2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
575 reports, newest first.
Air bags, Apr 13, 2026
My airbag light came on and I received a letter saying there was a recall but unfortunately I threw out the letter and when I called Toyota said there was a recall but it was fixed in 2012 when I didn’t own the vehicle and it seems like it didn’t last long because my airbags are not working so this will be the last time I buy a Toyota!! Thanks for Nothing
Engine, Dec 4, 2025
My daughter and I are leasing our Toyota Rav4 almost paid off. Our last 2 oil changes done by professional the engine has burned off the oil in between the oil changes. I seen multiple complaints for this same issue for other owners and that there's not been any recalls only investigations. I read 1 person their engine caught fire. I'm disabled if what happened to that person's family happened to my Toyota I might not be as lucky as I, my daughter and my oldest daughter who is disabled and needs help moving and I'd have to get my dog out of the car and we all get safely away from the car and pray we were in a safe area no one else gets hurt. This oil burning from these cars is a dangerous safety hazard and expensive. Instead of a investigation recalls are needed to get the malfunctioning pistons replaced before someone physically gets injured or killed. This is a known issue by the Toyota manufacturer and obviously more and more owners are finding and coming forward with complaints. As for me and my daughter the car is not a new model but it's a new vehicle to use and we didn't know about the pistons malfunctioning issues or oil burning off until it happened. Please do a recall so this issue will be resolved not just investigations because investigations aren't helping nor protecting the consumers/owners. Toyota knew/knows of the safety issues and won't step up to the plate to fix something they know is faulty. Oil is burning out of my car's engine in between oil changes, done by a professional, it really needs to be addressed and safety recalls sent out to hold Toyota accountable for something they know is faulty on their cars
Engine, Aug 21, 2025
My engine recently start to burning oil. Toyota had an extended Warranty for this issue which had to do with piston rings failure. which has expired. Searching the internet this problem is popping up all over the internet. Calling you
Structure, Jun 19, 2025
The paint on my car is peeling all over. There has been a recall with other years of this vehicle but my specific year is not included in the recall. The paint peeling is the same color and issue as with the current recall. Please add my year into this recall so I can get some assistance from Toyota.
Engine, Apr 15, 2025, fire
Issue started when I noticed the vehicle was burning oil, hence why I had to keep refilling the oil levels often. This is an issue many other RAV4 owners have reported. However, the problem was made worse when my mother used my vehicle to pick up some family from the nearest airport. On her way home, my engine blew a hole through itself, causing an engine fire. If it wasn't for the swift thinking of my stepfather, she, him, and my brothers could've been seriously injured or killed. I firmly believe this has to do with the reason why the engine was burning oil.
Electrical system, Air bags, Apr 12, 2025
The issue relates to the spiral cable assembly in my 2008 Toyota RAV4, which falls under Safety Recall 14V-168. According to the recall documentation, this part may fail, which could affect the vehicle’s safety features, including the airbag system. My vehicle is potentially affected by this recall, as it falls within the specified VIN range, but after contacting Toyota Customer Support, I was informed that my vehicle is not eligible for the recall, despite meeting the criteria outlined in the official recall notice. This inconsistency puts my safety at risk, as the failure of the spiral cable could lead to the malfunction of the airbag system. The problem has not been confirmed by a dealer or independent service center, as I have not yet been able to have the issue inspected or repaired. The vehicle has not been inspected by the manufacturer, police, or insurance representatives at this time. There have been no warning lamps or messages related to this issue prior to my inquiry, as the recall issue was identified through the NHTSA database and Toyota’s recall records.
Engine, Feb 21, 2025
The Rav4 is burning oil and consumption of oil. The oil is gone out before the next oil change. This has been going on for a while. There are no leaks and the milage on the 2008 Rav 4 Limited is only 88153.
Other or unspecified, Feb 17, 2025
I purchased the vehicle on [XXX] after seeing the carfax report the dealer furnished. Now my car is no longer driveable due to the numerous repairs it needs. I looked at a real carfax report recently and found out thar dealer didn't give me the true report. It only showed 2 owners and mileage close to the odometer reading. However, there are 4 previous owners and the mileage is 172,000 just before it was sold and then purchased by dealer and then sold to me. Dealer hid the part of the report about the odometer tampering. I now have a very expensive lawn ornament that I still owe over $9,000 on. I can't afford to fix and now stuck with it since I can't sell it. I am having trouble uploading documents. I've tried calling but it just hangs up. I'm calling the number that's online but it doesn't work. Please contact me [XXX] Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Oct 22, 2024
See Attached Letter
Steering, Other or unspecified, Engine, Aug 31, 2023
I have a toyota rav4 2008 2.4 the motor is no leaking oil, no blue smoke but i put 4 quarts oil on 1.000 miles,the comsuption oil is too much and the steering wheel column have problem and that is danger .i see on Google the problem on this car toyota rav4 2008 2.4 is came with factory problem on pistons and rings I call bernardi toyota framingham,ma on 08/27/2022 and i talk a service guy the problem and he say the recall for my car expires on 2018 but i read on Internet recall nver expires if the company o factory Still on ,I did call to service on toyota weslleyle,ma on 08/29/2023 and the service guy toll me the same My phone number [XXX] .. [XXX] my name Thank you.very much for help me INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Air bags, Aug 26, 2023, crash
2021 I was involved in a collision on the highway and my airbag did not deploy but airbag light remained on dash board even after repairing clockspring and attempting to reset airbag.
