2018 Toyota RAV4
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 331 owner complaints filed for this model year. This is the 9th highest complaint count among 26 RAV4 model years with reports.
Of the 2018 reports, 31 involved a crash and 32 involved a fire. 18 people were injured.
What owners report most often
Recalls and investigations
Electrical system, 12v/24v/48v batteryNov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
A battery short circuit increases the risk of a fire.
Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Campaign 23V734000 on NHTSA.gov
Equipment, other, labelsJun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Campaign 19V503000 on NHTSA.gov
Equipment, other, labelsDec 20, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Campaign 17V831000 on NHTSA.gov
Representative owner complaints: electrical system
129 reports, newest first. Show all
Electrical system, Engine, Oct 1, 2018
WHILE DRIVING ON SATURDAY MORNING 9/29/18, I STOPPED AT A STOP LIGHT AND MY 2018 TOYOTA RAV4 LOST ALL ENGINE POWER WHILE IN TRAFFIC. THE COMPUTER VIDEO SCREEN SHOWED THE MESSAGE "CHARGING SYSTEM FAILURE\MALFUNCTION". I THEN ATTEMPTED TO RESTART THE VEHICLE AND IT DID NOT CRANK OVER, I WAITED A FEW SECONDS, MADE ANOTHER ATTEMPT , THE VEHICLE STARTED. I PULLED OVER AND PARKED THE VEHICLE, LOOKED UP THE ERROR MESSAGE IN THE CAR MANUAL AND IT INSTRUCTED ME THAT IT WAS A SERIOUS PROBLEM AND TO TAKE THE VEHICLE IMMEDIATELY TO THE NEAREST TOYOTA DEALER. I THEN TOOK THE VEHICLE TO MY LOCAL DEALER, THEY RAN A VEHICLE DIAGNOSTIC REPORT, THEY FOUND NO ERROR MESSAGES OR VOLTAGE PROBLEMS WITH THE VEHICLE. THEY OFFERED NO REASON FOR THE LOSS OF VEHICLE POWER. THE SERVICE MANAGER STATED THAT THEY COULD ONLY DIAGNOSE THE VEHICLE SO FAR AND THAT THEY WOULD NEED "CORPORATE" TO SEND SOMEONE OUT TO DO FURTHER DIAGNOSTICS ON THE BLACK BOX. ON 10/1/18, I OPENED A PROBLEM REPORT WITH TOYOTA USA AND WAS GIVEN A CASE#. .
Electrical system, Aug 22, 2018, fire
MY RAV4 CAUGHT FIRE IN THE MIDDLE OF THE NIGHT WHILE PARKED ON THE STREET IN FRONT OF MY HOUSE. IT HAD BEEN PARKED FOR 12+ HOURS. AFTER BURNING FOR ABOUT 10 MINUTES, IT EXPLODED WITH A FORCE SO GREAT THAT IT LIFTED THE CAR ONTO THE CURB, KNOCKED OVER A FIREFIGHTER, AND DAMAGED OUR BOAT PARKED 10 FEET ACROSS THE STREET. THE INSPECTOR FROM THE FIRE DEPARTMENT DETERMINED THE INITIAL FIRE WAS FROM FAULTY ELECTRICAL WIRING BUT SAID HE HAD NEVER SEEN A CAR EXPLODE IN HIS 25 YEARS ON THE FORCE. TOYOTA CONDUCTED THEIR OWN INVESTIGATION AND AGREED IT WAS ELECTRICAL BUT COULD NOT DETERMINE FAULT DUE TO THE SEVERITY OF THE DAMAGE
Electrical system, Apr 13, 2018
I AM VERY DISAPPOINTED. I BOUGHT A RAV4 2018 IN FEBRUARY OF THIS YEAR, IT HAS ONLY 1,900 MILES AND IS ALREADY AT THE DEALER AFTER TAKING MY KIDS TO SCHOOL I WENT BACK HOME AND I USUALLY DO I ACTIVATE THE VEHICLE ALARM BUT IT DID NOT WORK. THE KEYS DOES NOT ACTIVATE OR DIS-ACTIVATE THE VEHICLE ALARM AND WHEN THE CAR IS ON THE TIRE PRESSURE SIGN STARTED TO BLINK. THE DEALER STAFF SAID THAT ONE OF THE COMPUTER IS NOT WORKING RIGHT. AT THIS MOMENT THEY DON'T KNOW WHAT IS GOING ON AND IRONICALLY IS NOT TIME FOR THE FIRST PAYMENT YET.
Electrical system, Mar 5, 2018
THE VEHICLE WAS STATIONARY IN A DRIVEWAY FOR APPROXIMATELY 2 HOURS. AFTER PULLING AWAY FROM THE HOUSE, DASH PANEL INDICATORS WERE SHOWING MALFUNCTIONS ON BRAKE SYSTEMS, AWS, ETC. IT SHOWED THAT ALL COMPUTER SYSTEMS WERE MALFUNCTIONING. I DROVE IMMEDIATELY TO THE DEALER. INSPECTION SHOWED THAT THE WIRE HARNESS ON THE VEHICLE HAD BEEN CHEWED APART, OFF, AND INSULATION HAD BEEN REMOVED. I INVESTIGATED THE INTERNET ON THIS PROBLEM AND IT SEEMS THAT SEVERAL VEHICLE MAKES AND MODELS WERE AFFECTED. IT SEEMS THAT THE MANUFACTURES WERE USING A FOOD BASED INGREDIENT IN THE INSULATION OF THE WIRES, (SOY). THIS IS ATTRACTING RODENTS, (SQUIRRELS) TO THIS FOR FOOD. IT COULD HAPPEN ANYWHERE, PARKED AT THE POST OFFICE, GROCERY STORE, YOUR FRIENDS HOUSE, ETC. MY VEHICLE ONLY HAS 980 MILES. I HAVE NEVER HAD THIS BEFORE. WHAT WOULD HAPPEN IF THE WIRES CATCH ON FIRE OR YOUR CAR STOPS ON THE FREEWAY BECAUSE OF THIS ISSUE. CAN THIS BE INVESTIGATED? AT THIS POINT, WHAT'S GOING TO KEEP THIS FROM HAPPENING AGAIN. WE'VE HAD SEVERAL TOYOTA VEHICLES IN THE PAST AND DID NOT HAVE ANY WIRE HARNESS PROBLEMS.