2008 Toyota RAV4
Problems, recalls and owner-reported issues
Engine is the leading concern among 575 owner complaints filed for this model year. This is the 5th highest complaint count among 26 RAV4 model years with reports.
Of the 2008 reports, 42 involved a crash and 16 involved a fire. 32 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bagsApr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V245000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: steering
73 reports, newest first. Show all
Steering, Dec 13, 2012
THERE IS A CLUNKING NOISE WHEN THE STEERING WHEEL IS TURNED TO THE LEFT OR RIGHT. *TR
Steering, Power train, Dec 8, 2012
2008 (STARTED AT 20,000 MILES, 1 YEAR OUT OF WARRANTY) TOYOTA RAV 4 STARTED A CLUNKING NOISE IN THE DRIVE SHAFT WHEN TURNING THE WHEEL. WE TOOK IT IN FOR SERVICE AND THE DEALER SAID THEY COULD NOT DUPLICATE THE PROBLEM. IT'S A CONSTANT SOUND! WHY THEY SAID THIS IS UNEXPLAINABLE. IT'S BEEN NON STOP SINCE AND GETTING WORSE. WE READ ON THE INTERNET THIS IS COMMON PROBLEM FOR RAV 4 OWNERS. WE WILL BE TAKING IT BACK IN AGAIN AND WILL PROBABLY BE TOLD THE SAME THING. I ALSO UNDERSTAND THERE IS A TAG ISSUED FOR THIS PROBLEM BY TOYOTA ALSO. THE REPAIR IS AVERAGED TO BE $800 AND SOME DEALERS ARE WILLING TO SHARE IN THE REPAIR COST. THIS SHOULD BE TOYOTA'S 100% RESPONSIBILITY! *TR
Steering, Suspension, Power train, Dec 3, 2012
HAPPY HOLIDAYS & HANUKKAH! BOB BRIDGE TOOK ADVANTAGE OF MY AGE & BACKGROUND. THEY CHARGED ME $1280 OUT THE DOOR FOR TSB RECALL SERVICE. IT'S UNFAIR & ABSURD 4 ME PAYING TOYOTA'S DESIGN FLAWS. CAN YOU PLEASE HELP ME GET IN TOUCH WITH PORTLAND REGIONAL OFFICE SO THEY CAN START REIMBURSEMENT TO ME? BOB BRIDGE IS MILKING BOTH ME & TOYOTA DISTRICT MANAGERS. THEY TOOK 14 DAYS TO PUT IN NEW STEERING SHAFT AND OFFERED ZERO IN-DEPTH REPORT ON FAILURE & STEERING SHAFT'S WARRANTY. RUSHED THROUGH THE JOB AND LEFT ME DYING BATTERY & ALTERNATOR. T-SB-0318-08 (STEERING SHAFT RECALL) STEERING NOW FEELS HARD SINCE THEY DIDN'T REFILL POWER STEERING RESERVOIR. MY ALTERNATOR & BATTERY WAS LEFT AS IS WITH DIMINISHING CAPACITY. I WILL ONLY PAY $150 OUT THE DOOR LABOR FOR THIS TSB SERVICE, THE REST WILL BE PAID BY TOYOTA'S DISTRICT OFFICE. WHEN CAN YOU SEND ME MY CHECK? *TR
Steering, Dec 2, 2012
EVERY TIME I MAKE A TURN (RIGHT OR LEFT), I HEAR THIS KNOCKING SOUND ON MY STEERING WHEEL. IT FEELS LIKE SOMETHING IS ABOUT TO BREAK. I JUST NOTICED THIS RIGHT AFTER I REPLACED THE BATTERY. *TR
Steering, Nov 14, 2012
STEERING COLUMN CLUNKING SOUND WHEN EVER YOU TURN THE STEERING WHEEL LEFT OR RIGHT OR GOING AT SPEEDS OF 25-35 AND 55-70. THE NOISE WAS NARROWED DOWN TO THE STEERING COLUMN ASSEMBLY. *TR
