2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: steering
73 reports, newest first. Show all
Steering, Other or unspecified, Engine, Aug 31, 2023
I have a toyota rav4 2008 2.4 the motor is no leaking oil, no blue smoke but i put 4 quarts oil on 1.000 miles,the comsuption oil is too much and the steering wheel column have problem and that is danger .i see on Google the problem on this car toyota rav4 2008 2.4 is came with factory problem on pistons and rings I call bernardi toyota framingham,ma on 08/27/2022 and i talk a service guy the problem and he say the recall for my car expires on 2018 but i read on Internet recall nver expires if the company o factory Still on ,I did call to service on toyota weslleyle,ma on 08/29/2023 and the service guy toll me the same My phone number [XXX] .. [XXX] my name Thank you.very much for help me INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Mar 21, 2022
I was starting to back out of my driveway and my steering wheel made a loud clunking noise and became free floating. The plastic air vent fell on my right foot. I did not attempt to drive the car after this incident. I had it towed to Toyota Service. I was told that the steering bracket had come loose and that they had never seen anything like it before. I did some online research and found that this has happened many times with 2006, 2007 and 2008 Toyota RAV 4 vehicles. I believe there are even case numbers for some of them. It was determined to be a failed weld each time! If this had happened to me over the summer, when I was driving in the mountains it cold have caused a serious or even fatal accident. I don't understand why this hasn't been recalled?! This is very dangerous for the unsuspecting people driving RAV 4s! The repair estimate for this is over $5,000!
Steering, Mar 8, 2022
The driveshaft welds that held the power steering motor to the vehicle frame failed. This caused steering wheel to be loose and unstable and the power steering motor to slam against the floor vent. It caused it to fall to the floor near the pedals where it could have obstructed the brake or accelerator pedal
Steering, Dec 27, 2021
Making knockings/wobbling sound when steering wheel turning left or right while driving. Sound increases everyday with van driven. This problem started about 2 months ago. I reported this problem to Toyota Coustomer Service Last week. This is very serious issue as a safety of a Van. I have several problems with Van It is Lemon
Steering, Sep 22, 2020
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL FAILED TO REMAIN CENTERED. THE CONTACT STATED THAT HE HAD TO MANUALLY CORRECT THE STEERING WHEEL TO KEEP THE VEHICLE DRIVING STRAIGHT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HIM THAT THE STEERING ISSUE WAS NORMAL VEHICLE OPERATION. THE CONTACT HAD YET TO NOTIFY A DEALER OR MANUFACTURER ABOUT THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 140,000.
Steering, Dec 6, 2019
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING, A ROCKING NOISE WAS HEARD COMING FROM THE FRONT SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
Steering, Sep 10, 2019
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHEN THE VEHICLE WAS STARTED AND WHILE IDLING, AN ABNORMAL CLICKING NOISE WAS HEARD COMING FROM THE STEERING WHEEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO TOYOTA OF MELBOURNE (24 N. HARBOR CITY BOULEVARD, MELBOURNE, FL 32935, (321) 426-9420) WHERE IT WAS DIAGNOSED THAT THE STEERING WHEEL AND SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 90906975. THE CONTACT WAS REFERRED TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000. THE VIN WAS INVALID.
Steering, Dec 7, 2018
WHEN TURNING LEFT THERE IS A CLICK OR CLUCK SOUND. ONLY TURNING LEFT NOT RIGHT HAVE HAD THE PROBLEM SINCE PURCHASED NEW IN 2008. NOW SEATING AT 92K MILES. NEVER IN AN ACCIDENT
Steering, Sep 6, 2018
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE PARKING THE VEHICLE, THE STEERING COLUMN DETACHED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WELDING FAILED ON THE VEHICLE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1801779, BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 105,000. THE VIN WAS NOT AVAILABLE.
Steering, May 25, 2018
I AM HAVING A STEERLING NOISE ISSUE WHEN BACKING UP OR MOVING FORWARD THERE'S A LOUD CLUNK FROM THE STEERING COLUMN AREA THAT I CAN FEEL IN THE WHEEL. I FEEL IT IN THE WHEEL WHEN DRIVING DOWN THE FREEWAY OR UNEVEN SURFACES AS WELL AS WHEN THE VEHICLE IS STOPPED AND IDLING WHILE TURNING THE WHEEL TO THE LOCKS. THIS VEHICLE WAS INSPECTED MY AN ASE CERTIFIED MASTER MECHANIC WHO FOUND NO ISSUES WITH THE RACK AND PINION SYSTEM BUT DIAGNOSED THE ISSUE AS AN INTERMEDIATE STEERING SHAFT FAILURE.
Steering, Apr 25, 2018
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING VARIOUS LOW SPEEDS, THE STEERING WHEEL MADE A LOUD CLUNKING NOISE AND THERE WAS ABNORMAL MOVEMENT IN THE STEERING COLUMN. A DEALER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,600.
