2011 Toyota Highlander
Problems, recalls and owner-reported issues
Steering is the leading concern among 186 owner complaints filed for this model year. This is the 17th highest complaint count among 25 Highlander model years with reports.
Of the 2011 reports, 14 involved a crash. 8 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Equipment, other, labelsApr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V123000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Representative owner complaints: visibility/wiper
25 reports, newest first. Show all
Visibility/wiper, Mar 20, 2019
DRIVER SIDE SUN VISOR STUCK IN DOWN POSITION, AND WILL NOT MOVE UPWARD OUT OF THE WAY, OBSTRUCTING DRIVER'S VIEW. IT CAN BE MOVED TO THE SIDE WINDOW, BUT THEN THE SIDE VIEW IS OBSTRUCTED. I HESITATE TO TRY AND FORCE IT UP, BECAUSE IT FEELS LIKE IT WOULD BREAK AND JUST FLOP AROUND. RESEARCHING THE PROBLEM, I HAVE LEARNED OF MANY OTHER OWNERS OF SIMILAR-VINTAGE TOYOTA HIGHLANDERS WHO HAVE EXPERIENCED THE SAME PROBLEM. THE TOYOTA DEALER QUOTED OVER $300 TO REPLACE WITH A NEW PART. THIS IS SAFETY ISSUE THAT SHOULD BE RECALLED BY THE MANUFACTURER.
Visibility/wiper, Apr 27, 2018
DRIVER SIDE SUN VISOR NO LONGER STAYS UP AND BLOCKS THE DRIVERS VISION WHILE DRIVING. THIS SEEMS TO BE A ON GOING PROBLEM WITH TOYOTA SUN VISORS.
Structure, Visibility/wiper, Mar 31, 2016
THE DRIVER SIDE WINDOW IS OFF THE TRACK AND UNABLE TO ROLL UP. PRIOR TO THE WINDOW FALLING OFF THE TRACK, THE DRIVER SIDE WINDOW WOULD MAKE A POPPING NOISE AND WOULD RATTLE WHEN GOING UP OR DOWN. THE ISSUE IS EXACTLY LIKE THE 2010 NHTSA REFERENCE #10037962 AND TSB REFERENCE #T-SB-0010-11.
Visibility/wiper, Sep 5, 2015
DRIVER'S SIDE VISOR IS BROKEN AND STUCK AT A 45 DEGREE ANGLE, AND WILL NOT STAY IN THE UPRIGHT POSITION, OBSTRUCTING VISIBILITY WHEN DRIVING. THIS APPEARS TO BE A DESIGN ISSUE OF THIS PARTICULAR MODEL, AS THERE ARE MANY SIMILAR COMPLAINTS ONCE DOING A SIMPLE INTERNET SEARCH.
Visibility/wiper, Jul 24, 2015
DRIVER'S SIDE VISOR WON'T STAY CLOSE TO THE CEILING .
Visibility/wiper, Jul 10, 2015
AS I ATTEMPTED TO LOWER THE VISOR ON THE DRIVERS SIDE, THE MECHANISM BROKE AND IT WOULD NEITHER STAY OR OR DOWN - BLOCKING VISIBILITY. I KNOW A COUPLE OF MY FRIENDS WHO OWN HIGHLANDERS HAVE HAD THE SAME PROBLEM AND THE DEALERSHIP I WENT TO SAID THAT TOYOTA WAS GOING TO DO SOME TYPE OF "EXTENDED WARRANTY" TO COVER THE COST. HOW DO I APPLY FOR THAT?
Visibility/wiper, Jun 16, 2015
THE DRIVER'S SIDE VISOR IS STUCK IN THE DOWN POSITION. THIS IS CREATING DIFFICULTY SEEING AND I HAVE HIT MY HEAD ON THE VISOR A FEW TIMES. I TOOK THE VEHICLE TO TOYOTA EXPECTING IT TO BE COVERED UNDER MY EXTENDED WARRANTY ONLY TO BE TOLD THAT THE COST WAS ROUGHLY $230 FOR THE PART AND AN ADDITIONAL $30 TO INSTALL. CLEARLY WITH THIS CREATING A VISIBILITY HAZARD AND THE SHEER NUMBER OF COMPLAINTS THIS SHOULD BE A FACTORY RECALL. ...UPDATED08/20/15 *BF UPDATED 11/27/15*JS
Visibility/wiper, Apr 29, 2015
THE SUN VISOR ON THE DRIVER SIDE FAILED AND FLIPPED DOWN, IT HAS SINCE REMAINED IN THE DOWN POSITION AND NO LONGER LOCKS IN PLACE. I AM TALLER THAN MY WIFE SO IT IS A PROBLEM FOR ME WHEN I DRIVE HER CAR. I JUST CHECKED THE FORUMS AND THIS IS SUCH A COMMON PROBLEM THAT YOU CAN'T EVEN ORDER REPLACEMENT SUN VISORS SINCE THEY SELLOUT VERY QUICKLY. *TR
Other or unspecified, Equipment adaptive/mobility, Visibility/wiper, Jan 14, 2015
THE SUN VISOR POPPED WHEN I WAS PULLING IT DOWN TO SHEILD MY EYES AND NOW IT WILL NOT RETURN TO ORIGINAL POSITION. CONCERN AS IT GETS IN MY WAY WHEN DRIVING. THIS IS THE DRIVERS SIDE VISOR WHICH I TEND TO HIT MY HEAD ON AND HAVE TO MOVE MY SEAT LOWER IN ORDER TO SEE PROPERLY. I TOOK IT TO MY DEALERSHIP AND THEY TOLD ME IT WOULD BE $300 TO FIX. THAT IS RIDICULOUS AS I FEEL THIS IS A FAULTY PART THAT COULD BE A HAZARDOUS SITUATION IF NOT TAKEN CARE OF. RECAL MAY BE IN ORDER TO CORRECT THIS ISSUE.
