2006 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 782 owner complaints filed for this model year. This is the highest complaint count among 26 Tacoma model years with reports.
Of the 2006 reports, 66 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Air bagsApr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Campaign 06V096000 on NHTSA.gov
Tires, beadMar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 06V061000 on NHTSA.gov
Representative owner complaints: steering
40 reports, newest first. Show all
Steering, Suspension, Structure, May 9, 2025
The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the NHTSA review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Suspension, Other or unspecified, Feb 26, 2023, crash
The frame is rusted so bad. The dealer wouldn’t replace due to the vehicle being registered in Florida as it’s not one of the states affected. But my Toyota came from a Pennsylvania dealer first then shipped to Florida after years of being in Pennsylvania and not having an issue up there. Now I’m stuck with a truck I can’t sell or fix. It’s not right. Where is the quality control on this.
Steering, Dec 2, 2021
The universal joint on the intermediate steering shaft corrodes and seizes causing a potential problem steering. It is a serious safety issue in my opinion. It is an on-going issue.
Steering, Suspension, Structure, Other or unspecified, May 20, 2020
THIS VEHICLE IS COVERED IN THE TOYOTA RUSTY FRAME LAWSUIT. AS SUCH, IT HAS BEEN INSPECTED BY 2 DIFFERENT DEALERS AND DEEMED NOT TO NEED A FRAME REPLACEMENT BOTH TIMES. IT WAS TREATED WITH CRC. ITS LAST INSPECTION WAS IN NOVEMBER OF 2018. ON SUNDAY, MAY 17TH, 2020, THE FRAME BROKE AT THE FRONT CROSS-MEMBER CAUSING THE LEFT FRONT LOWER CONTROL ARM TO SEPARATE AND STEERING THE VEHICLE/CONTROLLING THE VEHICLE BECAME NEAR IMPOSSIBLE. FORTUNATELY FOR ME, THIS HAPPENED IN A PARKING LOT BACKING OUT OF A PARKING SPACE AND TURNING LEFT (IN REVERSE AT LOW SPEED) AFTER A FULL 2 WEEKS OF DRIVING IN THE MOUNTAINS OF WEST VIRGINIA. I QUESTION ALL INSPECTIONS OF FRAMES BEING PERFORMED WITHIN THE TOYOTA DEALER NETWORK AND HOPE THAT NOBODY HAS THIS FAILURE WHILE THEY ARE DRIVING AT SPEED AS THE RESULTS WILL BE CATASTROPHIC. *TR
Steering, Apr 18, 2020
STEERING BECAME VERY STIFF WHILE DRIVING IN TOWN YESTERDAY. UPON MAKING A RIGHT TURN AT A FAMILIAR INTERSECTION, IT BECAME DIFFICULT TO MAKE THE TURN DUE TO VERY STIFF STEERING. THE FRONT END OF MY TRUCK CAME VERY CLOSE TO A VEHICLE COMING INTO THE INTERSECTION FROM THE STREET I WAS TURNING INTO, AND THEN THE USUAL RETURN OF MY WHEELS TO STRAIGHT AHEAD DID NOT OCCUR AS EXPECTED, AND I HAD TO QUICKLY FORCE THE