2015 Toyota RAV4
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 304 owner complaints filed for this model year. This is the 14th highest complaint count among 26 RAV4 model years with reports.
Of the 2015 reports, 37 involved a crash and 41 involved a fire. 30 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, 12v/24v/48v batteryNov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
A battery short circuit increases the risk of a fire.
Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Campaign 23V734000 on NHTSA.gov
Steering, electric power assist systemMar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
An unexpected loss of power steering increases the risk of a crash.
Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 15V144000 on NHTSA.gov
Trailer hitchesJan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Campaign 15V011000 on NHTSA.gov
EquipmentDec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Campaign 14V828000 on NHTSA.gov
Representative owner complaints
304 reports, newest first.
Engine, Mar 9, 2021, fire
I WAS DRIVING WITH MY 2 SONS FROM JFK AIRPORT TO WOODSIDE, QUEENS IN NEW YORK. WE JUST GOT OFF THE VAN WYKE HIGHWAY AND WERE TRAVELING WEST ON QUEENS BOULEVARD. THE SPEED LIMIT ON QUEENS BOULEVARD IS 25. WE WERE APPROACHING A RED LIGHT WHEN WE NOTICED SMOKE COMING FROM THE UNDER THE HOOD. I PULLED OVER AND TURNED OFF THE CAR, WHEN WE GOT OUT OF THE CAR WE NOTICED THERE WERE FLAMES STARTING TO COME OUT FROM UNDER THE HOOD. WE IMMEDIATELY GRABBED OUR ITEMS, PURSE, PHONE, COATS AND GOT AWAY SAFELY FROM THE CAR. WE CALLED 911 AND WITHIN A FEW MINUTES THE FIRE DEPARTMENT ARRIVED AND PUT OUT THE CAR. THE WHOLE FRONT OF OUR CAR AND DASH WERE BURNED AS WELL AS PART OF THE DRIVERS SEAT. OUR INSURANCE STATED THE CAR WAS TOTALED. OUR CAR WAS INSPECTED IN DECEMBER AND HAD LESS THAN 5,000 MILES. WE PURCHASED THE CAR NEW FROM TOYOTA IN 2015 AND HAD IT SERVICED BY THE DEALER EVERY 6 MONTHS. THE FIRE DEPARTMENT SAID LEAVES HAD CAUGHT FIRE, BUT IT HAD RAINED THAT DAY AND THE ENGINE SHOULD NOT GET HOT ENOUGH TO LIGHT LEAVES ON FIRE. AN ENGINE FIRE ON A 2015 CAR WITH LESS THAN 5000 MILES SHOULD NOT HAPPEN.
Structure, Mar 6, 2021
OUR MOON ROOF HAS COME LOOSE FROM ROOF ON TWO OCASIONS. DEALERSHIP HAS REPAIRED TWICE AT NO CHARGE TO US, BUT NO EXPLANATION AS TO WHY THIS IS HAPPENING. THE FIRST INDICATION BOTH TIMES WAS A RATTLE THAT SLOWLY BECOMES WORSE.
Steering, Electrical system, Engine, Mar 3, 2021
CAR RANDOMLY SHUT OFF ON MONDAY OF THIS YEAR.ALSO THE RADIO IS DEFECTIVE AND CAR TRY'S TO SWITCH GEARS WHILE DRIVING
Electrical system, Mar 2, 2021, fire
THE CAR WAS RUNNING ON THE STREET IN THE CITY WHEN IT SUDDENLY STOPPED, FIRE AND SMOKE ROSE FROM THE BATTERY'S SIDE. AFTER EXTINGUISHING THE FIRE, THE VEHICLE COULD NOT MOVE, AND HAD TO CALL THE TOW TRUCK TO THE REPAIR SHOP. I HAVE WITNESSES.
Steering, Electrical system, Feb 10, 2021
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CANNOT GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR A FEW DAYS, HAPPENS AGAIN, ENGINE RESTARTS AGAIN RANDOMLY WHILE MAKING A RIGHT TURN, SAME EXACT DESCRIPTION AS DESCRIBED PREVIOUSLY. MULTIPLE DATES OF OCCURENCE
Structure, Feb 8, 2021
THE PAINT ON THE PANEL ABOVE THE CAR HAS BEGAN TO BUBBLE UP AND TEAR OFF. THE PAINT CONTINUES TO COME OFF. THE PAINT BEGAN COMING OFF IN A CHUNK THAT WAS ABOUT 2' BY 3'.
