2011 Toyota RAV4
Problems, recalls and owner-reported issues
Vehicle speed control is the leading concern among 287 owner complaints filed for this model year. This is the 15th highest complaint count among 26 RAV4 model years with reports.
Of the 2011 reports, 44 involved a crash and 8 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Visibility/wiperSep 18, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.
Campaign 15V577000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Equipment, other, labelsApr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V123000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Air bags, side/windowFeb 1, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 RAV4 VEHICLES, MANUFACTURED FROM NOVEMBER 24, 2011, THROUGH DECEMBER 19, 2011. IN THE CURTAIN SHIELD AIRBAGS, PROPELLANT WITH THE INCORRECT SPECIFICATION WAS USED FOR THE INITIATOR ASSEMBLED IN THE AIRBAG INFLATOR. IN THIS CONDITION, THE INFLATOR MAY NOT PERFORM PROPERLY, CAUSING ONE OR BOTH CURTAIN SHIELD AIRBAGS TO NOT DEPLOY.
IN THE EVENT OF A CRASH, THE AIRBAGS MAY NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE VEHICLE IDENTIFICATION NUMBER TO IDENTIFY THE CURTAIN SHIELD ASSEMBLIES AND REPLACE THE ASSEMBLIES AS NECESSARY WITH NEW ONES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 8, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V029000 on NHTSA.gov
Representative owner complaints: engine
36 reports, newest first. Show all
Engine, Dec 4, 2024
A lot oil consumption from oil change to 1000 miles 4 quarts of oil consumption no warning light until car stops I’m been charging oil every 4 k miles now I have to check oil every day is been almost 4years with this problem
Electrical system, Engine, Sep 23, 2024, fire
I understand there is a recall on Rav4 starting fire from 2013. Our vehicle is a 2011 and started on fire in our driveway and is a total loss. May need to include other years.
Engine, Fuel/propulsion system, Jun 26, 2024
After pressing the accelerator pedal, I released the pressure on the pedal because of traffic and the accelerator continued to accelerate. had to hold the brake pedal down and then shifted to Park and shutoff engine. When restarted the car operate normally. This has happened in the past and is very scary and unsafe. My internet research on problem shows that there have been two problems associated with this occurrence. One, accelerator trapped by floor mats and the second was because the accelerator pedal could "stick". The floor mats are secured by manufacture securing systems so it must be the in the sticking pedal. I am contacting Toyota but not optimistic...is there anything the NHTA can do for Toyota at least checking my car for a sticking accelerator pedal sticking. Finally, has there been any other reports of this happening?
Engine, Vehicle speed control, Jan 23, 2024
The contact owns a 2011 Toyota Rav4. The contact stated while stopped at a red light with the brake pedal depressed, the vehicle accelerated and rolled forward. The contact quickly put the vehicle in park and was able to pull over down the road. The contact stated that while pulling over and then shifting from park to drive with the brake pedal depressed, the vehicle accelerated, and the contact quickly shifted back into park. There were no warning lights illuminated. The vehicle was left in front of an independent mechanic shop. The independent mechanic diagnosed that the canister purge valve needed to be replaced and the throttle body needed servicing. The vehicle was repaired. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 193,751.
Engine, Feb 25, 2022
The car had 115,000 miles on the engine and was just at 3,000 miles post oil change. Making a left turn over oncoming traffic the car died. Barely missed having an accident. As the car sat it did restart. No lights on the dash for engine issues. Drove 2 miles directly to my mechanic. The car had half a quart of oil remaining! Car now closely monitored burns 1/2 quart every 500 miles and more if highway driven.
Engine, Dec 15, 2021
Making a left hand turn across traffic and the car completely shut down. Restarted car. A mile later making a right turn and the car completely shut down. Took the car to my mechanic and they had it fail 3X while turning. Only 2000 miles since last oil change I had less than a quart of oil remaining. Oil burning / consumption put me and others at serious risk for a car accident.
