2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: electrical system
42 reports, newest first. Show all
Electrical system, Mar 13, 2026
Odometer Fraud. The contact purchased a 2006 Toyota Rav4. The contact discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,000, and at the time of registration, it was discovered that the mileage was 199,694.
Steering, Electrical system, Exterior lighting, Apr 3, 2021
FOR SOME TIME THERE HAS BEEN AN INTERMITTENT PROBLEM WITH THE DASHBOARD LIGHTS COMING ON AND LOSS OF POWER STEERING. THE CAR HAS BEEN CHECKED BY MECHANICS, INCLUDING ONE AT A TOYOTA DEALERSHIP, BUT THE PROBLEM WAS NOT FOUND. I HAVE EXPERIENCED THE PROBLEM WITH THE CAR STATIONARY, BUT I BELIEVE MY SON SAID IT HAS HAPPENED TO HIM WHILE IN MOTION.
Power train, Electrical system, Engine, May 2, 2019
LOSING OIL ENGINE MAKING NOISE NO POWER
Steering, Electrical system, Feb 1, 2019
STEERING FROZE UP WHILE LEAVING MY DRIVEWAY AND P/S LIGHT CAME ON. SHUT ENGINE OFF AND BACK ON, BUT DID NOT RESOLVE. I RECALL AT LEAST ONE OTHER TIME THAT STEERING LOCKED UP TEMPORARILY WHILE AT A STOP. TOOK TO DEALERSHIP FOR DIAGNOSTIC AS MANUAL RECOMMENDS. DIAGNOSTIC SHOWS DTCS U0105 AND U0121. FOUND TAB ST005-06 RELATED TO THIS ISSUE AND "UPDATED POWER STEERING ECU AVAILABLE". DIAGNOSTIC $150, PARTS AND LABOR $1600+ CLEARY THIS IS A SAFETY ISSUE REQUIRING A RECALL. PLEASE INVESTIGATE THERE ARE MANY MORE SIMILAR COMPLAINTS.
Electrical system, Other or unspecified, Electronic stability control (ESC), Jun 11, 2018
MOST LIGHTS ON DASHBOARD ARE LIT UP. VSC, ENGINE 4WD. ALSO MY MECHANIC SAID OUTS THROWING OFF A LOT OF FALSE READINGS. LIGHTS ARE ALWAYS ON SOMETIMES FEELS LIKE THE TRANSMISSION IS SLIPPING WHEN I GO FROM STOPPED TO GO ON A HILL. OUTS BEEN THIS WAY SINCE I BOUGHT IT.
Steering, Electrical system, Other or unspecified, Jan 6, 2018
AT INTERSTATE SPEEDS AND SOMETIMES QUICK ACCELERATION ALL THE LIGHTS COME ON THE DASH AND YOU LOSE ALL STEERING , IT LOCKS UP THIS HAS HAPPENED SEVERAL TIMES , TO MY SEVENTEEN YEAR OLD DAUGHTER SHE WAS LUCKY THERE WAS NOT A CORNER WHEN IT HAPPENED SHE WOULD'VE SHOT STRAIGHT OFF THE ROAD . THERE NEEDS TO BE A RECALL ON THIS I HAVE LOOKED IT UP AND THERE HAS BEEN SEVERAL COMPLAINTS OF THIS SAME ISSUE ON THE RAV4S AND SEVERAL OTHER TOYOTA'S. IF I KNEW THIS ISSUE WAS A PROBLEM I WOULD NOT OF PURCHASED THIS CAR FOR MY DAUGHTER.
Electrical system, Electronic stability control (ESC), Engine, Apr 25, 2017
COMPUTER PROBLEMS CAUSING ALL THE LIGHTS TO COME ON THE DASHBOARD AND DISABLING THE SHIFTING SOLENOID. IT ALSO DISABLES THE SAFETY BRAKING AND FOUR WHEEL DRIVE. THIS CAUSES THE VEHICLE TO BE UNSAFE.
