2002 Volkswagen Jetta
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 711 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Jetta model years with reports.
Of the 2002 reports, 32 involved a crash and 71 involved a fire. 75 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Exterior lighting, brake lights, switchMay 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 06V183000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchDec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V584000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V096000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
THIS CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 02V031000 on NHTSA.gov
Representative owner complaints
711 reports, newest first.
Engine and engine cooling, Visibility, Equipment, May 18, 2006
MY WIFE'S 2002 JETTA STATION WAGON TURBO HAS BEEN NOTHING BUT TROUBLE. ONLY 30 K AND TODAY A $2,600 REPAIR. VALVE FOR AIR CONDITIONER PUMP BROKE AND SENT METAL FRAGMENTS THROUGH THE SYSTEM NECESSITATING REPLACEMENT OF AC PUMP. COOLING FAN NOT WORKING- THAT'S $800.00. LAST REPAIR WAS AUTO WINDOWS- IDIOT DESIGNERS PUT IN PLASTIC COMPONENTS. MY WIFE TAKES EXCELLENT CARE OF HER VEHICLE (OIL CHANGE, ETC.) AND THIS INFERIOR BIT OF WORKMANSHIP JUST COSTS HER MORE MONEY. SHE WILL SHORTLY BE DUMPING THIS PIECE OF CRAP FOR TOYOTA COROLLA. *NM
Power train, Apr 26, 2006
2002 JETTA GLS AUTOMATIC CARS. THE SIDE BUTTON YOU PUSH ON THE SHIFT HANDLE GETS STUCK IN AND DOESN'T POP OUT. THIS CAUSES ME TO NOT BE ABLE TO REMOVE THE KEY OR CAN ACCIDENTALLY SHIFT INTO ANOTHER GEAR IF IT DOESN'T POP OUT. *JB
Electrical system, Apr 24, 2006
THE CAR WOULD NOT START, MADE A CLICKING SOUND WITH EACH ATTEMPT, AND THE RADIO AND AUTOMATIC WINDOWS WOULD NOT TURN ON/RESPOND TO CONTROL. THE CAR HAD TO BE TOWED AND THE STARTER WAS FOUND TO BE THE PROBLEM ON A RELATIVELY NEW CAR (3YRS. OLD), 40000K. HAVE SUBSEQUENTLY READ ANECDOTAL COMPLAINTS THAT VW'S HAVE STARTER PROBLEMS. *JB
Exterior lighting, Apr 20, 2006
2002 JETTA REAR LIGHTS WORK INTERMITTENTLY. *TS THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE LIGHT PROBLEMS. *JB
Air bags, Apr 18, 2006, crash
THE FRONT, SIDE AND SIDE-IMPACT AIRBAGS IN MY 2002 VOLKSWAGEN JETTA ALL FAILED TO DEPLOY WHEN I WAS STRUCK ON THE PASSENGER SIDE BY A TRUCK TRAVELING AT 40-50 MILES PER HOUR. THE PARAMEDICS AND RESPONDING OFFICER ENCOURAGED ME TO FILE THIS COMPLAINT, SAYING THAT I WAS FORTUNATE TO BE RIDING ALONE BECAUSE A PASSENGER WOULD NOT HAVE SURVIVED THE ACCIDENT WITHOUT AIRBAG PROTECTION. I HAVE ALREADY CONTACTED VW AND SUBMITTED THE FORMS AND PHOTOGRAPHS THEY REQUESTED FOR VALIDATION OF MY CLAIM, BUT - AS EXPECTED - THEY HAVE NOT RESPONDED. I HAVE NO INTENTION OF SUING, BUT I AM DISTURBED BY VOLKSWAGENS' RECENT CAMPAIGN TO MARKET THE JETTA BASED ON ITS SAFETY. IN THE 3 1/2 YEARS I OWNED THE CAR, I HAD TO RETURN IT FOR RECALLS/REPAIRS 14 TIMES, SO I BELIEVE THE AIRBAG FAILURE TO BE YET ANOTHER SYMPTOM OF THE JETTA'S POOR MANUFACTURING. I WOULD GREATLY APPRECIATE YOUR INVESTIGATION INTO THIS MATTER AND WOULD BE HAPPY TO PROVIDE DOCUMENTATION AND PHOTOGRAPHS. *NM
