2006 Toyota RAV4
Problems, recalls and owner-reported issues
Steering is the leading concern among 704 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 RAV4 model years with reports.
Of the 2006 reports, 26 involved a crash and 5 involved a fire. 10 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
704 reports, newest first.
Engine, Feb 27, 2020
THE ENGINE IS BURNING OIL LIKE MAD. I PURCHASED IT THREE WEEKS AGO AND THERE WERE NO ISSUES WHEN I LOOKED AT IT. I HOOKED MY OBD II SCANNER AND NO CODES POPPED, WHICH MADE ME GO AHEAD AND PURCHASE IT. I HEARD ABOUT THE TOYOTA 2AZ-FE ENGINES HAVING OIL ISSUES, BUT THIS IS GETTING OUT OF HAND. MY MECHANIC CHANGED MY OIL A LITTLE OVER A WEEK AGO AND NOTIFIED ME THAT I WAS A QUART LOW, BUT FILLED IT FOR ME. HE TOLD ME IF I WAS CONCERNED TO MONITOR IT, WHICH I HAVE. TONIGHT, FEBRUARY 27, 2020, I CHECKED MY OIL WHILE IT'S STATIONARY IN MY DRIVEWAY AND HAS NOT BEEN ON FOR OVER FOUR HOURS AND IT'S RIGHT AROUND THE LOW LEVEL LINE. I GOT MY OIL CHANGED AT 163,035 MILES. IT'S NOW LOW AT 163,260 MILES! I'M SCARED AND CONCERNED ABOUT DRIVING IT BECAUSE BEING A COLLEGE STUDENT AND WORKING, I WOULD DREAD THAT MY RAV4'S ENGINE BLOWS UP OR SEIZES ON ME OUT OF NO WHERE. PLEASE, THIS ISSUE IS SCARY AND CAN PLACE A LOT OF PEOPLE AND FAMILIES IN DANGER. I CAN PROVIDE PAPERWORK OF THE DAY OF THE OIL CHANGE AND MY ODOMETER. I TOOK A PICTURE OF IT WHICH I WILL ATTACH.
Suspension, Jan 28, 2020
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT EACH TIME THE VEHICLE WAS DRIVEN, IT SHOOK INTERMITTENTLY. NO WARNING INDICATOR LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE HAS PROGRESSIVELY WORSENED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130, 000.
Suspension, Dec 20, 2019
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT BOTH REAR WHEELS WERE WEARING OUT THE TIRES DUE TO NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) REGARDING THE REAR SUSPENSION ARM. THE VEHICLE WAS TAKEN TO NAGUABO AUTO SALES (272 NAGUABO PR 00718), BUT AN ALIGNMENT COULD NOT BE COMPLETED DUE TO THE SEAL ON THE REAR SUSPENSION. THE DEALER WAS SUPPOSED TO REPLACE BOTH SUSPENSION ARMS, BUT THEY WERE SEALED INSTEAD. THE CONTACT ALSO STATED THAT THE TIRES WOULD SLIDE WHILE DRIVING. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE IT WAS DETERMINED THAT AN ALIGNMENT COULD NOT BE COMPLETED DUE TO THE SEAL ON THE REAR SUSPENSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 182,999. THE VIN WAS INVALID.