Electrical system, Mar 9, 2017
I HAVE 2006 TOYOTA RAV4-BATTERY WARNING LIGHTS FLIPS AND GO,- WHEN I WAS DRIVING IN FREEWAY 68MPH, BATTERY WARNING SIGNALS FLIPS TWO TIMES WHILE I TRY TO ACCELERATE THE VEHICLE. AND ALSO ALL WARNING SIGNALS, CHECK ENGINE, TCS, VSC, 4 WD, BREAK, AND AIRBAG SIGNALS CAME AND VEHICLE LOST ALL ELECTRICAL POWER, STEERING BECOME HARD AND BREAK DIDN'T WORK, I HAD TO PULL OVER THE VEHICLE IN FREEWAY. IT HAPPED TWO TIMES, STILL THE BATTERY SIGNALS ARE FLIPS WHEN PUSH THE GAS. I HAD TO TOW THIS VEHICLE TWO TIMES. I CHECK THIS CAR WITH THREE MECHANICS AND AUTOZONE, THEY COULD NOT FIND OUT ANY PROBLEM,. THEY ALL SAID BATTERY AND ALTERNATORS ARE WORKING GOOD ( BATTERY AND ALTERNATORS ARE REPLACED TWO EARS AGO. I HAVE SEEN MANY 2006 TOYOTA RAV4 CUSTOMERS EXPERIENCING THE SAME PROBLEM. DRIVING THIS VEHICLE IS SCARY AND LIFE THREATENING. I HOPE HIGHWAY SAFETY IS; AWARE OF THIS PROBLEM AND THEY WILL MAKE AN ENQUIRY/ACTION.
Electrical system, Jan 30, 2017
TRANSMISSION HARSH SHIFT, NO ACCELERATION, EXTREAMLY DANGEROUS TO DRIVE, ECU NEEDS REPLACED, POOR QUALITY VEHICLE.
Engine and engine cooling, Electrical system, Oct 27, 2016
2006 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO DISAPPOINTMENT WITH ALTERNATOR REPAIR WORK AT DEALERSHIP. *SMD THE CONSUMER STATED SHE DID NOT THINK SHE NEEDED AN ALTERNATOR REPLACEMENT. AFTER THE ALTERNATOR WAS REPLACED, THE BATTERY LIGHT ILLUMINATED. ACCORDING TO THE INVOICE, THE DEALER REPLACED THE SHORT ENGINE BLOCK. THE DEALER NOT CHARGE THE CONSUMER FOR THE REPLACEMENT OF THE ALTERNATOR AND ENGINE SHORT BLOCK. HOWEVER, THERE WAS A CHARGE FOR AN ENGINE GASKET AND CYLINDER. *JB
Steering, Electrical system, Engine, Aug 13, 2016
UNSAFE DEFECTS MALFUNCTION
Steering, Electrical system, Engine, Jul 14, 2016, crash
TOYOTA DEFECTS MALFUNCTIONING
Steering, Electrical system, May 26, 2016
WHILE SITTING IN SLOW 5-10MPH TRAFFIC ON THE FREEWAY, THE POWER STEERING SEIZED AND THE AIRBAG DASHBOARD WARNING LIGHT CAME ON AT THE SAME TIME (FOR ABOUT 2-3 SECONDS AT A TIME). A FEW MILES LATER, OTHER WARNING LIGHTS (VSC, SLIP, ABS, ENGINE, BATTERY) ALL ILLUMINATED ON AND OFF RANDOMLY. TOOK IT TO THE MECHANIC TO HAVE IT LOOKED AT. THEY REPLACED THE BATTERY, BUT THE PROBLEM HAPPENED AGAIN ABOUT 12 HOURS LATER. THE ALTERNATOR IS A YEAR OLD AND THE BATTERY, TIRES, ALIGNMENT, AND ENGINE COILS ARE ALL BRAND NEW. AFTER HALF A DOZEN CALLS TO THE DEALERSHIP, COME TO FIND OUT, THE PROBLEM IS THE COMPUTER THAT CONTROLS THE POWER STEERING... A PROBLEM WHICH HAS BEEN ACKNOWLEDGED AND RECALLED FOR 2014-15 MODEL YEAR RAV4S. THIS IS A SERIOUS SAFETY FLAW, AND IT IS INSULTING AND NEGLIGENT THAT TOYOTA IS PRETENDING THIS ISN'T A SERIOUS PROBLEM FOR OTHER MODEL YEARS.
