2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: engine
149 reports, newest first. Show all
Engine and engine cooling, Electrical system, Oct 27, 2016
2006 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO DISAPPOINTMENT WITH ALTERNATOR REPAIR WORK AT DEALERSHIP. *SMD THE CONSUMER STATED SHE DID NOT THINK SHE NEEDED AN ALTERNATOR REPLACEMENT. AFTER THE ALTERNATOR WAS REPLACED, THE BATTERY LIGHT ILLUMINATED. ACCORDING TO THE INVOICE, THE DEALER REPLACED THE SHORT ENGINE BLOCK. THE DEALER NOT CHARGE THE CONSUMER FOR THE REPLACEMENT OF THE ALTERNATOR AND ENGINE SHORT BLOCK. HOWEVER, THERE WAS A CHARGE FOR AN ENGINE GASKET AND CYLINDER. *JB
Steering, Suspension, Engine, Sep 11, 2016
GOOD DAY ' PLEASE: APPRAISE UNSAFETY DEFECTS. THANKFUL.
Engine, Aug 31, 2016
EXCESSIVE OIL CONSUMPTION. - TOYOTA WON'T FIX
Steering, Electrical system, Engine, Aug 13, 2016
UNSAFE DEFECTS MALFUNCTION
Steering, Electrical system, Engine, Jul 14, 2016, crash
TOYOTA DEFECTS MALFUNCTIONING
Engine, Jun 30, 2016, crash
CONSUMING A LOT OF OIL, WHEN VEHICLE ARE IN MOTION,I DID OIL CHANGE AND NOT RUN EVEN 1000 MILE AND IT WHEN TO LOWER POINT WHEN I CHECK IT IN THE MORNING BEFORE START THE CAR, I COMPLAINT TOYOTA AGENCY NOTHING SOLVE I DO NOT WHAT TO DO, PLEASE HELP, THANKS IN ADVANCE FOR ANY HELP.
Engine, Jun 5, 2016
VEHICLE BURNS OVER ONE QUART OF OIL EVERY 1,000 MILES OR LESS. THIS WAS FIRST OBSERVED IN 2015 AFTER THE VEHICLE HAD ABOUT 120,000 MILES. THROUGHOUT IT'S LIFE THE VEHICLE HAS RECEIVED REGULARLY SCHEDULE MAINTENANCE. THIS PROBLEM CAN CREATE AN UNSAFE CONDITION AND POTENTIALLY SUDDEN ENGINE FAILURE IF NOT REGULARLY CHECKED.
Engine, Jun 2, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING AT ANY SPEED, THE VEHICLE CONSUMED OIL EXCESSIVELY. THE VEHICLE WAS DRIVEN TO THE DEALER AND PASSED THE OIL CONSUMPTION TEST. AT 2,500 MILES, THE VEHICLE BURNED ALMOST THREE QUARTS OF OIL. THE WARRANTY WAS EXTENDED THROUGH TO OCTOBER OF 2016. THE CONTACT STATED THAT THE TEST WAS INACCURATE. THE FAILURE MILEAGE WAS 112,100.
Engine, Feb 2, 2016
THIS COMPLAINT IS DUE TO A RECALL: WARRANTY ENHANCEMENT NOTIFICATION ZE7 CONCERNING EXCESSIVE OIL CONSUMPTION. A TOYOTA DEALERSHIP TESTED MY CAR ON 8/27/15 AND IT FAILED. I WAS ADVISED TO KEEP CHECKING & ADDING OIL AS NEEDED AND I WOULD BE NOTIFIED WHEN THE PARTS ARRIVED TO CORRECT THIS. WHEN I CALLED TODAY, 2/2/16, THEY STILL HAVEN'T RECEIVED PARTS FOR RAV4, I AM VERY UPSET THAT IT'S TAKING SO MANY MONTHS AND I'M RESPONSIBLE FOR THIS PROBLEM IN THE MEANTIME. I FEEL AS IF I'M DRIVING A TIME BOMB AND IT'S VERY BOTHERSOME TO KEEP CHECKING THE LEVEL.