Electrical system, Engine, Aug 6, 2020, crash
TL* THE CONTACT OWNED A 2011 TOYOTA RAV4. THE CONTACT STATED THAT THE TRACTION, ANTI LOCK BRAKING SYSTEM AND THE 4 WHEEL DRIVE WARNING LIGHTS WOULD INTERMITTENTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO GARY FORCE HONDA (2325 SCOTTSVILLE RD, BOWLING GREEN, KY 42104) WHERE SHE PURCHASED THE VEHICLE AND THEY DIAGNOSED THE VEHICLE WITH A DEFECTIVE TRACTION, ANTI-LOCK BRAKE AND 4 WHEEL DRIVE SENSORS. THE CONTACT WAS GIVEN AN ESTIMATE FOR THE REPAIRS BUT THE VEHICLE WAS NOT REPAIRED. ONE DAY WHILE DRIVING AROUND A CURVE AT 30 MPH, THE VEHICLE HYDROPLANED AND FLIPPED OVER, LANDING UPSIDE DOWN. THE SIDE AIR BAGS DEPLOYED UPON IMPACT; HOWEVER, THE DRIVER AND PASSENGER AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AT THE SCENE. THE CONTACT WAS TREATED AT THE SCENE FOR MINOR CUTS TO HER FACE. THE CONTACT WENT TO THE HOSPITAL THE NEXT DAY FOR CHECK UP, DESPITE BOTH THE CONTACT AND THE PASSENGER EXPERIENCING SORENESS DUE TO THE ACCIDENT, NO MAJOR INJURIES WERE REPORTED. THE VEHICLE WAS TOTALED AND TOWED TO AN INDEPENDENT JUNK YARD. THE MANUFACTURER NOR A TOYOTA DEALER HAD BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. *DT*LN*JB*JB
Engine, Feb 2, 2020
JUST PURCHASED 2011 RAV4 WITH 104K MILES AND SOON FOUND OUT IT HAS A BAD CAM GEAR! APPARENTLY THIS IS A KNOWN DEFECT FOR THIS YEAR! OF COURSE IT'S NOT UNDER WARRANTY AT THIS MILEAGE! SHOCKED LIKE EVERYONE ELSE TO FIND OUT THIS WASN'T RECALLED BY TOYOTA. THEY NEED TO STEP UP AND TAKE RESPONSIBILITY FOR THIS KNOWN FAULTY PART! NOT HAPPY WITH MY FIRST TOYOTA!
Engine, Aug 19, 2019
SEVERAL CARS HAVE HAD A CAMSHAFT TIMING GEAR ASSEMBLY PROBLEM SINCE DAY 1. SO MANY PEOPLE BACK 10 YEARS AGO HAD THE PROBLEM AND STORIES OF ENGINEERS BEING CALLED IN TO DIAGNOSE IT FILL THE NET. HOW DO WE NOW 11 YEARS IN KNOW THAT WHILE THE CAMSHAFT GEAR WAS IN NEED OF R/R THAT ENGINE DAMAGE OF ANY KIND DIDN'T OCCUR? T-SB-0041-13 HAS BEEN REVISED SO MANY TIMES IT IS RIDICULOUS THAT THIS HAS NOT BECOME A FULL FLEDGED RECALL.
