2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: air bags
57 reports, newest first. Show all
Air bags, Nov 12, 2013
THE "AIR BAG" LIGHT CAME ON LAST MONTH. I TOOK MY CAR TO THE TOYOTA DEALER AND HE DIAGNOSED A PROBLEM WITH THE CABLE TO THE AIRBAG, WITH A PRICE TAG OF ALMOST $600 TO REPAIR. THE DANGER WAS THAT THE AIR BAGS WOULD LIKELY NOT DEPLOY IN A CRASH. (MY OWN LOCAL MECHANIC TOLD ME THAT THE AIR BAGS WOULD DEFINITELY NOT DEPLOY). THERE ARE MANY OTHER REPORTS/COMPLAINTS OF THIS PROBLEM IN RAV4S IN THE YEARS OF 2006-08. THIS IS A SAFETY ISSUE AND THERE SHOULD BE A RECALL OF THESE VEHICLES BY TOYOTA IN ORDER TO INSURE THE SAFETY OF THEIR CUSTOMERS. TOYOTA SHOULD PROVIDE FOR THIS SERVICE AS IT IS VERY EXPENSIVE AND PUTS LIVES AT STAKE. TOYOTA HAS AGREED TO ASSIST ME BY PAYING HALF THE REPAIR FEE, FOR WHICH I'M GRATEFUL. HOWEVER, I CONTINUE TO BELIEVE THIS IS A DANGEROUS DEFECT AND SHOULD BE REPAIRED AS A RECALL. *TR
Air bags, Nov 7, 2013
THE AIRBAG WARNING LIGHT CAME ON AND STAYED ON LAST WEEK. TOOK IT TO MY LOCAL REPAIR SHOP. WITHOUT EVEN LOOKING THEY GUESSED THAT IT WAS THE CLOCKSPRING. AFTER BRINGING IT IN AND READING THE COMPTUER CODES, THEY CONFIRMED THAT THE CLOCKSPRING NEEDS TO BE REPLACED. SHOP SAID THEY CANNOT BUY AN AFTERMAKERT PART ANYMORE AND NEED TO GET AN OEM PART FROM TOYOTA, WHICH IS EXPENSIVE. CALLED TOYOTA DEALER SERVICE CENTER TO JUST DOUBLE CHECK IF THERE IS ANY OFFICIAL RECALL FOR THIS PROBLEM. APPARENTLY THERE IS A SIMILAR RECAL ON THE TUNDRA BUT NOT THE RAV4. *TR
Air bags, Nov 3, 2013
THE AIRBAG WARNING LIGHT IN MY 2006 RAV 4 HAS ACTIVATED. THIS CAR HAS NEVER BEEN IN A CRASH. THE REPAIR IS $500-$600 AND CAN ONLY BE PERFORMED BY A TOYOTA DEALER--A MONOPOLY. THIS IS A SAFETY ISSUE AND HAS BEEN A PROBLEM WITH SEVERAL OF THE TOYOTA VEHICLES MANUFACTURED DURING THIS TIME PERIOD. I AM AFRAID TO DRIVE THIS CAR UNTIL I CAN AFFORD THE FIX. ON A TEACHER'S SALARY, THIS HAS IMPEDED MY ABILITY TO GET TO MY JOB SAFELY. THE CAR HAS LOW MILEAGE AND SHOULD NOT BE DEFECTIVE OR PUTTING LIVES AT RISK. I BEG YOU TO REVIEW THIS ISSUE IN THE INTEREST OF PUBLIC SAFETY. *TR
Air bags, Sep 17, 2013
THE AIRBAG WARNING LIGHT BEGAN STAYING ON AFTER ENGINE START. AFTER TOYOTA INSPECTION THIS WAS DUE TO A FAILED CLOCK SPRING/SPIRAL WIRE IN THE STEERING WHEEL THAT CONTROLS THE AIRBAG AND OTHER STEERING WHEEL ELECTRICAL CONTROLS. FURTHER ONLINE INVESTIGATION SHOWED THIS TO BE A COMMON FAULT WITH TOYOTA VEHICLES ESPECIALLY RAV4'S OF 2006/7/8 VINTAGE WITH IN EXCESS OF 70,000 MILES - THIS WAS ALSO CONFIRMED BY MY TOYOTA DEALER. THERE IS A STRONG PROBABILITY THE DRIVER AIRBAG WOULD FAIL TO DEPLOY IN AN ACCIDENT DUE TO THE WIRE SHORTING OUT. THE DIAGNOSIS AND FIX AT A TOYOTA DEALER WAS QUOTED AS $509 WHICH WILL I AM SURE PREVENT MANY PEOPLE FROM FIXING THIS. NO INDEPENDENT MECHANICS I ASKED WOULD WORK ON THE AIRBAG SYSTEM - THEY ALL SAID IT HAD TO BE FIXED BY TOYOTA WHO THEN CAN CHARGE AN EXCESSIVE AMOUNT FOR THE WORK. *TR