Engine, Oct 5, 2015
ENGINE MADE KNOCKING NOISE WHILE ON THE FREEWAY, AND THEN THE CAR DIED - EVERYTHING QUIT. HAD TO COAST OFF THE NEAREST EXIT. THERE WAS NO WARNING - NO MAINTENANCE REQUIRED LIGHTS WERE LIT ON THE DASH. STILL HAD ANOTHER ALMOST 2,000 MILES TO GO BEFORE NEXT OIL CHANGE WAS DUE. ENGINE IS DEAD. PER TOYOTA "CATASTROPHIC INTERNAL DAMAGE FROM THE RODS." CAR WAS WELL TAKEN CARE OF, NEVER MISSED AN OIL CHANGE, AND 8 OF THE LAST 9 YEARS, THE CAR WAS LOYALLY SERVICED AT A TOYOTA DEALERSHIP.
Engine, Oct 2, 2015
THE 2006 RAV4 MODEL TOYOTA HAS A RECORD OF STUCK OR CLOGGED OIL RINGS CAUSING EXCESSIVE OIL CONSUMPTION WHICH CAN LEAD TO FAILURE OF ENGINE AND CATALYTIC CONVERTER. THIS DEFECT CAUSES OIL TO BURN AT A RATE OF APPROXIMATELY 1 QUART OR MORE EVERY 1,000 MILES. MY RAV4 WAS BROUGHT TO THE DEALERSHIP ON 7/16/2015 TO PERFORM THE FIRST PHASE OF AN OIL INSPECTION & CONSUMPTION TEST. ON 8/4/2015 THE VEHICLE WAS BROUGHT BACK TO THE DEALERSHIP FOR RE-INSPECTION. IT FAILED THE CONSUMPTION TEST & I WAS TOLD THAT AS SOON AS PARTS BECAME AVAILABLE I'D BE CONTACTED; HOWEVER, THERE WERE SEVERAL CUSTOMERS AHEAD OF ME AWAITING THE SAME REPAIR. TWO MONTHS HAVE PASSED & I HAVE YET TO HEAR BACK FROM THE DEALERSHIP AS TO WHEN THE REPAIR CAN HAPPEN. I CALLED THE SERVICE MANAGER 10/2/2015. THE SERVICE MANAGER TOLD ME HE WOULD LOOK INTO THE MATTER & RETURN MY CALL IN 15 MINUTES. HE NEVER CALLED BACK. TOYOTA HAS ONLY ISSUED A TSB ABOUT THIS ISSUE TO DEALERS/MECHANICS, THUS OWNERS MAY NOT BE AWARE THAT OIL IS BEING BURNED OFF AS THE EXCESS SMOKE IS ABSORBED BY THE CATALYTIC CONVERTER, WHICH CAUSES CAUSES PREMATURE FAILURE OF THAT PAR AS WELL. THIS NEEDS TO BE A RECALL ITEM. IF A CAR DOING 70MPH HAS AN ENGINE FAILURE DUE TO LOSS OF OIL THEN THE PERSON WILL LOOSE STEERING AND BRAKE CONTROL LEADING TO A SERIOUS ACCIDENT OR DEATH. THIS IS A MECHANICAL ISSUE AS WELL AS A SAFETY ISSUE.