Suspension, Dec 3, 2019
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION), HOWEVER THE PARTS FOR THE RECALL REMEDY WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. HERITAGE TOYOTA CATONSVILLE (6324 BALTIMORE NATIONAL PIKE, BALTIMORE, MD 21228, (844) 315-0964) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
Engine, Jul 6, 2019
MY CAR HAS BEEN CONSUMING LOTS OF OIL HOWEVER I WAS NEVER ABLE TO IDENTIFY WHERE THE LEAK WAS COMING FROM. I CONTACTED TOYOTA CERTIFIED REPAIR SERVICE WHEN I WENT TO GET OIL CHANGED THEY INDICATED THEY DID NOT IDENTIFY ANY LEAKS AND THE VEHICLE WAS OPERATING CORRECTLY ALTHOUGH I RETURNED TO TOYOTA CERTIFIED REPAIR SERVICE WITHIN APPROXIMATELY 3 WEEKS SERVICE ADVISOR ACKNOWLEDGED THAT LEAK SHOULD HAVE BEEN DIAGNOSED CLOSER. SERVICE ADVISOR VIEWED OIL EVERYWHERE UNDERNEATH HOOD AND IT AGAIN REQUIRED 2.5 QUARTS ON OIL IN THIS SHORT TIME FRAME. I WAS ADVISED TO DRIVE ANOTHER 1K MILES AND BRING BACK TO DETERMINE WHERE LEAK WAS LOCATED AND THEY WOULD ASSIST WITH REPAIR COSTS HOWEVER I BROUGHT BACK WITHIN 584 MILES AND VEHICLE AGAIN HAD CONSUMED ENORMOUS AMOUNT OF OIL YET NOW ADVISOR AND SERVICE MANAGER INSISTED THEY COULD NOT HELP WITH ANYTHING. ONLY AFTER BEING VISUALLY UPSET ABOUT THE MOST RECENT DEVELOPMENTS DID THE SERVICE ADVISOR LIBRA JONES MENTION ANYTHING ABOUNT THE WARRANTY ENHANCEMENT ZE7 BUT ALSO STATED MY WARRANTY HAD EXPIRED AND I WAS LEFT TO FEND FOR MYSELF. LIBRA JONES TOLD ME TO CONTACT TOYOTA TO SEE IF THEY WOULD HELP AND BRIEFLY MENTION THE GOODWILL ASSISTANCE PROGRAM. HOWEVER AFTER SPEAKING TO MILLIE@ TOYOTA, SHE HAD NO INTENTIONS OF ASSISTING WITH ANY REPAIR COSTS AND EVEN ASKED TO SPEAK TO A MANAGER IN REGARDS TO MY ISSUE AND SHE STATED SHE WOULD HAVE A MANAGER CONTACT WITHING 24 HOURS HOWEVER NO ONE BOTHERED TO EVER REACH OUT TO ME WHATEVER WHICH FORCED ME TO CONTACT MANY OF THE TOP EXECUTIVES TO ADDRESS MY CONCERNS. BASED ON THE EXECUTIVE ASSITANCE EBONEY BLANKS REACTIONS, TOYOTAL NEVER INTENDED TO OFFER ANY ASSISTANCE AS IT RELATES TO THEIR PRODUCTS. THEY INDICATED THEY MAILED OUT DOCUMENTS TO MY GRANDPARENTS HOWEVER RECORDS WOULD REFLECT IF THERE WERE ANY REPAIRS THAT REQUIRED ATTENTION MY GRANDPARENTS WOULD HAVE DONE PRIOR TO SELLING TO ME
Power train, May 13, 2019
WE PURCHASED A 2006 RAV4 LIMITED THE FIRST WEEK OF MARCH 2019. A REAR DIFFERENTIAL COUPLING GROWL NOISE WAS NOTICEABLE A MONTH AFTER WE PURCHASED THE VEHICLE. WHILE DRIVING THE REAR END STARTED MAKING A GROWLING NOISE. IN EARLY JANUARY 2015 TOYOTA ISSUED A WARRANTY ENHANCEMENT PROGRAM (ZF4) FOR YEARS 2006-2012 RAV4 TO HAVE THE DEFECTIVE BEARING REPLACED, BUT THEY PUT AN EXPIRATION DATE OF APRIL 30TH 2017 OR 9 YEARS FROM THE DATE OF FIRST USE REGARDLESS OF MILEAGE. I CAN'T UNDERSTAND HOW YOU CAN PUT AN EXPIRATION DATE ON A DEFECTIVE PART. THESE BEARINGS COULD GO BAD AND SEIZE AT ANY TIME POSSIBLY CAUSING AN ACCIDENT WITH INJURIES OR EVEN DEATH. WE HAPPEN TO OWN TWO OF THESE VEHICLES, SAME YEARS, ONE MAKING NO NOISE AND NOT GOING BAD YET, BUT THE OTHER DECIDED IT WAS TIME. THERE SHOULD BE A RECALL ON THIS REAR DIFFERENTIAL COUPLING BEARING, NOT A WARRANTY ENHANCEMENT PROGRAM. TOYOTA HAS ALREADY ACKNOWLEDGED A DEFECT WITH THE BEARING BY INITIATING A WARRANTY ENHANCEMENT PROGRAM, YOU CAN'T JUST SAY AFTER APRIL 30TH 2017 NO OTHER BEARINGS WILL FAIL AND IF THEY DO WE PASS THE BUCK ON THE PROBLEM. THANK YOU FOR HEARING MY CONCERNS, I LOOK FORWARD TO HEARING BACK FROM YOU. I WOULD LIKE TO DEBATE THE ISSUE WITH ONE OF THEIR REPRESENTATIVES WITH YOU LISTENING, I'D RIP'EM APART. IT IS TIME THESE BILLION DOLLAR COMPANIES OWN UP TO THEIR MISTAKES AND NOT PASS THE BUCK TO THE LITTLE GUY. THANK YOU AGAIN, (XXXX). YOU CAN CONTACT ME AT (XXXX). PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Engine, May 9, 2019
2.4 ENGINE BURNS EXCESSIVE OIL. APPARENTLY, OTHER TOYOTA MODELS WITH THE SAME 2.4 ENGINE HAVE HAD FREE REPAIRS. I BELIEVE TOYOTA SHOULD REPAIR THE 2.4 ENGINE IN MY 2006 RAV4 TO STOP THE EXCESSIVE OIL BURNING. IT NOW BURNS ONE QUART FOR EVERY 500-600 MILES.
