2009 Toyota Highlander
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 134 owner complaints filed for this model year. This is the 21st highest complaint count among 25 Highlander model years with reports.
Of the 2009 reports, 6 involved a crash and 5 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V023000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
134 reports, newest first.
Power train, Dec 18, 2012
THE VEHICLE SUDDENLY LOST POWER ON THE HIGHWAY. THE CAR WAS STILL RUNNING, BUT THERE WAS NO POWER TO THE WHEELS. THE FRONT DIFFERENTIAL HAD FAILED DUE TO A LEAK IN THE FRONT OF THE TRANSFER CASE. THIS FAILURE CAUSED THE TRANSMISSION TO FAIL AS WELL. *TR
Structure, Nov 28, 2012
THE POWER ARM BROKE OFF OF THE REAR POWER LIFT GATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE IS BOWED. *TR
Engine and engine cooling, Oct 25, 2012
I WAS TRAVELING 50 -60 MILES PER HOUR ON THE NEW JERSEY GARDEN STATE PARKWAY. WHILE DRIVING ALL OF A SUDDEN A HUGE VIBRATION OCCURRED THROUGH OUT THE VEHICLE. WHILE IT VIBRATED A LOUD NOISE OCCURRED. IT WAS SO LOUD MY DOG BEGAN TO BARK AND MY EARS COULD NOT TAKE THE NOISE OF THE VEHICLE. I TRIED TO BRAKE AND THE NOISE CONTINUED AS WELL AS THE VIBRATION. I CONTINUED TO TRY AND GET IN THE RIGHT LANE HOWEVER THE NOISE AND VIBRATION CONTINUED. THE VIBRATION FELT LIKE WHEN YOU GO ACROSS SPEED BUMPS THAT GIVES A RUMBLE SOUND. THE ROAD WAS SMOOTH AND THERE WERE NO SPEED BUMPS HOWEVER IT FELT AS IF I WAS GOING OVER SPEED BUMPS. ON 10/25/12 I TOOK THE VEHICLE TO TOYOTA OF HACKENSACK NJ WHERE THE VEHICLE WAS PURCHASED ON. I INFORMED THE SERVICE GUY ABOUT THE SITUATION. THEY DID A MULTI-POINT INSPECTION AND NOTHING CAME UP. THEY TEST DROVE THE VEHICLE IN CITY LIMITS AND NOTHING CAME UP. I THEN INFORMED THEM THAT THE VIBRATION DOES NOT OCCUR UNTIL YOU ARE ON THE HIGHWAY. THE TECHNICIAN THEN TEST DROVE WITH ME IN THE VEHICLE. THE VIBRATION DID NOT OCCUR. THIS SPECIFIC VIBRATION AND NOISE HAS ONLY OCCURRED TWICE SINCE I PURCHASED THE VEHICLE. I PURCHASED THE VEHICLE OVER A MONTH AGO DUE TO A FAULTY 2005 KIA SORENTO CRANKSHAFT BOLT DESIGN. IF IT HAPPENS AGAIN I WILL FILE ANOTHER COMPLAINT. *TR
Vehicle speed control, May 1, 2012, crash
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT WAS REVERSING FROM A PARKING SPACE AT 5 MPH WHEN THE ACCELERATOR PEDAL BECAME STUCK AND CAUSED THE VEHICLE TO ACCELERATE RAPIDLY. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO STOP THE VEHICLE AND AS A RESULT, SHE CRASHED INTO A TREE. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 783 AND THE CURRENT MILEAGE WAS 22,000.
