2009 Toyota Tacoma
Problems, recalls and owner-reported issues
Suspension is the leading concern among 519 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Tacoma model years with reports.
Of the 2009 reports, 25 involved a crash and 18 involved a fire. 2 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Equipment, other, labelsAug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V475000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleApr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Campaign 14V168000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsMar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V148000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: structure
54 reports, newest first. Show all
Structure, Jun 29, 2026
The contact owns a 2009 Toyota Tacoma. The contact stated that the frame on the driver’s and passenger’s side was severely rusted. The dealer was contacted about the failure and about the warranty enhancement program ZH6, which was associated with the failure. The manufacturer had extended the warranty coverage for frame corrosion on certain 2005–2010 model year Toyota Tacoma vehicles. The dealer informed the contact that the program had expired. The manufacturer was made aware of the failure. The manufacturer informed the contact that the warranty program had expired. The failure mileage was approximately 217,000.
Structure, May 22, 2026
Real bumper assembly rotted off the frame was dragging behind the truck I'm at 60mph luckily nobody was behind me pulled over and removed it all both frame rails was rusted in half Hanging On by a little piece every place I called will not fix it want me to buy a whole frame truck has 220 miles on it with no rear bumper
Structure, Oct 22, 2025
The contact owns a 2009 Toyota Tacoma. The contact stated that after maintenance service on the vehicle, it was discovered that the front subframe of the vehicle was severely corroded. The vehicle was taken to an independent mechanic, where it was inspected, and determined that the entire subframe had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where the same diagnostic result was provide,d and the contact was informed that the entire subframe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 85,000.
Structure, Oct 22, 2025
The contact owns a 2009 Toyota Tacoma. The contact stated that upon further inspection, the contact became aware that the chassis was rusted. The local dealer was contacted; however, the contact was informed that an unknown Toyota recall for warranty coverage had expired. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.
Structure, Oct 15, 2025
THE FRAME HAS RUSTED AND HOLES ARE UNSAFE. I AM WORRIED ABOUT DRIVING MY VEHICLE. THE SAFETY OF ME AND OTHER DRIVERS ON THE ROAD I AM TRAVELING ARE AT RISK. I WENT TO LIBERTY TOYOTA IN BURLINGTON, NJ AND THEY REFUSED TO REPAIR. THE RUST IS UNUSUAL AND THERE HAVE BEEN OTHER YEARS AFFECTED AND FRAMES REPLACED. MY WIFE PURCHASED THIS TRUCK FROM LIBERTY TOYOTA
Structure, Other or unspecified, Aug 21, 2025
Vehicle: 2009 Toyota Tacoma VIN: [XXX] Mileage: 128,400 Owner: Jacob Grove, Anderson, SC Summary of Issue: The frame of this 2009 Toyota Tacoma has developed severe rust perforation that makes the vehicle unsafe to drive. My independent mechanic has refused to work on it due to safety concerns, and Toyota of Greenville (SC) has confirmed that the frame is extensively corroded and requires replacement. Background: Toyota previously issued a Customer Support Program (CSP) for frame corrosion affecting 2005–2009 Tacomas in northern states, including Ohio, where this truck was purchased and operated. In June 2018, the vehicle was inspected at Don Wood Toyota in Athens, OH (91,600 miles). The dealership recorded “no perforation” and did not apply the protective coating or replace the frame. The truck has been minimally driven since (an average of 6,000 miles per year). In May 2024, at 128,400 miles, a mechanic and dealership confirmed the frame has multiple areas of severe perforation, including around brake lines and exhaust mounts. Concern: It is unreasonable that a vehicle frame could go from “no perforation” to “severe perforation” in only 36,000 miles and six years of light use. This indicates either: The 2018 inspection under Toyota’s CSP was inadequate, or The frame was already compromised but not properly addressed at the time. Safety Risk: The vehicle cannot be safely lifted, worked on, or driven in its current condition. The rapid deterioration presents a risk of frame failure while driving, endangering occupants and others on the road. Request: I am submitting this complaint so that NHTSA is aware of ongoing frame corrosion failures in 2005–2009 Toyota Tacomas, even in cases where Toyota previously inspected and declined to repair during the CSP period. This case demonstrates that the problem may not have been properly identified or corrected during program inspections, leaving unsafe vehicles on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Structure, Aug 7, 2025
The contact owns a 2009 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from underneath the vehicle. Upon inspection, the contact discovered a branch lodged beneath the vehicle and the corroded subframe with a hole in the front passenger’s side subframe. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 113,000.