Engine and engine cooling, Apr 6, 2006
A 2002 JETTA VOLKSWAGEN, 2.0 LTR ENGINE, CATALYTIC CONVERTER GONE BAD. ENGINE LIGHT CAME ON IN OCTOBER, RIGHT AROUND 78,000 MILES. HAD IT CHECKED IN DECEMBER AND FOUND FAULTY O2 SENSORS. CHANGED THOSE. ENGINE LIGHT STILL ON. HAD TECHNICIAN DO A THOROUGH CAR CHECK, FOUND ORIGINAL FUEL FILTER (AT 80,000 MI.), NEW SPARK PLUGS, CHECKED ELECTRICAL TO MAKE SURE NOT SHORTING OUT, CHANGED WIRES, MADE SURE O2 SENSORS OPERATING CORRECTLY, CHECKED WITH OTHER TECHNICIANS ON INTERNET TO DO ALL POSSIBLE CHECKS, CHANGES, AND FIXES. NOTHING ELSE CAN BE DONE. TECHNICIAN CHECKED WITH HIS DEALER AND FOUND CATALYTIC CONVERTERS ARE ON BACKORDER UNTIL CHRISTMAS 2006 FOR THE EXACT SAME PART, CAR, AND TYPE. *JB
Air bags, Mar 14, 2006, crash
THE '02 JETTA 1.8T 4-DOOR WAS STOPPED AT A RED LIGHT. THE JETTA PROCEEDED INTO INTERSECTION. JETTA WAS HIT (T-BONED) ON DRIVERS SIDE DOOR AND REAR PASSENGER DOOR BY 1995 GRAND MARQUIS, MERCURY IN EXCESS OF 45 MPH. TICKET WAS ISSUED FOR FAILING TO STOP AT A RED LIGHT, NO BRAKING ON PART OF THE MERCURY. EXTENSIVE DAMAGE TO THE JETTA - THE FRONT DOOR WAS DRIVEN INTO THE DRIVERS CAGE WHICH MOVED THE FRONT SEAT AND BENT THE STEERING WHEEL. THE FRONT WINDSHIELD FORMED A LARGE CRACK, PROBABLY FROM A SIDE STRESS POINT AND DID NOT SHATTER, THE DRIVERS SIDE WINDOWS IN BOTH DOOR SHATTERED. SEVERE FRAME DAMAGE COULD BE SEEN AND NONE OF THE DRIVERS SIDE DOORS COULD OPEN, NOR THE PASSENGER SIDE EITHER AFTER THE ACCIDENT. THE DRIVERS SIDE AIRBAGS (2), LOCATED BETWEEN THE TWO DAMAGED DOORS AND ALSO THE AIRBAG BETWEEN THE DRIVERS SIDE DOOR AND WINDSHIELD FAILED TO DEPLOY. VW CLAIMS THAT THE CAR DECIDED BECAUSE THE SEAT BELT WAS IN USE, THE CAR MADE AN INTELLIGENT DECISION NOT TO DEPLOY THE AIRBAGS. THIS IS EITHER FALSE OR AN ERROR IN HOW THE CAR IS DESIGNED. AIRBAGS SHOULD DEPLOY AND NOT DECIDE THAT THE SEAT BELT WAS SUFFICIENT - IT WAS NOT SUFFICIENT, AS THERE WERE MEDICAL INJURIES. JETTA IS TOTALED, BUT BEING HELD BY USAA, PENDING ANYONE WHO WILL INVESTIGATE THIS ISSUE ON MY BEHALF. OTHERS SHOULD NOT HAVE TO SUFFER IF A PROBLEM CAN BE IDENTIFIED HERE AND RESOLVED. *JB
Air bags, Feb 24, 2006
DT*: THE CONTACT STATED THE DRIVER'S SIDE AIR BAG DEPLOYED UNEXPECTEDLY WHILE DRIVING AT 60 MPH. THERE WAS A POLICE REPORT FILED. THE POLICE DETERMINED THERE WAS NO DEBRIS IN THE ROAD AT THE TIME OF THE INCIDENT. A REPRESENTATIVE FROM THE MANUFACTURER INSPECTED THE VEHICLE AND DISCOVERED A DENT IN THE METAL IN THE REAR OF THE VEHICLE. THIS WAS DETERMINED TO BE THE CAUSE OF THE PREMATURE DEPLOYMENT.