Electrical system, Visibility, Apr 5, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WINDOW WAS ACTIVATED, BUT FAILED TO FUNCTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 16V096000 (SEAT BELTS), 15V689000 (VISIBILITY), 13V383000 (SUSPENSION), AND 11V113000 (VEHICLE SPEED CONTROL). THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
Electrical system, Nov 6, 2015
SUDDEN ACCELERATION WHEN THE VEHICLE IS STARTED. WHEN THE VEHICLE IS STARTED AFTER A HUMID NIGHT, THE ENGINE GOES TO FULL POWER WITHOUT DEPRESS OF THE ACCELERATOR PEDAL. WHEN THE ENGINE IS SHUT DOWN AND RESTARTED THE SITUATION IS CLEARED. THIS A SAFETY CONCERN AS THE VEHICLE IS OUT OF CONTROL IF PUT IN GEAR. THIS CONDITION HAS HAPPENED 5 TIMES IN THE LAST 60 DAYS. I CONTACTED TOYOTA AND AM NOT COMFORTABLE WITH THEIR DIRECTION BASED ON THE SAFETY CONCERN.
Electrical system, Visibility, Mar 6, 2015
THE POWER WINDOW MASTER SWITCH IT DOESN'T WORK WELL . SOMETIMES WORKS AND SOMETIMES NOT, TO MALFUNCTION OVERHEAT.. *TR
Electrical system, Engine, Jan 20, 2015
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VSC AND THE CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE COMPUTER SOFTWARE NEEDED TO BE UPDATED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE.
Steering, Exterior lighting, Electrical system, Apr 9, 2014
I WAS DRIVING ON THE HIGHWAY ABOUT 60 MPH AND POWER STEERING WENT OUT. CAR MADE A NOISE AND ALL THE DASHBOARD LIGHTS CAME ON LIKE IT WAS SLIDING ON ICE, NO BAD WEATHER THAT DAY. COULD NOT TURN STEERING WHEEL AND SPEEDOMETER WENT TO 0 AND WOULD NOT WORK THE REST OF THE JOURNEY. MADE IT TO THE TOYOTA DEALERSHIP WHERE I WAS TOLD NOTHING WAS WRONG, AND IT WAS "THE COLD WEATHER" THAT PROBABLY CAUSED IT. THEY RAN A FEW TESTS BUT NOTHING WAS DONE TO THE CAR. NO ANSWERS TO MY PROBLEM AND NOTHING HAPPENED SINCE. BUT NOW I AM WORRIED BECAUSE OF THE RECENT RECALL AND MAKES ME THINK THIS INCIDENT WAS RELATED. *TR
Steering, Electrical system, Apr 12, 2013
I HAVE ALWAYS BELIEVED IN TOYOTA'S RELIABLE VEHICLES TILL I BOUGHT MY RAV4. LATELY I HAVE HAD THE UNFORTUNATE EXPERIENCE OF HAVING TO REPLACE ALL SIX COILS WITH NEW ONES, BECAUSE TOYOTA MAID A BAD DESIGN FOR THE 2006 RAV4. AND NOW I NEED TO REPLACE THE STEERING SHAFTS BECAUSE THEY ARE BAD TOO. TOYOTA PLEASE HELP WITH COVERING THE COST OF PARTS AND LABOR. *TR