Other or unspecified, Service brakes, Engine, Mar 15, 2019, crash
THE COMPLAINT SPECIFIED DOES NOT SEEM TO HAPPEN FREQUENTLY OR CONSISTENTLY, HAS HAPPENED RANDOMLY 2 TIMES IN A 6 WEEK PERIOD. SPECIFICALLY, CAR WAS ENGAGED IN THE DRIVE GEAR ON AUTO TRANSMISSION AND WAS STOPPED AT THE MOMENT, ONCE AT THE PARKING SPOT AT LOCAL WALMART, BROUGHT TO COMPLETE HALT WITH FOOT ON THE BRAKE, AND READY TO SHIFT LEVER TO PARK, BEFORE I COULD DO THAT, BRAKE WENT SOFT AND CAR MOVED/SURGED FORWARD, HITTING THE SAFETY POLE IN THE PARKING SPOT. THE SAFETY POLE SAVED FROM HEAD ON HITTING THE CAR ALREADY PARKED IN THE OPPOSITE PARKING SPOT. THE PICTURE OF THE FRONT OF THE CAR AGAINST THE SAFETY POST IS ATTACHED. ANOTHER TIME, WAS STOPPED WITH FOOT ON THE BRAKE, WAITING TO MERGE INTO TRAFFIC, AT THE LOCAL HYVEE STORE, SUDDENLY BRAKING WAS GONE, ENGINE SURGED WITHPOWER AND THE CAR JUMPED INTO THE MIDDLE OF INTERSECTION. FORTUNATELY I WAS ABLE TO AVOID THE COLLISION WITH OTHER CARS ON THE ROAD. BOTH TIMES THE CAR WAS AT STANDSTILL, IN DRIVE GEAR, FOOT ON THE BRAKE. IN FORTY OR MORE YEARS OF DRIVING I HAVE NEVER HAVE THIS HAPPENED BEFORE I DID FILE A CLAIM WITH STAE FARM, BECAUSE THERE WAS DAMAGE TO THE FRONT BUMPER. A PICTURE IS ATTACHED. I HAVE NOT YET DRIVEN THIS CAR, AFTER IT WAS REPAIRED BY THE BODY SHOP, DUE TO PROFOUND FEAR THAT THIS INCIDENCE CAN HAPPEN AGAIN. TOYOTA COMPANY SAYS THEY HAVE FOUND NOTHING WRONG, JUST LIKE THEY HAVE DENIED FOR SIMILAR ISSUES WITH THEIR OTHER CARS IN THE PAST. PLEASE HELP
Engine, Mar 3, 2019, fire
FIRE UNDER THE HOOD
Structure, Vehicle speed control, Service brakes, Engine, Feb 15, 2019, crash
WAITING AT STOP SIGN - CAR BEGAN ACCELERATING, ENGINE REVVING, RACING (AGAIN, WHILE AT A COMPLETE STOP). I BRAKED AND VEHICLE TOOK FULL CONTROL SEEMINGLY PULLING SIDEWAYS FIRST AND THEN LURCHING OUT ONTO THE ROADWAY CASING A DEVASTATING CRASH TOTALING MY CAR AND CAUSING THE OTHER PERSON'S VEHICLE EXTENSIVE DAMAGE. I COULD HAVE BEEN SERIOUSLY INJURED OR KILLED. IT'S THE SECOND TIME THIS HAPPENED. 1ST TIME PULLING INTO PARKING SPACE - ACCELERATED LURCHING FORWARD NO MATTER HOW MUCH I BRAKED STRIKING CURB AND POST - STALLED OUT, THANK GOODNESS. A CASE HAS BEEN OPENED WITH TOYOTA BUT I AM TOLD THEY'LL DENY ANYTHING WRONG EVEN THOUGH I HAVE 10 PAGES OF COMPLAINTS IN HAND OF PEOPLE WHO HAVE EXPERIENCED THIS SAME NIGHTMARE I DID. IT'S TIME FOR TOYOTA TO TAKE FULL RESPONSIBILITY AND DO SOMETHING IMMEDIATELY. A CLASS ACTION LAWSUIT SEEMS PRETTY OBVIOUS AT THIS POINT CONCERNING THIS DANGEROUS SAFETY ISSUE SINCE TOYOTA IS NOT TAKING RESPONSIBILITY BY ISSUING/SENDING OUT RECALLS ON THIS DANGEROUS MECHANICAL FAILURE WHICH NEXT TIME MAY CAUSE A DEATH.
