTE TO WORK (AND BOUGHT THIS CAR BECAUSE OF WHAT I THOUGHT WAS ITS SAFETY AND RELIABILITY). ON MY FIRST VISIT TO THE DEALER, TOYOTA MADE A FIX ACCORDING TO A TECHNICAL BULLETIN. ON THE SECOND VISIT, THEY DID NOTHING BECAUSE THEY COULD NOT REPLICATE THE PROBLEM--EVEN THOUGH THEY WERE TOLD THAT THE PROBLEM HAPPENS INTERMITTENTLY. ON THIS SECOND VISIT, THEY MERELY TEST DROVE THE VEHICLE AND WE WERE TOLD WE COULD RENT A LOANER VEHICLE FROM THEM AT THEIR COST BECAUSE THERE WAS NO PROBLEM WITH THE VEHICLE. *JB
Electrical system, Structure, Jan 6, 2006
DT*: THE CONTACT STATED SINCE PURCHASE OF THE VEHICLE THE DASHBOARD PANEL WAS BLACK DURING THE DAY. SHINING A FLASH LIGHT ON THE DASH IS THE ONLY WAY THE DASHBOARD GAUGES CAN BE SEEN. THE GAUGES ARE NOT DIGITAL. THE DEALERSHIP DETERMINED THE DASHBOARD PANEL WAS NOT ABLE TO BE READ BUT THIS IS HOW THE VEHICLE WAS MADE. THE DASHBOARD WORKED PROPERLY AT NIGHT.*AK UPDATED 01/25/06. *JB
Air bags, Jan 2, 2006, crash
WHO DO I NEED TO SPEAK WITH REFERENCE EASE OF ROLLOVER OF THE TOYOTA HIGHLANDER AND THE FACT THAT THE AIR BAGS DID NOT OPEN AT ALL WHEN I WAS FLIPPED OVER THREE TIMES? THE SPEED WAS NOT A FACTOR I WAS DOING 25 MILES WHEN BROADSIDED BY A 87 FORD RANGER GOING 25, WHICH HIT THE DRIVER DOOR LOW IMPACT ON THE HIGHLANDER SENT MY HIGHLANDER AIRBORN FLIPPING AND SPINNING. THE PRINCE WILLIAM POLICE HAVE THE REPORTS ON THE ACCIDENT. THE HIGHLANDER IS IN STATE FARM HANDS NOW. THE ACCIDENT HAPPENED ON MAY 14TH IN PRINCE WILLIAM COUNTY ON ROUTE 1. *NM
Power train, Dec 14, 2005
RECURRING ISSUE: WHILE TRAVELING AT BOTH HIGHWAY AND CITY STREET SPEEDS, THE DRIVER ATTEMPTED TO PASS BY FULLY DEPRESSING THE ACCELERATOR AND THE VEHICLE FAILED TO ACCELERATE FOR APPROXIMATELY 1-2 SECONDS. THIS HAS RESULTED IN NEAR-MISS ACCIDENT/INJURY INCIDENTS. THE DEALER WAS CONTACTED AND STATED THIS WAS A ROUTINE COMPLAINT FOR THIS VEHICLE AND THE LEXUS RX-330. THE MANUFACTURER, TOYOTA CORPORATE, WAS CONTACTED AND THE INDIVIDUAL STATED THIS WAS NOT A KNOWN ISSUE. NO MEDIATION WAS PROVIDED FROM EITHER CONTACT. THIS ISSUE SEEMS TO BE RELATED TO EXISTING ODI ID NUMBERS: 10113278, 10114325, 10115243, 10120592, 10128880, 10129705, 10131894, 10132578, 10137651, 10145021. *JB
Power train, Dec 12, 2005