Power train, Feb 24, 2006
OCCASIONALLY WHEN THE CLUTCH PEDAL IS DEPRESSED, IT DOES NOT FULLY RETURN TO IT NORMAL POSITION. THIS OFTEN OCCURS WHEN SITTING AT A LONG RED LIGHT. WHEN THE LIGHT TURNS GREEN AND I ATTEMPT TO RELEASE THE CLUTCH IT REMAINS DEPRESSED, RESULTING IN ENGINE STALL. THIS POSSES A DANGER BECAUSE STALLS WHEN ATTEMPTING TO ACCELERATE CAN LEAD TO ACCIDENTS, BY PREVENTING THE DRIVER FROM ACCELERATING TO AVOID COLLISION. I HAVE TAKEN THE MY AUTO IN FOR DIAGNOSIS AND REPAIR ON 4 OCCASIONS. THE FIRST TIME THE CLUTCH MASTER CYLINDER WAS REPLACED, THE SECOND TIME THE CLUTCH MASTER CYLINDER WAS RE-BLED, AND THE 3RD & 4TH TIMES I WAS TOLD THAT THE CLUTCH WAS PERFORMING WITHIN VW SPECIFICATIONS BECAUSE THEY COULD NOT REPRODUCE THE PROBLEM. *NM
Engine and engine cooling, Feb 16, 2006
PURCHASED CAR ON 1-30-06 TOOK IT BACK ON 2-3-06 BECAUSE OF CHECK ENGINE LIGHT, TOOK IT BACK AGAIN ON 2-7-06 BECAUSE OF CHECK ENGINE LIGHT, AND TOOK IT BACK AGAIN ON 2-14-06 BECAUSE OF CHECK ENGINE LIGHT WAS TOLD IT WAS CATALYTIC CONVERTER BUT IS NOT COVERED UNDER WARRANTY FOR ME TO HAVE IT FIXED IT WILL BE 1100 DOLLARS BUT PART IS ON A MASSIVE BACK ORDER. *JB
Power train, Jan 25, 2006
EARLY CLUTCH FAILURE. WE JUST REPLACED THE CLUTCH ON 2002 JETTA AT 51,000 MILES. SHE OWNED OTHER MANUAL TRANSMISSION CARS AND DID NOT REPLACE THE CLUTCH THIS EARLY WITH ONE EXCEPTION, A VOLKSWAGEN, FOX. WAS THIS A PATTERN, MAYBE . *AK
Power train, Jan 13, 2006
THE TRANSMISSION BROKE ON MY 2002 JETTA TDI (AUTOMATIC) WHILE I WAS DRIVING HOME FROM THE U.S. MARINE CORPS BASE, BARSTOW, CALIFORNIA. IT ONLY HAS 66,500 MILES ON IT. I BELIEVE THE DESERT VW DEALERSHIP IS RESPONSIBLE BECAUSE THEY DID NOT CHECK THE TRANSMISSION THOROUGHLY AS I REQUESTED TWO MONTHS AGO. VW AMERICA IS NOT HELPING ME AT ALL WITH MY REQUEST TO HAVE THIS REVIEWED BY THEM. THE DEALERS TELL ME TO CALL VW AMERICA AND VW AMERICA TELLS ME TO CALL THE DEALERS. *NM
Engine and engine cooling, Jan 12, 2006
OIL LIGHT CAME ON REPEATEDLY DUE TO OIL SLUDGE PROBLEM, WHICH IS A KNOWN DEFECT. VW DID NOT COVER, DUE TO EXPIRED WARRANTY. *JB
Visibility, Dec 30, 2005
I PURCHASED THE CAR NEW IN JUNE AS A LEFT OVER, HAD IT A MONTH AND THE WINDOW ON THE DRIVERS SIDE FELL TO THE BOTTOM OF THE DOOR. BROUGHT IT TO THE DEALER AND WAS TOLD THEY REPLACED IT WITH METAL CLIPS AND IT WOULDN'T HAPPEN AGAIN. 5 MONTHS LATER IT HAPPENED AGAIN, SAME WINDOW. *JB
Air bags, Dec 4, 2005, crash