Power train, Engine, May 2, 2019
TAMARA RECALL ENGINE FAILURE ALMOST CAUSED A MAJOR ACCIDENT. DEALERSHIP TELLS ME THE IT'S AN RECALL BUT, IT HAS NOW EXPIRED. I DON'T UNDERSTAND HOW A SAFETY RECALL CAN EXPIRE. I NEED HELP FROM AN ATTORNEY ON THIS MATTER. BECAUSE THIS ISN'T RIGHT. CAN YOU RECOMMEND AN ATTORNEY? THEY SAID THEY COULD ONLY DO NEW RINGS AND NEW PISTONS BACK THEN BUT NOW TOYOTA WILL NOT EVEN DO THAT. SO NOW I JUST HAVE A 5,000 BILL FOR A NEW ENGINE.
Power train, Electrical system, Engine, May 2, 2019
LOSING OIL ENGINE MAKING NOISE NO POWER
Suspension, Structure, Apr 26, 2019
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE REAR AND FRONT AXLES WERE RUSTED OUT AND RUST COVERED THE BOTTOM OF THE VEHICLE. THE VEHICLE WAS TAKEN TO CURRY WATER TOWN TOYOTA (832 STRAITS TURNPIKE, WATERTOWN, CT 06795, (203) 758-8261), BUT THE MECHANICS REFUSED TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 180,000. .*BF CONSUMER STATED THE TOYOTA DEALER IN WATERTOWN, CT (CURRY) REFUSED TO DO A SAFETY RECALL ON THE REAR LOWER SUSPENSION ARM DUE TO AXLE RUST. THIS RUST WAS NEVER BROUGHT TO MY ATTENTION PREVIOUSLY. *JB
Other or unspecified, Service brakes, Apr 15, 2019
HAVING AN ISSUE WITH MY REAR RIGHT WHEEL SPEED SENSOR - SO THEREFOR IF I DON'T COUGH UP THE $1200 THAT TOYOTA IS ASKING, I WON'T HAVE THE SAFETY FEATURES OF ABS OR TRACTION CONTROL ON MY CAR. I WAS DRIVING ON THE HIGHWAY WHEN THE ABS, BRAKE AND TRACTION CONTROL WARNING LIGHTS CAME ON... THEY'VE BEEN ON FOR A WEEK.. CAR IS SITTING AT TOYOTA NOW WHILE I DECIDE WHAT TO DO
Suspension, Apr 12, 2019
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE SHOOK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO TOYOTA DE PONCE (URBANIZACIN PERLA DEL SUR, CARRETERA 2, ESQUINA CALLE RAFAEL LUGO GONZALEZ, PONCE PR 00716, (787) 651-8800), BUT THE PART WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000. PARTS DISTRIBUTION DISCONNECT.
Engine, Apr 8, 2019
OIL LIGHT CAME ON SECONDS BEFORE CHECK ENGINE LIGHT. CAR WOULD NOT ACCELERATE AND I HAD TO PULL OFF ROAD. ENGINE REQUIRED FOUR (4) QUARTS OF OIL. NO WARNING OF LOW OIL!! I WAS DRIVING ON AN INTERSTATE HIGHWAY AT THIS TIME!