CAR IS A 2005 TOYOTA HIGHLANDER LTD. V-6 4WD WITH 5-SP AUTO. ENGINE HESITATES SEVERELY WHEN ASKED TO ACCELERATE HARD AT SPEEDS SEEMINGLY BETWEEN 15 AND 70 MPH. (THESE ARE SPEEDS I'VE NOTICED IT) WHEN YOU "FLOOR" THE THROTTLE TO QUICKY MERGE WITH TRAFFIC OR TURN ACROSS A LINE OF ONCOMING TRAFFIC, THERE IS A RATHER LONG DELAY BEFORE VEHICLE BEGINS TO ACCELERATE. THIS BEHAVIOR ALSO OCCURS EXACTLY THE SAME WAY IN MY WIFE'S 2004 LEXUS RX-330, WHICH HAS THE SAME POWERTRAIN. I COMPLAINED TO LEXUS SHORTLY AFTER THE PURCHASE (BOUGHT NEW) AND THEY SAID THEY FOUND NOTHING WRONG. I'VE BEEN ON SEVERAL TOYOTA HIGHLANDER NEWSGROUPS AND THIS PROBLEM IS BEING WIDELY REPORTED. I HAVE HAD SEVERAL "CLOSE CALLS" BECAUSE OF THIS DELAYED ACCELERATION. IN THE TIME THAT THE CAR DECIDES TO DOWNSHIFT AND ACCELERATE, TRAFFIC HAS CLOSED IN ON YOU ENOUGH THAT SEVERAL ACCIDENTS HAVE BEEN NARROWLY AVOIDED. I HAVE NOT REPORTED THIS TO TOYOTA AS YET, BUT FEEL THAT THEY WILL SAY THE SAME AS LEXUS DID. *NM
Engine and engine cooling, Dec 6, 2005
CONSUMER 2005 HIGHLANDER HAS EXPERIENCED HESITATION DURING ACCELERATIONS AND SOMETIMES DECELERATION. *TS THE DEALER RECALIBRATED THE ECM WHICH IMPROVED THE HESITATION PROBLEM WHILE SHIFTING BUT ALSO REDUCED THE GAS MILEAGE. THE VEHICLE WAS TAKEN TO ANOTHER DEALER AND THEIR COMPUTER INDICATED THAT EVERYTHING WAS FINE. *NM
Power train, Dec 2, 2005
AUTOMATIC TRANSMISSION HESITATION - WHEN NEEDING TO ACCELERATE QUICKLY (AS WHEN ENTERING A FREEWAY) AFTER SLOWING DOWN OR COASTING, THE TRANSMISSION HAS DOWNSHIFTED TO A TOO-LOW GEAR OR NEUTRAL. THE ENGINE SPEEDS UP TO APPROXIMATELY 5000 RPM WITHOUT INCREASING THE CAR SPEED. LETTING UP ON THE GAS AND ACCELERATING MORE EASILY ALLOWS THE VEHICLE SPEED TO INCREASE. SO FAR, THIS HESITATION HAS NOT CAUSED ME TO BE REAR-ENDED. THE DEALER SAYS THIS OPERATION IS "NORMAL." *NM
Power train, Nov 14, 2005
ON OUR 2005 TOYOTA HIGHLANDER WITH A 4 CYLINDER ENGINE, AND ELECTRONIC TRANSMISSION. ON SEVERAL OCCASIONS, WHEN TAKING OFF FROM A STOP, LETTING OFF ON THE ACCELERATOR, AND IMMEDIATELY PUSHING THE ACCELERATOR RATHER HARD TO ATTEMPT TO MERGE INTO TRAFFIC, THE VEHICLE'S ENGINE INCREASES RPM'S, BUT NO POWER GOES TO THE WHEELS. IT IS AS IF THE TRANSMISSION COMPUTER CANNOT DETERMINE WHAT GEAR TO SHIFT INTO. YOU HAVE TO LET OFF THE ACCELERATOR, AND LET THE RPM'S COME BACK DOWN, AND THEN THE VEHICLE FINALLY DETERMINES WHAT GEAR TO SHIFT INTO, AND YOU CAN THEN PRESS DOWN ON THE ACCELERATOR TO REGAIN FORWARD MOMENTUM. WHEN YOU ARE TRYING TO MERGE INTO TRAFFIC, YOU NEED TO KNOW THAT WHEN YOU STEP ON THE ACCELERATOR, THE CAR IS GOING TO SHIFT INTO THE PROPER GEAR, AND MOVE FORWARD ACCORDINGLY. VERY DANGEROUS SITUATION IN MY OPINION. TOYOTA DEALERSHIP SAID THERE IS NOTHING WRONG WITH THE TRANSMISSION. THIS LOSS OF TRANSMISSION ACCELERATION HAS HAPPENED ON NUMEROUS OCCASIONS, NOT JUST ONCE. *NM