Engine, Feb 1, 2019
TL* THE CONTACT OWNS A 2011 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE STARTED TO EXPERIENCE HIGH OIL CONSUMPTION, WHICH EVENTUALLY CAUSED THE SPARK PLUGS TO BURN OUT. THE VEHICLE WAS TAKEN TO TOYOTA CARLSBAD (6020 AVENIDA ENCINAS, CARLSBAD, CA 92011) WHERE THEY TESTED THE OIL CONSUMPTION. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS AND WERE UNABLE TO PROVIDE ANY FURTHER ASSISTANCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 107,000. *BF CONSUMER STATED TOYOTA HAS DIAGNOSED YHIS VEHICLE AS HAVING AN OIL CONSUMPTION ISSUE. IT FAILED THE TEST 1/23/19 ON THE 3RD TESTING USING 1 QUART OF OIL FOR 598 MILES. AT 107,000 MILES I TOOK THE VEHICLE IN FOR OIL CONSUMPTON. THEY TOLD ME I HAD EXTENDED WARRANTY SO THEY EXAMINED THE CAR. LATER I WAS TOLD THAT I WAS TOLD INCORRECT INFO. CONSUMER TOOK THE VEHICLE IN A THIRD TIME. BOTH VISITS I WAS TOLD THE CAR PASSED THE OIL CONSUMPTION TEST PROBLEM IS GETTING WORSE.*JB
Other or unspecified, Engine, Jan 30, 2019
I WAS STOPPED AT A RED LIGHT WITH THE BRAKE FULLY ENGAGED WHEN RUNAWAY ACCELERATION TRIED TO TAKE OVER THE VEHICLE AND MAKE IT INCH FORWARD INTO ONCOMING TRAFFIC ON HWY 90. DUE TO MY QUICK ACTIONS OF CONTINUING TO PRESS BRAKE, I PUT VEHICLE IN NEUTRAL THEN PARK, THEN I SHUT OFF THE ENGINE AND TURNED ON FLASHERS. A POLICEMAN IMMEDIATELY DROVE ONTO HIGHWAY AND STOPPED TRAFFIC IN ORDER TO ESCORT ME TO MY CHURCH PARKING LOT ABOUT A BLOCK AWAY. WE THEN TOOK IT TO A RELATIVES HOME NEARBY. IT COULD BE THE ELECTRONIC THROTTLE, THROTTLE POSITION ON PEDAL, THROTTLE BODY MOTOR, COMPUTER PROGRAMMING ISSUE ETC.
Engine, Fuel/propulsion system, Aug 22, 2018
VVTI GEAR..WHEN THE VEHICLE IS FIRST STARTED THE ENGINE MAKES A LOUD RATTLING NOISE AS IF THERE IS NO OIL GETTING TO THE PISTONS
Engine, May 11, 2018
CAR IS 7 YEARS OLD WITH 123,000 MILES. RECENTLY STARTED BURNING OIL EXCESSIVELY. MY CAR IS NOT COVERED UNDER THE TOYOTA TSB RELATED TO THIS ISSUE. HAD IT TESTED AT TOYOTA DEALER & IT FAILED. LITERALLY RAN OUT OF OIL & DIDN'T KNOW IT; CAR JUST STOPPED IN TRAFFIC. TOYOTA REFUSES TO DO ANYTHING FOR ME.
Engine, Feb 6, 2018
EXCESSIVE OIL CONSUMPTION. AT LEAST ONE QUART OF OIL NEEDS BE ADDED EVERY 600 MILES. PROBLEM STARTED AT APPROXIMATELY 80,000 MILES. OIL SLUDGE BUILT UP IN A VALVE WHICH CAUSED THE VEHICLE TO STALL UNEXPECTEDLY.
Electronic stability control (ESC), Engine, Jan 23, 2018
RAV4 -CEL, 4WD, TRAC OFF ALL THREE LIGHTS CAME ON. I HAD THEM READ 4 TIMES BY 3 DIFFERENT MECHANICS. EACH TIME I WAS TOLD REAR OXYGEN SENSOR NEEDS TO BE REPLACED. I HAD THE SENSOR REPLACED TWICE IN LESS THAN 2 WEEKS TO CONFIRM IT WASN'T A FAULTY SENSOR. THE ALL 3 LIGHTS CAME BACK ON IN LESS THAN 24 HOURS. FYI: THE OTHER SENSOR WAS REPLACED AS WELL.