Suspension, Tires, Jan 2, 2012
COMPLAINANT HAD TO REPLACE THE ORIGINAL BRIDGESTONE TIRES (245/55R19) ON A 2009 TOYOTA HIGHLANDER LTD AFTER 20,679 MILES. TREAD WEAR WAS BELOW 3/32'S. TOYOTA WOULD NOT WARRANT OR PARTICIPATE IN THE REPLACEMENT COSTS. BRIDGESTONE OFFERED TO SPLIT THE COST OF REPLACING THE FOUR TIRES WITH THEIR DUELER H/L (P245/55R19) WHICH I ACCEPTED ON APRIL 20, 2010. MY COST WAS $491.32. THE REPLACEMENT TIRES AFTER 9 MONTHS AND 17,011 MILES HAVE 5/32'S WEAR. HOWEVER, WITH THAT TIRE WEAR, THE HIGHLANDER IS UNSAFE TO DRIVE WHEN THERE IS FROST/SNOW/RAIN/ICE ON THE ROAD. THE VEHICLE LOOSES TRACTION AND IS UNCONTROLLABLE AS IT SLIDES THROUGH INTERSECTIONS. AGAIN, THE TOYOTA DEALERSHIP REFUSED TO WARRANT OR PARTICIPATE IN THE TIRE REPLACEMENT COSTS. BRIDGESTONE HAS OFFERED TO SPLIT THE COST TO REPLACE THE TIRES. THIS WOULD AMOUNT TO AN ADDITIONAL $500 (EST.) TO REPLACE TIRES THAT DO NOT WEAR PROPERLY. HOW CAN PAYMENTS OF APPROXIMATELY $1,000 FOR EIGHT TIRES THAT PROVIDE PREMATURE AND UNSAFE TIRE WEAR BE JUSTIFIED? THE VEHICLE IN ITS CURRENT CONDITION, IS A HAZARD ON THE ROAD AND UNSAFE TO DRIVE. TIRE WEAR IS PREMATURE. THE HIGHLANDER SHOULD BE RECALLED FOR A FREE FOUR WHEEL TIRE REPLACEMENT AND ALIGNMENT. UPDATED IVOQ 01/26/12 *TR
Tires, Wheels, Nov 16, 2011
OUR CAR HAS 17,000. MILES AND TURNS OUT THE TIRES ARE BARE IN SPOTS AND THE CAR HYDROPLANED AND SKIDDED AND WOULD NOT HOLD THE ROAD IN A LIGHT SNOWSTORM. WE OFTEN SKIDDED RIGHT INTO ONCOMING TRAFFIC. WE HAVE DRIVEN MANY SUVS OVER THE YEARS -WE ARE 69- AND NEVER HAD A PROBLEM. TOYOTA EMAILED TO US THAT THE TOYO A20 P245/55R19 OPEN COUNTRY TIRES THE CAR CAME WITH ARE NOT MEANT FOR DRIVING IN SNOW. WE LIVE IN VT AND THE CAR WAS SOLD TO US AS AN ALL WHEEL DRIVE CAR FOR DRIVING IN SNOW. I HAVE LOOKED AT THE INTERNET AND OTHERS HAVE HAD THE SAME PROBLEM WITH THESE TIRES. I FEEL THERE SHOULD BE A RECALL ON THEM BEFORE SOMEONE IS KILLED. MY SON JUST PURCHASE A NEW HIGHLANDER AND I WORRY HIS TIRES ARE THE SAME. *TR
Air bags, Oct 23, 2011, crash
WITHOUT PREJUDICE MY VEHICLE WAS REAR -ENDED BY ANOTHER VEHICLE AT SPEED OF APPROXIMATELY 75, AND GOT CRASHED ON TO THE CAR IN FRONT AT SPEED OF 40 TO 50. AIR BAGS FAILED TO DEPLOY AND DASH BOARD INDICATOR LIGHT CAME ON AND IT DOES NOT GO OFF. I STRONGLY BELIEVE THIS IS A MANUFACTURER DEFECT. THIS SUV CONSISTS WITH SIX AIR BAGS. NON OF THEM RESPONDED. I PURCHASE WITH CONFIDENCE THAT AIR BAGS ARE IN WORKING ORDER. MANUFACTURER RISK OUR LIFE FOR NEARLY TWO YEARS. I DESERVE COMPENSATION FOR RISKING 6 LIVES. *TR