STEERING WHEEL BACK BEFORE I RAN UP OVER THE CURB ON MY RIGHT. LUCKILY THE CAR COMING INTO THE INTERSECTION HAD BEEN FAR ENOUGH BACK FROM THE INTERSECTION THAT WE DID NOT COLLIDE, AND IF I HAD NOT FORCED THE STEERING WHEEL BACK AT THE END OF THE TURN I MAY HAVE HIT PEDESTRIANS ON THE SIDEWALK. UPON INVESTIGATING THIS PROBLEM WITH A MECHANIC IMMEDIATELY AFTER THE INCIDENT (YESTERDAY AFTERNOON) AND AT ONLINE FORUMS, THE MOST LIKELY CAUSE SEEMED TO BE THE U-JOINT ON THE LOWER INTERMEDIATE SHAFT OF THE STEERING COLUMN DOWN JUST BEFORE THE STEERING GEAR, JUST INSIDE THE LEFT FRONT WHEEL. PER SOME ONLINE FORUM ADVICE, I USED PENETRATING OIL ON THAT U-JOINT TO LOOSEN IT, WITH GOOD RESULTS (STIFFNESS IS NOW GONE). BUT THIS SEEMS MOST LIKELY TO BE A TEMPORARY FIX. I DOUBT THAT LOOSENING THE U-JOINT TODAY WILL KEEP IT FROM A REPEAT PERFORMANCE AT SOME UNKNOWN AND UNPREDICTABLE TIME. CLEARLY THIS COULD CAUSE ACCIDENTS, AND PER ONLINE FORUMS, IT HAS APPARENTLY BEEN A KNOWN ISSUE FOR A WHILE. THERE ARE NO GREASE FITTINGS ON THE U-JOINT, SO THERE IS NO WAY TO PUT A MORE PERMANENT LUBRICANT (GREASE) INTO THE BEARINGS OF THE U-JOINT. ALSO, THE U-JOINT IN QUESTION IS NOT PROTECTED BY A RUBBER BOOT, AND IS COMPLETELY EXPOSED TO ALL THE WATER, DIRT, AND SALT THAT SPLASHES UP WHILE DRIVING. OTHERS HAVE NOTED THAT SPRAYING WITH PENETRATING OIL OR THE LIKE IS ONLY A TEMPORARY FIX, AND THE STIFF STEERING PROBLEM RETURNS AFTER A TIME, MAKING AN ACCIDENT MUCH MORE LIKELY.
Steering, May 28, 2019
STIFF STEERING WHILE STATIONARY. DIFFICULT TURNING WHILE MOVING AFTER NOT USING THE VEHICLE FOR A TIME. THIS OCCURRED AFTER LEAVING THE VEHICLE FOR 6 MONTHS OR SO AT THE DEALER FOR A RECALL IN 2012 OR SO. WHEN I GOT THE VEHICLE BACK IT WAS OK BUT I DON'T KNOW WHAT THEY DID TO IT. THIS PROBLEM JUST REOCCURRED LAST WEEK AFTER I DID NOT USE THE VEHICLE FOR A WHILE.
Steering, May 9, 2019
THE STEERING WHEEL GET REALLY TIGHT AND MAKE IT DIFFICULT TO TURN. IT FEELS LIKE IT'S GOING TO LOCK UP ON ME. CALL TOYOTA AND THE DEALER ABOUT IT. THEY DON'T SEEM TO CARE. TRUCK HAS 86,000 ORIGINAL MILES ON IT.
Steering, Suspension, Other or unspecified, Apr 8, 2019
RUSTED FRONT END PASSENGER SIDE COMPONENT BROKE OF THE FRAME DUE TO CORROSION. TOYOTA WARRANTY FOR REPAIR EXPIRED 31 JANUARY 2019 AND VEHICLE WAS TAKEN TO TOYOTA 2 MONTHS LATER AND TOYOTA WILL NOT HONOR REPAIR. VERY DISAPPOINTING ON TOYOTAS END. THE RUSTED FRAME TAKES LONGER THAN 2 MONTHS TO CORRODE. TOYOTA CARE NOT WILLING TO WORK WITH ME AND FIX THERE FAULTY AND VERY UNSAFE PRODUCT!
Steering, Aug 4, 2018
MY 2006 TACOMA IS VERY STIIF STEERING WHEEL EVERYTIME I USE THE VEHICLE . IM AFRAID OF ACCIDENT WAITING TO HAPPEN.