Structure, Oct 24, 2024
I just learned from my Mechanic that the Frame Corrosion is bad. The frame was inspected by Vanderstyne (now West Herr) Toyota on 06/20/2020. It passed the Inspection at that time, so they did not do anything. But within 4.5 years and only a little more than 6,000 miles driving since then - this corrosion shows up. I think the Toyota Specs for the Corrosion Inspection were not sufficient. Toyota should be held accountable for their negligence. I only have 72,900 miles on this Tacoma. I would have liked to keep it for another 5 years or so, but now I cannot and Toyota washed their hand when I contacted them.
Structure, Oct 7, 2024
See Attached Letter
Structure, Aug 25, 2024
My frame is rusting and has holes in places. Is there a recall for that?
Structure, Jun 11, 2024
Chassis in the middle frame back left too much rust and big hole due to rust
Structure, Feb 9, 2024
See attached document for complaint
Structure, Jan 4, 2024
We recently went to have new tires put on the Tacoma at Costco. The Costco technician said that the frame was rusted and he had a similar problem with his Tacoma and Toyota repaired it. He told us that he couldn't install the new tires with the rusted frame and suggested that we go to our Toyota Dealer. We went to Toyota Direct in Columbus, Ohio (where we have had the vehicle serviced every time) and they took pictures of the rust and told us they would call us back. Although we have inquired several times, they had not called us back so we reached out to Toyota Corporate and they said that the recall/warranty extension had expired and there was nothing they could do. Costco has refused to install the new tires until the frame is repaired. (our problem is not with Costco.) The Costco tech did tell us that he was surprised that the rust had not been noticed before by the Dealer during regular service as it would not have appeared so quickly. So the complaint goes against Toyota Corporate and Toyota Direct... why did they not notice any rust while the warranty/recall was in effect or any of the service visits if this is a standard problem with 2009 Toyotas. If the vehicle has a rusted frame, that could be dangerous to whoever is driving the vehicle. In addition, without being able to have new tires installed due to the frame issue, that creates another safety concern with winter weather approaching and tires that need replaced.
Structure, Sep 14, 2023
Just learned from CT Toyota dealer that my 2009 Toyota Tacoma frame has significant corrosion and that it's time to replace frame or vehicle. Very disappointed. Vehicle did go in for recall service on 12/7/17 and CRC spray was applied as frame was determined ok at that time. Looks like that didn't help much to prevent further corrosion less than 6 years later. Voicing my frustration over those that got new frames are still driving on road, while I have to retire my truck. Extending warranty to 12 years from date of first use clearly did me no help. Do I and others like this have any options?
Structure, Aug 19, 2023
Rust flaking frame small hole
Structure, Jun 9, 2023
Significant amount of rust and rot on multiple structural points of the truck’s frame. This deterioration has advanced much quicker than anticipated, compromising the structural integrity and safety of the vehicle. The rust and rot have affected crucial components of the frame, including crossmembers and suspension mounting points. I have entered my vin # multiple times in the past years to the Toyota frame recall webpage but I am continually denied frame replacement. I feel that the extent of rust and the time frame in which it occurred should allow for a manufacturer replacement or compensation.
Structure, Apr 10, 2023
I purchased this vehicle on 12/16/2019 with 20,990 miles on it. Now the vehicle has 33,000 miles on it and I was told by an independent service station that I have a large hole in the frame. I brought the truck on 4/07/2023 to a Toyota dealer and they said the recall for a new frame expired 12 years after the vehicle was purchased. I called Toyota and they told me the same thing. I had know idea that these trucks had frame rust issues when I bought it. I read that Canada received a 3 year extension to 15 years on Tacoma 2009 trucks with mileage under 36,000, I have only 33,000 miles. Please help!
