2009 Toyota Highlander
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 134 owner complaints filed for this model year. This is the 21st highest complaint count among 25 Highlander model years with reports.
Of the 2009 reports, 6 involved a crash and 5 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V023000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: electrical system
20 reports, newest first. Show all
Electrical system, Engine, Fuel/propulsion system, Nov 24, 2020
3 TIMES OVER THE LAST MONTH, WHILE I WAS DRIVING MY VEHICLE, THE CAR SUDDENLY LOST POWER WHILE I WAS DRIVING ON THE HIGHWAY. ALL THE DASHBOARD LIGHTS FLASHED ON, CHECK ENGINE LIGHT AND WARNING LIGHTS ILLUMINATED. THE VEHICLE LOST POWER, THE ACCELERATOR WAS NOT WORKING, AND I WAS JUST BARELY ABLE TO PULL THE CAR OVER TO THE SIDE OF THE ROAD. CAR TURNED OFF AND WAS ABLE TO TURN BACK ON, NOW WITH ILLUMINATED CHECK ENGINE LIGHT AND CHECK HYBRID SYSTEM WARNING LIGHT ILLUMINATED. THIS IS A BIG SAFETY ISSUE AS THE CAR IS LOSING POWER IN THE MIDDLE OF THE ROAD WHILE MY FOOT IS ON THE ACCELERATOR. THE FIRST TIME THIS HAPPENED I WAS ABLE TO PULL A COUPLE CODES FROM THE CODE READER. CODES WERE: U0001 & U0100 THE SECOND AND 3RD TIME THIS HAPPENED THERE WERE NO CODES COMING UP ON THE CODE READER.
Electrical system, May 28, 2019
LOCK ACTUATORS MAL-FUNCTION WHEN USING THE REMOTE OR WHEN USING THE POWER LOCKS. UNABLE TO LOCK DOORS EXCEPT MANUALLY WITH KEY OR BY HAND. AT TIMES, CERTAIN LOCKS WILL WORK AND SEEM IMPACTED BY WEATHER CONDITIONS, I.E. HUMIDITY OR RAINY DAY VS. FAIR WEATHER DAY. THIS CAUSES THE OWNER TO BELIEVE THE DOORS ARE LOCKED WHEN THEY ARE NOT AND THE INCONVENIENCE THEY ARE UNLOCKED WHEN LEAVING YOUR CAR PARKED IN A PUBLIC LOT.
Electrical system, Oct 22, 2018
2009 TOYOTA HIGHLANDER LIMITED DOOR ACTUATORS HAVE ALL BROKE, BEEN REPLACED AND BROKE AGAIN. SOME ARE BEING REPLACED FOR THE 3RD TIME SINCE I OWED THE VEHICLE (MAKING IT THE 4TH LOCK ON THE CAR). AT THE MOMENT ONLY 1 DOOR LOCK WORKS AND I HAVE TO CLIMB ACROSS TO OPEN THE OTHER DOORS. I AM EXTREMELY CONCERNED THAT THEY WILL ALL BREAK AND I WILL NOT BE ABLE TO GET MY DAUGHTER OUT OF THE CAR. I STARTED CONTACTING TOYOTA IN 2013 WHEN THEY ALL STARTED BREAKING. I ALSO CAN NOT OPEN THE CAR WITH THE KEY. 8/2012- DRIVERS LOCK AND ACTUATOR REPLACED AND WINDOW 6/2013- RIGHT REAR DOOR ACTUATOR REPLACED 7/2013- PASSENGER DOOR ACTUATOR REPLACED 3/2014- LEFT REAR DOOR ACTUATOR REPLACED 4/2014- DRIVERS LOCK ACTUATOR REPLACED (AGAIN) 5/2014- RIGHT REAR DOOR ACTUATOR REPLACED (AGAIN) 2015- LEFT REAR ACTUATOR BROKE AGAIN THIS TIME MY EXTENDED WARRANTY IS UP AND THEY WANT 600 TO FIX. 2016- PASSENGER ACTUATOR BROKE 9/2018- DRIVERS ACTUATOR BROKE FOR THE 3RD TIME. I AM LEFT WITH LEAVING THE CAR UNLOCKED AND HOPING NO ONE GOES IN OR CLIMB ACROSS MY VEHICLE. I HAVE CONTACTED TOYOTA NUMEROUS TIMES TO TRY AND GET THEM TO HELP AND THEY HAVENT DONE ANYTHING BUT TELL ME I'M NOW OUT WARRANTY EVEN THOUGH I CONTACTED THEM REGARDING THE ISSUES BEFORE MY EXTENDED WARRANTY WAS UP.