Suspension, May 13, 2011
2009 TOYOTA HIGHLANDER CLEARANCE BETWEEN BOTH REAR "SHOCK BASE PLATE" AND BOTH REAR TIRES ARE TOO CLOSE. EVERY TIME WHEN YOU HIT A "BUMP", BOTH REAR TIRES ARE HITTING THE "REAR SHOCK BASE PLATE". THIS WILL DAMAGE BOTH REAR TIRES AND CAUSE ACCIDENT !! DEFECTIVE ENGINEERING DESIGN !! TOYOTA SHOULD RECALL ALL HIGHLANDERS WITH THIS DEFECTIVE DESIGN !!! YOU DON'T WANT TO WAIT FOR AN ACCIDENT TO HAPPEN THEN MAKE A MANDATORY RECALL. THANKS FOR READING MY MESSAGE AND CONCERN OF SAFETY FOR ALL HIGHLANDER OWNERS. *TR
Tires, Feb 6, 2011
TOYOTA HIGHLANDER 19" RIMS WITH TOYO OPEN COUNTRY A20 TIRES ARE VERY UNSAFE. THIS TIRE/WHEEL COMBINATION WAS STANDARD ON 2008/09 LIMITED AND SPORT HIGHLANDERS. MY 2009 HIGHLANDER WOULD SLIP ALL OVER THE PLACE IN WINTER DRIVING. BY FAR THE WORST WINTER VEHICLE I EVER OWNED AND I'VE OWNED PLENTY THAT WERE NOT ALL-WHEEL DRIVE. LUCKILY THE TRACTION CONTROL SYSTEM IS GOOD AND SAVED ME FROM SEVERAL ACCIDENTS. TOYOTA USED VERY LARGE 19" RIMS AND PERFORMANCE TIRES ON THE VEHICLE. THE TIRES WERE WORN OUT AFTER 18 MONTHS AND 21,000 MILES. WHY TOYOTA THOUGHT BIG WHEELS AND PERFORMANCE TIRES WERE IMPORTANT TO AN SUV PURCHASER IS BEYOND ME. TOYOTA ALSO REFUSES TO STAND BEHIND THEIR SAFETY DEFECT (NOT TO MENTION THE TIRES ONLY LASTED 21,000 MILES). I PURCHASED 17" RIMS ON MY OWN AND TOYO PROVIDED CREDIT FOR 2 OF THE 4 NEW OPEN COUNTRY HT TIRES AND THE SUV IS NOW MUCH SAFER - IT NO LONGER FEELS LIKE I AM RIDING ON ROLLER SKATES! *TR
Child seat, Nov 4, 2010
SUNSHINE KIDS RADIAN XTSL LATCH LOOSENS ITSELF. TWO TIMES I'VE GONE TO PUT MY 2 YEAR OLD INTO HER SEAT AND THE LATCH HAS HAD AT LEAST 2 INCHES OF SLACK!! PLEASE FIX THIS!! (RELATED VEHICLE INFORMATION: MODEL YEAR=2009, MAKE=TOYOTA, MODEL=HIGHLANDER). *TR
Vehicle speed control, Oct 18, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED DEALER FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V023000, VEHICLE SPEED CONTROL: ACCELERATOR PEDAL. UPON RECEIVING THE VEHICLE HE WAS DRIVING APPROXIMATELY 22 MPH AND WHEN HE REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL, THE VEHICLE DID NOT STOP ACCELERATING. THE VEHICLE WAS NOT TAKEN TO BE EXAMINED FOR THE CAUSE OF FAILURE AND WAS NOT REPAIRED. THE FAILURE CONTINUED TO OCCUR WHENEVER HE RELEASED THE ACCELERATOR PEDAL. THE FAILURE AND CURRENT MILEAGES WERE 14,100.
