2005 Toyota RAV4
Problems, recalls and owner-reported issues
Air bags is the leading concern among 141 owner complaints filed for this model year. This is the 24th highest complaint count among 26 RAV4 model years with reports.
Of the 2005 reports, 22 involved a crash and 2 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontal, passenger side, inflator moduleOct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Campaign 19V741000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleDo not drive until repairedMay 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify owners, and dealers will replace the driver's frontal air bag, free of charge. Owners were mailed an interim notice June 17, 2015. The recall began on August 21, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 15V284000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Air bagsApr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Campaign 06V096000 on NHTSA.gov
Representative owner complaints: other or unspecified
11 reports, newest first. Show all
Other or unspecified, Dec 29, 2025
Electronic door locking mechanism on front passenger side has failed and cannot be controlled by the key fob like the other doors. Therefore, it is necessary for the driver to reach across the front seat to lock and unlock this door. The locking mechanism’s failure could be considered an inconvenience. However, there wss an incident where a friend and I were taking the train to the city, leaving the vehicle unattended in a railroad station parking lot for 10-12 hours. I used the key fob to lock all of the working doors, but my friend forgot to manually lock the front passenger door. Unfortunately, this oversight created the risk of theft. This could also pose a safety hazard to the front seat passenger in an emergency situation where he or she must quickly evacuate the vehicle in case of fire, for example. The critical issue lies in the fact that, in an emergency, the driver can press the key fob to quickly unlock all exit doors EXCEPT for the front passenger side, leaving that seat’s occupant struggling to locate the unlock button as smoke from the fire quickly fills the vehicle. First responders would have to pry the door open in this crisis situation when every second counts. A licensed auto mechanic has checked the vehicle and advised me that it would be necessary to dismantle and rebuild the car door at a cost of $300-$400 in order to correct this situation, which is an expense I cannot afford on my limited income. My vehicle is available for inspection as necessary. Thank you for any assistance you are able to provide.
Other or unspecified, Jun 20, 2024
Very often, while driving at normal speeds around curving and hilly roads, the traction control light comes on. It even locks the speed until the light goes off. And sometimes the VSC (Vehicle stability control) light comes on and takes control of the car. When the warning lights go off, the car returns to normal. I took the car to Kauai Toyota Service Department. They said that they cannot troubleshoot the problem until one of the lights stay on continuously. It is a little disconcerting when this happens while driving. I love this car and what to keep it. But I want to get to the problem and fix it. Is it possible for a repair facility to use a computer to back track the alarms and pinpoint the problem? Thanks for your time and response.
Steering, Other or unspecified, Service brakes, Feb 4, 2021