Visibility/wiper, Dec 17, 2014
THE DRIVER SIDE SUN VISOR SPRING BROKE PREVENTING THE VISOR FROM EITHER FOLDING BACK UP OR COMING DOWN COMPLETELY, CAUSING A VISIBILITY PROBLEM AND A SAFETY HAZARD. *TR
Visibility/wiper, Nov 28, 2014
THE DRIVER SIDE SUN VISOR SPRING IS BROKE SO THAT VISOR BLOCKS DRIVER'S VISION CAUSING POTENTIAL SAFETY ISSUE. STAYS IN PARTIALLY DOWN POSITION. CONTACTED DEALER AND TOYOTA CUSTOMER CARE. THERE WERE OVER 300 SUN VISORS ON BACK ORDER WITH NO DELIVERY PROMISE DATE AS PRODUCTION OF VISOR HAS BEEN HALTED. THERE ARE NO REPAIRS. INTERESTING TO NOTE THAT 17 OF THE 66 COMPLAINTS IN DATA BASE FOR HIGHLANDER ARE SUN VISOR ISSUES. TOYOTA CUSTOMER CARE SAYS NO RECALLS, SERVICE BULLETINS. DEALER WANTS OVER $300 TO REPAIR, IF HE COULD GET A VISOR. THIS CLEARLY A GENERIC ISSUE WITH SAFETY IMPLICATIONS! *TR
Visibility/wiper, Oct 1, 2014
DRIVER-SIDE SUN VISOR BROKE AND FAILED TO STAY IN UP POSITION, BLOCKING DRIVER'S VIEW OF ROAD AND CREATING A DISTRACTION. CAR WAS BROUGHT INTO DEALERSHIP FOR REPAIRS ON 16 AUGUST BUT SERVICE PERSONNEL INDICATED THAT THEY HAD NO VISORS IN STOCK. ORDERED ONE THAT DAY BUT COULD NOT GET THE PART UNTIL MID SEPT. PEOPLE AT THE DEALERSHIP INDICATED THAT THEY WERE HAVING TROUBLE GETTING THE PART BECAUSE THIS WAS A NATIONWIDE PROBLEM AND SUPPLIER COULD NOT KEEP UP WITH DEMAND. *TR
Visibility/wiper, Sep 26, 2014
DRIVER SIDE SUN VISOR SUDDENLY DROPS BLOCKING VIEW ALMOST HITTING A DEER ON THE ROAD. SUN VISOR (NOT USE OFTEN) IS NOW LOOSE AND WILL NOT GO BACK IN PLACE. SUN VISOR NOW BLOCKS VIEW WHICH DRAMATICALLY INCREASE THE PROBABILITY OF AN ACCIDENT THAT COULD BE FATAL. *TR
Electrical system, Visibility/wiper, Jun 24, 2014
THE REAR HATCH DOOR SENSOR GOES OFF WHEN THE CAR MAKES A TURN OR IS DRIVEN OVER BUMP. THE DEALERSHIP SAID THE DOOR SENSOR SYSTEM MUST BE REPLACED AT AN ESTIMATED COST OF MORE THAN $700. ALSO, DRIVER'S SIDE VISOR DOES NOT STAY UP. COST TO REPLACE, $300. *TR
Structure, Visibility/wiper, Jun 7, 2014
DRIVER SIDE VISOR HANGS DOWN AND WILL NOT RETURN TO UP POSITION. THERE HAVE BEEN SEVERAL CONCERNS OF THIS TYPE NOTED A ON THIS DATABASE AND THIS SHOULD BE ADDRESSED AS A SAFETY RECALL ISSUE SINCE IT OBSTRUCTS DRIVER VISIBILITY. *TR
Visibility/wiper, Feb 22, 2014
DRIVER SIDE VISOR WILL NOT STAY UP. BLOCKS DRIVERS VISION. APPEARS TO BE WIDESPREAD FAILURE SINCE 2002. TOYOTA WILL NOT COVER OUT OF WARRANT, WANTS $650 FOR REPLACEMENT PART!! *TR
Visibility/wiper, Jan 21, 2014
DRIVER SIDE SUN VISOR WILL NO LONGER GO UP ALL THE WAY. IT IS STUCK PARTIALLY UP AND HAS RESISTANCE. IT IS NOW ONLY DOWN AND BLOCKING MY VIEW OF DRIVING. THIS IS SAFETY ISSUES AND A RECALL ORDERED. *TR