Engine, Jun 15, 2016
I HAVE A DEFECTIVE VVT-I GEAR ON MY 2011 RAV4. UPON RESEARCHING THE DIAGNOSIS FROM MY LOCAL TOYOTA DEALER (DAVID MAUS TOYOTA), I DISCOVERED THAT TOYOTA HAS KNOWN ABOUT THIS ENGINEERING FLAW SINCE 2010 AND HAD PUT OUT A TECHNICAL SERVICE BULLETIN (T-SB-0146-10) SO THAT DEALERSHIPS WOULD KNOW HOW TO REPLACE THE DEFECTIVE PART. MY VEHICLE'S VIN # IS SPECIFICALLY LISTED ON THIS TSB AS AN EFFECTED VEHICLE. ALSO, THERE ARE MANY OF FORUMS, ONLINE, OF PEOPLE HAVING THE SAME PROBLEM AND TOYOTA IS REFUSING TO REPLACE THESE PARTS FOR OWNERS. THIS IS NOT A WEARABLE PART. IT SHOULD NEVER HAVE TO BE REPLACED AND IT IS A VERY EXPENSIVE REPAIR (APPROX. $2,000) WITH NO DISCOUNTS. I SHOULD MENTION THAT I HAVE BEEN DILLIGENT WITH MY CAR'S MAINTENANCE AND CAN PULL MOST (IF NOT ALL) OF MY OIL CHANGES, IF NECESSARY. APPARENTLY, THE SAME ISSUE WAS DISCOVERED WITH CERTAIN LEXUS MODELS, BACK THEN, AND THEY DID A RECALL FOR THOSE VEHICLES BUT NOT THE TOYOTA MODELS (CAMRYS, HIGHLANDERS, RAV4S, SIENNAS, AND VENZAS WERE ALL AFFECTED FROM THIS PARTICULAR FACTORY FROM THE YEARS OF 2009-2011). I FILED A CASE WITH TOYOTA'S CORPORATE OFFICE (CASE # 1606011778) AND THEY OFFERED A $400 REFUND AFTER I PAID FOR THE REPAIR. THIS IS JUST NOT ACCEPTABLE, IN MY VIEW. YES, THE VEHICLE IS OUT OF WARRANTY, BUT THIS IS NOT A WARRANTY ISSUE. THIS SHOULD HAVE BEEN A RECALL BACK IN 2010 WHEN THEY DISCOVERED IT AND DITRIBUTED THE TSB. I OFFERED TO PAY FOR THE PART (AT TOYOTA'S COST) IF THEY COVERED THE LABOR (THAT IS THE MOST EXPENSIVE COST TO THE REPAIR), BUT THEY WOULD NOT BUDGE. IT IS A TIME SENSITIVE ISSUE, AS WELL, BECAUSE I AM A SINGLE MOTHER. THIS IS MY ONLY VEHICLE AND OPERATING THE VEHICLE WITH A MALFUNTIONING VVT-I GEAR IS CAUSING DAMAGE TO THE ENGINE. I AM ATTACHING THE TSB WITH THE LISTED AFFECTED VIN #S.
Vehicle speed control, Engine, Apr 26, 2016
TL* THE CONTACT OWNS A 2011 TOYOTA RAV4. WHEN THE CONTACT DEPRESSED THE BRAKE PEDAL, THE ENGINE ROARED AND THE VEHICLE ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO REPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL; THEREFORE, THEY DECLINED TO HELP UNLESS THE DEALER REPLICATED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.