Engine, Fuel/propulsion system, Jun 27, 2015
DEAR OFFICER, I WOULD LIKE TO BRING YOUR ATTENTION TO A SERIOUS FLAW WITH CERTAIN TOYOTA MODELS RELATED TO EXCESSIVE OIL CONSUMPTION. BOWING DOWN TO THE THOUSANDS OF CONSUMER COMPLAINTS EARLY THIS YEAR TOYOTA ACCEPTED THAT IT IS ISSUE WITH THEIR ENGINE DESIGN WHICH CAN PUT ENGINE ON FIRE OR MAKE THE CAR COMPLETELY USELESS AFTER SEIZE. TOYOTA INDICATED THAT THEY WOULD PROVIDE PARTS EARLY THIS SPRING, YET IT IS THE END OF JUNE, AND TOYOTA (A GIANT CAR MANUFACTURER) STILL DOES NOT HAVE PARTS TO FIX THE SERIOUS PROBLEM TOYOTA CONSUMERS ARE SUFFERING THRU EVERY DAY. THE ISSUE: CERTAIN TOYOTA MODEL CARS BURN EXCESSIVE OIL. THE PROOF OF ISSUE(FROM INTERNET) 1. TOYOTA ENGINE EXCESSIVE OIL CONSUMPTION WWW.TOYOTAPROBLEMS.COM/TRENDS 2. TOYOTA NAMED IN CLASS ACTION LAWSUIT OVER EXCESSIVE OIL USAGE GOTACLASSACTION.COM/ 3. EXCESSIVE OIL CONSUMPTION ON 2AZ-FE ENGINE WWW.TOYOHEADQUARTERS.COM 4. CLASS ACTION LAWSUIT FILED OVER TOYOTA OIL CONSUMPTION WWW.CONSUMERCLASSLAWYERSBLOG.COM/ 5. "ALL TOYOTAS BURN ENGINE OIL!" AND "BURNING 1 LITRE OF ENGINE ... HTTPS://GRIPEVINE.COM/ THE IMPACT: LIFE ENDANGERMENT, RISK OF ENGINE FIRE, PEOPLE LEFT STRANDED IN THE MIDDLE OF NOWHERE, CONSTANT STRAIN OF CHECKING THE OIL EVERY FEW DAYS, FINANCIAL LOSSES TO CONSUMERS AND HEAVY IMPACT ON ENVIRONMENTAL POLLUTION TOYOTA RESPONSE: DELAY IN ACCEPTING THE RESPONSIBILITY, CANNOT ARRANGE PARTS FOR REPAIR, TEST METHOD PUTS CONSUMER AT RISK. THE REQUEST FOR SOLUTION: THE AMERICAN TOYOTA CONSUMERS ARE LOOKING FOR THE GOVERNMENT CONCERNED ORGANIZATION TO TAKE STRINGENT ACTIONS AGAINST TOYOTA AMERICA TO PROTECT THE LIVES AND MONEY AGAINST SUCH PRACTICES AND PROVIDE SAFE ENVIRONMENT. IF THE GOVERNING BODIES DON'T DO ANYTHING, IT WILL BE ENCOURAGEMENT FOR OTHER CAR MANUFACTURES, AND WILL HAVE DRASTIC IMPACT ON THE LIVES OF MILLIONS OF AMERICAN. THANK YOU!
Engine, Jun 3, 2015
EXCESSIVE CONSUMPTION OF OIL. IT WAS FIRST NOTICED APPROXIMATELY 3+ YEARS AGO IT WAS NOTICED WHEN CAR OIL LIGHT CAME ON AND CAR WAS ALMOST TOTALLY OUT OF OIL. AT APPROXIMATELY 2,000 MILES AFTER AN OIL CHANGE, IT IS NECESSARY TO ADD 2-3 QUARTS OF OIL. THIS HAS BEEN OCCURRING AFTER EVERY OIL CHANGE. TOYOTA RECENTLY TESTED AND AFTER 1,664 MILES FROM THE LAST OIL CHANGE, 3 QUARTS OF OIL WAS NEEDED TO TOP IT OFF. IT DID FAIL THE OIL CONSUMPTION TEST. I WANT TO KNOW WHY TOYOTA IS NOT EXTENDING CAR WARRANTY AS IS HONDA FOR THE SAME PROBLEM.
Engine, May 17, 2015
EXCESSIVE OIL CONSUMPTION ON THE RAV4 IS ONE QUART AT 1,100 MILES THAT THE LOCAL TOYOTA DEALERSHIP WILL NOT REPAIR ALTHOUGH THE HEAD TOYOTA MOTOR CORPORATION AS RELEASE A TECHNICAL SERVICE BULLENTIN SPECIFIC FOR THIS PROBLEM. LOCAL DEALERSHIP CLAIMS THIS IS "NORMAL" FOR A CAR??