Steering, May 7, 2018
THE STEERING ON MY TACOMA SOMETIME STIFFENS AND DOES NOT RETURN BACK TO CENTER OR SOMETIMES YOU CAN BARELY TURN THE WHEEL LEFT OR RIGHT DUE TO THE LOWER INTERMEDIATE SHAFT RUSTING IN ORDER TO DRIVE SAFELY YOU HAVE TO TEMPORARILY PUT WHITE LITHIUM GREASE ALL OVER IT BECAUSE THE DESIGN IS WIDE OPEN TO ROAD SPRAY AND SALT I'M ALMOST GOT INTO 5 HEAD-ON COLLISIONS.. AND RESEARCHING ONLINE THIS IS A VERY COMMON ISSUE WITH THESE TRUCKS AND ALSO VERY DANGEROUS THERE SHOULD HAVE BEEN SOME KIND OF PROTECTION OVER THE SMALL U JOINT IN THE STEERING SHAFT SPRAYING IT WITH PENETRATING OIL IS ONLY A TEMPORARY FIX UNFORTUNATELY THIS IS A $500 REPAIR AND WHO KNOWS HOW LONG IT WILL LAST BEING UNPROTECTED ONCE AGAIN
Steering, May 3, 2018
TRUCK HAS HARD STEERING IN ANY CONDITION. TOOK TO DEALER DEIHL IN BUTLER PA. THEY TOLD ME IT WAS THE STEERING SHAFT. THE DEALER IS GREAT THEY REPLACED MY FRAME REAR SPRINGS ALL U JOINTS AND DRIVESHAFTS.WE WERE TOLD THIS REPAIR WOULD COST $450 ROUGHLY. THIS IS A KNOWN PROBLEM AND SHOULD BE COVERED TOO..
Steering, Apr 17, 2018
STEERING LOCKING UP.TOOK SHAFT OFF WITH U JOINT. GOT OT TO LOOSEN UPWITH HEAT AND LUBE.PUT BACK ON TILL I CAN GET NEW ONE.DTARTING TO LOCK UP AGAIN. HAD FRAME RECALL DONE.TOYOTA SAID NO RECALL ON JOINT AT THAT TIME.
Steering, Apr 2, 2018
LOWER INTERMEDIATE STEERING SHAFT U JOINT SEIZED. IT IS SMALL AND EXPOSED TO THE ELEMENTS, AND THERE IS NO PROTECTIVE COVERING. IT IS A DANGEROUS PIECE TO HAVE FAIL. MANY OTHER TACOMA OWNERS OF THE SAME MODEL YEARS EXPERIENCE THIS PROBLEM.
Steering, Feb 28, 2018
STEERING GETTING VERY STIFF. HARD TO STEER AND HARD TO RETURN STEERING TO STRAIGHT AFTER COMPLETING TURN.
Steering, Feb 21, 2018
MY STEERING WHEEL HAS BECOME REALLY STIFF, BECAUSE THE #2 SHAFT STEERING WAS POORLY DESING, IT'S RUSTED AND GETS DIRTY BECAUSE IT DOESN'T HAVE A BOOT OR NOTHING COVERING IT. TRUCK IS STIFF WHEN TURNING, AND ALMOST GETS STOCK WHEN TURNING BACK TO STRAIGHT.
Steering, Feb 21, 2018
STEERING HAS SEIZED UP. U JOINT CONSTANTLY NEEDS TO BE LUBED.
Steering, Nov 11, 2017
LOWER INTERMEDIATE STEERING SHAFT UNIVERSAL JOINT BEARINGS RUST RESULTING IN THE STEERING WHEEL BEING DIFFICULT THE TURN. SOME OF HAVE REPORTED THE STEERING LOCKING. THE PART NUMBER IS: 45203-04020.
Steering, Apr 25, 2017
THE UNIVERSAL JOINT IN THE INTERMEDIATE STEERING SHAFT HAS RUSTED, CREATING AN UNSAFE CONDITION. THIS JOINT IN THE STEERING COLUMN SHOULD HAVE BEEN PROTECTED FROM THE ELEMENTS BY A BOOT, OR SOME OTHER MEANS, TO MAINTAIN LUBRICATION AND PREVENT THIS JOINT FROM RUSTING. ONLINE RESEARCH SUGGESTS THIS IS A COMMON, AND VERY DANGEROUS, PROBLEM. DUE TO THE COST OF THIS REPAIR ($400- 500), MANY PEOPLE MAY TRY TO SIMPLY LUBRICATE A DAMAGED JOINT, POSSIBLY RESULTING IN STEERING FAILURE.
