2022 Toyota RAV4
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 145 owner complaints filed for this model year. This is the 23rd highest complaint count among 26 RAV4 model years with reports.
Of the 2022 reports, 14 involved a crash. 12 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, sensor, occupant classification, front passengerJul 21, 2022
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Rav4, Rav4 Hybrid, and Rav4 Prime vehicles. The front passenger seat may have been assembled with interference between internal parts that may cause the Occupant Classification System (OCS) sensor to incorrectly detect the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Incorrect detection of an occupant may result in improper air bag deployment during a crash, increasing the risk of injury.
Dealers will inspect and repair the front passenger seat, as necessary, free of charge. Owner notification letters were mailed September 2, 2022. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 22TA08.
Campaign 22V519000 on NHTSA.gov
Representative owner complaints
145 reports, newest first.
Structure, Oct 17, 2024
The contact owns a 2022 Toyota Rav4. The contact stated that while either driving at various speeds or coming to a stop, a moving water sound would emit from both the rear driver and passenger side doors. The contact had taken the vehicle to the dealer on multiple occasions to have the doors drained to prevent mold from developing inside the vehicle. The contact was also informed by the dealer that the failure was a result of the vehicle's design and that no other repairs could be made to address the failure. The manufacturer was not notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 12,000.
Electrical system, Service brakes, Forward collision avoidance, Oct 14, 2024
While driving in stop-and-go traffic on a major highway, the auto braking system engaged and the brake would not release. The car came to an abrupt halt and the brake would not release, the gas pedal would not depress. I had to turn the car off, place the car in park and restart the car, the car then continued driving. There was a message on the dash about EPB.
Structure, Sep 3, 2024
The contact owns a 2022 Toyota Rav4. The contact stated that while driving and coming to a stop, there was a sound of moving water coming from the rear driver's side and passenger's side doors. The contact stated that upon opening the doors, she was able to partially drain the water; however, water was still leaking inside the rear driver's side and passenger's side doors during rainy weather. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.
Structure, Aug 4, 2024
Rear passenger door does not drain and holds water. This is a potential mold issue which is a health problem. This will also cause the doors to rust.
Engine, Fuel/propulsion system, Jul 19, 2024
Fuel Injector failed, causing the engine to run extremely rich, misfire, and cause severe drivability issues. Issue occurred just outside vehicle base warranty. Problem was verified and confirmed by vehicle dealership. MIL was illuminated when drivability issue and malfunction started.
Air bags, Jul 12, 2024
NO ACCIDENTS
Other or unspecified, Jun 28, 2024
On [XXX], I opened the unblemished retractable glass roof of my 2022 RAV4 XSE. The rear windows were rolled down approximately 4 inches. No other cars/people were in front, next to, or behind me. As I accelerated to approximately 35 mph, I heard an explosive blast and peered upward. I noticed that the retractable glass roof panel had completely shattered. Shards of the roof rained on me as I drove home. Once home, I closed the roof just enough to secure my vehicle. The motor /closing mechanisms were operable. Glass shards were present in the tracks as well as on the top of the intact remainder of the glass roof. Glass shards were present in both the front and back seats of the vehicle. Upon inspection, there were NO visible pits/holes in the shattered roof; however, the roof was almost completely displaced from the edges of the moonroof’s seal/frame (see pictures). I contacted my Insurance to file a claim, and my SUV was towed to Toyota. 6/24 Toyota’s estimator left a voicemail stating that the glass roof was being assessed. I left a message asking for the cause of the damage. On 6/25, Toyota called and stated that the roof panel was being replaced. The estimator was unable to determine the cause of the breakage and mentioned that this was the first time they had to replace a panoramic sunroof. No other outside agencies (only Toyota Carlsbad Collision) inspected and/or addressed the damaged glass roof. A faulty design and /or improper manufacturing of the glass was never addressed or considered. 6/27 Toyota billed my insurance $1971.52 minus the $500 deductible I was required to pay per the terms of my insurance. *** It should be noted that there are a number of RAV4 cases involving sudden glass roof explosions. These lawsuits allege that glass sunroofs of RAV4s shatter under normal driving conditions. In fact, on May 3, 2024, a class action suit brought before the US District Court in California, rejected Toyota’s rebuttal, and the lawsuit is moving forward. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Jun 10, 2024
I had another incident this week where I was stranded in a parking lot and had to call Triple A to get my car running properly again. They tested the battery and belts and all were good. When trying to start my car, it locked and said: "ENGINE STOPPED, POWER STEERING LOW". Not only was my car locked, but it was shaking and making scary noises. The same thing happened to me at a drive-thru a year ago. My car is a Toyota Rav 4 LE 2022 with 20K miles on it and is too new to be having these problems. Through looking up this issue on Google, I have seen that there are a good amount of Rav 4s that are newer dealing with this same issue.