WHEN DRIVING AT OR UNDER THE SPEED LIMIT ON SOME TURNS MY CARS SLIP INDICATOR GOES OFF WITHOUT ANY APPARENT ISSUES AND IT WILL START BEEPING AND SOMETIMES IT EVEN BREAKS ON IT'S OWN AND JERKS THE CAR. THE SLIP INDICATOR LIGHT HAS TURNED ONE WHILE DRIVING UNDER 30 MPH IN A DRY AND PAVED ROAD. THE BEEPING AND JERKING HAS HAPPENED ON THE FREEWAY
Other or unspecified, Jun 6, 2019
MY CHECK ENGINE LIGHT HAS BEEN ON FOR APPROXIMATELY 50,000 OF THE 255,000 MILES ON MY RAV4. IT HAS BEEN ON IT SEEMS MOSTLY BECAUSE OF OXYGEN SENSORS AND RELATED EMISSIONS "ISSUES" AND THIS HAS COST ME THOUSANDS OVER THE YEARS IN DIAGNOSTICS, TROUBLESHOOTING, AND MASKING OTHER PROBLEMS THAT REALLY WERE OCCURRING. THE CHECK ENGINE LIGHT IS ON SO MUCH THAT IT'S HARD TO TELL WHEN THERE REALLY IS A PROBLEM. RECENTLY MY CHECK ENGINE LIGHT WAS ON FOR ABOUT 9 MONTHS. THE MECHANIC CODES REVEALED THAT IT WAS RUNNING TOO "RICH." I PUT IT ON "NON-OPERABLE" FOR REGISTRATION PURPOSES WHILE I AGAIN TRIED TO FIGURE OUT WHY. ONE DAY (ON A TEMPORARY MOVING PERMIT) I WENT TO GET GASOLINE AND FILLED THE TANK HALFWAY. A FEW MILES LATER THE CHECK ENGINE LIGHT WENT OFF, FOR NO APPARENT REASON. I WENT TO GET A SMOG CHECK, AND WHEN I ASKED ABOUT THE FAIL POLICY AT THE STATION, THE ATTENDANT SAID, "THESE TOYOTAS ALWAYS PASS THE EMISSIONS, AS LONG AS THE CHECK ENGINE LIGHT ISN'T ON." HE WAS RIGHT, AND MY RAV4 PASSED WITH PERFECT EMISSIONS COMPLIANCE. IN THE PAST I HAVE REPLACED MY CATALYTIC CONVERTER, ALL THE OXYGEN SENSORS, AND EVENTUALLY THE ENTIRE EXHAUST MANIFOLD IN ORDER TO GET THE CHECK ENGINE LIGHT TO GO OFF AND PASS A CA SMOG CHECK. SOME YEARS AGO MY CHECK ENGINE LIGHT WAS ON FOR ABOUT A YEAR AND A HALF. IT WAS LEAKING OIL, AND MY MECHANIC SAID JUST TO MAKE SURE IT HAD ENOUGH OIL IN IT UNTIL I COULD AFFORD TO FIX THE "LEAKY GASKETS." BUT THE PROBLEM WAS REALLY A FAULTY OIL PUMP, AND THE ENGINE SEIZED. I HAD A REBUILT ENGINE PUT IN, AND THE CHECK ENGINE LIGHT WENT OFF. THE TOYOTA RAN FINE FOR 6 MONTHS. THEN THE CHECK ENGINE LIGHT CAME ON AGAIN. IN ALL OF THIS, TOYOTA CUSTOMER SERVICE ACCEPTS NO FAULT. THEY SAY I SHOULD COMPLAIN TO NHTSA, AND THEY DON'T HAVE ANY RECALLS. I HAVEN'T HAD SUCH AN UNRELIABLE CAR SINCE MY 1984 CHEVY CHEVETTE. MY NEXT CAR WON'T BE A TOYOTA.
Other or unspecified, Visibility/wiper, Jan 25, 2019
DRIVERS SIDE VISOR WILL NOT STAY UP. FALLS DOWN CONSTANTLY. DRIVER CANNOT SEE WHEN IT HAPPENS. I BOUGHT MY RAV4 USED AND DIDNT NOTICE IT UNTIL MY HUSBAND DROVE IT. IT DOESN'T BOTHER ME BECAUSE I'M SHORT. WHEN MY HUSBAND DRIVES IT WE HAVE TO RIG IT TO STAY UP BUT NOTHING EVER WORKS FOR LONG BEFORE IT FALLS DOWN AGAIN. IT COULD EASILY CAUSE AN ACCIDENT IF DRIVING IN HEAVY TRAFFIC.
Other or unspecified, Oct 3, 2018
THE DRIVER'S SIDE VISOR WILL NOT STAY IN POSITION. IT FLOPS DOWN WHEN I'M DRIVING, MAKING IT SUDDENLY HARD TO SEE. THE PROBLEM STARTED VERY GRADUALLY A FEW YEARS AGO BUT NOW HAS RAPIDLY GOTTEN MUCH WORSE. I THINK TOYOTA SHOULD HAVE A RECALL ON THIS PROBLEM. MY LOCAL DEALERSHIP WILL NOT COVER THE REPLACEMENT AND IN COST, NOR WILL TOYOTA. I KNOW ABOUT THE COMPANY BECAUSE I CALLED THEM AND THEY SAID IT'S MY PROBLEM TO FIX. HOWEVER, THIS IS A KNOWN SAFETY ISSUE, AND THEY ARE IGNORING THEIR RESPONSIBILITY. THE VISOR ALONE COSTS $107.52 ! THE INSTALLATION COST IS IN ADDITION TO THIS (BTW, I SELECTED TODAY'S DATE, BECAUSE I DON'T HAVE AN EXACT DATE. THE SAME APPLIES TO THE MPH - IT HAPPENS AT ALL MPH.).
Other or unspecified, Jan 18, 2018
THE VSC TRAC, VSC OFF, AND ABS LIGHTS... ALL STAY ON, ALL THE TIME. THERE ARE NO DIAGNOSTIC CODES SHOWING ON THE OBD CODE READER.