Steering, Electrical system, Engine, Jan 24, 2021
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CAN'T GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR 2 DAYS AND ON THE 3RD DAY, ENGINE RESTARTS AGAIN RANDOMLY WHILE MAKING A RIGHT TURN, SAME EXACT DESCRIPTION AS DESCRIBED PREVIOUSLY. DRIVEN CAR FOR A DAY AND INCIDENT HASN'T REPEATED YET. BUT, NOW NOT SURE IF THIS AFFECTED IT, SENSORS OF CAR DOOR OPEN SIGN IS ON WHEN CAR IS TURNED OFF AND ALL DOORS AND WINDOWS ARE IN PLACE FOR LOCKING. ONLY WHEN CAR IS OFF AND I CANNOT FIX IT.
Electrical system, Air bags, Structure, Jan 10, 2021, crash
I WAS ENTERING TRAFFIC FROM A STOP SIGN AND COLLIDED WITH A BLACK CAR AT NIGHT THAT DID NOT HAVE IT'S HEADLIGHTS ON. THEIR AIR BAG DEPLOYED, - MINE DID NOT. CITY OF RALEIGH, NC. STREETS.
Electrical system, Structure, Jan 10, 2021, crash
I WAS ENTERING TRAFFIC FROM A STOP SIGN AND COLLIDED WITH A BLACK CAR AT NIGHT TIME THAT DID NO HAVE IT'S HEADLIGHTS ON. CITY OF RALEIGH, NC. STREETS.
Structure, Dec 2, 2020
THE POWER LIFTGATE OF THIS MODEL FAILS TO OPEN IN COLD WEATHER. DIFFICULT TO OPEN AND CLOSE WHEN UTILIZING THE MANUAL OVER-RIDE BUTTON.
Structure, Nov 12, 2020
LIFT GATE STRUT IS CAUSING MISALIGNMENT OF THE LIFT GATE, SO LIFT GATE SHIFTING AND UNABLE TO OPEN.
Electrical system, Exterior lighting, Nov 10, 2020
THE DOM LIGHTS FUSE KEEPS BLOWING. IT APPEARS TO HAVE A SHORT BUT SOME TIMES THE FUSE TAKES A LITTLE TIME TO BLOW. YESTERDAY I TRIED TO REPLACE THE FUSE THREE TIMES, AND THREE FUSES WERE BLOWN IMMEDIATELY.
Steering, Sep 29, 2020
I WENT TO START MY CAR AND THE ELECTRIC POWER STEERING WARNING LIGHT WAS ON AND THE CAR WOULD NOT START. TOWED TO SHOP AND THEY CAN FIND NOTHING WRONG AND IT STARTS RIGHT UP. CONCERNED THE POWER STEERING WILL GO OUT WHILE I AM DRIVING.
Other or unspecified, Sep 24, 2020
MY CAR HAS 123,000 MILES I TAKE GREAT CARE OF IT I JUST HAD TO PUT A GEAR SHIFT ASSEMBLY IN TO THE TUNE OF 1100.00. MY TIRES WERE NOT RIDING WELL AND HE FOUND IT
Power train, Other or unspecified, Service brakes, Sep 4, 2020, crash
PULLING INTO PARKING SPACE THE ENGINE STARTED TO REV. PUT CAR IN REVERSE AND CAR WAS PUT IN HISH SPEED REVERSE CAUSING CAR TO HIT ANOTHER VEHICLE.
Service brakes, Aug 26, 2020
2015 RAV4 WITH LESS THAN 8,000 MILES. ON I-5 FREEWAY AT ABOUT 70MPH TRAFFIC SLOWED, I APPLIED BRAKES AND A RAPID THUMPING SOUND CAME ON FOLLOWED BY A SHAKING THAT SEEMED TO BE FROM FRONT LEFT OF CAR. WAS ON A THOUSAND MILE FAMILY EMERGENCY TRIP. WHENEVER I APPLIED BRAKES AT FREEWAY SPEED THE SAME THING HAPPENED. MY INDEPENDENT MECHANIC BY PHONE SAID IT MIGHT BE WARPED DISC.