Tires, Sep 28, 2005
CONSUMER TIRE PRESSURE WAS 38 PSI AND WAS TOLD BY DEALER AND GOODYEAR THAT IT WAS HIGH AND SHOULD BE AT 30 PSI. *JB
Vehicle speed control, Sep 26, 2005
I HAVE A 2005 TOYOTA HIGHLANDER LIMITED W/V6 ENGINE. WHEN I ACCELERATE AT LOW SPEEDS, THEN TAKE MY FOOT OFF THE GAS AND THEN TRY TO ACCELERATE AGAIN, THERE IS A PROLONGED HESITATION BEFORE THE VEHICLE STARTS TO ACCELERATE. THE SAME PROBLEM EXISTS WHEN YOU MAKE A TURN AND THEN TRY TO ACCELERATE AGAIN. THE OTHER DAY I WAS TRYING TO PULL OUT ONTO A WELL TRAVELED ROAD. I MOVED OUT INTO THE FIRST LANE AND THEN TOOK MY FOOT OFF THE GAS TO CHECK TO MAKE SURE THE NEXT LANE WAS CLEAR. I SAW THERE WERE CARS COMING AROUND THE CURVE TOWARDS ME IN BOTH LANES. I HIT THE GAS AND THE CAR HESITATED. THEN FINALLY IT STARTED TO MOVE. I BARELY MISSED BEING BROADSIDED. I'VE BEEN DRIVING FOR OVER THIRTY YEARS AND HAVE DRIVEN A NUMBER OF DIFFERENT VEHICLES. I HAVE NEVER EXPERIENCED THIS PROBLEM AND AM VERY CONCERNED FOR MY FAMILY'S SAFETY. I HAVE CONTACTED THE DEALER AND TOYOTA AND THEY SAY THIS IS NORMAL OPERATION. AS FAR AS I'M CONCERNED THIS IS ANYTHING BUT NORMAL AND NEEDS TO BE ADDRESSED. *NM
Power train, Vehicle speed control, Sep 8, 2005
DT: 2005 TOYOTA HIGHLANDER V6- THE CONSUMER DROVE OFF THE LOT ON JUNE 3, 2005; THE CRUISE CONTROL BEHAVED ERRATICALLY AND IT OFTEN FELT AS IF IT WAS ACCELERATING A COUPLE OF MILES BEHIND THE DESIRED SPEED. THE CONSUMER REQUESTED TO PASS THIS TURKEY WHICH YIELDED DIFFERENT RESULTS. THERE IS SOMETIMES AWKWARD DOWN SHIFTING AND RAPID ACCELERATION WHICH IS PRECEDED BY HESITATION. THE CONSUMER APPROACHED A VILLAGE INTERSECTION, DOWNHILL WITH HIS FOOT ON THE BRAKE. THE CONSUMER TOOK HIS FOOT OFF OF THE BRAKE AND BEGAN TO MAKE A LEFT TURN ONTO DESIRED STREET. THE CONSUMER TRIED TO APPLY A BIT OF GAS AND NOTHING HAPPENED. THE CONSUMER TRIED TO APPLY A BIT MORE GAS AND AGAIN NOTHING HAPPENED. THE THIRD TIME THE CONSUMER ADDED A BIT MORE GAS AND THE VEHICLE ACCELERATED TOO FAST CAUSING THE DRIVER'S AND PASSENGER'S HEADS TO TIP BACK. THIS WAS A NARROW MAIN STREET IN A MAIN VILLAGE. THERE WERE LOTS OF POSSIBLE TARGETS, CARS/ KIDS BIKES, AND OTHERS. THEN THERE WAS THE UNANTICIPATED DOWN SHIFTING FOR BRAKING EFFECT THAT TIPPED HEADS FORWARD, BUT THAT WAS ANOTHER STORY FOR ANOTHER DAY, AND NOT QUITE AS ANNOYING OR NEARLY OF THE SAME CONCERN. THE DEALER'S SERVICE MANAGER FIRST ASSERTED THAT THERE WERE NO ADJUSTMENTS ACCESSIBLE FOR THE MECHANICS. INABILITY TO DO SOMETHING. AFTER APPLYING MORE GAS AND VEHICLE HESITATION CONSUMER SEARCHED FOR A TECHNICAL SERVICE BULLETIN (TSB) AND FOUND NONE. BUT FOUND ONE FROM JUNE 3, 2005 THAT RELATED TO RECALIBRATING OF THE TRANSMISSION. ABSOLUTELY NO MENTION OF EXPRESSIONS OF CONCERN OR EARLIER TSBS. *AK *MR