Electrical system, Vehicle speed control, Electronic stability control (ESC), Engine, Mar 2, 2013
CAR AT ABOUT 37,000 MILES. ONLY DRIVE TO STORE AND DROP KIDS OFF TO SCHOOL. CAR PARKED FOR 10 MINUTES WHILE AT STORE SHOPPING. CAME BACK, STARTED THE ENGINE. THE ENGINE LIGHT, VSC AND 4WD LIGHTS ALL LIGHTED UP. WHEN TO LOCAL TOYOTA DEALER, DEALER SAID CAN'T SERVICE IT AT THIS TIME NEED TO MAKE APPOINTMENT. DEALER STATED BASED ON THE LIGHTS, THIS MIGHT BE THE IGNITION COIL.. IT'S KNOWN TO HAVE PROBLEM. ESTIMATED COST TO FIX ABOUT $1500. BUT WE NEED TO COMPUTERIZED THE CODES.. *TR
Engine and engine cooling, Electrical system, Electronic stability control (ESC), Feb 19, 2012
WE WERE ON THE ROAD (ON A FAMILY VACATION). THE DAY THAT WE WERE COMING BACK THE CHECK ENGINE LIGHT, THE VSC LIGHT AND THE SLIP WARNING LIGHT CAME ON AS WE WERE PULLING OUT OF THE HOTEL PARKING LOT. ON THE WAY TO THE DEALER, I ALSO FELT LIKE THE CAR WAS MISFIRING. THE DEALER FOUND "MULTIPLE CODES P0304, P0305, P0306, P0356, P1578, C1201. #6 COIL MALFUNCTIONING. RECOMMEND REPLACE #6 COIL PACK AND RECHECK. POSSIBLE THAT OTHER COIL MAY FAIL FROM THE RESULT OF #6 COIL FAILING." #6 COIL PACK WAS REPLACED AND THE RAV4 HAS BEEN RUNNING FINE SINCE. THE DEALER ALSO SAID THAT "TYPICALLY AFTER ONE COIL GOES THE OTHERS FOLLOW SHORTLY AFTER", SO I WILL KEEP AN EYE OPEN FOR THAT. IT IS STRANGE SINCE IGNITION COILS HAVE A LONG LIFE EXPECTANCY. I CHECKED ON-LINE AND THERE SEEMS TO BE A HIGH FAILURE RATE WITH COIL PACK PART # 90919-02251, WHICH IS THE ORIGINAL PART THAT CAME WITH THE CAR. I MADE SURE THE PART WAS REPLACED WITH THE LATEST REVISION (90919-A2007) OF THE NEW PART NUMBERS (90919-A2002, 90919-A2004 OR 90919-A2007) THAT TOYOTA CHANGED TO. IT IS ALSO INTERESTING THAT MOST OF THE FAILURES HAPPEN WITH #6, #4 AND #5 COILS (IN THAT ORDER). THE FAILURES SEEM TO CONCENTRATE AROUND THE RIGHT FRONT CORNER, WHICH IS CLOSE TO THE RADIATOR (HOT FLUID) EXIT. MAYBE THAT IS WHY THE LATER REVISION PART # COIL PACKS HAVE A DOUBLE METALLIC SCREEN OUTSIDE THE PLASTIC HOUSING, TO PROTECT THE ASSEMBLY. *TR
Electrical system, Jan 31, 2012
AFTER CHECK ENGINE LIGHT CAME ON I TOOK IT TO THE TOYOTA DEALER FOR SERVICE AND I WAS TOLD IT WAS FAULTY IGNITION COIL. THIS ALL STARTED WHEN I NEGLECTED CLOSE THE GAS CAP ALL THE WAY ABOUT A WEEK BEFORE. AT THAT TIME I CALLED TOYOTA AND THEY SAID TO TIGHTEN IT AND THE LIGHT WOULD GO OFF. IT DID FOR AWHILE BUT SOON STARTED A SERIES OF EVENTS THAT ENDED UP WITH THE COIL "D" HAVING TO BE REPLACED. *TT