Other or unspecified, Jul 10, 2020
REAR HATCH STRUT SEIZED AND BROKE CAUSING REAR HATCH DOOR TO NOT CLOSE COMPLETELY, REMOTE AND DOOR RELEASE IN CAR INOPERABLE. I HAD MY CAR SERVICED AND ADVISOR EXPLAINED THAT WATER (FROM WEATHER) CAUSED RUST AND LEFT STRUT BROKE. THE RIGHT STRUT IS CORRODED BADLY AND RECOMMENDED TO REPLACE AS WELL. TOTAL COST WOULD BE 1386.00 INCLUDED LEFT STRUT PART (427.00), RIGHT STRUT PART (739.00) AND ABOUT 200.00 IN LABOR. I CALLED TOYOTA CORPORATE FOR COMPLAINS AND THEY SAID THAT THERE WAS NO RECALLS AND THEIR WARRANTY WAS 3YR/3000 MILES WHICH DID NOT APPLY TO MY SITUATION. I CALLED MULTIPLE TOYOTA PARTS DEPTS, SOME OUT OF STATE TO COMPARE PRICES AND THEY REMAINED THE SAME. ONE PARTS EMPLOYEE INFORMED ME THAT THIS PART I NEEDED TO PROVIDE MY VIN NUMBER BECAUSE THESE STRUTS SUPPLY IS SPARSE AND THEY NEEDED TO SUPPLY LOCAL CUSTOMERS. I ASKED WHY THERE WASN'T A RECALL AND HE AGREED THAT THERE SHOULD BE ONE. AGREED THAT THE DESIGN IS POOR AND EXPECTATION TO LUBRICATE JOINTS TO PREVENT WATER DAMAGE ( WHICH WAS NOT IN ANY OF MY MAINTENANCE MANUELS.). I HAVE THE EXTENDED WARRANTY WHEN I PURCHASED MY NEW RAV4 AND ADVISOR CALLED AND PRESENTED PICTURES, THE CLAIM WAS DENIED.
Steering, Electrical system, Jun 25, 2020
I WAS EXITING A HIGHWAY ON A CURVE (EST. 40MPH) WHEN MY POWER STEERING FAILED INSTANTLY JERKING THE STEERING WHEEL TO THE RIGHT CREATING A SAFETY HAZARD. AT THE SAME TIME ALL OF MY DASHBOARD LIGHTS FLASHED ON AND OFF. I HAVE A TOYOTA RAV4 2015. THERE HAVE BEEN A RECALL FOR THIS DESCRIPTION BUT NOT ON MY VIN. *TR
Vehicle speed control, Service brakes, Jun 12, 2020, crash
SUA INCIDENT - COASTING BEFORE ENTERING GARAGE AS USUAL WITH MY RIGHT FOOT ON FLOOR AND NOT ENGAGED WITH ACCELERATOR OR BRAKE. UPON ENTERING THE GARAGE CAR BEGAN TO ACCELERATE, NATURALLY SHOCKING/BAFFLING ME, AS I HAD ALREADY STARTED BRAKING AND CONTINUED TO DO THAT TO NO AVAIL AS CAR PROCEEDED TO HIT BACK WALL OF THE GARAGE WHERE ACCELERATION STOPPED,CAR CAME TO REST. I NEVER DRIVE WITH TWO FEET AND AM ABSOLUTELY CERTAIN MY FOOT WAS ON THE BRAKE AND BRAKE WAS NOT RESPONDING. ALSO CAR DID NOT ACCELERATE WITH THE SAME SOUND AS IT NORMALLY WOULD IF I PRESSED THE GAS PEDDLE. IT ACCELERATED MORE LIKE IT WAS ON CRUISE CONTROL...VERY SMOOTH AND STEADY. ACTUALLY I'M GRATEFUL THE WALL WASN'T FAR AWAY SO IT DIDN'T ACCELERATE FURTHER. THE INCIDENT HAPPENED JUNE 11,2020 AT AROUND 10 AM. DO NOT KNOW REASON FOR SUA, BUT WILL NOTE THAT WE HAD THE GARAGE DOOR SENSORS REPOSITIONED ON JUNE 10. I'M NOTING THAT BECAUSE WHERE THEY ARE IS ABOUT WHEN I FELT ACCELERATION STARTING. *TR
Vehicle speed control, Jun 9, 2020, crash
WHILE SLOWLY PULLING INTO OWNERS GARAGE, VEHICLE SUDDENLY ACCELERATED WITH HIGH WHINING SOUND. VEHICLE CRASHED INTO GARAGE WALL AT HIGH RATE OF SPEED. FRONT END COMPLETELY DESTROYED, DOORS DO NOT OPEN, RADIATOR LEAKING AND GARAGE CABINET DESTROYED. INSURANCE COMPANY NOTIFIED. AIR BAG DID NOT DEPLOY. VEHICLE HAS 31,300 MILES. *TR