Electrical system, Jan 21, 2017
MY VEHICLE HAS AN ISSUE WITH THE DOOR LOCKS WHICH IS A SAFETY CONCERN, THE POWER DOOR LOCK ACTUATORS HAVE REPEATEDLY FAILED ON MY VEHICLE. EACH OF THE FOUR DOOR LOCK ACTUATORS HAVE BEEN REPLACED AND SEVERAL MULTIPLE TIMES. THE MOST RECENT WAS A DRIVERS (LEFT) SIDE REAR WHICH WAS REPLACED IN MARCH 2014 AND FAILED AGAIN. THIS MAKES THE 6TH OR 7TH TIME AN ACTUATOR HAS FAILED ON MY VEHICLE. THE COST TO REPLACE THESE IS APPROXIMATELY $600. HOWEVER MY BIGGEST CONCERN IS THAT THE VEHICLE IS UNLOCKED WHEN I BELIEVE IT IS LOCKED. THIS IS A WORRY BOTH WHEN TRANSPORTING YOUNG CHILDREN (WHO CAN OPEN THE DOOR AS CHILD SAFETY LOCKS ARE INOPERATIVE) AND POTENTIAL UNAUTHORIZED ACCESS OR THEFT OF THE VEHICLE. I OPENED A CASE WITH TOYOTA #1701210527. TOYOTA REFUSE TO CONTINUE TO ASSIST WITH THIS OR DETERMINE WHY MY VEHICLE REPEATEDLY HAS DOOR LOCK ACTUATORS FAIL.
Electrical system, Other or unspecified, Dec 23, 2015
REAR DOOR MOTOR LIFT NOT WORKING
Electrical system, Structure, Oct 26, 2015
LIFTGATE WILL NOT CLOSE OR OPEN WHEN AUTOMATIC BUTTON IS PUSHED EITHER ON THE DASH OR THE BUTTON ON THE LIFTGATE ITSELF. STAYS OPEN AND HAVE TO FORCE THE LIFTGATE DOWN MANUALLY. AT TIMES LIFTGATE WILL OPEN BY ITSELF WHILE STATIONARY OR VEHICLE IS MOVING. CLOSING OR OPENING THE LIFTGATE AUTOMATICALLY PROBLEM HAS BE ONGOING FOR ABOUT 6 MONTHS. BROUGHT TO DEALERSHIP AND THEY COULD NOT REPAIR, BUT I COULD TAKE TO BODY SHOP FOR REPAIR. CURRENTLY A SERVICE BULLETIN HAS BEEN ISSUED, BUT SHOULD BE A SAFETY RECALL.
Electrical system, Air bags, Sep 10, 2015
$7155 QUOTE TO REPLACE 2 ELECTRICAL HARNESSES. REASON: "WARNING: SRS AIRBAG CHECK. TAKE VEHICLE TO DEALER". THE JUNCTION BOX IS HIDDEN BEHIND THE DRIVER SIDE FRONT PANEL. THE PINS IN THE JUNCTION BOX BELONGING TO THE AIRBAG WIRING HARNESS (PART # 82141-48R51) THAT RUNS UNDERNEATH THE DASHBOARD WERE FRIED DUE TO ELECTRICAL SHORT (UNEXPLAINED). BECAUSE THE JUNCTION BOX ALSO BRINGS THE REAR WIRING HARNESS (PART # 82162-48D40 ) TO TAIL, HEADLINER, AND BACK OF THE VEHICLE, THIS MUST BE REPLACED AS WELL. I FEAR THAT THERE IS A MAJOR FLAW IN THE ELECTRICAL SYSTEM / SRS AIRBAGS OF THIS VEHICLE AND THE VEHICLE ELECTRICAL SYSTEM HAS EXPERIENCED PREMATURE FAILURE.
