2017 Toyota RAV4
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 307 owner complaints filed for this model year. This is the 13th highest complaint count among 26 RAV4 model years with reports.
Of the 2017 reports, 33 involved a crash and 24 involved a fire. 28 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Electrical system, 12v/24v/48v batteryNov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
A battery short circuit increases the risk of a fire.
Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Campaign 23V734000 on NHTSA.gov
Equipment, other, labelsJun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Campaign 19V503000 on NHTSA.gov
Tires, temporary/emergency spare tireMay 2, 2017
Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.
A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.
Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.
Campaign 17V295000 on NHTSA.gov
Representative owner complaints
307 reports, newest first.
Electrical system, Jan 19, 2023
Went out to the vehicle one day to run an errand and the warning light came on and said Electrical System Malfunction. I took it into the repair facility and was told at first it was the battery then was told no it's the alternator. I remembered I had an extended warranty on the vehicle so I took it into the Dealership. They said it's the Wire Harness and it's not covered due to corrosion. I have put less than 20, 000 miles on this vehicle. This needs to be addressed by the Manufacturer Toyota. I am asking NHTSA to do a recall on this vehicle.
Air bags, Dec 24, 2022
We owned 2 Toyota cars, highlander and RAV4( this is our second RAV4), we bought both time new, the first one after one year has some break and noise issues and my wife did not like it and we traded and got 2017 RAV4, from her experience, she did not wanted Toyota but different car, though I told her that it has longevity and she should get another Toyota and she agreed and gotten RAV4 2017 new car. However, this RAV4 cars have issues and my wife was right and I was wrong and will never buy RAV4 again. Today, in Portland, there is rain and raining and that small snow also now start melting with the rain, I parked my wife car in our driveway and went in, after lunch came back to drive, saw water was dripping, immediately looked for the sun roof locks, it was completed closed, reach my hand to the place where is the leak is coming, its from headliner areas by driver side where sun visor located. This is 2017 RAV4 with 26k mileage, I drop the car by the dealer where did we bought this car, their tech will be back on Monday, I cannot wait what they have to say for this obvious defect from the factories, I read more about it and there are a lot of this issues with RAV4 and needs factory attention for recall. MY MAIN CONCERN IS NOW: The real danger with this roof leak is not so much cosmetic , the real danger is damage to the airbags over the door and corrosion to the wiring harness, it should warrant recall!!
Electrical system, Air bags, Forward collision avoidance, Dec 9, 2022
I have attached a letter that I wrote Toyota but did not mail. Vechicle is a 2017 Rav Hybrid. We bought it in CA April 2021 and it had 28230 miles. Car went to Renton WA in August, 2021. Vechicle was serviced a couple of times, but in October 2022, dealer gave us a bill for $9700 due to a faulty wire halter. The Toyota people said the car is out of warranty. Please read the letter with lots more details. Thanks.
Engine and engine cooling, Nov 29, 2022, fire
The contact owned a 2017 Toyota Rav4. The contact stated that while the wife was driving approximately 35 MPH, the odor of smoke was present inside the vehicle. After stopping to inspect the vehicle, smoke and flames were seen coming from under the hood. The fire department was called to the scene to extinguish the flames. During the incident, the vehicle was destroyed and later towed away. A fire report was taken at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 60,000.
Other or unspecified, Nov 19, 2022
The door lock actuators failed I was locked out of my car
Other or unspecified, Visibility, Oct 30, 2022
While driving at about 55mph on an open highway, the moon roof exploded. There was a loud explosion inside the car by my right ear. The noise was deafening and distracting and caused a momentary loss of concentration on driving, a situation that was very dangerous and could have resulted in an accident with serious injury. I immediately pulled over and checked the tires, the body and underneath the vehicle, finding nothing. When I began driving again, I heard a loud wind noise and other strange noises above me. I started to open the cover of the moon roof, but shards of glass fell on me, so I closed it again. Pulling over again, I climbed on the door threshold to look at the roof of the car. Unbelievable! It looked like a volcano with the glass pointing upwards around a big hole. Toyota Corp. is claiming it was caused by an outside source. That is definitely not true. I was in the car, nothing landed on the roof. The highway I was on has no bridges, no overpass, no multi-story buildings, no schools or no place that would enable someone to drop or throw a large item on top of a car. And, there was nothing on the inside cover except broken glass. The glass on the roof was definitely pointing upwards. The result of my research on exploding roofs shows that this problem has affected multiple car brands and multiple sun/moon roof manufacturers. I'm asking the NHTSA to help protect USA drivers. If there had been a warning that the roof could suddenly explode while I was driving, I definitely would have selected a car without a glass roof. If the cover had not been closed, I would have been sprayed with glass in addition to the loud blast. Because this is a major safety issue, I'm begging the NHTSA to look into the problem and at the very least immediately issue warnings so drivers of vehicles with sun/moon roofs will be aware that this could happen. It would be much better to find out what defect is causing this to happen before anyone is killed! The consumer stated he feels that moonroof exploding should be reinvestigated and deemed as a safety issue.