Suspension, Structure, Mar 24, 2023
Went for an inspection and entire frame is completely rotting out. Could have ben killed. Truck only has 65,000 miles on it because it was previously owned by my 80 year old grandfather. Toyota should have to fix everyone of these issues not just a certain time frame.
Structure, Mar 23, 2023
The contact owns a 2009 Toyota Tacoma. The contact stated that he noticed that the subframe was excessively rusted. The vehicle was taken to a local dealer for routine oil change and tire rotation services, and after the contact made the mechanic aware of the failure, he was informed that the vehicle could not be raised up on the lift because the subframe had excessive rust and would fracture. The contact was informed that the subframe needed to be replaced. The contact then made Toyota of Bedford (18151 Rockside Rd, Bedford, OH 44146) aware of the failure; however, the dealer declined to diagnose or repair the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 104,000.
Structure, Nov 17, 2022
Went to get an undercoat application. Tech pointed out severe rust/rot on my truck frame, located on both front wheel control arm area. Vehicle was inspected by N.E. Undercoating, Plainfield Ct. No warnings. NEVER RECEIVED A FRAME RECALL NOTICE Contacted Toyota Corporation and they said "sorry, nothing we can do"
Structure, Jun 22, 2022
The contact owns a 2009 Toyota Tacoma. The contact stated while driving at an unknown speed, the vehicle started shaking abnormally. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the subframe needed to be replaced. The contact stated that she had received a recall in the past for the subframe however, the vehicle was not repaired. The dealer and manufacturer were notified of the failure but informed the contact that the recall had expired. The vehicle was not repaired. The failure mileage was approximately 95,000.
Structure, Other or unspecified, Apr 29, 2022
Never received notice for XX Warranty Enhancement Program and found out in March 2022 as vehicle cannot pass inspection due to rusty on frame. BRAND ENGAGEMENT ADVOCATE March 09, 2022 at 12:18 PM Dear [XXX], Thank you for contacting Toyota Motor Sales, U.S.A., Inc. regarding your frame concern in your 2009 Tacoma. We are sorry to learn you're experiencing a concern with your vehicle. We were able to further look into your frame concern and have verified your vehicle is beyond the parameters of the Warranty Enhancement Program for this concern. This warranty enhancement program was an extension of the vehicle's Basic Warranty. Primary coverage for this program expired on 01/31/19 and Secondary coverage for your vehicle expired 12 years after the date of first use: 06/30/20. Once the vehicle is outside of the program parameters, the cost of repairs becomes the owner’s responsibility, as the component is now outside of all factory coverage. We have also verified that one letter was sent to you at the mailing address we have on file. The remedy letter for the XX Warranty Enhancement Program was sent on 11/08/2018. We hope this provides clarity to your inquiry. Your comment has been documented at our National Headquarters under your case number. If we can be of further assistance, please feel free to contact us. Sincerely, [XXX] Toyota Brand Engagement Center INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Structure, Feb 24, 2022
Severe rusting and corrosion of chassis/under body, body and frame of truck.
Structure, Feb 3, 2022
The contact owns a 2009 Toyota Tacoma. The contact stated while driving approximately 60 MPH, the tire hit the wheel well and the frame was ripped apart. The dealer sent a technician to the contact’s home to inspect the vehicle. The contact was informed that the sub frame needed to be replaced however, the vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer informed the contact that the vehicle was out of warranty. The failure mileage was approximately 250,000.
Structure, Jan 26, 2022
The contact owns a 2009 Toyota Tacoma. The contact stated that while the vehicle was at an independent mechanic for routine maintenance, the mechanic informed him that there was a hole in the sub-frame and that the sub-frame was severely corroded. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. Additionally, the extended warranty had expired. The vehicle had previously been serviced in 2017 when the dealer applied an undercoating to the subframe. The failure mileage was 65,136.