Air bags, Seats, Mar 11, 2019
MY RAV4--VIN: [XXX]--HAS A PROBLEM WITH THE DRIVER SIDE AIRBAG CONNECTOR. WHEN THE WARNING LIGHT IS ON, IT DEACTIVATES ALL OF THE AIRBAGS. IT HAS BECOME PERMANENTLY ON IN RECENT DAYS. IT HAS BECOME A SAFETY HAZARD. WHEN I START MY VEHICLE AND THE AUTOMATIC CHECK UP, THE AIRBAG LIGHT KEEPS LIGHTING UP. THE AIRBAG LIGHT ON THE DASHBOARD WOULD BE ON WHEN STATIONARY OR IN MOTION. IT WILL KEEP ON FOR THE DURATION OF THE DRIVE. THE ERROR CODE FOUND BY MY INDEPENDENT MECHANIC IS B1821. BUT MY MECHANIC CAN NOT FIX THIS PROBLEM. EVEN REPLACING THE FRONT DRIVER SEAT MAY NOT FIX THE PROBLEM, ACCORDING TO MY MECHANICS. IT WAS A DESIGN PROBLEM WITH THE CONNECTOR. I HAVE ASKED TOYOTA TO FIX THIS FOR FREE. TOYOTA REFUSED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
Air bags, Mar 5, 2019
THE SIDE AIRBAG CONNECTOR FAILED TO WORK SPORADICALLY. WHEN IT FAILED TO PASS THE ONBOARD TEST, THE WHOLE AIRBAG SYSTEM STOPS WORKING, WHICH BECOMES A SAFETY HAZARD.
Steering, Feb 27, 2019
VEHICLE DID HAVE AN OFFICIAL RECALL(STEERING SHAFT ASSEMBLY) VEHICLE WAS REPAIRED 2X'S. VEHICLE IS EXPERIENCING SAME PROBLEM. STEERING GETS TIGHT AND KNOCKS. SENT LETTER TO TOYOTA IN CALIFORNIA CREATED CASE #[XXX] DEALER REFUSES TO REPAIR *TT CONSUMER STATED THERE ARE 2 ODI NUMBERS #352270 AND #1182873. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *LN*JB
Exterior lighting, Feb 27, 2019
PLEASE REQUIRE A RECALL AND REPLACEMENT OF HIGHLIGHTS ON ALL NEWER CARS. THEY ARE MUCH TOO BRIGHT. I CAN'T SEE A THING WHEN THESE CARS ARE DRIVING TOWARD ME BECAUSE THE LIGHT IS BLINDING. I HAVE HIT ANIMALS IN THE ROAD AND IN 2 INSTANCES HAVE ALMOST STRUCK PEOPLE. PLEASE REQUIRE A RECALL AND REPLACEMENT OF ALL THESE LIGHTS, AND PLEASE REQUIRE ALL STATES TO TEST THE BEAM DIRECTION ANNUALLY, PARTICULARLY ON TRUCKS AND LARGE SUVS WHICH TIP UPWARD IN THE FRONT END WHEN THEY ARE TOWING OR CARRYING A LOAD IN THE BACK OF THE VEHICLE. ALL OF THESE LIGHTS ARE A HAZARD AND I FEEL IT IS JUST A MATTER OF TIME UNTIL I STRIKE A BICYCLIST OR PEDESTRIAN BECAUSE I SIMPLY CAN'T SEE BEYOND THE VEHICLE WITH THAT MUCH LIGHT IN MY EYES. (I HAVE HAD MY EYES EXAMINED FOR PHOTOSENSITIVITY AND THAT IS NOT THE PROBLEM.) PLEASE ACT ON THIS.
Steering, Electrical system, Feb 1, 2019
STEERING FROZE UP WHILE LEAVING MY DRIVEWAY AND P/S LIGHT CAME ON. SHUT ENGINE OFF AND BACK ON, BUT DID NOT RESOLVE. I RECALL AT LEAST ONE OTHER TIME THAT STEERING LOCKED UP TEMPORARILY WHILE AT A STOP. TOOK TO DEALERSHIP FOR DIAGNOSTIC AS MANUAL RECOMMENDS. DIAGNOSTIC SHOWS DTCS U0105 AND U0121. FOUND TAB ST005-06 RELATED TO THIS ISSUE AND "UPDATED POWER STEERING ECU AVAILABLE". DIAGNOSTIC $150, PARTS AND LABOR $1600+ CLEARY THIS IS A SAFETY ISSUE REQUIRING A RECALL. PLEASE INVESTIGATE THERE ARE MANY MORE SIMILAR COMPLAINTS.