Engine, May 15, 2015
WHEN MY CAR HAD JUST UNDER 100K MILES ON IT I STARTED EXPERIENCING THE FOLLOWING OIL USAGE LEVELS: TWO OIL CHANGES AGO THE OIL LIGHT CAME ON BETWEEN OIL CHANGES; OIL DID NOT REGISTER ON THE DIPSTICK AND IT TOOK APPROXIMATELY 4 QUARTS OF OIL BEFORE OIL EVEN REGISTERED ON THE DIPSTICK. ONE OIL CHANGE AGO I CHECKED THE OIL AFTER APPROXIMATELY 2K MILES AND OIL DID NOT REGISTER ON THE DIPSTICK. IT TOOK APPROXIMATELY 3 QUARTS OF OIL BEFORE OIL REGISTERED ABOVE THE LOWEST MARKING ON THE DIPSTICK. I RECEIVED TOYOTAS WARRANTY EXTENSION NOTICE AND SCHEDULED THE EXCESSIVE OIL USAGE TEST. ON MARCH 7, 2015, PART 1 OF TOYOTAS TECHNICAL SERVICE BULLETIN TEST WAS PERFORMED; I DID NOT STAY WITH THE CAR WHILE THE OIL CHANGE WAS PERFORMED. ON APRIL 13, 2015, THE SECOND PART OF THE TEST WAS PERFORMED. I WAS SURPRISED TO BE INFORMED MY CAR DID NOT MEET TOYOTAS SPECIFICATIONS FOR EXCESSIVE OIL USAGE AS I HAD NOT USED A FULL QUART OF OIL IN THE 1,100 MILES SINCE THE OIL CHANGE. I WAS TOLD THE DEALERSHIP WOULD PERFORM NO FURTHER ACTION AND MY NEXT ALTERNATIVE WOULD BE TO CONTACT TOYOTAS REGIONAL OR CORPORATE OFFICE. I CONTINUE TO EXPERIENCE OIL USAGE AT EXCESSIVE RATES; HOWEVER, BASED ON TOYOTAS STANCE THUS FAR, MY OIL USAGE IS NOT CONSIDERED EXCESSIVE.
Engine, Feb 24, 2015
OIL LIGHT CAME ON INDICATING LOW OIL ALTHOUGH THE CAR HAD BEEN SERVICED AT A LOCAL SHOP WITHIN IN THE LAST MONTH. IT THEN BECAME A PROBLEM WITH CONTINUALLY HAVING TO STOP THERE AND "TOPPING OFF" ALTHOUGH I WAS GOING THERE WHEN THE "MAINTENANCE" LIGHT CAME ON. IT WOULD NEED 1 TO 2 QUARTS EACH TIME. HAVE TO CARRY OIL ALL THE TIME IN MY CAR AS EVEN THOUGH WE CHECK IT FAIRLY OFTEN, EVERY 1 TO 2 WEEKS. IT ALWAYS NEEDS OIL. THE SHOP WANTED TO DIAGNOSE THE PROBLEM FOR ME, BUT NOW I CAN SEE IT IS A VERY WIDESPREAD PROBLEM WHICH I FEEL SHOULD HAVE BEEN ADDRESSED YEARS AGO. *JS
Steering, Service brakes, Engine, Feb 22, 2015
PROBLEMA CON SISTEMA DE FRENO.AL FRENAR EL AUTO RAV4 EL PEDEDAL DE FRENO PIERDE PRECION BAJA HASTA EL FONDO . CUAL HAY QUE ESTAR APLICANDO VARIAS VECES EL PEDAL FRENO PARA MANTENER PECION EN EL FRENADO DE EL AUTO. EL COSUMO DE ACEITE EXSESIVO.EN EL MOTOR .EL CONTROL DEL VOLANTE SONIDO FUERTE AL GIIRAR. *TR
Engine, Feb 2, 2015
I HAVE THE RAV4 2006 4 CYLINDER MOTOR. VALVE LOUD ALL THE TIME, AND YARIS. ALL TIME. TOYOTA IN ME SAID THE ONLY THING THAT WAS RESET TACOMA THAT WAS THE SAME PROBLEM. *TR
Electrical system, Engine, Jan 20, 2015
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VSC AND THE CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE COMPUTER SOFTWARE NEEDED TO BE UPDATED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. THE VIN WAS NOT AVAILABLE.