Air bags, Aug 27, 2013
AIRBAG LIGHT ILLUMINATION, FAILED CLOCK SPRING (EXTREMELY TYPICAL WITH TOYOTA) - OUT OF WARRANTY OF COURSE! *TR
Air bags, Jul 7, 2013
MY AIRBAG LIGHT ON MY 2006 TOYOTA RAV4 IS ON DUE TO MANUFACTURING DEFECT. TOYOTA RECALLED THE 2007 AND 2008 MODELS FOR THE SAME REASON. THERE ARE HUNDREDS IF NOT THOUSANDS OF COMPLAINT ABOUT THIS ISSUE ON THE INTERNET. I CONTACTED PREMIER TOYOTA IN AMHERST OHIO ABOUT THIS MATTER AND THE SERVICE MANAGER[XXX] TOLD ME IT WOULD BE $300 TO TEST IT AND $500 TO FIX IT. THIS IS A SAFETY ISSUE THAT SHOULD BE ADDRESSED AS A MANUFACTURERS DEFECT. ANY HELP YOU CAN GIVE ME IN THIS MATTER WOULD BE APPRECIATED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Air bags, Jul 2, 2013
WHILE DRIVING THE VEHICLE THE AIR BAG LIGHT CAME ON. AFTER CHECKING THE OWNERS MANUAL WE MADE AN APPOINTMENT WITH THE LOCAL DEALER. THEY EXPLAINED THE PROBLEM WAS IN THE CLOCK IN THE AIR BAG MECHANISM AND NEEDED REPLACED OR THE AIR BAG WOULD NOT DEPLOY IN A CRASH. THE VEHICLE HAS BEEN GARAGE KEPT AND WELL MAINTAINED. I THINK A TOYOTA RECALL SHOULD BE IN ORDER SINCE THIS IS A SAFETY ISSUE AND INVOLVES MANY TOYOTA RAV-4 VEHICLES. THE TOYOTA DEALERSHIP WANTS 600 DOLLARS TO FIX THE PROBLEM. I REALLY CAN'T AFFORD IT BUT MY WIFE DEPENDS ON THE VEHICLE, AND TO INSURE HER SAFETY, I'M GOING TO HAVE TO FIND THE MONEY TO GET THE WORK DONE. HELP !! HOW ABOUT A RECALL ??? *TR
Air bags, Jun 19, 2013
MY 2006 TOYOTA RAV4 AIRBAG DASH LIGHT BEGAN REMAINING ON CONSTANTLY AND WAS DIAGNOSED BY FINDLAY TOYOTA IN FLAGSTAFF, AZ ON 3/20/13 WITH: "RECOMMEND REPLACING SPIRAL CABLE DUE TO OPEN CIRCUIT IN SPIRAL CABLE... $583 TO REPLACE SENSOR." I CALLED TOYOTA CUSTOMER EXPERIENCE CENTER AT 1-800-331-4331 ON 6/19/13 AND SPOKE WITH [XXX], WHO CONFIRMED THAT NO RECALLS ARE AVAILABLE FOR THIS PROBLEM ON THE RAV4S, DESPITE THIS ISSUE BEING THE EXACT SAME AS FOUND IN TOYOTA TACOMAS: MARCH 08, 2012 CUSTOMER FAQS FOR TOYOTA TACOMA STEERING WHEEL SPIRAL CABLE ASSEMBLY RECALL 1. WHICH MODELS ARE INVOLVED IN THE RECALL? TOYOTA IS RECALLING 495,000 CERTAIN 2005 TO EARLY 2009 MODEL YEAR TOYOTA TACOMA VEHICLES SOLD IN THE U.S. NO OTHER VEHICLES ARE INVOLVED IN THIS RECALL. 2. WHAT IS THE CONDITION? DUE TO THE COMBINATION OF THE STEERING WHEEL SPIRAL CABLE DESIGN AND CHARACTERISTICS UNIQUE TO THE TACOMA CHASSIS, FRICTION BETWEEN THE SPIRAL CABLE AND THE RETAINER IN THE STEERING WHEEL SPIRAL CABLE ASSEMBLY MAY OCCUR IN SOME VEHICLES. FRICTION OVER TIME MAY RESULT IN DAMAGE TO CERTAIN CIRCUITS THAT PROVIDE CONNECTIVITY TO THE DRIVER?S AIR BAG MODULE. IF CONNECTIVITY IS LOST, THE AIR BAG WARNING LAMP WILL REMAIN ILLUMINATED, AND THE DRIVER?S AIR BAG MAY BECOME DEACTIVATED, PREVENTING DEPLOYMENT IN THE EVENT OF A CRASH. 