2016 Toyota RAV4
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 239 owner complaints filed for this model year. This is the 18th highest complaint count among 26 RAV4 model years with reports.
Of the 2016 reports, 33 involved a crash and 12 involved a fire. 27 people were injured.
What owners report most often
Recalls and investigations
Electrical system, 12v/24v/48v batteryNov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
A battery short circuit increases the risk of a fire.
Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Campaign 23V734000 on NHTSA.gov
TiresApr 22, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Campaign 16V236000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipApr 7, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Campaign 16V198000 on NHTSA.gov
Representative owner complaints: electrical system
58 reports, newest first. Show all
Electrical system, Structure, Lane departure, Sep 3, 2026, fire
I was driving 9/3 and my left blinker light came on solid. I was not using my blinker. Within a few seconds my check engine light came on and another light. Then within 2 minutes the front left engine/tire caught fire.
Electrical system, Aug 14, 2026
The repair shop I was able to pull into as I was experiencing the issue with my vehicle reported: "Battery is unstable and is arcing off of the positive terminal. Battery tray, battery hold down tie, and battery j hook hold down were missing upon arrival." The issue was fixed by a Brakes Plus location, given I was able to pull in there - it was around the corner from where I was driving. The issue has been fixed, and I have no issue with inspection of the vehilce. The car died while I was driving on a main street. The recall note states that the vehicle could have caught on fire, though no fire or crash happened. I made a simple right-hand turn and almost every light imaginable illuminated on the dashbard. I was able to turn the vehicle off and on again and get the car to the Brakes Plus location. This location had to order the parts from Kansas. I called the Toyota Dealership informing them what had happened, that the car was unable to be moved and got the response that I needed to take it to them for repair. I called at least two times since I received the notice for the fix in the mail and I was told that I would be contacted when they were ready to fix my car specifically. I was informed they would call, but they did not take down my contact information. I reached out to Toyota and they opened a claim where I uploaded documents - the original recall notice, the letter informing of the fix, the invoice from Brakes Plus, proof of purchase On Friday,XXX, I received a letter notifying me that my claim was not eligible for reimbursement. Since I tried to reach out and get an appointment scheduled inspection and the fix (if needed), and I never received a call to schedule after being told the dealership would reach out to me when they were ready, I believe they should have paid me back for the repair. I can provide the Toyota Brand Engagement Case number as requested. I am hesitant to upload documents here as these documents contain name, address, etc.
Electrical system, Engine, Jul 16, 2026
Intermittent stalling in various conditions including idling, highway driving and city driving.
Power train, Electrical system, Engine, Jan 5, 2026
I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for repairs and maintenance. They said they fixed it. It worked for about a 12 days and then the headlights started dimming over time as the week went on the engine light came back on and the driver side bulb was out again. So from 12/23/25 to 1/5/2026 was the length of time the truck worked but still poorly performance wise. The gas goes very quickly still and I have to fill it way too often now in its condition. I’ve spent about $5400.00 in total with trying to repair and keep gasoline in it to work. I’m taking it back to the dealership today after reporting this to NHTSA.
Electrical system, Dec 22, 2025
Odometer Fraud. The contact purchased a 2016 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was purchased from a private seller. At the time of the purchase, the mileage was 98,000. The vehicle was taken to an independent mechanic, and a Carfax report indicated that in November 2025, the mileage was reported at 170,000.
Electrical system, Jun 13, 2025
The contact leased a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) and requested to be removed from the recall distribution list because the contact no longer had the vehicle. The dealer and the manufacturer were contacted.
Electrical system, May 27, 2025
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Structure, Engine, Apr 28, 2025, fire
While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.
Electrical system, Apr 11, 2025
The contact owns a 2016 Toyota Rav4. The contact received a notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Apr 7, 2025
The contact owned a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list. The local dealer was not contacted; however, the manufacturer was contacted.
Electrical system, Mar 25, 2025
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the battery charge was reduced, and the vehicle would not immediately start and the vehicle occasionally stalled. The contact also stated that the battery was replaced on four occasions. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The failure mileage was 91,475. Parts distribution disconnect.
Electrical system, Mar 18, 2025
The contact owns a 2016 Toyota Rav4. The contact stated that the battery warning light was illuminated, and the battery was replaced at the local independent mechanic. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.
Electrical system, Mar 17, 2025
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Fuel/propulsion system, Visibility/wiper, Feb 2, 2025, crash
I had a significant car accident in 2020 and luckily only broke my thumb. I was rear ended. The car I had at the time was a brand new Toyota Rav4, which luckily did have side airbags and they deployed appropriately. However, I have since had the opportunity to drive other vehicles and would like to ensure the safety of myself and others on the road whether the car be foreign or domestic. Please see the following requests: 1. Toyota's electronics freeze intermittently. This is not the first Toyota Rav4 that I have had and it seems to have done this in the majority of them (2/3). This is dangerous as it can become a distraction to the driver if not familiar with this abnormality. The backup camera also variously changes it's functions, preferences, and layout. 2. The navigation system has to be updated by a chip instead of updated wirelessly. 3. It is not an electric vehicle. 4. I should not have to pay for gasoline or electricity if the sun can be used as a fuel source. Please research the and utilize solar cell panel paint to charge all electric cars and implement that into all domestic and foreign electric cars as soon as possible due to the inflating economy. 5. With full self driving availability please ensure that all cars on the road, whether they be electric or gas, have this capability due to safety issues as well as the extent of morbidity and mortality cases due to trauma patients. I have already emailed you on this problem. Please follow up. 6. Due to the younger generation and their addiction to social media as well as their cell phones, please ensure that there is voice capability within all cars. It may also be beneficial for a camera to be installed inside of the car since the younger generation is so prone to filming themselves. This would also help with liability issues if an accident were to occur. 7. Ensure there is a way to charge a cell phone without needing to plug in the phone.
Electrical system, Jan 21, 2025
The contact owns a 2016 Toyota Rav4. The contact stated that after driving and parking the vehicle, the vehicle failed to restart. The contact opened the hood and saw smoke. The contact stated that the battery had melted. There were no warning lights illuminated. The local dealer was contacted, and the vehicle was inspected at the residence. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local dealer, where it was diagnosed and determined that the failure was related to the electrical system. There was also fluid leaking from the battery. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 130,000. VIN tool confirms parts not available.
Electrical system, Jan 10, 2025
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Dec 20, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Sep 20, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while his wife was driving approximately 30 MPH, the instrument cluster and the infotainment display were turning off and on and resetting. The contact stated that his wife parked the vehicle and while attempting to restart the vehicle, the vehicle was not starting. The contact was able jumpstart the vehicle. The contact's wife drove the vehicle to a battery store where the battery was checked and was confirmed that it was within normal operating procedure. The failure reoccurred and the contact was able to drive the vehicle to a dealer where it was diagnosed and determined that the battery needed to be replaced. The contact questioned the dealer about NHTSA Campaign Number: 23V734000 (Electrical System) and was informed by the dealer that the recall repair was completed. The vehicle was not repaired. The failure mileage was approximately 96,000. VIN tool confirms parts not available.
Electrical system, Sep 17, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Aug 25, 2024
I needed a battery change so I changed it.
Electrical system, Jul 31, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Jul 29, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Jul 26, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Numbers: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Jul 12, 2024
The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Electrical system, Jun 7, 2024
Battery recall and Toyota on 6/7/2024 stated that the battery issues is unrelated to the recall and they cannot do anything. I was refused service a few months back for this recall.