Power train, Aug 12, 2005
HESITATION WHEN ACCELERATING. COMPLAINT FILED WITH DEALER ON 8/10/05. I WAS ADVISED THAT THIS IS NORMAL. THIS IS A CONSTANT CONDITION AND NOT SAFE. *NM
Power train, Aug 8, 2005
MY 2005 HIGHLANDER OFTEN HESITATES RIGHT WHEN I NEED THE MOST ACCELERATION. *NM
Seats, Jul 28, 2005
I AM A CERTIFIED CHILD PASSENGER SAFETY TECHNICIAN AND HAD A PARENT COME TO ME WITH CONCERN ABOUT THE THIRD ROW SEATING IN HER TOYOTA HIGHLANDER 2005. THE HEAD RESTRAINTS IN THIS MODEL ONLY HAS TWO NOTCHES. THE FIRST IS UP ABOUT 4 INCHES AND THE SECOND AROUND 5 INCHES. THERE IS A HUGE GAP IN BETWEEN. THIS SEAT CANNOT BE USED FOR A CHILD IN A NO BACK BOOSTER SINCE THIS HEAD RESTRAINT HAS NO NOTCHES THAT CAN ACCOMMODATE THIS CHILD'S HEAD HEIGHT. IT IS EITHER TOO LOW OR TOO HIGH. I HAVE CONTACTED TOYOTA AND THEY STATED THAT THEIR VEHICLES MEET OR EXCEED ALL SAFETY STANDARDS. THEY REFERRED ME TO CONTACT THEIR LOCAL CONSUMER RELATIONS PERSON WHICH THE PARENT IN CONCERN HAD BUT THE GENTLEMAN HAD NO CLUE WHAT SHE WAS TALKING ABOUT. UNLESS THIS IS YOUR PRIMARY FOCUS THIS MAY HAVE GONE UNNOTICED BUT THIS PARENT HAD THE CONCERN AND CHECKED INTO IT. SHE IS ABSOLUTELY RIGHT. THIS NEEDS TO BE ADJUSTED IN SOME WAY. IT SEEMS THAT ADDING A FEW NOTCHES COULD ACCOMMODATE MANY MORE PASSENGERS IN THIS VEHICLE. THIS IS USELESS TO HER AND THIS IS THE MAIN REASON WHY SHE PURCHASED THIS 7 PASSENGER VEHICLE. *NM
Vehicle speed control, Jul 22, 2005
DT: CALLER SAID THAT TWICE HIS VEHICLE WOULD NOT ACCELERATE WHEN HITTING THE GAS PEDAL. WHEN PRESSING THE GAS PEDAL TO PASS A CAR NOTHING HAPPENED FOR A FEW SECONDS. DEALER SAID THERE WAS NOTHING THEY COULD DO ABOUT IT, AND THAT WAS THE WAY THE VEHICLE WA SDESIGNED. DEALER SAID THEY COULD NOT DUPLICATE THE PROBLEM. MANUFACTURER HAS NOT BEEN CONTACTED YET.*AK
Power train, Jul 15, 2005
1-MERGING INTO TRAFFIC ON INTERSTATE, AND MAKING A TURN AND MERGING INOT TRAFFIC 2-ENGINE HESITATION FOR A FEW SECONDS, THEN VEHICLE RESPONDS WITH SURGE IN SPEED. CARS COMING BEHIND ME HAD TO BRAKE/CHANGE LANES TO KEEP FROM HITTING ME. 3-I DIDN'T TRY TO HAVE THE PROBLEM FIXED, BECAUSE I UNDRSTAND THAT TOYOTA IS SAYING THIS IS NORMAL, AND NOT A PORBLEM.