Steering, Oct 22, 2012
I HAVE EXPERIENCED A CLUNKING NOISE WHEN TURNING THE STEERING WHEEL AT LOW OR NO SPEEDS FOR MUCH OF THE TIME I HAVE OWNED THE CAR. IT WAS REPORTED AND CHECKED WHILE UNDER WARRANTY. THE DEALER MADE AN ADJUSTMENT BUT DID NOT RECORD IT IN THEIR SERVICE RECORDS. NOW, AT 42,159 MILES, THE NOISES HAVE BECOME MORE FREQUENT AND I CAN FEEL IT WHILE TURNING THE WHEEL. TODAY, THE DEALER FOUND A TECHNICAL SERVICE BULLETIN FOR INTERMEDIATE SHAFT NOISE AND ARE RECOMMENDING REPLACEMENT OF THE SHAFT. CHECKING THE WEB I HAVE FOUND THAT THERE HAVE BEEN MANY COMPLAINTS ON THIS WITH 2006 - 2008 RAV4'S INCLUDING NUMEROUS REPORTS TO THE NHTSA. IT IS A KNOWN SAFETY ISSUE. I CONTACTED TOYOTA TODAY AND WAS TOLD THERE IS NO RECALL ON THE VEHICLE FOR IT AND THE CAR IS OUT OF WARRANTY. I WILL HAVE TO PAY THE COST FOR THE SHAFT REPLACEMENT. SINCE THIS IS A KNOWN SAFETY PROBLEM, I FEEL THERE SHOULD BE A RECALL ON IT AND TOYOTA SHOULD TAKE CARE OF THE REPAIRS AT NO COST. *TR
Steering, Electrical system, Oct 3, 2012
I WAS MAKING A SLOW SPEED TURN WHEN, WITHOUT WARNING, IT BECAME VERY DIFFICULT TO STEER, AS IF THE POWER STEERING QUIT WORKING. AS I ACCELERATED THE STEERING STARTED WORKING AGAIN. A FEW DAYS LATER IT HAPPENED AGAIN AND THIS TIME THE BATTERY WARNING LIGHT CAME ON. BOTH TIMES THIS HAPPENED IT ALMOST CAUSED A COLLISION. I ENDED UP TAKING IT TO THE DEALER AND LEARNED THE ALTERNATOR WAS GOING BAD. AN ALTERNATOR ON A FOUR YEAR OLD VEHICLE WITH 60K MILES SHOULD LAST LONGER. I'VE SINCE LEARNED, FROM SAFETY SITES, THAT THIS IS A COMMON SAFETY ISSUE WITH THE RAV AS THE STEERING IS ELECTRICALLY POWERED. THERE IS ALSO SOME INDICATION THE ALTERNATORS ARE FAILING TOO SOON. *TR
Steering, Power train, Service brakes, Sep 5, 2012
SLIPPING BRAKES, REQUIRING FREQUENT CHECKUPS AND REPLACEMENT POPPING NOISE IN THE STEERING WHEEL ( WHICH AFTER TWO YEARS OF COMPLAINING, I WAS INFORMED IS A DEFECTIVE STEERING SHAFT ) SUDDEN ACCELERATION INCREASING NOISE FROM UNDER THE VEHICLE JUMPING WHEN THE VEHICLE IS PLACE IN REVERSE. *TR
Steering, Electrical system, Exterior lighting, Aug 11, 2012
I HAVE A 2008 TOYOTA RAV4 AND IT HAS HAD A WHINING SOUND WHEN IDLING OR ACCELERATING FOR A WEEK. TODAY I WAS DRIVING IT AND THE POWER STEERING QUIT WHILE I WAS DRIVING IT. I COULD BARELY STEER IT, IF MY WIFE WAS DRIVING, SHE COULD NOT HAVE TURNED THE VEHICLE. MANY OF THE WARNING LIGHTS CAME ON- BRAKE LIGHT (CHECKED THE PARKING BRAKE), ABS, SRS, BATTERY, VSC, MAINTENANCE, AND SLIP INDICATOR LIGHTS. ALSO THE RADIO QUIT WORKING, ALL AT ONCE. NEW BATTERY INSTALLED LAST MONTH. WE HAVE OWNED THIS VEHICLE SINCE NEW FROM THE DEALERSHIP, HAD 2 RECALLS FIXED FOR AIR BAG SENSOR AND FLOOR MATS, BUT NO OTHER PROBLEMS UNTIL THIS. *TR