MY WIFE WAS IN A CAR ACCIDENT ON 12/2/05 IN HER 2002 VW JETTA GLS. A LADY HAD RAN A RED LIGHT AND COLLIDED WITH THE FRONT DRIVER SIDE OF THE CAR AT APPROX: 40 MPH. THE CAR WAS EQUIPPED WITH FRONT AND SIDE AIRBAGS; NEITHER OF WHICH AIRBAG DEPLOYED. MY WIFE HIT HER HEAD ON THE FRONT DRIVER SIDE WINDOW BECAUSE THE AIRBAGS DID NOT DEPLOY. *NM
Electrical system, Vehicle speed control, Nov 16, 2005, crash
PLEASE REFER TO MY PREVIOUS COMPLAINT SUBMITTED 9/17/2005 REGARDING MY '02 VW JETTA. THE CRASH WAS A RESULT OF SUDDEN ACCELERATION AND EXTENDED BRAKING DISTANCE. THE REASON I AM WRITING AGAIN IS TO ADDRESS THE FACT THAT MY LOCAL NEWS (DENVER CHANNEL 7 NEWS) DID AN UNDERCOVER FEATURE IN REGARDS TO THE VOLVO'S SUDDEN ACCELERATION AND DECELERATION. THE MECHANIC USED IN THE PIECE DETERMINED THE PROBLEM WAS THE ELECTRONIC THROTTLE. THUS, VOLVO IS ANNOUNCING A MAJOR RECALL ON ALL 1999-2002 VOLVO'S. THIS ISSUE IS RAMPANT AMONG THE AUTO INDUSTRY INCLUDING VWOA. PLEASE EXTEND YOUR INVESTIGATION TO INCLUDE VW AND HOPEFULLY VWOA WILL DO A MAJOR RECALL ON ALL CARS EQUIPPED WITH ELECTRONIC THROTTLES. PLEASE NOTE THAT I WAS REQUIRED TO ATTEND DMV COURT SINCE I WAS ISSUED A TICKET. THE JUDGE RULING OVER MY CASE ENDED UP DISMISSING MY CASE BECAUSE OF THE EVIDENCE I HAD BROUGHT TO COURT. MORE OVER, THE JUDGE WAS A FORMER MECHANIC FOR 8 YEARS AND HE HAS WORKED EXTENSIVELY ON VW'S. HE WAS VERY FAMILIAR WITH MY SITUATION. I DON'T HAVE MY VIN # HANDY, BUT IT WAS LISTED IN MY COMPLAINT ODI ID #: 10136890. PLEASE REFER TO MY CASE NUMBER FOR FURTHER DETAILS. *JB
Exterior lighting, Nov 15, 2005
DT: THE CONTACT STATES IS NHTSA A RECALL CAMPAIGN ID # 04V096000 CONCERNING THE EXTERIOR LIGHTING BRAKE LIGHT SWITCH. THE CONSUMER WAS EXPERIENCING THE SAME SYMPTOMS AS INDICATED IN THE RECALL, BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. THE CONTACT HAD IT REPAIRED AT HIS OWN EXPENSE. *JB UPDATED 12/7/2005. *NM
Air bags, Nov 8, 2005
MY HUSBAND WAS DRIVING DOWN MANCHESTER ROAD (A BUSY 4 LANE ROAD) GETTING READY TO MAKE A RIGHT HAND WHEN THE PASSENGER AIRBAGS DEPLOYED. HE SAID IT SOUNDED LIKE A GUNSHOT WENT OFF IN THE CAR. HE WAS ABLE TO PULL THE CAR INTO A WALGREENS PARKING LOT. MY 4 YEAR OLD SON WAS SUPPOSE TO BE IN THE CAR WITH HIM. HE WOULD HAVE BEEN INJURED IF HE WAS. THIS IS A SERIOUS DEFECT AND NEEDS TO BE ACKNOWLEDGED AND DEALT WITH. THERE WAS NO IMPACT AND NOT A MARK ON THE CAR INDICATING AN ACCIDENT. VW IS REFUSING TO PAY FOR THE REPAIR BECAUSE THEY STATE THAT AN ACCIDENT HAD TO OCCUR BECAUSE AIR BAGS DON'T JUST GO OFF. MY CAR INSURANCE COMPANY IS ALSO NOT PAYING BECAUSE THERE IS NO VISIBLE DAMAGE ON THE CAR TO BE FIXED THEREFORE THERE IS NO CLAIM TO BE FILED. *JB