Steering, Suspension, Service brakes, Hydraulic, Engine and engine cooling, Seat belts, Vehicle speed control, Wheels, Seats, Aug 23, 2010
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SUSPENSION WAS LOOSE AND THE BRAKING SYSTEM WOULD NOT OPERATE PROPERLY. THE BRAKES WOULD GO TO THE FLOORBOARD WHEN DEPRESSED. THE BRAKES WOULD NOT ENGAGE INTERMITTENTLY WHEN DEPRESSED. THE CONTACT STATED THAT THE DRIVER'S SEAT WOULD NO LONGER MOVE BACKWARD, AND WAS POSITIONED ENTIRELY TOO CLOSE TO HE STEERING WHEEL. THE CONTACT STATED THERE WAS LITTLE ROOM FOR MOVEMENT WHEN DRIVING. THE VEHICLE WAS TAKEN TO FOUR SEPARATE DEALERS AND THE CONTACT WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 400 AND THE CURRENT MILEAGE WAS 6,500. THE CONSUMER STATED WHEN SHE REALIZED A POLICE OFFICER WAS BEHIND SHE ATTEMPTED TO STOP, THE VEHICLE CONTINUED TO ACCELERATE AND THE BRAKES COLLAPSED VERY LOW TO THE FLOOR. THE CONSUMER HAD TO PUMP THE BRAKES TO SLOW THE VEHICLE DOWN. THE CONSUMER ALSO STATED THE LUG NUTS BROKE ON THE FRONT DRIVER SIDE WHEEL. THE CRUISE CONTROL WAS INOPERATIVE, AND THE ENGINE HAD A SLIGHT TICKING SOUND AND THE ROTORS WERE RUSTING. UPDATED EVOQ 12/23/10 THE CONSUMER STATED THE SEAT BELT WRAPPED TIGHTLY AROUND HER THROAT. THE FRONT WHEEL WAS LOOSE, THERE WAS A WHINING NOISE COMING FROM THE VEHICLE. WHEN THE CONSUMER ATTEMPTED TO ACCELERATE THE VEHICLE WOULD STALL, THE CRUISE CONTROL NO LONGER WORKED. THE ACCELERATOR PEDAL NO LONGER STAYS IN PLACE AND THE STEERING WHEEL TURNED IN DIFFERENT DIRECTIONS. UPDATED 07/07/11. *JB
Electrical system, Equipment, Aug 3, 2010
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED FOUR TIMES. THE CONTACT STATED THE REPAIRS WERE MADE BY AN AUTHORIZED DEALER AND THE UNIT WOULD WORK FOR A SHORT TIME BEFORE FAILING AGAIN. IN ADDITION, THE DOOR LOCKS WOULD FAIL INTERMITTENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER DUE TO THE FAILURE OF THE AIR CONDITIONING UNIT. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE FAILURE MILEAGE WAS 4,624.. UPDATED 11/22/10 *BF THE CONSUMER STATED THE CD PLAYER, DOOR AND HATCH LOCKS FAILED. THE CONSUMER HAS SINCE RECEIVED A 2010 REPLACEMENT VEHICLE. UPDATED 11/23/10
Tires, Jul 4, 2010
TURNING RIGHT FROM CITY HIGHWAY TO CITY STREET AT ABOUT 15 MPH AND RR TIRE HAD SIDEWALL BLOWOUT. HAD TO REPLACE TIRE WITH SAME BRAND AS ONLY BRIDGESTONE AND TOYO MAKE A TIRE THIS SIZE FOR 2009 TOYOTA HIGHLANDER. 245/55R19. *TR
Power train, Jun 9, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHILE TURNING AT APPROXIMATELY 5 MPH IN SNOWY CONDITIONS, THE VEHICLE BECAME STUCK IN THE SNOW. THE VEHICLE WAS ABLE TO REVERSE BUT WOULD NOT ACCELERATE FORWARD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED AT THAT TIME. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 11,000. UPDATED 11/03/10 *BF UPDATED 11/04/10
Electrical system, Vehicle speed control, Apr 12, 2010
2009 TOYOTA HIGHLANDER WAS INVOLVED IN THE FLOOR MAT RECALL. WHEN VEHICLE WAS TAKEN TO DEALER AND CONSUMER WAS TOLD THERE WAS NOTHING THEY COULD DO BECAUSE THE FLOOR MATS WERE NOT TOYOTA FLOOR MATS. *KB THE CONSUMER STATED AT TIMES THE VEHICLE WOULD NOT START. THE DEALER PERFORMED A DIAGNOSTIC TEST AND STATED THE BATTERY WAS WEAK. *JB