Engine, Jan 14, 2015
VEHICLE SUDDENLY STARTED CONSUMING LARGE AMOUNTS OF OIL, APPROXIMATELY 1 QUART PER 1,000 MILES. OIL HAS BEEN CHANGED AT REGULAR INTERVALS AND VEHICLE HAS BEEN WELL TAKEN CARE OF IN TERMS OF REGULAR MAINTENANCE INTERVALS. *TR
Steering, Engine, Jan 13, 2015
I BROUGHT MY 2006 RAV4 TO THE TOYOTA DEALERSHIP FOR TWO DIFFERENT RECALL NOTICES INCLUDING THE SUSPENSION AND AIRBAG. UPON INSPECTION, THEY NOTIFIED ME THE WATER PUMP NEEDED REPLACING AND THAT THE STEERING COLUMN BRACKETS WERE LOOSE. THEY SAID THIS IS A COMMON PROBLEM AND TRIED TO TELL ME THAT IT IS CAUSED BY NORMAL WEAR & TEAR. MY LAST VEHICLE I HAD FOR OVER 190,000 MILES AND NEVER HAD THIS PROBLEM. UPON RESEARCHING, THIS SEEMS TO BE A COMMON PROBLEM. I WAS TOLD THIS PROBLEM NEEDS TO BE FIXED IMMEDIATELY AS FAILURE TO FIX IT COULD RESULT IN LOSS OF STEERING CONTROL. PREVIOUSLY I HAVE BROUGHT THE LOUD POPPING NOISE TO VARIOUS TOYOTA DEALERSHIPS AND HAVE NEVER BEEN TOLD OF THIS ISSUE IN 9 YEARS. THIS ISSUE WOULD NOT HAVE BEEN CAUGHT IF IS WASN'T FOR THE RECALL ON THE AIRBAG. ANYTHING THAT APPEARS TO BE A "COMMON" ISSUE IN A VEHICLE THAT CAN RESULT IN LOSS OF STEERING IS A SERIOUS SAFETY ISSUE AND SHOULD BE RECALLED AND FIXED BY TOYOTA AT NO COST TO THE CONSUMER. THE COST IS ESTIMATED AT $600+ TO REPAIR. *TR
Power train, Engine, Fuel/propulsion system, Nov 21, 2014
AT APPROXIMATELY 81000 MILES, RAV-4 STARTED TO BURN OIL AT A RATE OF TWO QUARTS PER EVERY 3000 MILES. NOW AT 120,000 MILES, IT BURNS ONE QUART EVERY 1000 MILES. BY COMPARISON, MY 1987 TOYOTA CAMRY DOES NOT BURN A DROP. *TR
Engine, Nov 4, 2014
THERE IS A VERY PRONOUNCED RATTLE, CLACKING, OR SUCH NOISE FROM THE ENGINE WHEN TRAVELING AT AROUND 25 MPH WHILE GENTLY ACCELERATING FROM BETWEEN 1500 AND 2000 RPM. IT IS QUITE REPEATABLE. IT OCCURS MORE READILY WHEN GOING UPHILL BUT I CAN INDUCE IT ON FLAT GROUND AS WELL. IT SOUNDS IT IS FROM THE TOP END BUT BECAUSE IT ONLY HAPPENS AT-SPEED I CANNOT KNOW FOR SURE. THE SOUND RESEMBLES VALVETRAIN NOISE. THIS VEHICLE WAS PURCHASED FROM A TOYOTA DEALER WITH APPROX. 46K MILES AND IT HAS MADE THIS NOISE SINCE I FIRST OWNED THE CAR. IT HAS BEEN REPORTED TWICE AND BOTH TIMES I WAS TOLD THAT IT IS NORMAL, "ALL RAV4S DO THAT". I DON'T KNOW IF THIS IS RELATED IN ANY WAY TO THE WELL-KNOWN OIL CONSUMPTION ISSUE THAT THIS ENGINE HAS (2.4 LITER INLINE 4), AS I ALSO EXPERIENCE EXCESSIVE OIL CONSUMPTION. *TR
Engine, Oct 27, 2014
THE 2006 RAV4 IS KNOW TO BURN OIL AT EXCESSIVE RATE WHICH WILL CAUSE THE ENGINE TO LOCK UP AT A HIGH RATE AND LEAD TO NOT BEING ABLE TO CONTROL THE VEHICLE BECAUSE OF LOSS OF STEERING OR BRAKING. *TR
Engine, Oct 16, 2014
OIL CONSUMPTION, INSURANCE WILL NOT PAY TO CORRECT THIS DEFECT THAT APPARENTLY IS A PROBLEM WITH TOYOTA RAV 4 THIS AN ISSUE WITH 2006 RAVS AND THE SHOULD BE A RECALL AS THIS IS A VERY EXPENSIVE ISSUE THAT IS RELATED TO THE VEHICLE MAKING AND NOT NEGLECT BY THE OWNER. *TR