Vehicle speed control, Engine, Fuel/propulsion system, May 22, 2023
Starting in June 2018, I have had seven episodes of unintended acceleration. (I have owned the car, purchased in private sale, since June of 2013.) There were common elements to each incident:1. gradually slowing; 2. foot on brake; 3. engine accelerates sharply, a moment before complete stop in first six, a moment after in seventh and last. In each incident able to maintain control as foot already was on brake; yet in three of the incidents, including the last two, the car bucked forward a few inches despite the pressure on the brake. Situation resolved when I turned off the ignition, a reflex developed after the first incident. This last incident was particularly upsetting as I was in a long line of slow moving cars on a relatively narrow road with pedestrians on each side of my car. Each incident has been reported to the local dealer with which I have been trading for many years. They did a thorough inspection when I reported the incidents to them in January of 2020 and again just today after the last incident that occurred on May 19, 2023. They could find nothing wrong and include on their report "TAS STATES SUSPECTED DRIVER ERROR, PEDAL MISS [sic] APPLICATION." I do NOT accept this conclusion. I note in the last incident I had come to complete stop momentarily before the engine accelerated and despite my heavy pressure on the brake bucked forward, with control established only when I shut the engine down. During the entire period of these incidents I also have been driving two other vehicles, a 2008 Camry and a 2023 Camry. I have had no such incidents while driving these two cars. I do NOT drive with two feet, always the first question asked when such an incident is reported. Finally, I believe my car dates from a period when Toyota was vehemently denying such a problem in their cars when they knew full well that such was the case, a deception for which they were found criminally liable. Such history does not instill confidence in corporate Toyota.
Engine, Jul 20, 2022
The contact owns a 2008 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormal knocking sound coming from the engine compartment. There were no warning lights illuminated. The contact stated that her husband checked the oil level and noticed that the oil level was low. The contact stated that two weeks prior to the failure, an oil change service was performed. The contact stated that her husband added oil; however, two weeks later he checked the oil level again and the oil level was low. The contact stated that the vehicle consumed one quart of oil every two weeks or approximately every 200 miles. The contact stated that the vehicle was taken to the dealer and the service manager stated that it was a known issue with the vehicle. The contact was notified of a TSB however, the vehicle was over the mileage. The manufacturer was not notified of the failure. The approximate failure mileage was 110,000.
Structure, Other or unspecified, Jun 11, 2022
Severe rust on frame and undercarriage. Other 2008 Toyota models were recalled due to the same rust issues. Unsure of when rust first started.
Engine, May 6, 2022, fire
Vehicle suddenly lose power while the cars are being driven, the engine shut off, and catch on fire.
Steering, Mar 21, 2022
I was starting to back out of my driveway and my steering wheel made a loud clunking noise and became free floating. The plastic air vent fell on my right foot. I did not attempt to drive the car after this incident. I had it towed to Toyota Service. I was told that the steering bracket had come loose and that they had never seen anything like it before. I did some online research and found that this has happened many times with 2006, 2007 and 2008 Toyota RAV 4 vehicles. I believe there are even case numbers for some of them. It was determined to be a failed weld each time! If this had happened to me over the summer, when I was driving in the mountains it cold have caused a serious or even fatal accident. I don't understand why this hasn't been recalled?! This is very dangerous for the unsuspecting people driving RAV 4s! The repair estimate for this is over $5,000!