Electrical system, Jun 2, 2024
The Multimedia dashboard is completely blank. Not able to use sound, gps, music, etc. Cant set time or any adjustments to vehicle. This seems to be a manufacturing issue. Dealer said there is nothing they can do about it. Was told will need to pay $1600 to replace it. Don't know how long a new won will last. Can't keep spending $1600 everytime the electrical system Malfunctions. Please help.
Lane departure, May 21, 2024
The Blind Spot Warning system fails to alert the driver when a vehicle in the adjacent lane is partially behind the current vehicle. It only activates when the nearby vehicle is completely behind the current vehicle. Due to this limitation, the system does not provide adequate warnings for nearby vehicles, which has nearly caused several accidents when the driver attempted to change lanes.
Other or unspecified, May 11, 2024
The radio screen in this vehicle keeps going black. When it is connected to CarPlay, the GPS will randomly shut off. At times, the radio steering wheel controls and the volume knob on the radio will not adjust the volume creating a safety hazard as I not able to lower or turn off the volume. Freeway Toyota in Hanford California did a software update about a year ago in relation to the same issue but the issue persists.
Electrical system, Other or unspecified, May 8, 2024
Vehichle has stranded me twice with multiple error messages when I try to start it. All kinds of lights go on and off on the dash and messages include: Parking Brake Unavailable, Voltage Abnormality Steering Power Low, Hybrid System Not Available, Braking Power Low-Stop in a Safe Place, Antilock Brake System Malfuntion, Rear Cross Traffic Alert Unavailable, Blindspot Monitoring Unavailable, Pre-Collision System Unavailable, Visit Dealer. It makes all kind of weird noises and vibrations in the break peddle also during this. I have been told this is a problem with low battary of the 12V but that battery is charged by the Hybrid battary and does nothing but run electronic features, does not start the vehichle. Have read this has happened to people while actually driving the vehichle, I am scared this will cause an accident. 2 year old vehicle.
Steering, Apr 30, 2024
My vehicle is 2 years old and had 17,000 miles on it when the steering wheel began to peel and chip. Toyota says that it was "caused by the user". There are reports all over the internet about this same problem on this same vehicle.
Steering, Apr 19, 2024
Steering wheel is deteriorating on vehicle. It is low mileage and and has one driver.
Tires, Apr 16, 2024
Tire split on the inside of the tire wall about 1 inch up. Less than 20,000 miles on them. I do not believe this is normal. 225/60 R18. Car was serviced by Toyota on March 21st.
Steering, Apr 16, 2024, crash
The contact owned a 2022 Toyota RAV4. The contact stated that while driving at approximately 20 MPH, the steering wheel independently veered in the right direction. As a result, the vehicle crashed into an unoccupied parked vehicle. The contact's vehicle flipped twice and the driver's side of the vehicle was severely damaged. The air bags deployed. The contact and the back seat passenger received medical treatment. The contact sustained a lower back injury and heart issues, and the passenger sustained a bump on the head. A police report was filed. The vehicle was towed to the contact's residence, then the vehicle was towed to the dealer. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 24,000. The VIN was not available.
Suspension, Apr 11, 2024
Loud clunk over bumps, suspension sounds loose and dangerous. Vehicle was purchased new and has 24,443 miles, this sound is NOT normal for a new vehicle.
Other or unspecified, Apr 3, 2024
When driving on the interstate, the sunroof (aka, the moonroof) spontaneously shattered. It was most certainly NOT stuck by any object.
Air bags, Structure, Forward collision avoidance, Mar 14, 2024, crash
My wife and I were traveling down SR74 mp 12 and rear ended a cow at 68 miles per hour. The airbags did not deploy from impact and yet the car is totaled the hood started through the safety glass of the windshield.