Engine, Jan 18, 2019
EVER SINCE MY VEHICLE HIT 100,000 MILES, IT HAS BEEN BURNING OIL EXCESSIVELY AT THE RATE OF ABOUT 2-3 QUARTS EVERY 800-1000 MILES. THE VEHICLE CURRENTLY HAS APPROX. 116,000 MILES ON IT. PRIOR TO REACHING 100,000 MILES, IT WAS TESTED BY TOYOTA VIA A SERVICE "BULLETIN", NOT A "RECALL" FOR THIS ISSUE, AND PASSED. BUT, AFTER REACHING 100,000 MILES IT WAS TESTED AGAIN, AND FAILED. UNFORTUNATELY, THE VEHICLE IS NO LONGER UNDER ANY TYPE OF WARRANTY COVERAGE, MAKING REPAIRS FINANCIALLY IMPOSSIBLE
Engine, Jan 15, 2019
IT WAS RECALLED FOR MOTOR OIL CONSUMPTION. BUT WAS NOT ABLE TO TAKE IT FORBPERSONAL REASONS. RECALL EXPIRED IT CAN NOT BE FIXED. NOW CAR IS CONSUMING ALOT OF OIL. DON'T KNOW WHAT TO DO.
Steering, Jan 5, 2019
STEERING 'CLUNKS' AND CAR WON'T TURN AT LOW SPEEDS/STATIONARY, RADIO MOMENTARILY CUTS OUT AND DASH LIGHTS FLASH. CAN TURN THE STEERING WHEEL FURTHER AFTER A FEW SECONDS. HAPPENS INTERMITTENTLY, SO FAR ONLY AT LOW SPEEDS/WHILE PARKING OR LEAVING A PARKING SPACE.
Suspension, Dec 25, 2018
FRAME HAS SEVERE CORROSION ROTTED THROUGH. THIS PROBLEM MUST HAVE BEEN PROGRESSING FOR SOME TIME, BUT THE INDICATOR OF A RATTLING WAS MOST EVIDENT RECENTLY. I BEGAN HEARING A CLANGING SOUND UNDER THE REAR OF THE DRIVERS SIDE WHEN I WENT OVER SMALL BUMPS IN THE ROAD, SUCH AS A MANHOLE OR SMALL POTHOLE. IT GOT PROGRESSIVELY WORSE IN A MATTER OF DAYS, OCCURRING OVER SMALL CRACKS IN THE ROAD SO I BROUGHT IT TO MY LOCAL MECHANIC. HE HAS DEEMED IT UNSAFE TO DRIVE WITH SEVER ROTTING THROUGH OF THE FRAME. MY RESEARCH ONLINE INDICATES THIS IS SIMILAR TO BRIAN WARNER ET AL. V. TOYOTA MOTOR SALES, U.S.A., INC., CLASS ACTION SETTLEMENT ON THE TACOMA, TUNDRA AND SEQUOIA AND RECENT INVESTIGATION INTO THE 4RUNNER BY NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA).
Suspension, Nov 23, 2018
TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, A BUMPING NOISE WAS HEARD COMING FROM THE REAR OF THE VEHICLE AND THE VEHICLE WOULD NOT DRIVE IN A STRAIGHT LINE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE REAR SUSPENSION EXPERIENCED SEVERE RUSTING AND CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO ARLINGTON TOYOTA (2095 N. REND RD, PALATINE, IL) WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INDICATED THAT THE VEHICLE WAS SERVICED IN 2013 PER NHTSA CAMPAIGN NUMBER: 13V383000 (SUSPENSION) TO PREVENT THE FAILURE FROM OCCURRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 104,000.
Engine, Nov 22, 2018
BURNING ENGINE OIL, TURNS OUT NEED TO FILL ENGINE OIL VERY FREQUENTLY. SEARCH ONLINE, IT'S A RECALL. BUT IT'S EXPIRED FOR ME
Steering, Nov 22, 2018
HEAR CLUNK SOUND WHEN TURNING THE STEERING. CHECK WITH TOYOTA SUNNYVALE DEALER, THEY SAID THE STEERING INTERMEDIATE SHAFT NEEDS TO BE REPLACED