Service brakes, Hydraulic, Apr 1, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHILE DRIVING DOWN HILL AT 2 MPH, THE BRAKES BEGAN TO SHUDDER AND THE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INDICATED SHIFT TO P FUNCTION. WITHIN A FEW MINUTES, ANOTHER WARNING LIGHT INDICATED, BRAKE DEFAULT CONTACT THE DEALER IMMEDIATELY ILLUMINATED. THE VEHICLE WAS TURNED OFF AND AFTER IT WAS RESTARTED; THE WARNING LIGHTS WERE NO LONGER ILLUMINATED. THE CONTACT CALLED THE DEALER AND WAS INFORMED THAT THEY WERE NOT FAMILIAR WITH THAT TYPE OF FAILURE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED WHEN THE COMPLAINT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 20,107.
Air bags, Mar 9, 2010
PASSENGER SIDE FRONT AIR BAG WARNING LIGHT INDICATES AIR BAG NOT FUNCTIONAL. OCCURS AT RANDOM TIMES, WILL STAY THAT WAY FOR DAYS OR WEEKS, THEN REVERT TO NORMAL. SOMETIMES AT SAME TIME FAN GOES TO HIGH, AIR CONDITIONING GOES ON, OR FLOOR/AIR DIAL SWITCHES TO ALL DEFROST, OR EMERGENCY LIGHTS SWITCH ON. DEALERSHIP SAID THE PROBLEM WAS MALFUNCTIONING WEIGHT LEVER IN SEAT, COULDN'T EXPLAIN THE REST OF IT, AND THEY NEVER DID ANYTHING TO TRY TO FIX IT. HOWEVER, IT SEEMS TO BE ELECTRONIC ISSUE AS IT SOMETIMES WORKS. *TR
Vehicle speed control, Mar 9, 2010
TL* THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHENEVER THE VEHICLE IS SITTING IDLE AND THE CONTACT WOULD ATTEMPT TO ACCELERATE, THE TWO FRONT WHEELS WOULD BEGIN TO SPIN OUT WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 2,500.
Power train, Mar 3, 2010
WE BOUGHT A NEW 2009 TOYOTA HIGHLANDER IN JULY,2009. IMMEDIATELY, IT DEMONSTRATED A HUGE VIBRATION IN REVERSE, AND NOW IN DRIVE. WHEN I STOP AT A LIGHT, IT FEELS LIKE IT WILL BOLT WHEN I TAKE MY FOOT OFF THE BRAKE. WE WENT THROUGH ARBITRATION, BUT THEY CLAIMED, SINCE WE COULDN'T PROVE IT WAS A SAFETY HAZARD, WE HAD NO CASE. I THINK THESE VEHICLES SHOULD ALSO BE INVESTIGATED. I HAVE READ SIMILAR COMPLAINTS ON THE INTERNET FROM OTHER HIGHLANDER OWNERS. I AM REALLY FEARFUL TO DRIVE MY FAMILY IN THIS VEHICLE. FOR TOYOTA TO TELL ME THAT, YES THERE IS A SEVERE VIBRATION, BUT THERE IS NOTHING WRONG WITH THE VEHICLE IS ABSOLUTELY PREPOSTEROUS. TOYOTA SAYS THEY DON'T KNOW WHAT IS WRONG WITH IT, SO THEY SAY NOTHING IS WRONG WITH IT. OUR OWN MECHANIC SAYS THAT HE BELIEVES IT WILL JOIN THE OTHER RECALLS AT SOME POINT. BUT I REALLY HOPE YOU WILL LOOK INTO IT SOON. THANK YOU. *TR
Vehicle speed control, Mar 1, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT ON AT LEAST FOUR OCCASIONS, THE VEHICLE SUDDENLY ACCELERATED WHEN THE DRIVER WOULD DEPRESS THE PEDAL GENTLY AFTER A STOP. THE VEHICLE ALSO ACCELERATED WHEN THE VEHICLE WAS SHIFTED INTO REVERSE. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP BUT THE DEALER COULD NOT FIND WHAT THE CAUSE FOR THE FAILURE WAS. HE CALLED THE MANUFACTURER AND THE REPRESENTATIVE INSTRUCTED HIM TO TAKE THE VEHICLE TO THE DEALERSHIP. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 7,000. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.