Steering, Power train, Seats, Dec 20, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 30 TO 70 MPH, THE DRIVE TRAIN VIBRATED UNCONTROLLABLY, AND THE SEAT AND STEERING WHEEL ALSO VIBRATED. THE MANUFACTURER WAS NOTIFIED. THE DEALER REPLACED THE TIRES, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Steering, Jun 28, 2016
STEERING ISSUE. WHEN I TURN THE STEERING WHEEL I EXPERIENCE STIFFNESS ON/OFF ON THE TURN. I NOTICED THE U JOINT WAS RUSTED OUT. I SPRAYED IT WITH SILICONE, WORKED FINE FOR A WHILE, NOW THE STIFFNESS IS BACK. I BELIEVE TOYOTA NEEDS TO RECALL THIS U JOINT REPLACEMENT. THIS IS A HUGE SAFETY ISSUE
Steering, Jun 20, 2016
STEERING ISSUE. WHEN I TURN THE STEERING WHEEL I EXPERIENCE STIFFNESS ON/OFF ON THE TURN. I NOTICED THE U JOINT WAS RUSTED OUT. I SPRAYED IT WITH SILICONE, WORKED FINE FOR A WHILE, NOW THE STIFFNESS IS BACK. I BELIEVE TOYOTA NEEDS TO RECALL THIS U JOINT REPLACEMENT. THIS IS A HUGE SAFETY ISSUE.
Steering, Structure, Engine, Oct 23, 2015
WHILED I WAS DRIVING I WENT OVER A BUMP IN THE ROAD. THE FAN ON MY TRUCK STARTED MAKING A LOUD NOISE. I TOOK THE VEHICLE TO A REPAIR SHOP TO BE CHECKED. THIS I WHEN I FOUND OUT THAT THE FRAME ON MY 2005 TOYOTA TACOMA WAS CRACKED AND CAVING IN WHERE THE MOTOR MOUNTS ATTACH TO THE FRAME. THIS CAUSED THE MOTOR TO DROP DOWN AND THE FAN STARTED HITTING ON THE SHROUD. ALSO IT PIERCED A HOLE IN MY UPPER OIL PAN WHEN THE MOTOR DROPPED DOWN AND HIT THE RACK AND PINION. UPON RESEARCH THERE ARE MANY MANY CASES OF THIS HAPPENING TO THE 2005 -2006 TACOMA TRUCKS. THIS IS CLEARLY A SAFETY ISSUE THAT TOYOTA REFUSES TO FIX.
Steering, Sep 22, 2015
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE STEERING COLUMN DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THE STEERING COLUMN WAS REATTACHED TO THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE DIAGNOSIS WAS UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,435.
Steering, Aug 3, 2015
AFTER FRAME WAS REPLACED I STARTED HAVING STIFFNESS IN MY STEERING.
Steering, May 23, 2015
WITH OUT WARNING, MY STEERING GOT VERY STIFF AND THE WHEELS WOULD NOT RETURN TO CENTER AUTOMATICALLY. AFTER RESEARCHING I FOUND THAT IT COULD BE THE U-JOINT ON THE LOWER STEERING SHAFT. I SPRAYED LUBRICANT ON THE U-JOINT AND THIS TEMPORARILY RESOLVED THE ISSUE. THE BINDING RETURNS EVERY WEEK OR SO. THE U-JOINT IS NOT PROTECTED FROM THE ELEMENTS ALLOWING ROAD GRIME, SALT AND OTHER CONTAMINANTS TO GET INTO THE U-JOINT. THIS IS A VERY BIG SAFETY CONCERN AND SHOULD BE RECALLED. WHEN I SPOKE TO THE DEALER THEY STATED TO KEEP LUBING IT UNTIL IT STOPS WORKING. THIS SEEMS TO BE DANGEROUS AND I WILL BE WORKING TO REPLACE IT. I AM SEEING THAT THE COST IS ~ $350 TO HAVE A DEALERSHIP PERFORM THE REPAIR. PLEASE INVESTIGATE AS THIS IS A VERY BIG SAFETY ISSUE AND MANY TACOMA OWNERS OF THE 2005 TO AT LEAST THE 2012 MODEL ARE INDICATING HAVING THIS ISSUE AT DIFFERENT MILEAGE.