Other or unspecified, Mar 4, 2024
Was driving to my daughters in the rain. As was pulling in my rav 4 started jumping and sputtering and cut off with a message of “engine stopped, power steering low”. Tried to crank it and same thing. Let it set over night and cranked fine. Took to dealership and they said could not find anything wrong. Have googled and tons of this same report on there but no solution. Needs to be recalled and fixed. Car just cuts off while driving
Suspension, Feb 9, 2024
6/15/23 @ 18,357 miles the car was given a four wheel alignment at the owners request. Due to loud tire noise and visible cupping on the right rear inside edge, it was clear the car's wheel alignment was wrong. The dealer's before and after alignment is attached. When presented the before and after, I noted RR Camber was.-2.3 vs. a range of -1.8 to -0.3 degrees. The reading was unchanged from initial. They advised me the camber cannot be adjusted and is "fixed" from the Factory. The form also read "One of more value are not within specification. Tire wear, handling and safety problems may result". But they had no remedy. I escalated at Dealer. Dealer opened a ticket with Toyota to look at my car. Of note, my Sister in Law's RAV4car has the same issue. I felt I had made my concerns clear and Toyota Corp would address. 2/1/24 At 30,345 the problem is still unresolved and dealer gave me Toyota Corp number and I opened case 240201000061. 4 calls later I am told to bring my car to dealer 2/20/24. Research shows TSB 0042-14 for earlier RAV4. My safety problem is not new to Toyota, it is just a later model. When I told Toyota Corp their response from 6/15/23 to 2/1/24 is unacceptable, they took no ownership. When I asked if I should drive an unsafe car they said it is my choice. When I advised them of the language from the dealer said the tires were unsafe, they said the Dealer is independent from Toyota. In short, the dealer is "Independent". Toyota has a problem with their design using a static camber strut which causes premature wear which can lead to a blow out as shown by forums. Toyota is only interested in getting the car to 36,000 miles and little focus on safe design. I was surprised not to see this already listed. Perhaps it exists under another year? A company Hard Race has made adjustable rear Toe Arms for the RAV4. The dealer confirmed same.
Other or unspecified, Jan 31, 2024
1.Air conditioning - evaporator drain hose is not connected and that’s why it’s pouring water into the passenger side, and there is mold and odor, per Toyota of Montgomery. Available for inspection. 2.Mold is health hazard - increased migraines and respiratory issues. 3.Issue found and confirmed by Toyota of Montgomery, after repeated complaints that AC wasn't working properly during regular service visits. Audio of this information from Service Manager. 4.To my knowledge the problem has existed since purchased (brand new). I happened to discover the water [XXX]. Odor has been there almost the whole time I have owned the car. There have been no warnings, messages, recalls or notification that the problem existed. Contacted Toyota Manufacturing [XXX] , waiting for call back at this time. Note: I have audio recordings of dealerships' employees including GM, Service Manager, Sales Manager, Salesman and service personnel. I don't know how to load them here from my phone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Jan 26, 2024
Sunroof blew out on its own without being hit or touched
Steering, Electrical system, Engine, Jan 25, 2024
Safety issue: "Engine Stopped/Started: Due to Steering Power Low" Yesterday, it was heavy rain. My new 2022 RAV4 shut down and would not start due to the warning sign "Steering Power Low." I restarted a few times, but the whole car was jerking and the rpm's were fluttering up and down. The yellow check engine light and the orange warning signs, followed by an exclamation point, came on, along with the messages "Engine Stopped Steering Power Low" and "Not Ready to Drive." then shut down the car. I called for a pickup instead and was not able to start the car until the next day. It was so terrifying, and I was fortunate that the accident did not occur. What would happen if it were to happen as I or other RAV4 owners were in the middle of the road or nowhere for help? As I looked up problems with the new RAV4 online, other RAV4 owners had the same issues, with zero diagnosed reports from Toyota dealers (see links below). [XXX] [XXX] This is a safety concern; I'd be happier that the accidents have not happened yet. So, I urge the Toyota manufacturer to investigate the issue, rectify it, and start making a recall of the 2019–2024 RAV4 to fix the problems before an accident occurs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Fuel/propulsion system, Jan 24, 2024
On 11/15/23 I went to Byers Toyota Dealership and asked them to check my car due to the gas smell inside of the car when driven and outside of my car when parked for a longer period of time. The smell is coming from the rear. The car also has a very strong gas smell when the tank is open to pump gas. I did not notice any leaks. On the visit on 11/1523, they fixed the leaking evaporator according to your bulletin from May 2023 to alleviate the burning oil smell coming from my car’s HVAC heater. They also checked the fuel pump and told me that I have the correct one and it should function as designed. The service advisor told me that the gas smell is exhaust fumes and it is normal for Toyota type of engine. They did not have any explanation for the fuel smell when my car is parked. Since the smell was still present, I scheduled another appointment at the dealership on 1/3/24, they kept my car overnight but they were not able to duplicate any of my concerns. I did not contact Toyota Customer Care because they can be very unpleasant if the dealership cannot duplicate the problem.