Electrical system, Engine, Oct 28, 2022, fire
While driving the vehicle I smelled something burning and saw smoke coming out of the air vents. I immediately pulled to the side of the road and got out. I noticed fire and smoke coming from under the hood. I called 911 and the Fire Dept. arrived to put the fire out. It was towed to a nearby storage yard until the insurance company could be notified. After talking with and submitting photos to the insurance company the vehicle was considered a total loss. We are waiting to hear back from the insurance company concerning our claim. Upon researching engine fire related to defective battery in these vehicles I learned that almost 2 million 2013-2018 Toyota RAV4 have been affected. I am just thankful everyone was able to get out of the vehicle safely before it caught on fire.
Service brakes, Oct 16, 2022
Front brakes needed replacement at 40k miles. 24k miles later, I'm being told they need replacement again. At May 2022 ispection the measurements were 11/32 for all four brakes. Less than 6 months & less than 5k miles later, the right front is at 6/32, left front 9/32, rear are 11/32 & 10/32. I'm being told the right front pads & rotors are bad and the discs(?) are extremely rusty. How does this happen so quickly? Forums I've read say this is an issue with many 2017 RAVS. Apparently, Toyota used low-grade rotors on that model and year. I had complained of a slight grinding noise coming from the front wheels on several occasions only to be told they can't find anything. I've had no safety issues yet but this ongoing problem is unacceptable and may eventually result in a collision.
Steering, Sep 15, 2022
Although just aligned, steering consistently pulls to the right.
Electrical system, Aug 27, 2022
My vehicle is on it's 3rd replacement in less than 5 years because it randomly fails. It will not start. This is after I had recently taken my vehicle in for service, where the service technicians have checked the battery performance as "Good". There have never been any warnings before my vehicle would not start. Absolutely no symptoms prior to the failure. When I pressed the start button, the vehicle gave no indication that it would turn over. It's been a terrible inconvenience and very unsettling, because now that it's happened to me twice. The original battery and now the replacement in less than 5 years. I'm not sure when it will happen again.....it's so unpredictable. This last time, I was stuck in a parking lot and had to be towed to the nearest Toyota dealership.
Air bags, Aug 22, 2022, crash
While traveling around 40 mph on a roadway another vehicle ran a stop sign approximately 2 feet in front of my vehicle. This vehicle came onto the roadway from a side road at a sustained speed with no braking. I swerved to avoid impact and went over an embankment. The vehicle sustained extensive damage to the front and underneath. It is a total loss. The airbags did not deploy during the accident. There were also serious injuries to the driver and passenger. The driver sustained a broken neck in 4 places. The passenger sustained massive hematomas, a fractured arm, and 7 fractured ribs in the chest and separated sternum. There were no warning lights or messages displayed. An inspection has not been performed on the airbag system. The vehicle is currently located at the insurance company's salvage yard.
Other or unspecified, Aug 3, 2022
While driving the vehicle, the sun roof glass shattered. The cover of the roof was closed, so no glass spilled into the car, but could have been dangerous if it the cover was open.
Other or unspecified, Jul 30, 2022
6 months after warantee expired passenger front door lock actuator failed. Dor can only be locked /unlocked from manual rocker lock inside door. Electrick lock doesnt function. Within 6 months of that failure, drivers door developed same problem. Door can only be locked from inside and unlocked from outside with key.
Exterior lighting, May 23, 2022
Discoloration/fogging of tail light lens on driver side. Picture uploaded.
Electrical system, Structure, Engine, May 20, 2022, fire
On Saturday, May 14, 2022, my vehicle burned. and has since been totaled. The car had been trouble-free since I bought it in 2018. I was so pleased with it that I had just paid off the balance on the loan the week before because I wanted to keep it for 10 years. Prior to it burning, I had just driven it a couple miles for the first time in 2 weeks (it had been parked in a friend's garage). There were no warning lights visible during that time. I got out of the car for 3 minutes and was about to get back in when I noticed white smoke coming out of the hood. Within 30 seconds the hood had become engulfed in flames. The entire front and interior of the car was destroyed in the blaze, which the Fire Department had to extinguish. No one was injured, but two cars on either side were damaged by the fire. The car had last been serviced by Headquarter Toyota in Miami on January 22, 2022. They had not done the government-recommended inspection of the engine area during the servicing.