Electrical system, Structure, Aug 10, 2015
LIFT GATE AND POWER DOOR MOTOR BROKE. THE DOOR STOCKED AND COULD NOT BE OPENED OR LOCKED. I WAS LUCKY THAT MY TODDLER WAS NOT AROUND. I AM HORRIFIED WHAT WOULD HAPPENED IF HIS HAND STOCK IN IT AND THE DOOR COULD NOT BE OPEN. WE TOOK IT TO MOLLE TOYOTA. THEY TOLD ME THAT BESIDE THE LIFT GATE AND MOTOR THE WHOLE REAR DOOR AND HINGE HAS TO BE REPLACE. THEY SAID THAT IF I DON'T REPLACE THE DOORS I WILL HAVE SAME PROBLEM FEW MONTHS LATER. THEY SAID THAT TOYOTA MODIFIED THE NEW REAR DOOR THAT THEY ARE AWARE THAT THE DOOR IN MY VEHICLE CAUSING PROBLEMS. THEY REFUSED TO PAY FOR THE DOOR BECAUSE IT'S OUTSIDE WARRANTY. THE COST OF MOTOR AND LIFT GATE REPAIR IS $1500 THE COST WITH NEW DOOR IS $3500. I DON'T UNDERSTAND WHY TOYOTA DOES NOT PAY FOR DOOR THAT THEY ARE AWARE THAT ARE DEFECTIVE AND NEEDED TO BE MODIFIED. I ALSO THINK THAT THERE SHOULD BE A RECALL ON THIS PART BECAUSE SOMEONE CAN GET INJURED.
Electrical system, Jun 2, 2015
RECENT TROUBLE WITH ELECTRICAL REAR DOOR HATCH CLOSING PROPERLY. MY ONGOING PROBLEM IS AT LEAST 4+ YEARS THAT NOBODY HEARS ME. IT'S ELECTRICAL, AUTO LOCK DOORS, AC OR HEAT SHUTS OFF AND ON AD IT WANTS, TOTALLY WENT TO HI HEAT WHEN I WAS DRIVING, BUTTONS DO WHATEVER THEY WANT TO DO NO MATTER WHAT IS TURNED OFF OR ON.
Electrical system, Wheels, Other or unspecified, May 24, 2015
THIS VEHICLE HAS AN ELECTRICAL PROBLEM, MOST MECHANIC SHOPS I TOOK IT WERE NOT ABLE TO FIND OUT THE NATURE OF THE PROBLEM. I'VE CHANGED THE BATTERY TWICE AND STILL EXPERIENCING THE SAME PROBLEM. AT THE HIGH WAY I NOTICED THE THAT THE TEMPERATURE OF THE ENGINE GETS HIGH, WHICH OBLIGED TO DRIVE IN A MUCH LOWER SPEED WITH THE FLASHERS ON WHICH ALWAYS INCREASES THE TRAFFIC SAFETY RISKS.
Electrical system, Structure, Apr 18, 2015
THE POWER TAILGATE WILL NOT OPEN AND CLOSE AUTOMATICALLY. YOU HAVE TO FORCE IT TO OPEN MANUALLY AND FORCE IT TO CLOSE MANUALLY BECAUSE THE MOTOR GETS STUCK IN ONE POSITION. WE CALLED THE TOYOTA TO SEE IF THERE WAS ANY RECALLS AFTER READING SIMILAR COMPLAINTS ON THE INTERNET AND FEW LAWSUITS AGAINST TOYOTA FOR THE SAME PROBLEM, AND TOYOTA SAID NO THERE ARE NO RECALLS FOR THE TAILGATE MOTOR. THE MOTOR ITSELF COSTS ABOUT $1200 AND ONLY THE TOYOTA HAS IT, PLUS THE LABOR TO REPLACE IT WHICH COULD AMOUNTS UP TO $1500 IF YOU FIND AN OUTSIDE MECHANIC/BODY SHOP TO DO IT FOR YOU. IN ADDITION, YOU MIGHT NEED TO CHANGE THE RAILS AND SHOCKS THAT HOLD THE TAILGATE TO THE BODY OF THE CAR. IF YOU TAKE IT TO THE TOYOTA, IT COULD COST CLOSE TO $5000.00. SINCE THIS HAS OCCURRED WITH TOO MANY CONSUMERS, WE BELIEVE THERE SHOULD BE A RECALL FOR THIS PROBLEM BECAUSE IT COULD CAUSE SOME INJURIES IF SOMEONE GETS TRAPPED BETWEEN THE TAILGATE AND THE REAR BUMPER/CARGO AREA. *TR
Electrical system, Apr 9, 2015, fire
TL* THE CONTACT OWNED A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE ON THE FRONT DRIVER'S SEAT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V743000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 110,000.