Visibility/wiper, Jan 21, 2014
DRIVER SIDE SUN VISOR WILL NO LONGER GO UP ALL THE WAY. IT IS STUCK PARTIALLY UP AND HAS RESISTANCE. IT IS NOW ONLY DOWN AND BLOCKING MY VIEW OF DRIVING. THIS IS A SAFETY ISSUE AND NEED TO BE RECALLED. *TR
Visibility/wiper, Dec 22, 2013
SUN VISOR WILL NO LONGER GO UP ALL THE WAY. IT IS STUCK PARTIALLY UP AND HAS RESISTANCE. IT IS NOW ONLY DOWN AND BLOCKING MY VIEW OF DRIVING. *TR
Visibility/wiper, Dec 2, 2013
THE DRIVER'S SIDE VISOR NO LONGER STAYS UP...IT FALLS DOWN HALFWAY WHICH IS BLOCKING MY VISION. THIS IS A VERY DANGEROUS SAFETY CONCERN. I CALLED THE DEALER AND WAS TOLD IT WOULD HAVE TO BE REPLACED FOR A COST OF $318.00. THIS IS OUTRAGEOUS AND TOYOTA SHOULD BE ASHAMED FOR NOT POSTING A RECALL ON SOMETHING SO DANGEROUS WHEN THERE ARE SO MANY COMPLAINTS. *TR
Visibility/wiper, Nov 10, 2013
DRIVERS SIDE VISOR IS BROKEN & WILL NOT STAY UP! ONLY REMEDY FROM TOYOTA DEALERSHIP IS TO PAY FOR ANOTHER (PROBABLY DEFECTIVE) VISOR (PARTS & INSTALLATION). THIS IS DEFINITELY A SAFETY HAZARD & TOYOTA NEEDS TO BE PROFESSIONAL ENOUGH TO FIX THIS PROBLEM (WITHOUT CHARGING THEIR CUSTOMERS)! I'M EXTREMELY DISAPPOINTED IN THIS LACK OF QUALITY FROM TOYOTA. *TR
Visibility/wiper, Nov 5, 2013
DRIVERS SIDE VISOR IS BROKEN & WILL NOT STAY UP! ONLY REMEDY FROM TOYOTA DEALERSHIP IS TO PAY FOR ANOTHER (PROBABLY DEFECTIVE) VISOR (PARTS & INSTALLATION). THIS IS DEFINITELY A SAFETY HAZARD & TOYOTA NEEDS TO BE PROFESSIONAL ENOUGH TO FIX THIS PROBLEM (WITHOUT CHARGING THEIR CUSTOMERS)! I'M EXTREMELY DISAPPOINTED IN THIS LACK OF QUALITY FROM TOYOTA. *TR
Visibility/wiper, Jul 19, 2013
TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER'S SIDE SUN VISOR FELL DOWN AND FAILED TO REMAIN UPRIGHT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS ADVISED THAT THE SUN VISOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 74,000. *TR
Visibility/wiper, Jan 16, 2013
SUN VISOR DOES NOT RETURN TO UPRIGHT POSITION. IT HANGS AND OBSTRUCTS DRIVER'S VISION. I HAVE READ ONLINE THE EXCESSIVELY HIGH NUMBER OF TOYOTA OWNERS WHO EXPERIENCE THIS PROBLEM. IT IS SO DANGEROUS AND A FIX IS COST PROHIBITIVE. TOYOTA SHOULD BE HELD RESPONSIBLE FOR MANUFACTURING A DEFECTIVE PART. VISION IS PROBABLY THE MOST CRITICAL COMPONENT FOR A DRIVER AND WHEN IT IS OBSTRUCTED BY A PART OF THE MANUFACTURER'S NEGLECT, THEN IT SHOULD BE ADDRESSED IMMEDIATELY. *TR
Visibility/wiper, Dec 16, 2012
LEFT SIDE SUN VISOR FAILED, VISOR DROPS DOWN IN FRONT OF DRIVER. *TR