Electrical system, Other or unspecified, Electronic stability control (ESC), May 7, 2020
NUMEROUS TIMES OVER THE LAST COUPLE OF MONTHS MY CARS EPS LIGHT WILL COME ON AFTER PUTTING MY CAR INTO REVERSE THE CAR DOES NOT CONNECT AND GOES INTO NEUTRAL INSTEAD CAUSING THE CAR TO ROLL FORWARD CREATING HAZARDS BECAUSE IT HAPPENS ON HILLS AND FLAT AREAS. I THEN HAVE TO PUT MY CAR INTO PARK, TURN IT OFF AND RESTART THE CAR TO GET THE CAR TO GO INTO THE CORRECT GEAR. I HAVE TAKEN THE CAR TO TOYOTA BUT THEY WON?T DO ANYTHING BECAUSE MY VIN IS NOT UNDER RECALL. STARTING IN 2019 I STARTED NOTICING FLAKES OF PAINT IN CRACKS OF DOORWAYS AND CREASES OF THE CAR. LAST MONTH A BIG PIECE OF PAINT STARTED COMING OFF THE TOP OF MY CAR IN FRONT OF MY SUNROOF. *TR
Steering, Apr 27, 2020
WHILE DRIVING ON CITY STREETS AND MAKING A TURN AT APPROXIMATELY 20-25 MPH, THE VEHICLE'S ELECTRIC POWER STEERING CUT OUT WITHOUT ANY WARNING. THE STEERING BECAME EXTREMELY HEAVY WITH NO ASSIST. THE RED STEERING WHEEL ICON LITE UP. THIS IS THE SECOND TIME THAT THIS INCIDENT HAS OCCURRED AND LUCKILY I DID NOT HAVE MY FAMILY IN THE VEHICLE.
Fuel/propulsion system, Apr 21, 2020
CAR WILL NOT START ON 1ST TRY. IT MAY START 2ND OR 3RD TIME WHILE HOLDING GAS PEDDLE TO THE FLOOR. LOUD POPPING SOUND FROM UNDERNEATH THE CAR. SOUNDS LIKE CHANGING GEARS ON A MANUAL. CAR HAS LESS THAN 50K MILES
Power train, Apr 13, 2020
TL* THE CONTACT OWNS A 2015 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO TOYOTA OF SOMERSET (4195 S HWY 27, SOMERSET, KY 42501) AND GAMBREL TOYOTA(311 W CUMBERLAND GAP PKWY, CORBIN, KY 40701), HOWEVER, THE MECHANICS WERE UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 23,000.
Electrical system, Other or unspecified, Engine, Mar 3, 2020, fire
SHORTLY AFTER DRIVING WITH NO ISSUES, THE PARKED CAR STARTED TO SMOKE FROM UNDERNEATH THE HOOD. WITHIN SECONDS, A LARGE FIRE HAD STARTED WHICH COMPLETELY CONSUMED THE CAR AND ALSO SPREAD TO MY WIFE'S CAR AND THE HOUSE'S CARPORT. INSURANCE INVESTIGATOR INFORMED US THAT THE FIRE LIKELY STARTED IN/NEAR THE ENGINE TOWARDS THE DRIVERS SIDE BASED ON WHERE THE HOTTEST PARTS OF THE FIRE APPEARED TO HAVE BEEN. HOWEVER, NO CONCLUSIVE DETERMINATION WAS MADE REGARDING THE CAUSE. THE CAR WAS IN GOOD CONDITION AND HAD NOT HAD ANY MAINTENANCE WORK PERFORMED ON IT RECENTLY. THERE WERE ALSO NO SIGNS OF INTRUSION BY RODENTS OR OTHER ANIMALS. THIS HAPPENED WITH NO WARNING. I'VE ALSO SINCE LEARNED THIS HAD HAPPENED ONLY ONE MONTH BEFORE TO THE PARENTS OF ONE OF OUR CHILDRENS' FRIENDS. THEY ALSO HAD A RAV4, ALTHOUGH NOT THE SAME MODEL YEAR (I BELIEVE IT WAS A 2013). I HAVE ALSO SEEN MANY OTHER REPORTS WHILE RESEARCHING THIS ISSUE. IF THERE IS A DEFECT OR DESIGN FLAW CONTRIBUTING TO THESE FIRES, IT SHOULD BE ADDRESSED QUICKLY!