Vehicle speed control, Engine, Jan 27, 2016
WHEN BRAKING, SUDDEN ACCELERATION OCCURRED- SEEMS TO RESET BY LETTING UP ON BRAKE AND REAPPLYING. HAS HAPPENED ON VARIOUS LOCATIONS AND TYPES OF ROADS. WHILE OUT OF STATE DEALERSHIP REPLACE PURGE VALVE- SEEMED OK, BUT THEN ON 1/25/16 WAS BACKING OUT OF DRIVEWAY HAD FOOT ON BRAKE AND FELT ENGINE RACING, PUT INTO PARK WITH RACING ENGINE, TURNED KEY OFF RESTARTED AND SEEMED OK HAD GARAGE CHECK COULD NOT FIND ANYTHING NO CODES SHOWING CURRENTLY BACK AT DEALERSHIP TO PUT ON THEIR COMPUTER. THIS IS AN ON-GOING ISSUE FOR SEVERAL MONTHS, BUT DOES NOT HAPPEN ON ANY REGULAR BASIS SO IT HAS NOT BEEN IDENTIFIED BY ANY GARAGE YET. PLEASE HELP
Vehicle speed control, Engine, Oct 11, 2015
FOUR UNINTENDED ACCELERATION INCIDENTS HAS OCCURRED WITH MY TOYOTA RAV4. RECENT INCIDENTS ON 9/1415 (COLLEGE PARK, MD WHEN BRAKE APPLIED AT A RED LIGHT WITH VEHICLE AHEAD; PASSENGER/WITNESS IN CAR). HIGH RPM AND ENGINE REV OCCURRED; BOTH FEET ON BRAKE IN ATTEMPT TO KEEP CAR FROM ADVANCING; PUT CAR IN NEUTRAL AND THEN PARK AND ENGINE STOPPED REVVING. AND ON 10/5/15 (DAMASCUS, MD WHEN BRAKE APPLIED AT STOP SIGN WITH VEHICLE AHEAD). BOTH FEET ON BRAKE, CAR TO NEUTRAL THEN TO PARK. ACTIONS DID NOT STOP ENGINE RPS. TURNED KEY TO TURN OFF VEHICLE. RUBBER MAT (ON TOP OF TOYOTA CARPET MATS) WAS REMOVED BEFORE LEAVING THE TOYOTA SERVICE CENTER ON 9/15/15. PROVING ON 10-5-15 THAT THE UNINTENDED ACCELERATION PROBLEM IS NOT A RESULT OF FLOOR MATS WHICH TOYOTA WOULD LIKE EVERYONE TO BELIEVE. VEHICLE WILL BE TAKEN TO DARCAR FREDERICK MD TO FILED SECOND INCIDENT REPORT ON MONDAY, 10/12/15 (DELAY BECAUSE I LEFT ON TRAVEL 10/5/15). INTENT WILL BE TO DETERMINE TRADE-IN VALUE OF CAR AND MOST LIKELY PURCHASE ANOTHER VEHICLE. IT'S TIME THAT TOYOTA RECOGNIZE UNINTENDED ACCCELERATION PROBLEMS WITH THEIR RAV4S.
Electrical system, Engine, Jul 15, 2015
ABOUT A YEAR AGO, I PACKED MY CAR TO GO ON VACATION. I PUT THE DOG IN THE CAR AND RETURNED TO MY HOUSE TO GET SOMETHING. WHEN I RETURNED TO THE CAR, IT WAS LOCKED. I ASSUMED I HAD INADVERTENTLY PUSHED THE LOCK BUTTON ON THE REMOTE SO IGNORED IT. OVER THE LAST 6 MONTHS, THIS HAS HAPPENED MORE FREQUENTLY. ON JULY 6, 2015, MY MOTHER AND I WENT TO WALMART. I WENT IN AND SHE STAYED IN THE CAR. WHEN I RETURNED THE DOOR WAS LOCKED AND SHE COULD NOT OPEN IT WITH THE POWER DOOR LOCK ON THE DOOR, SO I HAD TO USE MY REMOTE. TODAY, I WAS TAKING THINGS OUT OF THE REAR COMPARTMENT AND THE KEYS WERE HANGING