Exterior lighting, Nov 3, 2005
DT: THE CONTACT STATED THE HAZARD FLASHING LIGHTS SWITCH MALFUNCTIONED. ALL OF THE EXTERIOR LIGHTS ON THE CAR BURNED OUT. THE TURN SIGNALS WOULD TICK, BUT THE BLINKER LIGHT WOULD NOT COME ON. THIS WAS TEMPORARILY SOLVED BY REMOVING THE HAZARD LIGHT SWITCH. VOLKSWAGEN ISSUED RECALL 04V584000 ON THE HAZARD SWITCH, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER AND THE DEALER HAVE BEEN CONTACT, AND NEITHER OFFERED ANY FREE SOLUTION. *AK
Air bags, Oct 30, 2005
WE OWN A 2002 VW JETTA 2.0L. WE WERE DRIVING THROUGH AN INTERSECTION AND THE PASSENGER SIDE CURTAIN AND PASSENGER SEAT AIRBAG DEPLOYED WITHOUT CAUSE. WE PULLED OFF TO THE SIDE TO CHECK FOR ANY EXTERIOR DAMAGE THAT COULD OF CAUSED THE DEPLOYMENT BUT COULD NOT SEE ANY. WE DROVE IT HOME (@ 1 MILE) AND HAD IT TOWED TO THE DEALERSHIP WHERE WE WILL HEAR ABOUT THEIR COURSE OF ACTION TO REPAIR THE ISSUE. IS THIS A OCCURRENCE THAT IS UNDER INVESTIGATION? IF SO IT MIGHT BE HELPFUL TO KNOW SINCE THIS WILL BE A VERY COSTLY REPAIR AND HAVEN'T HAD THE BEST OF LUCK WITH VW EVEN THOUGH IT'S STILL UNDER WARRANTY. *NM
Seats, Oct 26, 2005
MY HUSBAND WAS DRIVING TO WORK ONE MORNING IN OUR 2002 VW JETTA, WITH THE SEAT WARMERS ON. WHEN SUDDENLY HE FELT A BURNING SENSATION ON HIS BOTTOM. TURNED OFF THE SEAT WARMER ONLY TO FIND OUT THERE WAS A BURN HOLE IN THE SEAT FROM THE SEAT WARMERS. SINCE THEN WE HAVE REFUSED TO TURN IT BACK ON AGAIN. *NM
Power train, Oct 13, 2005
I HAVE A 2002 VOLKSWAGEN JETTA 1.8L TURBO. MY FIRST CLUTCH STARTED SLIPPING AT 17K MILES, FINALLY REPLACED AT 20K. I FOUGHT WITH VW AND THEY ACTUALLY PAID FOR IT BECAUSE I HAD BROUGHT IT IN ON 3 DIFFERENT OCCASIONS AND NO ONE COULD FIND OR ADMIT TO A PROBLEM. NOW AGAIN AT 39K IT HAS STARTED SLIPPING AND IS NOW AT 41K. I AM DUE TO CHANGE IT ANY TIME. I AM ONCE AGAIN CALLING VW TRYING TO ARRANGE THEM TO TAKE CARE OF THE COST. I AM HOPING THEY WILL PAY FOR IT AS THE HAVE QUOTED ME $2200 TO FIX. I HAVE BEEN SEARCHING ON THE INTERNET & FOUND HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. AND REPLACING THE CLUTCH ISN'T A PERMANENT FIX AND MOST PEOPLE HAVE HAD TO PAY FOR IT. THEY HAVE BEEN BLAMING THE DRIVERS FOR POOR DRIVING SKILLS. MEANWHILE THEY ARE PUTTING MANY PEOPLE IN DANGER BECAUSE ANY KIND OF ACCIDENT COULD OCCUR WHEN YOUR CLUTCH DECIDES TO POP/ FAIL. ESPECIALLY ON THE FREEWAY. INCREDIBLY DANGEROUS. ANYWAYS, MOST PEOPLE SAY THAT OIL IN THE FLYWHEEL IS LEAKING OUT SATURATING THE CLUTCH DISK CAUSING IT TO SLIP & EVEN BREAK UP. THEREFORE VERY EARLY BREAKDOWN AND SOMETIMES IMMEDIATE/ UNEXPECTED CLUTCH FAILURE. *NM