3. ARE THERE ANY WARNINGS THAT THIS CONDITION HAS OCCURRED? YES. THE AIRBAG WARNING LIGHT IS DESIGNED TO ILLUMINATE WHEN THE VEHICLE IS STARTED. IT GOES OFF AFTER ABOUT 6 SECONDS, INDICATING THE SYSTEM IS OPERATING AS DESIGNED. IF THE AIRBAG WARNING LIGHT REMAINS ILLUMINATED AFTER THIS PERIOD, PLEASE CONTACT YOUR LOCAL TOYOTA DEALER FOR DIAGNOSIS AND APPROPRIATE REPAIR. THIS EXACT CONDITION EXISTS IN MY 2006 RAV4, HOWEVER, I CANNOT AFFORD THE $583 REQUIRED FOR AN AUTHORIZED DEALER TO REPAIR IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Air bags, Apr 17, 2013
AIR BAG WARNING LIGHT CAME ON. TOOK IT TO DEALER SAYS CLOCK SPRING ASSEMBLY NEEDS TO BE REPLACED BEFORE THEY CAN DETERMINE IF THAT IS THE PROBLEM. *TR
Air bags, Apr 6, 2013
I'M PRETTY SURE THE AIRBAG MALFUNCTION WARNING LIGHT OF MY 2006 RAV4 IS NOT A MATTER OF WEAR AN TEAR. THERE ARE SEVERAL COMPLAINTS ON 2006-2008 RAVS4 WITH IDENTICAL PROBLEM. YOU DON'T WANT TO HEAR THIS, BUT IS HARDLY DIFFICULT TO FIND A WAY TO GET IN CONTACT WITH TOYOTA MOTORS, IT SEEMED THAT THEY DO NOT WANT TO HEAR FROM THE TOYOTA OWNER?S PROBLEMS. MOREOVER, I EXPLAINED THEM THE AIRBAGS WARNING LIGHT ILLUMINATES SPORADICALLY AT APPROXIMATELY 72,000 MILES AT 45 MILES/HOUR AND NOW REMAINS ON WITH NO APPARENT REASON, I DROVE MY CAR TO THE DEALER TRYING TO GET MY CAR REPAIRED BY TOYOTA, BUT THEY DOESN'T ASSUME ANY RESPONSIBILITY DUE THAT THE MALFUNCTION OCCURRED AFTER 3 YEAR OR 60,000 MILES OF WARRANTY. I HAVE NOTICED THEY HAVE AN AIR BAGS RECALL CAMPAIGN FOR 2007 AND NEWER RAVS4, SO IT DOES SEEM SUSPICIOUS AT FIRST GLANCE BECAUSE 2006 IS NOT INCLUDED EVEN THOUGH MANY OWNERS HAVE EXPERIENCED AND FILED COMPLAINTS AGAINST TOYOTA DUE TO THE SAME PROBLEM. REALISTICALLY THIS IS A SAFETY MATTER, SO 2006 TOYOTA RAV4 NEEDS TO BE RECALLED. *TR
Air bags, Mar 4, 2013
AIR BAG WARNING LIGHT WENT ON SHORTLY AFTER VEHICLE (2006 TOYOTA RAV4) WAS STARTED ON 3/1/13, BEFORE DRIVING AT APPROXIMATELY 77690 MILES. TOOK TO TOYOTA DEALERSHIP SERVICE DEPARTMENT AT FIRST AVAILABLE APPOINTMENT (3/4/13). TOLD THAT AIR BAG SPIRAL CABLE NEEDS TO BE REPLACED OR AIR BAG WILL NOT DEPLOY IN A CRASH. (NO EXPLANATION GIVEN ON WHAT IS WRONG WITH THE CURRENT.) PART NEEDS TO BE SPECIAL ORDERED AT A $280.22 COST WITH $99 SERVICE CHARGE PLUS TAX. ADVISED AGAINST TAKING TO INDEPENDENT AUTO REPAIR SHOP AS IT MAY NOT STOP THE WARNING LIGHT FROM GOING ON. VEHICLE IS WELL MAINTAINED AND HAS NOT BEEN IN ANY CRASHES OR DRIVEN IN A TURBULENT WAY. *TR
Air bags, Feb 2, 2013
AIR BAG WARNING LIGHT ILLUMINATED. ILLUMINATED SPORADICALLY AT FIRST, NOW STAYS ON ALL THE TIME. NOTICED IT WOULD COME ON AT FIRST WHILE CORNERING, BELIEVE IT TO BE RELATED TO THE WIRING IN THE STEERING COLUMN FOR THE AIR BAGS. THIS IS A COMMON FAILURE ON THIS MODEL. THERE SHOULD BE A RECALL ON THIS SAFETY RELATED PROBLEM. *TR