Electrical system, Structure, Mar 31, 2015
THE TAILGATE MOTOR UNEXPECTEDLY MALFUNCTIONED AND CLOSED THE DOOR IN AN UNBALANCED WAY CAUSING THE BREAKING OF THE TAILGATE HINGES / ARMS. THE TAILGATE STOPPED / FROZE AND REMAINED AJAR ABOUT 1 INCH ON RIGHT PASSENGER SIDE OF THE DOOR AND LATCHING ON DRIVER'S SIDE OF THE DOOR. THE DOOR WOULD NOT MANUALLY OR ELECTRONICALLY OPEN BACK UP. HAD TO HAVE THE DOOR PHYSICALLY REMOVED BY TOYOTA DEALERSHIP AND REPLACED ENTIRE TAILGATE HATCH, MOTOR AND HINGES. COSTING ME IN THE NEIGHBORHOOD OF $5,000 FOR PARTS, LABOR, AND A RENTAL CAR FOR 12 DAYS TO REPAIR AS MY INSURANCE WITH PROGRESSIVE INSURANCE DECLINED COVERAGE UNDER MY COMPREHENSIVE INSURANCE AS THEY RELATED BACK TO WEAR AND TEAR. POTENTIAL SEVERE CRUSHING INJURY OR FATALITY COULD HAVE RESULTED FROM WHAT OCCURRED. SINCE THE DOOR CONTINUED TO CLOSE AFTER MALFUNCTIONING AND FROZE IN PLACE (UNABLE TO PHYSICALLY OPEN), HAD SOMEONE'S HAND OR BODY PART BEEN CAUGHT UNDER COULD HAVE RESULTED IN BEING CAUGHT / TRAPPED BETWEEN THE DOOR AND THE LATCHING AREA. QUICK SEARCH ON THE INTERNET SHOWS THAT THIS IS NOT THE FIRST TIME THAT THIS HAS OCCURRED. ALL SHOWING SIMILAR COST ASSOCIATED WITH REPAIR AND ALL WITH THE SAME LIFE ALTERING OR SEVERE INJURY CONSEQUENCE. WOULD LIKE TO GET TOYOTA TO RECALL THE HIGHLANDER AND FIX THE FAULTY MOTOR BEFORE SOMEONE GETS HURT OR WORSE, KILLED BY THIS DEFAULT
Electrical system, Structure, May 2, 2014
LIFTGATE DOES WILL NOT OPEN. SCHAUMBURG TOYOTA REPORTED THE FOLLOWING ON THEIR SERVICE REPORT THE FOLLOWING: "FOUND AUTO OPEN & CLOSE MOTOR SEIZED. NEED: TO GO TO BODYSHOP - REPLACE L/HINGE, MOTOR-DOOR". TOYOTA SCHAUMBURG IS SPECULATING (PURE SPECULATION) THAT THE CAR WAS BUMPED INTO AND THEREFORE THE DISTANCES (WHICH DISTANCES ?) ARE SKEWED. WE (OWNERS) BELIEVE THAT NO SUCH INCIDENCE HAPPENED. WE E-MAILED TOYOTA (CASE # [XXX].) WHO REFERRED US BACK TO [XXX]. [XXX] DID CALL BUT OFFERED NO PROOF OF THEIR SPECULATION (THAT THE CAR WAS BUMPED INTO), NEITHER DID [XXX] PROVIDE THE MISALIGNMENT NUMBERS. [XXX] DID MENTION THAT TOYOTA HAS KNOWN ABOUT THIS PROBLEM BUT THEY WILL HONOR THE PROBLEM ONLY WITHIN 3 MONTHS/36,000 MILES. THE POWER TO MY LIFTGATE IS NOW DISABLED AND I WOULD LIKE FOR TOYOTA TO ACKNOWLEDGE THAT THEY HAVE KNOWN ABOUT THIS PROBLEM AND THEREFORE MAKE THE LIFTGATE FULLY FUNCTIONAL (POWER CONNECTED) FOR ME. WE (OWNERS) ARE HONEST WHEN WE SAY THAT THE CARE WAS NOT BUMPED INTO FROM REAR-SIDE AND WE SHOULD NOT BE PAYING FOR THESE REPAIRS. I HAVE TRIED MY BEST TO WORK IT OUT WITH TOYOTA CORPORATION AND SCHAUMBURG TOYOTA, HOWEVER, BOTH ARE TRYING TO DEFLECT THE RESPONSIBILITY AWAY FROM THEMSELVES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Latches/locks/linkages, Apr 8, 2014
LEFT DRIVER'S DOOR ACTUATOR WORKS SOMETIMES WHEN PRESSING REMOTE CONTROL TO UNLOCK DOOR. LEFT REAR DOOR WORKS SOMETIMES WHEN PRESSING REMOTE CONTROL TO UNLOCK DOOR. *TR
Electrical system, Structure, Sep 5, 2013