Steering, Mar 8, 2022
The driveshaft welds that held the power steering motor to the vehicle frame failed. This caused steering wheel to be loose and unstable and the power steering motor to slam against the floor vent. It caused it to fall to the floor near the pedals where it could have obstructed the brake or accelerator pedal
Electrical system, Mar 8, 2022, fire
The contact owns a 2008 Toyota Rav4. The contact stated while driving 5 MPH, there was smoke coming from the front of the vehicle. There was no warning light illuminated. The contact pulled over to inspect the vehicle and became aware that the alternator was smoking. The vehicle was turned off and towed back to the residence. The contact purchased the alternator and fixed the vehicle. Neither the dealer nor the manufacturer had been notified of the failure. The approximate failure mileage was 126,000
Engine, Jan 31, 2022, fire
The contact's daughter owned a 2008 Toyota RAV 4. The contact stated that his wife was driving with their daughter on the highway at approximately 65 mph. The contact stated that his wife said no warning lights were illuminated. The contact's wife reported that the vehicle began to make a loud buzzing noise from the engine. The contact's wife was able to pull over on the road shoulder when she noticed smoke issuing from under the hood. The vehicle burst into flames from under the hood. The contact's wife and daughter jumped out of the vehicle, the daughter burned the palm of her right hand. The police and fire department arrived. The police attempted to extinguish the fire and called the fire department which extinguished the fire with water. The vehicle was undrivable and the police had it towed to an impound lot. The police nor the fire department issued a report. The daughter did not seek medical attention for the burn on her right hand. The contact said that the insurance company will inspect the vehicle this week. The contact said the vehicle was completely burned. The manufacturer was informed of the failure. The failure mileage was approximately 150,000.
Steering, Dec 27, 2021
Making knockings/wobbling sound when steering wheel turning left or right while driving. Sound increases everyday with van driven. This problem started about 2 months ago. I reported this problem to Toyota Coustomer Service Last week. This is very serious issue as a safety of a Van. I have several problems with Van It is Lemon
Structure, Dec 27, 2021
This vehicle will not pass inspection due to unsafe frame/rotted frame. I've brought it to three different shops to see if it was just one area of the frame, but the whole framework has been declared unsafe. It has been well cared for and is in excellent condition otherwise and since it's well known that the Toyota frames have a long-standing bad reputation I feel I should get a frame replacement. Its scrap value is just $200! A massive rip-off to me!
Structure, Jul 28, 2021
I purchased this vehicle used in 2013 it had a recall in 2014 for pin welds and Rocker panels and now they are rusted out again.
Suspension, Jul 6, 2021
The contact owns a 2008 Toyota Rav4. The contact stated while driving at various speeds, the vehicle failed to drive in a straight line and would erroneously drift out of the lane. The vehicle was taken to the local dealer who diagnosed that the rear suspension was faulty and needed to be repaired. The contact indicated that the vehicle was previously repaired under NHTSA campaign number: 16V596000 (Suspension) however, the failure occurred. The vehicle was not repaired. The approximate failure mileage was 157,000.
Engine, Mar 5, 2021
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT UPON INSPECTION OF HER ENGINE, SHE DISCOVERED THAT THE OIL HAD COMPLETELY EMPTIED WITHOUT WARNING. SINCE THE DISCOVERY, THE CONTACT WOULD FREQUENTLY REPLACE THE OIL APPROXIMATELY EVERY MONTH DUE TO THE EXCESSIVE OIL CONSUMPTION. THE CONTACT THEN TOOK THE VEHICLE TO MAGIC TOYOTA (21300 HWY 99, EDMONDS, WA 98026) WHERE SHE WAS INFORMED THAT THE FAILURE WAS A KNOWN ISSUE AND THE VEHICLE WAS UNDER WARRANTY HOWEVER, THE WARRANTY HAD EXPIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
Power train, Mar 5, 2021
REAR DIFFERENTIAL IS MAKING A LOUD RUMBLING NOISE IN THE BEGINNING OF 1ST, AND 2ND GEAR. BROUGHT IT IN TO TOYOTA AND THEY SAID IT WAS NOT LEAKING AND I WENT INTO THE SHOP AND ALSO LOOKED AT IT MYSELF AND IT WASN'T LEAKING. DID THE REAR DIF SERVICE LIKE TOYOTA RECOMMENDED BECAUSE THE CAR HAS BEEN SUPER RELIABLE AND I WOULD LIKE TO KEEP IT THAT WAY. I HAVE DONE 2 REAR DIF SERVICES BEFORE AND HAD NO PROBLEMS. RIGHT WHEN THEY DID THE SERVICE A COUPLE DAYS LATER IT STARTED MAKING THE RUMBLING NOISE AGAIN AND IS NOW LEAKING AND MADE A PUDDLE IN MY DRIVEWAY. I TOOK A LOOK AT IT MYSELF AND ALL PLUGS ARE TIGHTENED BUT IT IS NOW LEAKING FROM THE COUPLING WHERE THE DRIVESHAFT CONNECTS AND THE DRIVERS SIDE AXLE SEAL. THEY WANT ME TO PAY 1000 DOLLARS FOR A WHOLE NEW COUPLING ASSEMBLEY THAT IS REFURBISHED NOT INCLUDING THE DS AXLE SEAL AND LABOUR. I WILL POST PICTURE BELOW OF THE PROBLEM.