Steering, Mar 29, 2018
STEERING INTERMEDIATE SHAFT WORN OUT : MAKING CLUNKING NOISE WHEN TURNING EITHER WAY ALSO WHEN REVERSING CAR TOYOTA TECHNICIAN FOUND THIS DEFECT/ISSUE
Steering, Feb 22, 2018
VERY BAD CLUNKING / POPPING SOUND WHEN I BACK UP AND TURN MY WHEELS. SEEMS TO HAPPEN MOSTLY WHEN I FIRST DRIVE THE SUV IN THE MORNING. ONLY HAS 96,000 MILES ON IT.
Steering, Jan 3, 2018
I WAS DRIVING MY 2008 RAV 4 AND I MADE A TURN & ALL OF A SUDDEN MY STEERING WHEEL LITERALLY BECAME FREE FLOATING. I CAN MOVE THE STEERING WHEEL 8 TO 12 INCHES UP AND DOWN WITH NO RESISTANCE. I CAN ALSO MOVE IT 6 TO 8 INCHES LEFT TO RIGHT WITH NO RESISTANCE. IT'S NOT GUIDED IN ANY WAY, YOU CAN MOVE IT AROUND IN A LARGE CIRCULAR MOTION. I WAS ABLE TO STILL STEER SOMEWHAT. THE COLUMN STILL SEEMS TO BE ATTACHED TO SOMETHING. WHEN YOU DO STEER, IT MAKES A HORRIBLE POPPING SOUND. THE DEALERSHIP SAID: A FRAME WELD DID GIVE OUT FOR THE STEERING COLUMN ASSEMBLY. THE STEERING COLUMN ASSEMBLY IS EVERYTHING BETWEEN THE WHEEL AND THE INTERMEDIATE SHAFT. THE STEERING ASSEMBLY IS MOUNTED TO THE INSTRUMENT PANEL REINFORCEMENT BAR. THIS IS A LARGE BAR THAT RUNS THE LENGTH OF YOUR DASHBOARD. THIS BAR HAS A FEW WELDED MOUNTS ON IT THAT ALLOW YOU TO BOLT THE STEERING COLUMN ASSEMBLY INTO, IT IS THESE WELDS WHICH FAILED. THE AIR DUCT ON THE DRIVERS SIDE FELL ONTO MY FEET/PEDALS WHILE I WAS DRIVING. LUCKILY IT DIDNT GET CAUGHT BEHIND MY PEDALS. I SOFT DRIVE APPROX 8000-9000 MILES A YEAR. I'VE HAD NO ACCIDENTS. TOYOTA IS CHARGING ME $2200 TO REPLACE THIS & WILL NOT COER THE COSTS. THIS IS A MAJOR SAFETY ISSUE & I DID RESERCH & THIS HAS HAPPENED NUMEROUS TIMES! CHECK IT OUT HERE: HTTP://WWW.RAV4WORLD.COM/FORUMS/99-4-3-MECHANICAL/115306-STEERING-ASSEMBLY-FRAME-WELD-BROKE.HTML
Steering, Sep 15, 2017
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE PULLING OUT OF THE DRIVEWAY, THE STEERING WHEEL STARTED TO MAKE A CLICKING SOUND AND THE CHECK ENGINE AND ESC WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSIST MOTOR NEEDED REPLACEMENT. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 1709132080. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,800. UPDATED 11/02/17*LJ CONSUMER STATED THE VSC LIGHT COMES ON AND CHECK ENGINE. NOW THAT THE INTERMEDIATE SHAFT DOES NOT WORK CORRECT THE CRUISE CONTROL DOES NOT WORK. UPDATED 7/17/18*JB
Steering, Air bags, Aug 24, 2017, crash
TL* THE CONTACT OWNED A 2008 TOYOTA RAV4. WHILE DRIVING 40 MPH, THE STEERING SEIZED AND THE VEHICLE CRASHED INTO A BUILDING. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED AND DEEMED A TOTAL LOSS. THE OCCUPANT SUSTAINED LEFT AND RIGHT BROKEN ARMS, STITCHES, AND A BROKEN ROTATOR CUFF. MEDICAL ATTENTION WAS RECEIVED AT WEST CHESTER MEDICAL CENTER. A POLICE REPORT WAS FILED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 116,000. *LN *TR
Steering, Jun 29, 2017
I BOUGHT MY TOYOTA WITH 47316 MILES, NO WARRANTY. AT 49000 MILES MY POWER STEERING LITE STARTED INTERMITTENTLY COMING ON, AT 60000 MILES IT COMES ON ALL THE TIME . TOOK THE VECHILE TO LOCAL TOYOTA, WAS TOLD BY ONE GENTLEMAN HE HAS SEEN THIS RECENTLY. COULDN'T FIX IT AS THEY HAVE NO PROGRAMS FOR THE ISSUE. TOLD ME TO CALL TOYOTA, THEY MAY HELP ME WITH THIS HIGH PRICE ISSUE. TALK TO TWO DIFFERENT EMPLOYEES AT MAIN NUMBER. I WAS TOLD THEY WOULDN'T DO ANYTHING SINCE, I HAVE NOT HAD TOYOTA DO MY MAINTENANCE. I EXPLAINED TO THEM, I HAVE NOT HAD IT LONG. BUT I HAVE YEARS OF PREVIOUS OWNERS TOYOTA MAINTENANCE. SAID IT'S NOT IN MY NAME, I CAN'T CONTROL THE STEERING WHEEL WHEN THE P/S LIGHT IS ON. CAN TAKE UP TO 16 TRUE TO GET IT OFF. TOYOTA RESET IT , CODE CAME RIGHT BACK. THIS CAR IS NOT BROKE IN .THIS IS NOT RIGHT THE COST WE PAY FOR THIS. HOPE SOMEONE MAKES THEM MAKE THERE ISSUES RIGHT SIZE
Steering, May 4, 2017
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE THE VEHICLE WAS BEING OPERATED, AN ABNORMAL NOISE COULD BE HEARD. THE CONTACT WENT TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS A STEERING COLUMN FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER. THE FAILURE MILEAGE WAS 59,000. UPDATED 06/23/17*LJ *AS
Steering, Mar 10, 2017, crash
"TAKATA RECALL" I HAD A WRECK MARCH 8, 2017 AND I COULD NOT CONTROL THE STEERING WHEEL AND LANDED IN SOME HEAVY BUSHES ON A OFF RAMP. WHEN TO THE HOSPITAL WITH NECK PROBLEMS AND PUT A REPORT INTO MY INSURANCE. THE CAR WAS IN MOTION WHEN THE STEERING PROBLEM HAPPEN. ON I-5 58 SOUTH BOUND OFF RAMP NEAR INTERSECTION WITH NW MORGAN STREET, GRANTS PASS, OREGON HAPPEN SO FAST COULD NOT BREAK.