Service brakes, Hydraulic, Feb 26, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHILE DRIVING 15 MPH DURING A SNOW STORM THE WHEELS LOCKED. THE BRAKES ALSO LOCKED WHILE DRIVING DOWN A HILL WHICH CAUSED THE VEHICLE TO SLIDE 200 FEET. THE DEALER WAS NOTIFIED. THE FAILURE MILEAGE WAS 10,250. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 10,430. UPDATED 11/16/10. *LJ
Engine and engine cooling, Feb 17, 2010, fire
BRAND NEW 2009 TOYOTA HIGHLANDER DEFECTIVE FRONT O2 SENSOR MADE OUT OF CERAMIC BUILT INTO ALL CARS IN JAPAN THEN SHIPPED TO U.S. FIRST SIGN OF SENSOR DAMAGE THE CARS TRACTION CONTROL LIGHT GOES ON. SOON AFTER THE FRONT O2 CERAMIC SENSOR HEATS UP. THEN THE CAR WILL NOT START. WHEN YOU TRY TO START IT UP AT THIS POINT ENGINE HAS CAUGHT ON FIRE. THE GENERAL MANAGER OF DEALERSHIP STATED THAT TOYOTA KNOWS OF THIS DEFECTIVE PART BUT WILL NOT RECALL. WE BELIEVE OWNERS SHOULD BE NOTIFIED. THE PART WAS REPLACED. HOWEVER, WE DID NOT FEEL CAR WAS SAFE AFTER SEEING ENGINE ON FIRE. THE DEALERSHIP WOULD NOT REFUND MONEY. OUR ONLY OPTION ALLOWED WAS TO TRADE IN CAR FOR ANOTHER AT OUR COST. THIS ALL HAPPENED WITHIN 3 DAYS OF TAKING DELIVERY OF THE VEHICLE AND HAVING ONLY DRIVEN IT 40 MILES.*TR
Service brakes, Hydraulic, Feb 4, 2010
TL*THE CONTACT OWNS 2009 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 22 MPH AND ENGAGING THE BRAKE PEDAL IN ATTEMPT TO STOP THE VEHICLE, SHE WAS FORCED TO APPLY EXTREME PRESSURE. THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. A CLAIM WAS FILED WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 58,000.
Vehicle speed control, Feb 1, 2010
TL*THE CONTACT OWNS A 2009 TOYOTA HIGHLANDER. WHILE DRIVING 40 MPH AND REMOVING HER FOOT FROM THE BRAKE PEDAL THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT APPLIED NORMAL PRESSURE TO THE BRAKE PEDAL WHEN THE VEHICLE SLOWED DOWN AND STOPPED. THE FAILURE IS CONSISTENT AND OCCURS DAILY. THE DEALER STATED THAT THEY COULDN'T DUPLICATE THE PROBLEM OR IDENTIFY A FAILURE WHERE THE ACCELERATOR PEDAL LOST PRESSURE WHILE DRIVING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 700 AND THE CURRENT MILEAGE WAS 3300.