Steering, Engine, May 20, 2022, crash
The driver owned a 2017 Toyota Rav4. The contact called on behalf of her son who was driving approximately 35 MPH when he lost control of the steering due to the functionality of the steering wheel and accidentally crashed into a pole. There were no warning lights. The 2 front and 1 side air bag deployed. The police and fire and ambulance arrived on the scene. The driver was transported to the hospital where he received a CT scan for his injury. There was a police report. The vehicle was destroyed and towed to a salvage yard. The manufacturer was notified of the failure. The approximate failure mileage was 76,000
Engine, May 13, 2022, fire
The contact owned a 2017 Toyota Rav4. The contact stated while driving at 10 MPH, the vehicle stalled. There was no warning light illuminated. The contact veered to the side of the road. The contact was unable to restart the vehicle after several attempts. The contact saw smoke coming out from underneath the hood of the vehicle and immediately exited the vehicle. The contact then saw flames coming out from underneath the hood of the vehicle. The contact was able to extinguish the fire with the assistance of the fire department. There were no injuries sustained. A fire department report was filed. The vehicle was towed to a tow lot where it was totaled. The dealer and manufacturer were not notified of the failure. The failure mileage was approximately 76,000.
Tires, May 13, 2022
The contact owns a 2017 Toyota Rav4. The contact stated that while operating the vehicle, the Tire Pressure Monitoring System (TPMS) warning light would activate even though the air pressure in the tires were normal. The contact indicated that the failure also occurred immediately after refueling. No further information was available. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 30,000.
Electrical system, Engine, Apr 30, 2022
Vehicle automatically slows down and shakes violently. We had it checked out at a Toyota dealership and they didn’t find any problems with the vehicle when they performed a diagnostic check. It continues to happen when vehicles is on the fwy. EV light appears on screen flashing on and off.
Other or unspecified, Mar 30, 2022
My mechanic showed me that the axle shaft assembly on my Toyota RAV4 is leaking grease and that, if not repaired soon, could be a safety issue when driving.
Power train, Mar 25, 2022
The contact owns a 2017 Toyota Rav4. The contact stated while driving at 55 MPH, the vehicle started making a rumbling sound and was also shuddering. There were no warning lights illuminated. The contact veered to the side of the road. The vehicle was taken to an independent mechanic who test drove the vehicle, and the tires were balanced and rotated; however, the failure reoccurred while driving. The vehicle was taken back to the independent mechanic where it was diagnosed that the engine block stabilizers needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the torque converter needed to be replaced. The vehicle was not repaired. The contact stated that the failure had become significantly worse while driving between 25-30 MPH and 45-50 MPH. The manufacturer was not notified of the failure. The failure mileage was approximately 94,000.
Visibility/wiper, Mar 18, 2022
on a nice clear spring day in california, driving on the 101 freeway my 2017 toyota rav4 xle sun roof just Exploded..no trucks around me...and no overpasses...it just exploded outwards i belive....no warning .....could have very easily cause a serrious accident/injury...some glass dropped on driver/passanger...dome rolloed off top of the car.
Other or unspecified, Feb 8, 2022, crash
The axle broke while I was driving. I was on CA HWY 101 NB, it was a day after the rain so I was careful not to speed. As I was heading towards a decline the car made a loud pop sound that came from the rear left side. I looked back because my initial thought was the tire popped but as I looked at my rear view mirror the car veered rapidly to the left headed straight to the median. Safety at risk: I tried to break but it seemed like the breaks were not responding well. I turned the wheel to not hit the median and the car turned completely, facing traffic and sliding to the right side of the freeway where it stopped on its side. The car was checked and we have a letter from Toyota saying the part broke due to speeds over 80 mph. But I was not driving over 80, and and axle is probably not supposed to break at that speed. There were no warning lights, or symptoms. My vehicle seemed completely healthy.
Electrical system, Jan 10, 2022
The contact owns a 2017 Toyota RAV4. The contact stated that occasionally the vehicle would not immediately start-up, or would take multiple attempts before starting. The vehicle was towed to the local dealer, but the cause of the failure was not yet determined. The manufacturer was also notified of the failure. The failure mileage was 66,000.
Other or unspecified, Jan 4, 2022
The shifter makes a irregularly rough shift out of park . It is available for inspection if possible. The safety of me or passengers has not been compromised. The problem has not been confirmed from any dealer or manufacturer. The shifter component has not been inspected or checked to confirm the issue or potential issue. There was no warning light to indicate a issue.