Service brakes, Air, Other or unspecified, May 26, 2005
MY DAUGHTER LEASED A 2005 4 CYLINDER, FWD TOYOTA HIGHLANDER IN FEBRUARY 2005, AND HAS PUT ON ABOUT 5,000 MILES. THE CAR WAS LEASED IN LOUISVILLE, KY. A FEW DAYS AGO SHE WAS DRIVING ON THE HIGHWAY AT ABOUT 65MPH, AND NOTICED THAT THE GAS PEDDLE WAS STUCK, AND WOULD NOT COME UP SO AS TO REDUCE THE SPEED. THE FIRST TIME THIS HAPPENED, SHE MANAGED TO REACH DOWN AND PULL THE PEDDLE ASSEMBLY UP, AND DECELERATION OCCURRED. THE NEXT DAY THIS SITUATION REPEATED 2 MORE TIMES, THE LAST TIME BEING ON THE WAY TO THE DEALER TO HAVE THE VEHICLE "REPAIRED" UNDER WARRANTY. THE DEALER FIXED THE ASSEMBLY, AND STATED THE ASSEMBLY HAD COME LOOSE. WHILE THE REPAIR SEEMS TO HAVE BEEN SUCCESSFUL TO DATE, AND THE DEALER WAS VERY COOPERATIVE, I THOUGHT YOU FOLKS SHOULD KNOW ABOUT THIS "DEFECT" AND BE ALERT TO THE POSSIBILITY OF MORE SUCH FAILURES. WHILE MY DAUGHTER WAS TOO SHY OR RETICENT TO CONTACT YOU, I THOUGHT IT'S INEVERYONE'S BEST INTEREST TO AVOID POSSIBLE FUTURE FATALITIES. NOT EVERYONE IS AS ATHLETIC OR CALM AS MY DAUGHTER IN THIS TYPE OF SITUATION. THANK YOU FOR YOUR ATTENTION TO THIS MATTER.
Engine and engine cooling, May 10, 2005
INTERMITTENT PROBLEM: WHILE TRAVELING APPROX 30 MPH (OR CRUISING SPEED), ATTEMPTED TO PASS ANOTHER VEHICLE. THE ACCELERATOR WAS PRESSED TO THE FLOOR AND THE VEHICLE REFUSED TO ACCELERATE FOR A PERIOD OF APPROXIMATELY 2 SECONDS. ACCELERATION RESUMED AFTER THIS PERIOD. CONTACTED TOYOTA. TOYOTA SAID THIS IS A NORMAL PHENOMENON IN THEIR DRIVE-BY-WIRE SYSTEMS.