Structure, Other or unspecified, Oct 26, 2017, crash
"TAKATA RECALL". I WAS DRIVING AND STOPPED FOR A LIGHT DOWN A ROAD IN STATEN ISLAND, NY. AS I WAS WAITING, A DEER WAS CROSSING THE ROAD. SIMULTANEOUSLY, A BUS WAS NEXT TO ME AND SCARED THE DEER WHICH CAUSED IT TO RUN STRAIGHT INTO MY VEHICLE DOING A FAIR AMOUNT OF DAMAGE WHICH HAS SINCE BEEN FIXED. MY AIRBAG DID NOT INFLATE, EVEN THOUGH I WAS HIT PRETTY HARD. I WAS SHAKEN UP BUT SUFFERED NO MAJOR INJURIES. RECALL#15V284
Vehicle speed control, Other or unspecified, Nov 6, 2015, crash
RAV4 WAS TOTAL STOPPED ON A STOP SIGN. ON TAKING THE FOOT OFF THE BRAKE PADDLE TO MOVE AHEAD ON GREEN SIGNAL, EVEN BEFORE THE FOOT TOUCHED THE ACCELERATOR PADDLE THE VEHICLE ACCELERATED AT HIGH SPEED INTO THE VEHICLE IN FRONT. THE DRIVER HAS BEEN DRIVING THIS RAV4 FOR FEW YEARS AND HAS A VERY CLEAN DRIVING RECORD AND WAS AT REGULAR UNIVERSITY STOP. THE DAMAGE WAS SO BAD THAT THE VEHICLE WAS TOTALLED BY INSURANCE. THE DAMAGE LOOKS LIKE A HIGH SPEED IMPACT. A OLD 2005 RAV4 WITH 122000 MILES ON IT CANNOT MOVE THAT FAST EVEN IF TRIED. THE DAMAGE SPEAKS FOR ITSELF. THE POLICE OFFICER WAS INFORMED THAT THE INCIDENT WAS CONFUSING AND LATER THINKING BACK, IT LOOKED IMPOSSIBLE TO BE BECAUSE OF HUMAN ERROR EVEN IF TRIED. THE HOUSEHOLD HAS CLEAN RECORD (NO TICKETS, NO ACCIDENTS FROM US) ON 3 VEHICLES FOR PAST 15 YEARS. THE INCIDENT HAPPENED ON A REGULAR DAILY UNIVERSITY STOP WHERE THE VEHICLES ARE DRIVEN SLOWLY ANYWAYS. THE DAMAGE SPEAKS FOR ITSELF THAT THE VEHICLE HAD UNCONTROLLABLE SITUATION. INCIDENT HAPPENED MOVING FROM A DEAD TOTAL STOPPED VEHICLE (0 MPH). BUT THE DAMAGE LOOKS LIKE THE VEHICLE CRASHED IN WITH A HIGH SPEED. BOTH THE DRIVER AND THE OTHER DRIVER WERE CONFUSED, AS NOTED TO THE ATTENDING POLICE OFFICER.
Other or unspecified, Sep 2, 2015
THE RIGHT SIDE GAS TANK STRAP HAD RUSTED OUT AND BROKE, CAUSING THE GAS TANK ASSEMBLY TO DROP DOWN ONTO THE DRIVESHAFT.
Engine and engine cooling, Electrical system, Other or unspecified, Mar 7, 2013, fire
FIRST TIRE INDICATOR LIGHT CAME ON. CHECKED PRESSURE IN ALL TIRES. TIRES WERE AT CORRECT AMOUNT. WENT TO RESET LIGHT WHICH DID NOT WORK. SUV WAS ON AN INCLINE (DRIVEWAY). LET CAR SIT FOR AN HOUR ON FLAT SURFACE. STARTED RAV4.THE TIRE INDICATOR LIGHT CAME ON PLUS ABS AND VSC TRAC LIGHTS. CONSULTED OWNERS MANUAL WHICH STATED TO TAKE TO TOYOTA. NO OTHER BRAKE WARNING LIGHTS CAME ON. WAS 1/2 MILE FROM DEALER WHEN SMOKE STARTED COMING INTO PASSENGER CABIN. SMOKE/FIRE WAS COMING FROM THE ENGINE AND UNDER RAV4. SMOKE WAS A BLUISH GREY. PULLED OFF THE MAJOR ROAD INTO AN ABANDONED BUSINESS DRIVEWAY. TURNED RAV OFF AND RAN. PASSERBY CALLED 911. FIRE TRUCKS/POLICE ARRIVED. RAV WAS A TOTAL LOSS. CALLED TOYOTA USA TO REPORT FIRE. THEY ARE SAYING THAT IT WAS NOT MECHANICAL OR ELECTRICAL. BUT THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. CAUSE OF FIRE WAS UNDETERMINED AND THERE WAS NO EVIDENCE OF ANY SORT OF DEFECT OR MALFUNCTION WITH ANY OF THE ELECTRICAL OR MECHANICAL SYSTEMS FOUND. RAV WENT TO DEALER FOR ALL REQUIRED SERVICE AND NEVER HAD AND MAJOR PROBLEMS. IF IT WAS NOT ELECTRICAL THEN WHAT CAUSED MY LIGHTS TO COME ON. THEE VSC TRAC LIGHT HAD NEVER COME ON SINCE I OWNED THE CAR. I HAVE OWNED TOYOTAS SINCE 1973 AND NEVER HAD ANYTHING LIKE THIS HAPPEN. THE RAV4 WAS MY 5TH TOYOTA.