Steering, Suspension, Jul 24, 2012
AT AROUND 9:30 AM ON JULY 8, I WAS ON I-15 IN S. UTAH WHEN MY RIGHT REAR TIE ROD FAILED. VERY SCARY AND I WAS LUCKY I DID NOT END UP ROLLED OVER IN THE DITCH, HIT ANOTHER VEHICLE, OR GET HIT BY ANOTHER VEHICLE. I HAD NO IDEA WHY MY CAR WAS SO SUDDENLY OUT OF CONTROL. I ORIGINALLY THOUGHT I HAD BLOWN A FRONT WHEEL. THERE WAS NO PREVIOUS WARNING, SUCH AS A SHIMMY OR VIBRATION OR ANY STEERING ISSUES AT ALL. I ASKED THE TOW TRUCK TO TAKE ME TO THE TOYOTA DEALER WHICH WAS ABOUT 50 MILES AWAY. HOWEVER, HE CONVINCED ME THAT IT WAS SIMPLE TO REPLACE THE TIE ROD AND SINCE MY RAV4 WAS A 2008, AFTERMARKET PARTS WOULD BE EASY TO GET FROM NAPA. IT WAS A SUNDAY, SO I ENDED UP GETTING THE CAR DROPPED OFF AT GOODYEAR IN CEDAR CITY, SINCE I WOULD NEED AN ALIGNMENT AFTER THE NEW TIE ROD WAS PUT IN. ON MONDAY MORNING I FOUND OUT YOU CAN ONLY GET THE TIE ROD PART FROM THE DEALER AND THEY DID NOT HAVE ANY IN STOCK, SO HAD TO WAIT UNTIL WEDNESDAY TO GET IT FIXED. AFTER IT WAS FIXED, THEY WERE NOT ABLE TO DO AN EXACT ALIGNMENT AND SAID IT WAS OFF BY A MM. FYI - THERE WAS NO RUST ON THE BROKEN TIE ROD. *TR
Steering, Jul 23, 2012
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE STEERING WHEEL HAD BECOME STIFF AND HARD TO MANEUVER. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED AND ADVISED THE CONTACT NOT TO DRIVE UNTIL THE REPAIRS WERE COMPLETE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 25,500.
Steering, Apr 16, 2012
TL* THE CONTACT OWNS 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE POWER STEERING FAILED. THE CONTACT STOPPED THE VEHICLE AND THE VEHICLE WAS TOWED TO A DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE, BUT BELIEVED THAT THE FAILURE WAS DUE TO AN ELECTRICAL ISSUE. THE DEALER REPAIRED THE BATTERY AND VARIOUS OTHER ELECTRICAL COMPONENTS. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE 40,000.
Steering, Air bags, Jan 17, 2012
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT A COMPONENT IN THE STEERING WHEEL FAILED, AND CAUSED THE ILLUMINATION OF THE AIR BAG WARNING LIGHT. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 88,143 AND THE FAILURE MILEAGE WAS UNKNOWN.
Steering, Jan 12, 2012
CPSC#I1210211A. 2008 TOYOTA RAV4. CONSUMER STATED WHILE DRIVING ON INTERSTATE 93 ONE OF THE REAR TIE RODS FELL APART, CAUSING HIM TO SWERVE BACK AND FORTH ACROSS FOUR LANES. *LN THE CONSUMER STATED THE COST TO REPLACE THE TIE ROD WAS $500. THE MECHANIC INFORMED THE CONSUMER THE FAILURE WAS DUE TO WEAR AND TEAR.