Air bags, Feb 1, 2013
AIRBAG LIGHT CAME ON AND I TOOK CAR TO MY DEALER (FOR REPAIR OF ANOTHER PROBLEM) ON 9/22/11. I WAS INFORMED THAT THE SPIRAL CABLE CONTROLLING THE DRIVER AIRBAG WAS DEFECTIVE AND THAT IT WOULD BE ABOUT $500 OR MORE TO REPAIR. I TOLD THEN THAT I FELT THAT IT SHOULD BE TOYOTA'S PROBLEM TO REPAIR SINCE IT WAS DEFINITELY A SAFETY HAZARD SHOULD I BECOME INVOLVED IN AN ACCIDENT. I HAVE SINCE FOUND OUT THAT THIS IS A COMMON PROBLEM WITH TOYOTA'S, ESPECIALLY RAV 4'S. THIS SHOULD REALLY BE A RECALL PRIORITY. *TR
Air bags, Dec 17, 2012
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 103,000. THE VIN WAS NOT AVAILABLE.
Air bags, Nov 14, 2012
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 68,647.
Air bags, Nov 6, 2012
AIR BAG LIGHT CAME ON. MECHANIC SAYS THE CLOCKSPRING IN THE STEERING COLUMN NEEDS TO BE REPLACED AT A COST OF $600. FAILURE OF THE AIRBAG CLOCKSPRING IN 2005-2009 TOYOTA TACOMA PICKUPS IS THE SUBJECT OF AN EXISTING RECALL (NHTSA CAMPAIGN ID NUMBER: 12V092000); BELIEVE THIS IS RELATED. *TR
Air bags, Oct 18, 2012
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE PARKED, THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. AFTER SOME TIME, THE WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT THE WIRING IN THE AIR BAG ASSEMBLY, WHICH WAS LOCATED IN THE STEERING COLUMN, WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 11V245000 (AIR BAGS) THAT COULD HAVE BEEN RELATED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE RECALL DID NOT INCLUDED THE 2006 MODEL VEHICLES, ONLY THE 2007-2008 MODELS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. UPDATED 11/14/12*LJ UPDATED 11/15/12*JB
Air bags, Oct 14, 2012
THE AIR BAG SENSOR LIGHT CAME ON WHILE DRIVING. I TOOK MY CAR INTO A TOYOTA DEALERSHIP AND THE TOLD ME THERE WAS A PROBLEM WITH THE AIR BAG SPIRAL CABLE AND IT WOULD COST $486 TO FIX. THEY ALSO SAID THAT MY AIR BAGS ARE DISABLED BECAUSE OF THIS SO WOULD NOT GO OFF IN THE EVENT OF A WRECK. I HAVE DONE RESEARCH AND THIS IS A VERY COMMON PROBLEM IN 2006 RAV4 MODELS. I WOULD LIKE TO FILE A COMPLAINT AGAINST TOYOTA, I BELIEVE THIS IS SOMETHING WE SHOULD NOT HAVE TO PAY TO FIX AS IT IS CLEARLY A DESIGN FLAW AND AFFECTS OUR SAFETY EVERY TIME WE DRIVE THE CAR. I PERSONALLY WILL NOT BE ABLE TO FIX THIS, I CAN'T AFFORD IT, AND I DO NOT THINK WE SHOULD EVEN BE RESPONSIBLE TO PAYING FOR THIS IN THE FIRST PLACE. AIR BAGS SHOULD HAVE A LIFETIME WARRANTY. *TR
Air bags, Sep 21, 2012
AIR BAG LIGHT STAYS ON. *TR
Air bags, Sep 4, 2012
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE SRS WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 76,000.