Engine and engine cooling, Electrical system, Sep 13, 2011
DRIVING BACK FROM GAS STATION ALL THREE LIGHTS CAME ON IN DASH -- VSC, CHECK ENGINE & 4WD. RESEARCHED AND FOUND THAT GAS CAP NOT SEALING COLD CAUSE PROBLEM, REMOVED / RETIGHTENED GAS CAP NUMEROUS TIMES. LIGHTS WON'T GO OFF. I HAD CAR TESTED WITH OBD READER ATTACHED AND CODES (PO300, PO303, PO305 & PO356 SAYS IT'S IGNITION COIL F--PRIMARY/SECONDARY CIRCUIT MALFUNCTION. CAR ONLY HAS 43000 MILES AND CHECKING ON THE INTERNET, SEEMS TO BE A LOT OF TOYOTA IGNITION FAILURES BETWEEN 40000 & 55000 MILES. *TR
Engine and engine cooling, Electrical system, Sep 7, 2011
2006 TOYOTA RAV 4. CONSUMER STATES IGNITION COIL AND PLUG FAILURE *TGW THE CONSUMER STATED WHILE DRIVING, VARIOUS DASHBOARD LIGHTS ILLUMINATED AND THE TRANSMISSION SHIMMIED AND THE ENGINE MISFIRED AND THE VEHICLE BECAME DISABLED. AN INSPECTION BY THE DEALER REVEALED A MISFIRE CODE AND THAT A NUMBER TWO COIL AND PLUG HAD TO BE REPLACED. A MONTH AND A HALF LATER, THE CONSUMER EXPERIENCED THE SAME PROBLEM AGAIN. IT WAS DETERMINED THAT ANOTHER IGNITION COIL HAD FAILED AND THE SUV WAS OPERATING IN FOUR CYLINDER MODE. THE CONSUMER WAS INFORMED HIS MODEL VEHICLE HAD A DESIGN/ENGINEERING PROBLEM WHICH WAS IDENTIFIED AND DOES NOT OCCUR ON SUBSEQUENT YEAR RAV 4 MODELS. *JB
Electrical system, Air bags, Jul 14, 2011
A WARNING LIGHT APPEARED ON THE DASHBOARD INDICATING AN AIRBAG MALFUNCTION. I CALLED TOYOTA SERVICE AND WAS TOLD THE CAR REQUIRED A REPAIR, AND THE AIRBAGS WOULD NOT FUNCTION AT ALL UNTIL THIS REPAIR WAS DONE. TODAY THE TOYOTA TECH TOLD US A "SPIRAL CABLE ASSEMBLY HAD GONE BAD." HE SAID IT WILL COST $514.00 TO MAKE THIS REPAIR, AND AGAIN, THE AIRBAGS WILL NOT WORK UNLESS IT IS DONE. I ASKED IF THIS WAS A RECALL ISSUE WITH TOYOTA AND THE SERVICE MANAGER REPLIED, "I HAVE NO IDEA." I ASKED IF THIS WAS A COMMON PROBLEM WITH THIS CAR AND HE REPLIED, "WE SEE IT ALL THE TIME IN RAV3'S AND TUNDRA'S." I INDICATED THE CAR IS ONLY 5 YEARS OLD WITH JUST OVER 60K MILES, AND THAT I HAVE NEVER (EVER) HAD AN AIRBAG FAILURE IN ANY VEHICLE UNTIL NOW. HE AGAIN SAID, "WELL, WE SEE IT ALL THE TIME WITH THIS MODEL." THIS SURELY APPEARS TO BE A DESIGN FLAW THAT IS VERY COSTLY TO AN AVERAGE CONSUMER. CAN THEY GET AWAY WITH THIS? PLEASE HELP! (THANKS MUCH-)