Steering, Jan 10, 2012
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE REAR PASSENGER TIE ROD FAILED, CAUSING THE CONTACT TO LOOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER DIAGNOSED THAT THE TIE ROD SEPARATED FROM THE VEHICLE. BOTH REAR TIE RODS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED AND ASSISTED WITH REPAIRS TO THE FAILURE. THE FAILURE MILEAGE WAS 76,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 77,000. UPDATED 04/27/12*LJ THE CONSUMER STATED HE WAS REIMBURSED 1/4 OF THE PRICE AND WAS TOLD THE ISSUE WOULD NOT BE LOOK IN TO ANY FURTHER. UPDATED 04/27/12
Steering, Dec 17, 2011
THE STEERING STARTED FEELING LOOSE AND THERE IS A PRONOUNCED CLUNK ANY TIME YOU TURN THE WHEEL EITHER WHEN STOPPED OR MOVING. DEALER SAYS THE STEERING COLUMN IS WORN AND NEEDS TO BE REPLACED. DEALER CLAIMS IT'S NOT A SAFETY ISSUE, BUT I CAN NOT SEE HOW A STEERING ISSUE CAN NOT BE A SAFETY ISSUE. *TR
Steering, Dec 1, 2011
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 35 MPH AND TURNING THE STEERING WHEEL, THE CONTACT HEARD A THUMPING NOISE AND NOTICED A HESITATION IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIANS STATED THE INTERMEDIATE STEERING SHAFT HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.
Steering, Exterior lighting, Jan 4, 2011
NUMBER 1 -- I AM VERY HAPPY WITH MY RAV4. IT WAS A COLD EVENING AFTER DARK AND I LEFT WORK. THE BATTERY HAD FAILED. NOT A PROBLEM, I GOT A JUMP AND THE CAR STARTED. I LET IT SIT AND OBTAIN SOME CHARGE. WHAT WAS VERY UNUSUAL WERE THE NUMBER OF SYSTEMS THAT COULD FAIL WHENEVER A POWER SURGE WAS NEEDED, SAY FROM THE POWER STEERING, POWER BRAKES, ETC. THE POWER SURGE WOULD LEAD TO A LIGHTS OUT, OR LOSS OF STEERING, OR ENGINE TEMPORARILY STALLING, ETC. IT RECOVERED EACH TIME AFTER THE SURGE WAS OVER (GOOD NEWS). I AM REPORTING THIS BECAUSE IF THE BATTERY FAILURE HAD OCCURRED AT SPEED I COULD HAVE EASILY LOST CONTROL OF THE CAR. I VIEW MYSELF AS VERY LUCKY. THE BATTERY WAS THE ORIGINAL BATTERY SUPPLIED WITH THE CAR. I HAVE NOT YET RETURNED IT FOR RE-CYCLING. IT IT WOULD BE HELPFUL TO YOU FOR SAFETY STUDY REASONS I CAN MAKE IT AVAILABLE.
Steering, Suspension, May 7, 2010
2008 TOYOTA RAV 4 LIMITED HAS HAD HANDLING ISSUES ON THE FREEWAY WITH STABILITY. THIS HAS HAPPENED A COUPLE OF TIMES. DEALER SAYS THAT "NOTHING IS WRONG." PREVIOUS TIME THIS OCCURRED, VEHICLE RETURNED HANDLING DIFFERENTLY. CONSIDERING THE COMPUTER BRAIN RUNNING THIS CAR, WE BELIEVE THEY RESET THE COMPUTER. THIS IS HAPPENING AGAIN. WE ARE TAKING IT IN AGAIN. *TR
Steering, Service brakes, Hydraulic, Feb 22, 2010, crash
TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT WHEN TRYING TO STOP AT A STOP SIGN, THE BRAKE PEDAL WOULD NOT MOVE DOWN AS HE TRIED TO DEPRESS IT AND HE COULD NOT STEER THE VEHICLE. HE CONTINUED MOVING FORWARD UNTIL THE VEHICLE COLLIDED WITH A GUARDRAIL. THE CONTACT WAS SLIGHTLY INJURED AND A POLICE REPORT WAS TAKEN. HE CONTACTED THE DEALERSHIP AND WAS TOLD THAT NO ONE COULD INSPECT THE VEHICLE UNTIL IT WAS REPAIRED AT THE BODY SHOP. THE VEHICLE WAS AT THE BODY SHOP AT THE TIME OF THE COMPLAINT. THE CONTACT HAD NOT SPOKEN WITH THE MANUFACTURER TO-DATE. THE CURRENT AND FAILURE MILEAGES WERE 18,561.