Air bags, Jul 13, 2012
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC WHICH LOCATED THE FAILURE AT THE AIR BAG SPIRAL CABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 88,000.
Electrical system, Air bags, Jul 14, 2011
A WARNING LIGHT APPEARED ON THE DASHBOARD INDICATING AN AIRBAG MALFUNCTION. I CALLED TOYOTA SERVICE AND WAS TOLD THE CAR REQUIRED A REPAIR, AND THE AIRBAGS WOULD NOT FUNCTION AT ALL UNTIL THIS REPAIR WAS DONE. TODAY THE TOYOTA TECH TOLD US A "SPIRAL CABLE ASSEMBLY HAD GONE BAD." HE SAID IT WILL COST $514.00 TO MAKE THIS REPAIR, AND AGAIN, THE AIRBAGS WILL NOT WORK UNLESS IT IS DONE. I ASKED IF THIS WAS A RECALL ISSUE WITH TOYOTA AND THE SERVICE MANAGER REPLIED, "I HAVE NO IDEA." I ASKED IF THIS WAS A COMMON PROBLEM WITH THIS CAR AND HE REPLIED, "WE SEE IT ALL THE TIME IN RAV3'S AND TUNDRA'S." I INDICATED THE CAR IS ONLY 5 YEARS OLD WITH JUST OVER 60K MILES, AND THAT I HAVE NEVER (EVER) HAD AN AIRBAG FAILURE IN ANY VEHICLE UNTIL NOW. HE AGAIN SAID, "WELL, WE SEE IT ALL THE TIME WITH THIS MODEL." THIS SURELY APPEARS TO BE A DESIGN FLAW THAT IS VERY COSTLY TO AN AVERAGE CONSUMER. CAN THEY GET AWAY WITH THIS? PLEASE HELP! (THANKS MUCH-)
Air bags, Feb 22, 2011
2006 TOYOTA RAV 4. CONSUMER STATES AIR BAG SYSTEM IS DEFECTIVE AND HAS NOT WORKED FOR THE PAST THREE MONTHS.*TGW THE CONSUMER STATED THE AIR BAG LIGHT ILLUMINATED. A SPIRAL CABLE WAS NEEDED AT A COST OF $404.56 TO FIX THE PROBLEM. *JB
Air bags, Oct 26, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING AT AN UNKNOWN SPEED THE CONTACT STATED THAT A WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE VEHICLE NEEDED A SPIRAL CABLE AND A STEERING SHAFT IN ORDER TO FIX THE AIR BAG. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 87,828 AND THE CURRENT MILEAGE WAS 87,900.
Air bags, May 20, 2010
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT PASSENGER SIDE AIR BAG DEPLOYED. THE DEALER WAS UNABLE TO DETERMINE WHAT CAUSED IT TO DEPLOY; HOWEVER, HE CONFIRMED THAT IT COULD BE REPAIRED. THE VEHICLE WAS NOT REPAIRED WHEN THE COMPLAINT WAS FILED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.