Power train, Apr 13, 2005
TOYOTA, HIGHLANDER 2005. GOING DOWN A MOUNTAIN AT APPROXIMATEKY 50 MPH AND THE VEHICLE STOPPED SUDDENLY, BACK END FLIPPED UP, AND THE VEHICLE STARTED TO FISH TAIL. THE VEHICLE SLID INTO A BUSY ITERSECTION THEN STALLED. HAD THE VEHICLE TOWED TO TOYOTA, WHERE IT WAS DIAGNOSED WITH A DEFECTIVE TRANSMISSION. WHILE WORKING ON THE VEHICLE I DISCUSSED THE PROBLEM W/A CUSTOMER SERVICE REPRESENTATIVE ABOUT GETTING A NEW VEHICLE. (THIS VEHICLE WAS ONLY 3 MONTHS OLD). AND WAS TOLD THAT IF I TOOK THE VEHICLE INTO ARBITRATION THEY WOULD IMMEDIATLY CEASE WORKING ON THE VEHICLE AND WOULD TAKE AWAY MY FREE RENTAL CAR LEAVING ME STRANDED W/NO TRANSPORTATION. TOYOTA BLACKMAILED ME. *AK
Vehicle speed control, Apr 12, 2005
WHILE APPLYING THE ACCELERATOR PEDAL VEHICLE HESITATED TO ACCELERATE. DRIVER APPLIED THE ACCELERATOR PEDAL NUMEROUS TIMES AND THE VEHICLE ACCELERATED UNCONTROLLABLY. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE , AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT IT WAS NORMAL FOR THE VEHICLE TO HESITATE WHEN APPLYING THE ACCELERATOR PEDAL. *AK *BF *NM
Power train, Mar 19, 2005
TOYOTA HIGHLANDER: TRANSMISSION TERRIBLY SLOW TO RESPOND. VERY DANGEROUS. TAKES AT LEAST A FULL SECOND TO RESPOND -- EITHER TRANSMISSION OR THROTTLE IS DEFECTIVE. *AK TOYOTA WILL NOT DO ANYTHING ABOUT THIS PROBLEM. THIS IS VERY SERIOUS. THE COMPANIES ATTITUDE IS: "IF WE DON'T ADMIT THERE IS A PROBLEM, THERE IS NO PROBLEM. "
Vehicle speed control, Mar 16, 2005
WHILE DRIVING ABOUT 30 MPH DRIVER PRESSED ON THE ACCELERATOR IN ORDER TO PASS A VEHICLE ON THE RIGHT HAND SIDE. THE VEHICLE REFUSED TO ACCELERATE WHEN PEDAL WAS APPLIED, AND FINALLY ACCELERATED AFTER A FEW SECONDS.*AK
Wheels, Mar 10, 2005
WE TOOK OUR 2005 TOYOTA HIGHLANDER TO THE TIRE SHOP FOR A TIRE ROTATION @ 10,000 MILES. WHEN THE WHEEL NUTS WERE HAND TORQUED TO 85PLI TWO WHEEL STUDS BROKE. THE EMPLOYEE TOLD US THAT THE METAL SEEMED SOFT. WE HAVE THE BROKEN STUDS IF YOU WANT US TO SEND THEM IN FOR TESTING. *AK
Structure, Feb 1, 2005
I HAVE JUST PURCHASED A 2005 TOYOTA HIGHLANDER LIMITED. I FIND THAT IN THE BRIGHT FLORIDA SUNSHINE, THE INSTRUMENT CLUSTER (SPEEDOMETER ETC.) IS SO DEEPLY RECESSED INTO THE DASH, THEY ARE DARK AND IMPOSSIBLE TO READ -- ESPECIALLY WITH SUN GLASSES. THIS IS RATHER DISCONCERTING WHEN I CANNOT SEE/READ THE SPEEDOMETER! I HAVE REPORTED THIS TO TOYOTA BUT THEY HAVE NOT RESPONDED TO DATE.*AK
Electrical system, Oct 26, 2004
AFTER PLACING THE KEY INTO THE IGNITION THE KEY WILL NOT TURN. THE VEHICLE WAS BEING TOWED. *AK