IN THE DOOR TO THE HOUSE. I HEARD THE CAR DOOR LOCK ITSELF. I TOOK IT TO THE DEALERSHIP AND WE COULD OPEN THE DOOR AND WATCH IT LOCK ITSELF IN LESS THAN ONE MINUTE OF BEING OPENED. DURING THAT TIME, THE INSIDE ELECTRONIC DOOR LOCKS WOULD NOT WORK TO OPEN THE DOOR, IT WOULD ONLY OPEN WITH THE REMOTE OR THE MANUAL DOOR LOCK. THE DEALERSHIP WANTS ME TO BRING THE CAR IN FOR INSPECTION TOMORROW, BUT TOYOTA CORPORATE WILL NOT ASSURE ME THAT I WON'T HAVE TO PAY FOR THE DIAGNOSIS OF THIS PROBLEM. I FEEL THIS IS A SAFETY FEATURE OF THE RAV4 AND THEY SHOULD BE WILLING TO DIAGNOSE THIS FOR FREE. IF THEY DON'T, I WILL NOT TAKE THE CAR IN. I TOLD THEM I AM VERY CONCERNED THAT THIS MAY HAPPEN TO SOMEONE ELSE AND COULD INVOLVE CHILDREN GETTING LOCKED IN A CAR WITHOUT THE ABILITY TO UNLOCK THE DOOR (IF THEY DON'T KNOW HOW TO USE THE MANUAL LOCK). ...UPDATED 09/11/15 *BF UPDATED 10/13/15*JS
Service brakes, Engine, Apr 30, 2015
ON 4/22/2015, I HAD BEEN DRIVING MY 2011 TOYOTA RAV4 LIMITED EDITION AT HIGHWAY SPEED FOR ABOUT 2 HOURS. AFTER LEAVING THE INTERSTATE I WAS BRAKING AND COMPLETING A COUNTERCLOCKWISE U-TURN GOING ABOUT 10 MPH WHEN THE ENGINE BEGAN TO RACE UNCONTROLLABLY. BASED ON MY PREVIOUS EXPERIENCE WITH THIS PROBLEM (THIS IS THE FOURTH TIME THIS HAS OCCURRED) I THREW THE SHIFTER INTO PARK WHILE CONTINUING TO BRAKE. THIS QUICKLY BROUGHT THE ENGINE SPEED DOWN TO IDLE. I HAD MY WIFE CONFIRM THAT I HAD MY RIGHT FOOT ON THE BRAKE PEDAL ONLY. THERE WAS NO ?PEDAL MISAPPLICATION.? THE FLOOR MATS WERE SECURELY IN PLACE AND THERE WERE NO LOOSE OBJECTS ON THE FLOOR. THE ROAD WAS DRY AND THE TEMPERATURE WAS PROBABLY IN THE 50S. THE ODOMETER WAS ABOUT 51,000 MILES. THIS WAS THE FIRST RECURRENCE OF THIS PROBLEM SINCE 12/26/2014. I BROUGHT THE CAR TO MY TOYOTA DEALER. THEY COULD NOT IDENTIFY THE PROBLEM AND SAID THEY WOULD CHARGE ME IF I BROUGHT THE CAR IN AGAIN FOR A RECURRENCE OF THE PROBLEM. *TR
Electrical system, Service brakes, Engine, Feb 6, 2015
I WAS DRIVING DOWN SUBURBAN ROAD AT APPROX 20-25 MPH BEFORE ATTEMPTING TO COME TO A COMPLETE STOP AT A RED LIGHT. THE BRAKES LOST POWER AND ENGINE QUICKLY REDLINED TO 6000 RPM. IT WAS ONLY BY IMMEDIATELY SHIFTING INTO NEUTRAL THAT I AVOIDED RUNNING A REDLIGHT AND PLOWING THROUGH AN INTERSECTION. I PLACED IN PARK AND SHUT OFF ENGINE WITHIN 3-5 SECONDS TO AVOID ENGINE DAMAGE. I WAITED ABOUT 10-15 SECONDS STUCK AT A RED LIGHT BEFORE RESTARTING ENGINE AND LIMPING IT BACK HOME LESS THAN HALF A MILE AWAY. *JS