REAR DOOR/HATCH ELECTRIC MOTOR AND LATCH/LOCK ASSEMBLY FAILED. SEVERAL INCIDENCES OF THE REAR ELECTRIC HATCH FAILING TO SEAT/CLOSE OCCURRED PRIOR TO THE FAILURE. THE DOOR WOULD START DOWN BUT WOULD NOT CLOSE/LATCH. TOYOTA SERVICE DEPARTMENT (DOTHAN, AL) SAID THE DOOR NEEDED TO BE ADJUSTED AND DID SO. ABOUT ONE MONTH LATER THE DOOR CLOSED WITH A LOUD NOISE AND WOULD NOT OPEN AFTERWARDS. UPON OUTSIDE INSPECTION, I SAW THE DOOR WAS OFFSET ABOUT A QUARTER OF AN INCH TOWARD THE PASSENGER SIDE AND SEATED ABOUT THE SAME (1/4 INCH) FURTHER IN THAN NORMAL. THE DOOR WOULD NOT OPEN AT ALL AT THAT POINT. THE SAME SERVICE DEPARTMENT INITIALLY ACCUSED ME OF DAMAGING THE CAR IN AN ACCIDENT (UNTRUE). THEY PRIED THE DOOR OPEN, AND RECOMMENDED I DISABLE THE ELECTRIC DOOR MOTOR AND ONLY OPERATE THE DOOR MANUALLY. LATER THE SAME SERVICE PERSONNEL ADMITTED THERE WAS A DESIGN PROBLEM WITH THE DOOR HINGES THAT CAUSED THE FAILURE. *JB
Electrical system, Vehicle speed control, Apr 17, 2013
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT SHE ATTEMPTED TO ACCELERATE BUT THE VEHICLE HESITATED, AFTER A BRIEF DELAY, THE ACCELERATOR ENGAGED CAUSING THE VEHICLE TO LUNGE FORWARD. ALSO, THE CONTACT STATED THAT ALL OF THE LIGHTS ON THE INSTRUMENT PANEL CONTINUOUSLY FLICKERED AND THE DRIVER'S SIDE BRAKE LIGHT WAS DEFECTIVE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THEY WERE NOT ALLOWED TO TOUCH THE VEHICLE AND CONTACTED AN INVESTIGATOR TO DIAGNOSE THE FAILURE. THE INVESTIGATOR WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 800 AND THE CURRENT MILEAGE WAS 26,500. *TR
Electrical system, Equipment, Aug 3, 2010
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED FOUR TIMES. THE CONTACT STATED THE REPAIRS WERE MADE BY AN AUTHORIZED DEALER AND THE UNIT WOULD WORK FOR A SHORT TIME BEFORE FAILING AGAIN. IN ADDITION, THE DOOR LOCKS WOULD FAIL INTERMITTENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER DUE TO THE FAILURE OF THE AIR CONDITIONING UNIT. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE FAILURE MILEAGE WAS 4,624.. UPDATED 11/22/10 *BF THE CONSUMER STATED THE CD PLAYER, DOOR AND HATCH LOCKS FAILED. THE CONSUMER HAS SINCE RECEIVED A 2010 REPLACEMENT VEHICLE. UPDATED 11/23/10
Electrical system, Vehicle speed control, Apr 12, 2010
2009 TOYOTA HIGHLANDER WAS INVOLVED IN THE FLOOR MAT RECALL. WHEN VEHICLE WAS TAKEN TO DEALER AND CONSUMER WAS TOLD THERE WAS NOTHING THEY COULD DO BECAUSE THE FLOOR MATS WERE NOT TOYOTA FLOOR MATS. *KB THE CONSUMER STATED AT TIMES THE VEHICLE WOULD NOT START. THE DEALER PERFORMED A DIAGNOSTIC TEST AND STATED THE BATTERY WAS WEAK. *JB
Engine and engine cooling, Electrical system, Jan 27, 2010, fire
2009 TOYOTA HIGHLAND HAD BEEN DRIVED FOR ABOUT 10 MINUTES, PARKED, LOCKED AT 7:25 AM ON JAN 22, 2010. APPROXIMATELY 20 MINUTES LATER A 6TH FT HIGH FLAMES WERE DISCOVERED BY THE OWNER COMING FROM THE ENGINE. SOMEONE HAD ALREADY REPORTED THE FIRE AND THE FIRE DEPARTMENT RESPONDED BY 7:50 AM.*CW