Exterior lighting, Oct 11, 2005
DT: THE CONTACT STATES THERE IS RECALL 04V096000 CONCERNING BRAKE LIGHT SWITCH ON OTHER VEHICLES OF SAME MAKE/MODEL AND YEAR, BUT THIS VEHICLE IS NOT IN RECALL. HE CANNOT GET VEHICLE OUT OF PARK. THIS HAPPENS INTERMITTENTLY. DEALER REPLACED THE PART, AND WANTED THE CONTACT TO PAY FOR IT. MANUFACTURER SAID THIS VEHICLE WAS NOT INCLUDED IN THE RECALL AND OFFERED NO HELP TO CONTACT TO PAY THE EXPENSES. *AK
Engine and engine cooling, Oct 10, 2005
ENGINE SLUDGE DIAGNOSED ON PASSAT. *NM
Service brakes, Hydraulic, Oct 9, 2005
WE HAVE A 2002 VOLKSWAGEN JETTA TDI GLS. SINCE THE VEHICLE WAS NEW WE HAVE HAD AN INTERMITTENT SERIOUS PROBLEM WITH THE BRAKING SYSTEM. WE LIVE NEAR FORT COLLINS, CO; WHEN WE TRAVEL TO OTHER PARTS OF THE COUNTRY WITH LOWER ELEVATION, OUR BRAKES BEGIN TO MALFUNCTION. INITIALLY, THEY BEGIN TO DRAG; YOU USUALLY HAVE TO TURN OFF THE IGNITION TO GET THEM TO RELEASE. SOMETIMES YOU CAN PUMP THEM HARD AND GET THEM TO RELEASE. DURING THIS PHASE THE BRAKES WEAR QUICKLY AND BECOME VERY HOT. WITHIN A DAY THE PROBLEM PROGRESSES TO A MUCH WORSE CONDITION. AS YOU PRESS THE BRAKE PEDAL, THE PEDAL FEELS AS THOUGH IT IS PULLING AWAY FROM YOUR FOOT. AS YOU PRESS A LITTLE MORE, THE PEDAL SUDDENLY PULLS VIOLENTLY FROM YOUR FOOT AND THE VEHICLE BRAKES SLAM ON. AT THIS TIME THE ABS DOES NOT WORK AS FAR AS I CAN TELL. WHEN THE BRAKES PULL FROM YOUR FOOT THERE IS A NOISE LIKE AIR BEING SUCKED INTO SOMETHING. WHEN THE BRAKES SLAM ON IN THIS FASHION, ONE OF SEVERAL THINGS HAPPEN. THE BRAKES MAY STAY LOCKED ON, LEAVING YOU TO TRY TO GET THEM TO RELEASE, OFTEN IN AN INTERSECTION OR TRAFFIC. THEY MAY RELEASE ENTIRELY, AND BE OKAY UNTIL THE NEXT BRAKING INCIDENT. MANY TIMES THEY DRAG SOMEWHERE BETWEEN LIGHT ENOUGH THAT YOU MIGHT JUST THINK THE CAR IS RUNNING POORLY TO SO HEAVILY THAT YOU CAN BARELY MOVE THE CAR WITHOUT KILLING THE ENGINE. WE WERE MOST RECENTLY IN THE PORTLAND, OREGON AREA WHEN THIS HAPPENED. IT BEGAN TO HAPPEN THE FIRST NIGHT WE WERE IN TOWN, WITH THE DRAGGING. THE NEXT MORNING WE DROVE TO THE COAST, AND THE MORE SERIOUS MALFUNCTION BEGAN. WE TRIED TO DRIVE AROUND A SMALL COASTAL TOWN, ONLY TO HAVE TO PARK AND WALK EVERYWHERE WE NEEDED TO GO. ON THE WAY BACK WE WERE UNFORTUNATE TO FIND OURSELVES IN BUMPER TO BUMPER, STOP AND GO TRAFFIC. WITH NEARLY EVERY SINGLE USE OF THE BRAKES, THEY WOULD SLAM TO THE FLOOR. WE HAVE TO TRY TO STAY FAR ENOUGH AWAY FROM OTHER VEHICLES TO AVOID BEING HIT FROM BEHIND OR SKIDDING INTO THE VEHICLE IN FRONT OF US. *NM