Steering, Service brakes, Hydraulic, Feb 17, 2010, crash
I WAS DRIVING IN A SNOW STORM AT APPROXIMATELY 20MILES/HR.THE ROAD HAD NOT BEEN PLOWED RECENTLY, SO THERE WAS SOME SNOW THAT HAD ACCUMULATED, BUT IT WAS CERTAINLY PASSABLE AND I WAS DRIVING A 4 WHEEL,TOYOTA, RAV 4, 2008, IN EXCELLENT UPKEEP. ALL OF A SUDDEN THE CAR STARTED DRIFTING TO THE RIGHT, WHEN I TRIED TO SLOWLY CORRECT THE DIRECTION OF THE VEHICLE, THE STEERING WOULD NOT WORK. I COULD NOT MOVE THE WHEEL, THE BRAKSE DID NOT WORK, EVERYTHING IN THE CAR FROZE. I WAS HELPLESS AND HAD TO WATCH AS THE CAR SLOWLY DROVE ITSELF OFF THE SIDE OF THE ROAD INTO A DEEP DITCH. HALF WAY THROUGH THIS HARROWING TIME SPAN A BEEPING NOISE CAME ON(THE VEHICLE STABILITY CONTROL SYSTEM?), BUT ONLY AFTER THE CAR WAS INCAPACITATED FOR WHAT SEEMED LIKE MINUTES. I WAS ON A STRAIGHT AWAY AND THERE WERE NO HILLS AT THIS LOCATION. THE VEHICLE TRAVELED APPROXIMATELY 300+ FEET, AS EVIDENCED BY THE TRACK MARKS LEFT IN THE SNOW. LUCKILY THE DITCH WAS FILLED WITH SNOW, SO I DID NOT CRASH INTO A TREE OR ROLL OVER. THE SNOWPACK STOPPED THE CAR AND IT ENDED UP TILTED ON ITS RIGHT SIDE, BURIED ALMOST TO THE TOP OF THE PASSENGER WINDOW. WHEN I TRIED TO OPEN THE RIGHT WINDOW TO CRAWL OUT, IT WAS INOPERABLE. I WAS TOWED OUT OF THE DITCH AND BECAUSE OF THE SOFT SNOW COVER THERE WAS NO DAMAGE TO THE CAR. I HAVE ALSO HAD 1 OTHER STEERING PROBLEM WITH THE CAR WHEN IT DID NOT RESPOND AS EXPECTED(ALTHOUGH THE STEERING WHEEL WAS NOT FROZEN) AND I SUBSEQUENTLY SIDE SWIPED A CAR I WAS PASSING WHILE DRIVING IN A PARKING GARAGE. I AM AN EXCELLENT NEW ENGLAND DRIVER WITH A STELLAR DRIVING RECORD. THIS CAR HAS BEEN A DISASTER THE INFREQUENT TIMES I IT. IT USUALLY SITS IN THE GARAGE, SINCE I PREFER MY 109,000 MILE, RELIABLE, 2001, MERCURY MOUNTAINEER; AFTER EXPERIENCING THE FIRST STEERING EVENT WITH THE RAV4, WHICH I KNOW WAS NOT MY FAULT. I DROVE THE RAV 4 DURING THE SECOND INCIDENT BECAUSE I THOUGHT IT WOULD BE SAFER, BEING A NEW CAR! HA *TR
Steering, Feb 10, 2010
STEERING WANDERS - 2008 TOYOTA RAV4 WITH ELECTRONIC-ASSISTED. STEERING WANDERS SLIGHTLY FROM THE DAY IT WAS PURCHASED. *TR
Steering, Feb 1, 2010
DANGEROUS TORQUE STEER ON 2008 TOYOTA RAV4 4X4. HAS BEEN AN ISSUE SINCE VEHICLE WAS NEW. DEALER TWICE HAS TOLD ME IT IS NORMAL FOR THIS VEHICLE AND THE SIENNA IS EVEN WORSE. YOU CAN LOSE CONTROL OF VEHICLE WHILE ACCELERATING TO PASS. *TR