Steering, Feb 15, 2017
I HAVE 106.700 MILES ON MY CAR AND I START HEAR CLICKING AND KNOCKING NOISES INSIDE ON MY RACK AND PINION WHEN MY CAR IS NOT IN MOTION AND I TURN MY WHEEL I HEAR THIS NOISE ALSO WHEN II HIT POTHOLES I FEEL SOMETHING LOOSE IN MY STEERING WHEEL AS FAR AS IM SEARCHIG MANY PEOPLE OF TOYOTA RAV4 OWNERS HAVING SAME PROBLEM, TOYOTA SHOULD MAKE THIS AS A RECALL
Steering, Feb 3, 2017
WHEN TURNING THE STEERING WHEEL A LOUD BANGING NOISE COMES FROM THE STEERING COLUMN. IT FEELS VERY UNSAFE AND SCAREY TO DRIVE. WAS TOLD IT IS THE STEERING AND THAT TOYOTA IS VERY AWARE OF THE ISSUE WITH THIS YEAR CAR, HOWEVER SINCE NOBODY HAS DIED YET IT IS NOT BEING RECALLED. THE STEERING IS SOMETIMES UNRELIABLE AND I NEVER KNOW IF IT WILL STEER WHERE I WANT IT TO OR NOT. I AM AFFRAID TO DRIVE IT, TOYOTA TELLS ME ITS SAFE. I AM NOT WILLING TO BE THE FIRST ONE TO DIE BECAUSE OF TOYOTA GREED TO NOT RECALL AND FIX THIS HUGE SAFETY ISSUE. WHEN CAR IS IN MOTION AT LOW AND HIGH SPEEDS TURNING ANY DEGREE EITHER WAY
Steering, Oct 24, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE OPERATING THE VEHICLE AND TURNING THE STEERING WHEEL IN EITHER DIRECTION, THE STEERING COLUMN MADE A CLICKING NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEERING COLUMN WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Steering, Suspension, Oct 5, 2016
1ST ISSUE WAS REPEATED RECALL OVER LOWER ARM SUSPENSION BAR THAT WAS PERMANENTLY GLUED, TO REMEDY SAFETY CONCERN. NOW INTERMEDIATE STEERING ARM IS BAD, AND PROBLEMS W CAR SWAYING, AND TIRES FEELING WOBBLY. BEING TOLD TOYOTA WILL NOT COVER EXPENSES TO REPAIR RELATED SUSPENSION ISSUE. $750.00 CAR HAS ONLY 53,000 MILES... MANY OTHER RAV4 OWNERS W SAME PROBLEM. AFRAID TO DRIVE.
Steering, Seat belts, Engine, Sep 2, 2016
THERE ARE HAVE BEEN 6 RECALLS TO DATE SINCE WE PURCHASED 2008 RAV4. MOST RECENTLY, SEATBELTS WERE DEEMED UNSAFE IN THE REAR, WHERE WE HARNESS OUR CHILDREN'S CARSEATS. THIS WAS IN APRIL 2016, AND WE HAVE YET TO BE CONTACTED ABOUT A REMEDY. PLEASE LET ME KNOW IF THERE IS ANYTHING I CAN DO TO PUSH FOR A FIX TO THIS SITUATION. WE ARE FRUSTRATED THAT THIS CAR IS A LEMON, BUT NOT ACCORDING TO LAW, SINCE THE RECALLS ARE ROLLED OUT OVER THE COURSE OF THE LAST 6-8 YEARS.
Steering, Aug 3, 2016
CLUNK IN STEERING WHEEL WHEN TURNING TO THE LEFT OR RIGHT.